Ford Excursion I (1999-2005) except 6.0l Wiring diagrams

6.0L 7.3L POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) 5.4L/6.8L 6.0L A/C CLUTCH RELAY A/C CLUTCH SOLENOID A/C COMPRESSOR CLUTCH DIODE A/C HIGH PRESSURE SWITCH (IN RIGHT SIDE OF ENGINE COMPT) A/C PRESS SWITCH SIG 18 69 PNK/ A/C CLUTCH RELAY WIRE AUXILIARY AIR CONDITIONING CIRCUIT BLK WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN/ORG WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (BEHIND LEFT SIDE OF DASH) DK BLU/ORG WIRE DUAL PRESSURE (6.0L) (AT FRONT OF ENGINE) EXC 6.0L (AT LEFT SIDE OF ENG COMPT) EXCEPT 6.0L FRONT BLOWER MOTOR SPEED CONTROLLER (AT RIGHT REAR SIDE OF ENGINE COMPT) FUSE 10 FUSE 107 FUSE 23 FUSE 27 GRY WIRE GRY/WHT WIRE HEATER BLOWER MOTOR (AT RIGHT REAR SIDE OF ENGINE COMPT) HOT AT ALL TIMES HOT IN LT BLU/PNK WIRE LT GRN WIRE LT GRN/WHT WIRE NCA WIRE OR RUN ORG/ WIRE ORG/BLK WIRE PNK/ORG WIRE PNK/YEL WIRE RED WIRE RED/YEL WIRE RUN WIRE SUNLOAD SENSOR (ON TOP CENTER OF DASH) SWITCH TAN WIRE TAN/LT GRN WIRE VACUUM PUMP MOTOR (6.0L) (IN RIGHT SIDE OF ENGINE COMPARTMENT) VIO WIRE WHT WIRE WHT/VIO WIRE YEL WIRE YEL/RED WIRE

2 2 LEFT TAIL LAMPS RIGHT TAIL LAMPS 6.0L 6.0L 1 2 AUXILIARY RELAY BOX 4 (EXCEPT 6.0L) (AT LEFT REAR SIDE OF ENGINE COMPARTMENT) AUXILIARY RELAY BOX 5 (6.0L) (AT LEFT REAR SIDE OF ENGINE COMPARTMENT) BACK-UP LAMPS CIRCUIT BATTERY CHARGE TRAILER TOW RELAY BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE BRN WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) FUSE 6 DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/ORG WIRE EXCEPT 6.0L FUSE 115 FUSE 38 HOT AT ALL TIMES HOT IN LEFT LICENSE PLATE LAMP LEFT REAR PARK/STOP TURN LAMP LEFT TURN TRAILER TOW RELAY LT GRN WIRE LT GRN/ORG WIRE MICROPROCESSOR ORG/ WIRE ORG/LT BLU WIRE PARK LAMP RELAY PARKING LAMP TRAILER TOW RELAY REVERSING LAMP TRAILER TOW RELAY RIGHT LICENSE PLATE LAMP RIGHT REAR PARK/STOP TURN LAMP RIGHT TURN TRAILER TOW RELAY RUN WIRE TAN/WHT WIRE TRAILER TOW CONNECTOR (4 PIN) TRAILER TOW CONNECTOR (7 PIN) VEHICLE SECURITY MODULE (VSM) (BEHIND LEFT SIDE OF DASH) WHT WIRE YEL WIRE

5.4L/6.8L 7.3L 6.0L 6.0L 8 16 A/C PRESS SW IN A/C PRESS SW IN A/C CLUTCH SOLENOID A/C COMPRESSOR CLUTCH DIODE A/C HIGH PRESSURE SWITCH (IN RIGHT SIDE OF ENGINE COMPT) 6.0L A/C PRESS SWITCH SIG RTN 18 69 PNK/ A/C CLUTCH RELAY WIRE BLK WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BLOWER MOTOR SWITCH BRN WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) COOLING FAN SPEED SIG DK BLU WIRE DUAL PRESSURE (6.0L) (AT FRONT OF ENGINE) ELECTRONIC FAN CLUTCH (6.0L) ELECTRONIC FAN CLUTCH CTRL EXC 6.0L EXCEPT 6.0L EXCEPT 6.0L 6.0L FRONT FUNCTION SELECTOR SWITCH ASSEMBLY FRONT HEATER BLOWER MOTOR RESISTOR (AT REAR OF ENGINE COMPT) FUSE 10 FUSE 107 FUSE 23 FUSE 25 FUSE 27 FUSE 28 GRY WIRE GRY/WHT WIRE HEATER BLOWER MOTOR (AT RIGHT REAR SIDE OF ENGINE COMPT) HIGH MED LOW HOT AT ALL TIMES HOT IN HOT IN RUN HOT IN START OR RUN ILLUMINATION LT BLU WIRE LT BLU/PNK WIRE LT GRN WIRE LT GRN/WHT WIRE MIX FLOOR DEFROST OFF MODE SWITCH VENT NORMAL MAX MODE SELECTOR SWITCH MIX FLOOR DEFROST NCA WIRE OFF MODE SWITCH VENT NORMAL MAX OR RUN ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) REAR AIR CONDITIONING CIRCUIT (EXCURSION) RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE SIG RTN SOLID STATE SWITCH TAN WIRE TAN/LT GRN WIRE TEMPERATURE BLEND DOOR ACTUATOR TEMPERATURE CONTROL POTENTIOMETER VACUUM PUMP MOTOR (DIESEL) (IN RIGHT SIDE OF ENGINE COMPT) VIO WIRE VREF WHT WIRE WHT/VIO WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

168837 INSTRUMENT CLUSTER FOUR WHEEL DRIVE CONTROL MODULE 4 SPEED 5.4L/6.8L 6.0L 6.0L/7.3L 6.8L 5.4L ABS CONTROL MODULE RESTRAINTS CONTROL MODULE ACCELERATOR PEDAL POSITION SENSOR MAIN LIGHT SWITCH (W/ FOG LAMPS) AUXILIARY RELAY BOX 5 (LEFT REAR SIDE OF ENGINE COMPT) BLK) (OR YEL/ TAN/RED WIRE BLK/ YEL WIRE BLOWER MOTOR RELAY CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) COIL ON PLUG (COP) 10 COIL ON PLUG (COP) 2 COIL ON PLUG (COP) 1 COIL ON PLUG (COP) 4 COIL ON PLUG (COP) 3 IGNITION TRANSFORMER CAPACITOR 1 COIL ON PLUG (COP) 5 COIL ON PLUG (COP) 6 IGNITION TRANSFORMER CAPACITOR 2 COIL ON PLUG (COP) 7 COIL ON PLUG (COP) 8 COIL ON PLUG (COP) 9 (6.8L) DK BLU/LT GRN WIRE DK GRN WIRE ELECTRONIC FAN CLUTCH (6.0L) EXCEPT 6.0L EXCEPT 6.0L 6.0L FOG LAMP RELAY FROM FUSE 115 (DIAGRAM 2 OF 4) FUEL HEATER RELAY FUEL HEATER WASTE GATE SOLENOID FUSE 103 FUSE 107 FUSE 110 FUSE 116 FUSE 25 FUSE 26 FUSE 38 FUSE 43 FUSE 44 FUSE 45 FUSE 8 GRADE/ LOAD SWITCH GRN LT RED/ WIRE GRY/YEL WIRE IGNITION SWITCH INJECTOR DRIVER MODULE (IDM) INJECTOR DRIVER MODULE (IDM) POWER RELAY LOCK LOCK OFF LT GRN RED/ WIRE LT GRN WIRE LT GRN/VIO WIRE NCA WIRE OFF ORG DK BLU/ WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PARKING LAMP TRAILER TOW RELAY PASSIVE ANTI-THEFT TRANSCEIVER MODULE PASSIVE ANTI-THEFT TRANSCEIVER PCM POWER RELAY RED WIRE RED YEL/ WIRE RED/BLK WIRE RED/LT GRN WIRE RED/YEL WIRE REVERSING LAMP TRAILER TOW RELAY REVERSING LAMPS RELAY (LATE PRODUCTION) RUN WIRE TAN/RED WIRE TO FUSE 27 (DIAGRAM 4 OF 4) TO FUSE 31 (DIAGRAM 2 OF 4) TO FUSE 48 (DIAGRAM 2 OF 4) VIO WIRE WHT WIRE WHT/YEL WIRE YEL RED/ WIRE YEL WIRE YEL/ WHT WIRE