Ford Excursion I (1999-2005) diesel Wiring diagrams

A/C DEMAND SIG BLEND DOOR ACTUATOR BLEND DOOR ACTUATOR AIR BAG SLIDING CONTACT AMBIENT AIR TEMPERATURE SENSOR (ON LEFT FRONT OF ENGINE COMPT) AMBIENT TEMP BLEND DOOR SENSE + BLOW MOTOR RLY CONTROL BRN WIRE BRN/LT BLU WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) DIESEL DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK GRN/ORG (OR GRY/RED) WIRE DK GRN/ORG WIRE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (BEHIND CENTER OF DASH) FAN TEMP FAN SPEED (+) SPEED (-) (+) FUSE 28 FUSE 34 GASOLINE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN IGN IN CAR TEMP SENSOR SUNLOAD SENSOR SIG BLEND DOOR MONITOR IN-VEHICLE TEMPERATURE SENSOR (BEHIND LEFT SIDE OF DASH) LOGIC GND BLOWER SPEED CONTROL SIGNAL RETURN LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK/BLK WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) SIG RTN RED/LT GRN WIRE RED/WHT WIRE REMOTE SOLENOID ASSEMBLY REST REST REST SENSOR RETURN BLEND DOOR SIGNAL - SOLENOID ASSEMBLY SOLENOID ASSEMBLY SPEED CONTROL SERVO (IN RIGHT SIDE OF ENGINE COMPT) SIG RTN SPEED CONTROLLER STEERING WHEEL RADIO SWITCH TAN/WHT WIRE TEMP TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH) UBP DIAG VIO WIRE WHT WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/VIO WIRE YEL/LT GRN WIRE YEL/RED WIRE

5.4L, 6.8L 5.4L, 6.8L, 7.3L 6.0L 7.3L A/C CLUTCH SOLENOID A/C COMPRESSOR CLUTCH DIODE AIR FILTER SENSOR AUTO A/C BATTERY BATTERY 2 BATTERY CHARGE TRAILER TOW RELAY STARTER RELAY BLK WIRE BRAKE FLUID LEVEL SWITCH CRANKSHAFT POSITION SHIELD DATA LINK CONNECTOR (DLC) DAYTIME RUNNING LAMPS (DRL) RELAY 1 (6.0L) A/C CLUTCH SOLENOID DAYTIME RUNNING LAMPS (DRL) RELAY 2 DIESEL ENGINE COMPARTMENT LAMP FRONT BLOWER MOTOR SPEED CONTROLLER FRONT HEATER BLOWER MOTOR RESISTOR FUEL PUMP HORN LEFT FRONT FOG LAMP LEFT FRONT PARK/ TURN LAMP LEFT FRONT SIDE LAMP LEFT HEADLAMP LEFT TURN TRAILER TOW RELAY LEFT TURN TRAILER TOW RELAY RIGHT TURN TRAILER TOW RELAY LT BLU WIRE MAN A/C NCA WIRE ORG/ WIRE PARKING LAMP TRAILER TOW RELAY PCM POWER DIODE PCM POWER RELAY PNK PNK PNK PNK PNK PNK WIRE POWERTRAIN CONTROL MODULE (PCM) WINDSHIELD WIPER MOTOR RESTRAINTS CONTROL MODULE REVERSING LAMP TRAILER TOW RELAY RIGHT FRONT FOG LAMP RIGHT FRONT PARK/ TURN LAMP RIGHT FRONT SIDE LAMP RIGHT HEADLAMP RIGHT TURN TRAILER TOW RELAY SPEED CONTROL SERVO TRANSFER CASE HIGH TO LOW RELAY TRANSFER CASE LOW TO HIGH RELAY VACUUM PUMP MOTOR WHT WIRE YEL WIRE

AIR BAG SLIDING CONTACT AIR CONDITIONING SYSTEM BLK WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) DIESEL DK BLU WIRE DK GRN WIRE FUSE 37 GASOLINE GRY WIRE HORN HORN RELAY HOT AT ALL TIMES LT GRN WIRE NCA WIRE ORG/ WIRE POWERTRAIN CONTROL MODULE (ON LEFT SIDE OF FIREWALL) SIGNAL RETURN RED WIRE SPEED CONTROL SERVO (IN RIGHT SIDE OF ENGINE COMPT) SIGNAL RETURN STEERING WHEEL/ SPEED CONTROL SWITCH VEHICLE SECURITY MODULE (VSM) (BEHIND LEFT SIDE OF DASH) YEL WIRE

3 3 759 760 679 975 210 85 688 1332 158 1083 162 904 WARNING SYSTEM 4 DK 54 53 1269 2 12 45 39 INTERIOR LIGHTS SYSTEM 6.0L EXCEPT 6.0L AIR FILTER SENSOR (DIESEL) (ON LEFT SIDE OF ENGINE COMPARTMENT) ANTI-LOCK BRAKE SYSTEM ANTI-THEFT SYSTEM EXTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM BATTERY SAVER RELAY BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/YEL WIRE BLU WIRE BRAKE FLUID LEVEL SWITCH (ON BRAKE FLUID RESERVOIR) BRN WIRE BRN/LT BLU WIRE BRN/WHT WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) COMPUTER DATA LINES COMPUTER DATA LINES SYSTEM COOLANT TEMPERATURE SENSOR 2 (DIESEL) (AT TOP OF ENGINE, ON WATER PUMP) DEFOGGER SYSTEM DIESEL DK BLU/ORG WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE ELECTRONIC SUSPENSION SYSTEM EXCURSION EXCURSION PICKUP W/O REMOTE KEYLESS ENTRY FUEL TANK SELECTOR SWITCH FUEL TANK SELECTOR VALVE FUEL TANK UNIT EXCEPT CALIFORNIA FUSE 33 FUSE 35 FUSE 41 FUSE 45 GASOLINE GRN WIRE GRY/BLK WIRE GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN START OR RUN ILLUMINATION (6 BULBS) INSTRUMENT CLUSTER INTERIOR LAMPS RELAY LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED (OR RED/WHT) WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE MAIN LIGHT SWITCH MICROPROCESSOR NCA WIRE ORG/ WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE ORG/RED WIRE OVERHEAD CONSOLE PICKUP PNK WIRE PNK/LT BLU WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PRIMARY FUEL SENDER (ON FUEL TANK) RED WIRE RED/WHT WIRE RED/YEL WIRE SECONDARY FUEL SENDER (ON FUEL TANK) SPEED CONTROL SERVO (IN RIGHT SIDE OF ENGINE COMPT) STARTING/CHARGING SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM INTERIOR LIGHTS SYSTEM TAN WIRE TAN/LT GRN WIRE TAN/ORG WIRE TRANSMISSIONS SYSTEM TRIP COMPUTER MODULE (ON FRONT CENTER OF ROOF) W/ AUXILIARY FUEL TANK W/ ROOF OPENING PANEL W/O AUXILIARY FUEL TANK W/O ROOF OPENING PANEL WARNING SYSTEM WARNING SYSTEM DEFOGGER SYSTEM INTERIOR LIGHTS, POWER WINDOWS SYSTEM WHT WIRE WHT/LT BLU WIRE WHT/RED (OR BRN/ORG) WIRE WHT/RED WIRE YEL WIRE YEL/RED WIRE YEL/WHT WIRE