Ford Excursion I (1999-2005) brn/pnk Wiring diagrams

BRN/LT GRN WIRE BRN/PNK WIRE COOLING FAN SPEED SIG DK BLU WIRE ELECTRONIC FAN CLUTCH ELECTRONIC FAN CLUTCH CONTROL ENGINE COOLANT TEMPERATURE (ECT) SENSOR (ON TOP LEFT FRONT OF ENGINE) GRY/RED WIRE NCA WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) RED/ORG WIRE SIG RTN VREF YEL/BLK WIRE YEL/WHT WIRE

5.4L/6.8L 7.3L 6.0L 6.0L 8 16 A/C PRESS SW IN A/C PRESS SW IN A/C CLUTCH SOLENOID A/C COMPRESSOR CLUTCH DIODE A/C HIGH PRESSURE SWITCH (IN RIGHT SIDE OF ENGINE COMPT) 6.0L A/C PRESS SWITCH SIG RTN 18 69 PNK/ A/C CLUTCH RELAY WIRE BLK WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BLOWER MOTOR SWITCH BRN WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) COOLING FAN SPEED SIG DK BLU WIRE DUAL PRESSURE (6.0L) (AT FRONT OF ENGINE) ELECTRONIC FAN CLUTCH (6.0L) ELECTRONIC FAN CLUTCH CTRL EXC 6.0L EXCEPT 6.0L EXCEPT 6.0L 6.0L FRONT FUNCTION SELECTOR SWITCH ASSEMBLY FRONT HEATER BLOWER MOTOR RESISTOR (AT REAR OF ENGINE COMPT) FUSE 10 FUSE 107 FUSE 23 FUSE 25 FUSE 27 FUSE 28 GRY WIRE GRY/WHT WIRE HEATER BLOWER MOTOR (AT RIGHT REAR SIDE OF ENGINE COMPT) HIGH MED LOW HOT AT ALL TIMES HOT IN HOT IN RUN HOT IN START OR RUN ILLUMINATION LT BLU WIRE LT BLU/PNK WIRE LT GRN WIRE LT GRN/WHT WIRE MIX FLOOR DEFROST OFF MODE SWITCH VENT NORMAL MAX MODE SELECTOR SWITCH MIX FLOOR DEFROST NCA WIRE OFF MODE SWITCH VENT NORMAL MAX OR RUN ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) REAR AIR CONDITIONING CIRCUIT (EXCURSION) RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE SIG RTN SOLID STATE SWITCH TAN WIRE TAN/LT GRN WIRE TEMPERATURE BLEND DOOR ACTUATOR TEMPERATURE CONTROL POTENTIOMETER VACUUM PUMP MOTOR (DIESEL) (IN RIGHT SIDE OF ENGINE COMPT) VIO WIRE VREF WHT WIRE WHT/VIO WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

BLK WIRE BLK/PNK WIRE BRN/PNK WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE EXCURSION GROUND HOT IN RUN CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) FUSE 27 ISO LEFT CENTER SENSOR INPUT LEFT INNER PARKING AID SENSOR (ON REAR BUMPER, LEFT OF CENTER) LEFT OUTER PARKING AID SENSOR (ON LEFT SIDE OF REAR BUMPER) LEFT OUTER SENSOR INPUT LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE ON/OFF SWITCH ORG/ WIRE PARKING AID DISABLE SWITCH PARKING AID SPEAKER PICKUP PNK WIRE POWER RED WIRE REVERSE INPUT RIGHT CENTER SENSOR INPUT RIGHT INNER PARKING AID SENSOR (ON REAR BUMPER, RIGHT OF CENTER) RIGHT OUTER PARKING AID SENSOR (ON RIGHT SIDE OF REAR BUMPER) RIGHT OUTER SENSOR INPUT SENSOR GROUND SENSOR POWER SPEAKER STATUS LED VIO WIRE VIO/ORG WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL WIRE

A/C CLUTCH RELAY A/C CLUTCH RELAY ABS CONTROL MODULE ACCESSORY DELAY RELAY ADJUSTABLE PEDAL SWITCH AUXILIARY A/C RELAY AUXILIARY RELAY BOX 1 (BEHIND GLOVE BOX) AUXILIARY RELAY BOX 3 (LEFT REAR SIDE OF ENGINE COMPT) AUXILIARY RELAY BOX 4 AUXILIARY RELAY BOX 5 (LEFT REAR SIDE OF ENGINE COMPT) AUXILIARY RELAY BOX 5 (LEFT REAR SIDE OF ENGINE COMPT) BATTERY BATTERY II (6.0L/7.3L) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLU/ BLK WIRE BRAKE PEDAL POSITION SWITCH BRAKE PRESSURE SWITCH (5.4L/6.8L) BRN/PNK WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) CONSOLE POWER POINT DATA LINK CONNECTOR (DLC) DAYTIME RUNNING LAMPS RESISTOR DK BLU/ORG WIRE DK GRN/ ORG WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DRIVER SEAT MODULE DRIVER SIDE FRONT SEAT ADJUST SWITCH DVD PLAYER REAR INTEGRATED CONTROL PANEL POWER CHOKE 2 ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE EXCEPT 6.0L 6.0L EXTERIOR REAR VIEW MIRROR SWITCH FOUR WHEEL DRIVE CONTROL MODULE FROM FUSE 10 (DIAGRAM 1 OF 4) FROM FUSE 16 (DIAGRAM 1 OF 4) FRONT CIGAR LIGHTER FUSE 1 FUSE 10 FUSE 108 FUSE 11 FUSE 111 FUSE 114 FUSE 12 FUSE 13 FUSE 14 FUSE 15 FUSE 16 FUSE 17 FUSE 18 FUSE 19 FUSE 2 FUSE 3 FUSE 20 FUSE 21 FUSE 34 FUSE 4 FUSE 5 FUSE 6 FUSE 602 FUSE 7 FUSIBLE LINK A FUSIBLE LINK B INDICATOR FLASHER RELAY INJECTOR DRIVER MODULE (IDM) POWER RELAY INSTRU- MENT PANEL POWER POINT JUNCTION BLOCK LEFT "C" PILLAR) LEFT TURN TRAILER TOW RELAY LT BLU/ WHT WIRE LT BLU/BLK WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN/RED WIRE LT GRN/VIO WIRE MAIN LIGHT SWITCH MULTIFUNCTION SWITCH NCA WIRE ORG DK GRN/ WIRE ORG/ WIRE ORG/LT GRN WIRE ORG/YEL WIRE PASSENGER SIDE FRONT SEAT ADJUST SWITCH PASSIVE ANTI-THEFT TRANSCEIVER MODULE PNK/WHT WIRE POINT RADIO REAR POWER POINT REAR WIPER MOTOR ASSEMBLY RED WIRE RED/ LT GRN WIRE RED/LT BLU WIRE RIGHT TURN TRAILER TOW RELAY TAN/WHT WIRE TAN/YEL WIRE TO FUSE 12 (DIAGRAM 1 OF 4) TRANSFER CASE HIGH TO LOW RELAY TRANSFER CASE LOW TO HIGH RELAY VEHICLE SECURITY MODULE (VSM) VIO/ WHT WIRE VIO/WHT WIRE W/O VIDEO CASSETTE PLAYER VIDEO CASSETTE PLAYER WHT LT BLU/ WIRE WHT/ VIO WIRE WHT/VIO WIRE YEL WIRE YEL/BLK WIRE ``C" PILLAR POWER

360 76 1145 1143 570 1028 CUSTOMER ACCESS 570 322 CUSTOMER ACCESS A/C SYSTEM ANTI-THEFT SYSTEM BLK WIRE BLK/WHT WIRE BLU WIRE BRN/ORG WIRE BRN/PNK WIRE CCS CKP(+) CKP(-) PWR GND PWR GND DIAG GRD IGN COIL 1 IGN COIL 5 CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) COIL ON PLUG DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (DLC) (BEHIND LEFT SIDE OF DASH) 10 2 DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/ORG WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE DK LT EGR SOL CUST ACCESS FUSE FUSE 22 FUSE 23 GRN WIRE GRY WIRE GRY/RED WIRE HEGO 12 MAF TFT HOT AT ALL TIMES HOT AT ALL TIMES CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) FUSE 116 HOT IN RUN OR START IAT FUEL PUMP MON A/C PRESS SW NOT USED DATA OUTPUT IGN COIL 6 IGNITION TRANSFORMER CAPACITOR 1 IGNITION TRANSFORMER CAPACITOR 2 (ON REAR OF RIGHT CYL HEAD) KNOCK SENSOR VSS (-) LOCK OFF LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE LT LT PNK/ LT WIRE NCA WIRE O/D OFF IND ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH OVERHEAD CONSOLE PCM POWER DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PWR GND CUST ACCESS PWR GND IGN COIL 3 RED WIRE RED/LT GRN WIRE RED/YEL WIRE RUN WIRE SHIFT SOL 1 SHIFT SOL 2 TRANS CTRL IND REPROG PWR TAN WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TCS TO DTR SENSOR (DIAGRAM 4 OF 4) TO FUEL PUMP RELAY (DIAGRAM 2 OF 4) TRANSMISSION CONTROL SWITCH VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLK/ORG WIRE BLK/WHT WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) CRANKSHAFT POSITION (CKP) SENSOR (ON LOWER FRONT CENTER OF ENGINE) CRANKSHAFT POSITION SENSOR SHIELD DIFFERENTIAL PRESSURE FEEDBACK EGR (DPFE) SENSOR (CALIFORNIA) (AT TOP OF ENGINE) DK BLU WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE FEDERAL CALIFORNIA EXCEPT PICKUP PICKUP FROM PCM POWER RELAY (DIAGRAM 1 OF 4) FUEL PUMP RELAY FUEL TANK UNIT (CALIFORNIA) (AT FUEL TANK) FUSE 40 GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES LT BLU/ORG WIRE NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE TAN/LT BLU WIRE THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY) VIO/ORG WIRE WHT/RED WIRE YEL/WHT WIRE

A/C SYSTEM A/T AUTOMATIC TRANSMISSION MODULE (ON LEFT SIDE OF TRANSMISSION) BLK WIRE BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE BRN/YEL WIRE COAST CLUTCH SOLENOID DK BLU/YEL WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL SOLENOID EVR SOLENOID VALVE (CALIFORNIA) (ON LEFT SIDE OF ENGINE) FUEL INJECTORS GRN WIRE GRY WIRE GRY/RED WIRE GRY/WHT WIRE IDLE AIR CONTROL (IAC) VALVE (ON THROTTLE BODY ASSEMBLY) LT BLU WIRE LT BLU/ORG WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT LT M/T ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED (OSS) SENSOR (ON TOP OF TRANSMISSION EXTENSION HOUSING) PNK/LT BLU WIRE PNK/WHT WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED (TSS) SENSOR (ON TOP OF TRANSMISSION, AT CONVERTER HOUSING) VAPOR MANAGEMENT VALVE (ON RIGHT REAR OF ENGINE COMPT) VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE

6 14 2 DATA LINK CONNECTOR (DLC) (BEHIND LEFT SIDE OF DASH) A/C SYSTEM A/T AUXILIARY POWERTRAIN CONTROL MODULE (APCM) (BEHIND LEFT SIDE OF DASH) AUXILIARY RELAY BOX 5 (AT LEFT REAR SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRAKE PRESSURE SWITCH BRN/PNK WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) CLUTCH PEDAL POSITION (CPP) SWITCH (M/T) (ABOVE CLUTCH PEDAL) COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM CUST ACC TP SIG A/C CLUTCH INPUT SPEED CTRL IND CHASSIS GND DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE FUSE 103 FUSE 20 FUSE 34 FUSE 22 FUSE 24 GRADE/LOAD SWITCH (A/T) GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT AT ALL TIMES CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) FUSE 116 HOT IN INJECTOR DRIVER MODULE POWER RELAY LOCK OFF LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE M/T M/T A/T MASS AIRFLOW (MAF) SENSOR NCA WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE OVERHEAD CONSOLE STARTING/CHARGING SYSTEM PARK BRAKE SWITCH ABS CONTROL (ON PARK MODULE BRAKE ASSEMBLY) PCM POWER DIODE PCM POWER RELAY PNK/BLK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FENDER, NEAR BATTERY) PWR GND PTO CTRL RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE STARTING/ CHARGING SYSTEM CRUISE CONTROL SYSTEM TACH OUTPUT A/C CLUTCH RLY DATA OUTPUT LINK START RLY CTRL FUEL PMP RLY TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT (OR TAN/LT BLU) WIRE TAN/WHT WIRE TAN/YEL WIRE TO FUEL PUMP RELAY (DIAGRAM 2 OF 4) VIO WIRE WATER IN FUEL SENSOR (AT TOP RIGHT SIDE OF ENGINE) WHT RED/ WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 CHARGE MONITOR (IPR) CTRL GLOW PLUG SYS CHARGE MONITOR 360 33 357 359 70 553 878 COOLING FANS SYSTEM AIR CHARGE TEMPERATURE (ACT) SENSOR (CENTER FRONT OF ENGINE, IN INTAKE SYSTEM) BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BRN/LT GRN WIRE BRN/PNK WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR COOLING FANS SYSTEM CRANKSHAFT POSITION (CKP) SENSOR DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/YEL WIRE DK GRN/WHT WIRE EGR THRTL POS EGR VALVE ACTUATOR (AT TOP OF ENGINE) ELEC FAN CLTCH ENGINE COOLANT TEMPERATURE (ECT) SENSOR ENGINE OIL TEMPERATURE (EOT) SENSOR FAN SIG RTN EGR VALVE ACT EGR THRTL ACT SIG RTN FAN SPD SIG FOUR-WHEEL DRIVE CONTROL MODULE (BEHIND RIGHT SIDE OF DASH) GLOW PLUG SYS GRY WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE INJECTION EXHAUST BACK CONTROL PRESSURE PRESSURE SENSOR (ICP) SENSOR INJECTION PRESSURE REGULATOR INTERMEDIATE SHAFT SPEED SENSOR LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN/RED WIRE LT GRN/YEL WIRE NCA WIRE ORG/ WIRE ORG/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FENDER, NEAR BATTERY) RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE REF VOLT SPEED SENSOR ASSEMBLY STARTING/ CHARGING SYSTEM STARTING/ CHARGING SYSTEM 552 1086 1185 THROTTLE POSITION (TPS) SENSOR TURBINE SHAFT SPEED SENSOR TURBO VANE CTRL TURBO VANE CTRL EGR THRTL ACT VARIABLE GEOMETRIC TURBO ACTUATOR VIO/LT BLU WIRE VIO/ORG WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/YEL WIRE YEL WIRE YEL/RED WIRE YEL/WHT WIRE

570 322 CUSTOMER ACCESS A/C SYSTEM ANTI-THEFT SYSTEM BLK WIRE BLK/WHT WIRE BLU WIRE BRN/ORG WIRE BRN/PNK WIRE CCS CKP(+) CKP(-) PWR GND PWR GND CASE GND IGN COIL 1 IGN COIL 10 CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) COIL ON PLUG CUSTOMER ACCESS DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (DLC) (BEHIND LEFT SIDE OF DASH) 10 2 DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/ORG WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE DK LT LT EGR SOL CUST ACC 1 FUSE FUSE 22 FUSE 23 GRN WIRE GRY WIRE GRY/RED WIRE HEGO 12 MAF TFT HOT AT ALL TIMES HOT AT ALL TIMES CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) FUSE 116 HOT IN RUN OR START IAT FUEL PUMP MON A/C PRESS SW FUEL INJ 10 DATA OUTPUT IGN COIL 6 IGNITION TRANSFORMER CAPACITOR 1 KNOCK SENSOR VSS (-) LOCK OFF LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE NCA WIRE NOT USED O/D OFF IND ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH (A/T) OVERHEAD CONSOLE PCM POWER DIODE PCM POWER RELAY PNK LT WIRE PNK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PWR GND CUST ACC 1 PWR GND IGN COIL 5 RED WIRE RED/LT GRN WIRE RED/YEL WIRE RUN WIRE SHIFT SOL 1 SHIFT SOL 2 TRANS CTRL IND EPROM PWR TAN WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TCS TO DTR SENSOR (DIAGRAM 4 OF 4) TO FUEL PUMP RELAY (DIAGRAM 2 OF 4) TRANSMISSION CONTROL SWITCH VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE