Ford Escort V facelift (1991-1996) starting system Wiring diagrams

3 2 DATA LINK CONNECTOR BACKUP LAMPS BLK WIRE BLK/DK BLU WIRE BLK/LT GRN WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRAKE ON/OFF IN BRAKE ON/OFF SWITCH (1994) (ON BRAKE PEDAL SUPPORT) DATA LINK CONN DATA LINK CONN - DATA LINK CONN + DK BLU WIRE DK BLU/ORG WIRE DK BLU/RED WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/RED WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (TOP LEFT SIDE OF ENGINE) HOT AT ALL TIMES HOT IN START OR RUN I/P FUSE PANEL IGNITION SWITCH LOCK LOCK UP LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE MANUAL LEVER POSITION SWITCH (LEFT SIDE OF ENGINE, ON TOP OF TRANSAXLE) METER FUSE NCA WIRE NEAR FLOOR) ORG/ WIRE PARTIAL POWERTRAIN CONTROL MODULE (BELOW CENTER OF I/P) RED WIRE RED/BLK WIRE RED/DK BLU WIRE RED/DK GRN WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE SHFT SOL OUT #1 SHFT SOL OUT #3 SHFT SOL OUT #2 TCC SOL OUT SOLENOID CONTROL ASSEMBLY (LEFT SIDE OF ENGINE) SPEED CONTROL AMPLIFIER START IN (TP) SWITCH INPUT STARTING SYSTEM STOP FUSE STOP LAMP SWITCH (1993) THROTTLE POSITION SENSOR (TOP LEFT REAR OF ENGINE, ON THROTTLE BODY) TRANS RNGE-DRIVE IN TRANS RNGE-OD IN TRANS RNGE-LOW IN TRANSAXLE TRANSMISSION OIL TEMPERATURE SENSOR TURBINE SPEED SENSOR (LEFT SIDE OF ENGINE, ON TOP OF TRANSAXLE) VANE AIR FLOW METER (ON AIR CLEANER) VANE AIR FLOW METER IN VEH SPD SENS IN VEHICLE SPEED SENSOR (VSS) (LOWER REAR OF TRANSAXLE) VSS IN (-) TURBINE SPD SENS IN (-) WHT/BLK WIRE WHT/DK BLU WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/DK BLU WIRE YEL/DK GRN WIRE YEL/RED WIRE YEL/WHT WIRE

BACKUP LAMPS BLK WIRE BLK/DK BLU WIRE BLK/DK GRN WIRE BLK/LT GRN WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL OR WIRE BLK/YEL WIRE BRAKE ON/OFF IN VSS (-) (ECT) SENSOR DATA (-) MASS AIR FLOW SENSOR BRN/BLK WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/RED WIRE BRN/WHT WIRE CLUTCH/NEUTRAL INPUT DATA DATA LINK CONNECTOR DK BLU WIRE DK BLU/RED WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/RED WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ENGINE COMPT. FUSE BOX ENGINE COOLANT TEMPERATURE SENSOR (LEFT REAR OF ENGINE) FUEL INJECTOR FUSE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE PANEL (1993) ENGINE METER FUSE (1994) HOT IN START OR RUN I/P FUSE PANEL IGNITION SWITCH INSTRUMENT CLUSTER LOCK LOCK UP LT GRN/BLK WIRE LT GRN/DK BLU WIRE LT GRN/WHT WIRE MANUAL LEVER POSITION SWITCH (LEFT SIDE OF ENGINE, ON TOP OF TRANSAXLE) MASS AIR FLOW SENSOR SHFT SOL OUT #2 SHFT SOL OUT #3 METER FUSE NCA WIRE ORG/DK GRN WIRE PARTIAL PCM POWER RELAY (BELOW CENTER OF I/P) PNK/BLK WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (BELOW CENTER OF I/P) RED/DK BLU WIRE RED/DK GRN WIRE RED/WHT WIRE RED/YEL WIRE REF VOLT RUN WIRE SHFT SOL OUT #1 SOLENOID CONTROL ASSEMBLY STARTING SYSTEM STO/MIL TRANS RNGE-DRIVE IN STOP FUSE STOP LAMP SWITCH BRAKE ON/OFF SWITCH TCC SOL OUT THROTTLE POSITION SENSOR (TOP LEFT REAR OF ENGINE, ON TRANS OIL TEMP IN VSS (+) TRANS RNGE-OD IN TRANS RNGE-REVERSE IN TURBINE SPD SENS IN (+) TRANSAXLE TRANSMISSION OIL TEMPERATURE SENSOR TURBINE SPD SENS IN (-) TRANS RNGE-LOW IN SIGNAL RETURN THROTTLE POS SENSOR TURBINE SPEED SENSOR (LEFT SIDE OF ENGINE, ON TOP OF TRANSAXLE) VEHICLE SPEED SENSOR (VSS) (LOWER REAR OF TRANSAXLE) WHT WIRE WHT/BLK WIRE WHT/DK BLU WIRE WHT/DK GRN WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE YEL/DK BLU WIRE YEL/DK GRN WIRE

145 OHMS FULL 22 OHMS EMPTY ACTIVE CHIME IN DOOR SW IN BATTERY POWER 15 16 AIR BAG DIAGNOSTIC MONITOR (CENTER OF DASH BELOW RADIO) AIR BAG IND AIR BAG INDICATOR CONTROL ALTERNATOR ANTI/SLOSH/BULB PROVEOUT MODULE BACK/UP/ UPSHIFT SW BLK WIRE BLK/DK GRN WIRE BLK/ORG WIRE BLK/RED (OR BLK/DK GRN) WIRE BLK/YEL BLK/YEL WIRE BLK/YEL WIRE BRAKE FLUID LEVEL SW (IN MASTER CYLINDER RESERVOIR) BRAKE IND CHARGE IND CHECK COOLANT IND CHINE OUT CONN A CONN B CONN C CONTROL MODULE (PCM) (LEFT SIDE (BELOW CENTER OF ENGINE) OF I/P) COOLANT COOLANT LEVEL SW (IN TOP OF COOLANT RESERVOIR) DATA LINK CONNECTOR DK BLU WIRE DK BLU/RED WIRE DK BLU/WHT WIRE DK BLU/WT WIRE DK GRN WIRE DK GRN/BLK DK GRN/RED WIRE DK GRN/RED WIRE DK GRN/WHT WIRE DK GRN/WT WIRE DK GRN/YEL WIRE DOOR COURTESY LT SWS ENGINE COMPT. FUSE BOX FASTEN BELTS IND. FUEL CUTOUT IND FUEL GAUGE FUEL PUMP FUEL PUMP/FUEL GAUGE SENDER (IN FUEL TANK) FUEL SHUTOFF INPUT GROUND (SEDAN / RIGHT REAR CORNER OF TRUNK) (HATCH/WAGON / BELOW REAR SEAT) HAZARD LTS HEADLIGHTS HEADLIGHTS ON IN LEFT SEAT BELT SW IN HI-BEAM IND HOT HOT IN AT ALL TIMES OR RUN HOT IN I/P FUSE PANEL IGNITION SW ILLUMINATION LT ILLUMINATION LTS IND OUT INERTIA FUEL SHUTOFF SW INSTRUMENT INSTRUMENT CLUSTER JOINT CONN (BEHIND RIGHT SIDE OF I/P KEY IN IGNITION IN BELT IND OUT MODULE GROUND IGN SW ILLUM OUT (/) KEY IN IGNITION SW (PART OF IGNITION SW) LEFT SEAT BELT BUCKLE SW LEFT TURN IND LIFTGATE LATCH SW LIFTGATE MALFUNCTION/ AJAR CHECK ENG IND IND LT GRN WIRE LT GRN/RED 154 WIRE LUGGAGE COMPARTMENT LT METER OHMS OIL PRES IND OIL PRES SW (LOWER REAR OF ENGINE) OR RUN PANEL DIMMING MODULE PARK BRAKE SW (ON PARK BRAKE ASSEMBLY) PARK LT RELAY POWERTRAIN RED WIRE RED/BLK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN IND ROOM METER SIL STARTING SYSTEM STO/MIL SWITCHED POWER TAN WIRE TAPED TO HARNESS NEAR GROMMET) TEMP GAUGE TEMP SENDER TURN UPSHIFT IND (M/T) WAGON ONLY WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK 129 WIRE YEL/BLK WIRE YEL/DK GRN WIRE YEL/RED WIRE YEL/WHT WIRE

* PREMIUM SOUND 1.8L 40A (EX 1.8L) A/C 20A (1.8L) 10A (EX 1.8L) A/C RELAY AIR ABS BAG ALTERNATOR AM/FM RADIO/ STEREO CD PLAYER BATTERY BLK WIRE BLK/DK BLU WIRE BLK/DK GRN WIRE BLK/RED WIRE BLK/WHT WIRE BTN 60A (1.8L) CIGAR CIGAR LIGHTER I/P COOLING COOLING FAN AIR BAG ABS HI SPEED DIAGNOSTIC MAIN RELAY MODULE RELAY (1.8L A/T) COOLING FAN POWER RELAY (1.9L) COOLING FAN RELAY (1.8L M/T) DAYTIME RUNNING LIGHTS MODULE DK BLU WIRE DK BLU/BLK WIRE DK BLU/YEL WIRE DK GRN WIRE ELECTRONIC ELECTRONIC RADIO/ RADIO ELECTRONIC RADIO EX PREMIUM SOUND ENGINE COMPARTMENT FUSE BLOCK FUEL INJECTOR FUEL PUMP RELAY HEAD HEADLT RELAY HEATED OXYGEN SENSOR HORN RELAY I/P FUSE BLOCK HEGO I/P FUSE BLOCK RADIO I/P HORN FUSE PANEL (1.8L ONLY) IG 1 IGNITION SW IGNITION SYSTEM LOCK MAIN 80A (1.8L) 100A (EX 1.8L) MULTI/FUNCTION HEADLAMP SWITCH NOT USED ORG/DK BLU WIRE PCM POWER RELAY POWER CD PLAYER MIRROR SW RED WIRE RED YEL/ WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE ST IG 2 STARTER ASSEMBLY STARTING SYSTEM TO I/P FUSE BLOCK WHT WIRE WHT/DK GRN WIRE WHT/RED WIRE YEL RED/ WIRE YEL WIRE