Ford Econoline E350 Super Duty (1999-2012) hot in start or run Wiring diagrams

BATTERY BATTERY JUNCTION BOX (BJB) (AT LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (BJB) (AT LEFT SIDE OF ENGINE COMPT) FUSE 23 BATTERY VOLTAGE GAUGE BLK WIRE BLK/ORG WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CHARGE IND DK GRN WIRE EXCEPT STRIPPED CHASSIS FUSE 14 FUSE 18 FUSIBLE LINK A FUSIBLE LINK B (12 GA- GENERATOR HOT IN START OR RUN INSTRUMENT CLUSTER LT GRN/RED WIRE MICROPROCESSOR ORG/ WIRE ORG/LT BLU WIRE RED WIRE STARTER MOTOR (AT LOWER RIGHT REAR OF ENGINE) STRIPPED CHASSIS WHT WIRE WHT/BLK WIRE WHT/YEL WIRE YEL WIRE

1 4 5 18 16 17 6 28 47 48 49 50 10 5 45 28 44 61 29 60 VSOUT APPVREF APP APPRTN 24 27 34 30 RLC OD CNCL 28 40 27 52 BFP VREF 45 37 62 38 30 67 68 KAPWR PCMRC VPWR VPWR VPWR 5.4L 6.8L 6.8L 5.4L ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH, ABOVE ACCELERATOR PEDAL) BATTERY JUNCTION BOX (BJB) BLK/GRN WIRE BLU/BRN WIRE BLU/GRY WIRE BLU/RED WIRE BLU/WHT WIRE BRAKE FLUID PRESSURE TRANSDUCER BRN/GRN WIRE BRN/RED WIRE BRN/YEL WIRE ENGINE COMPT) ENGINE CONTROLS EXCEPT STRIPPED CHASSIS FUSE 35 FUSE 46 (LEFT FRONT OF ENGINE COMPT) FUSE 76 FUSE 75 FUSE 79 GND GND GND GND GND 22 69 70 50 GRN WIRE GRN/ORG WIRE GRN/WHT WIRE GRY/VIO WIRE HOT AT ALL TIMES HOT IN START OR RUN NCA WIRE OD OFF OVERDRIVE (EXCEPT FLEX FUEL) CANCEL SWITCH PCM POWER RELAY POWERTRAIN CONTROL MODULE (PCM) REVERSING LAMP RELAY RTN STRIPPED CHASSIS SYSTEM VIO/GRN WIRE VIO/ORG WIRE VIO/WHT WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/VIO WIRE

6 3 TCIL RLC 62 38 34 46 30 22 13 14 23 11 10 KAPWR PCMRC VPWRA VPWRB BATTERY JUNCTION BLK/GRN WIRE BLU/BRN WIRE BLU/RED WIRE BOX (BJB) (RIGHT FRONT OF ENGINE COMPT) BRN/GRN WIRE BRN/RED WIRE BRN/YEL WIRE CAN (+) COMPUTER DATA LINES COMPUTER DATA LINES SYSTEM DK GRN/ORG WIRE ENGINE CONTROLS SYSTEM FUSE 35 FUSE 46 FUSE 75 FUSE 76 FUSE 79 GRY/VIO WIRE HOT AT ALL TIMES HOT IN START OR RUN INSTRUMENT CLUSTER NCA WIRE OD CANCEL VSOUT CAN+ CAN- GND GND GND OD OFF OVERDRIVE CANCEL SWITCH PCM POWER RELAY POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF ENGINE COMPT) REVERSING LAMP RELAY SYSTEM VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/LT GRN WIRE YEL/BLU WIRE YEL/GRY WIRE

1 4 5 18 16 17 6 28 47 48 49 50 10 5 45 28 44 61 29 60 VSOUT APPVREF APP APPRTN 24 27 34 30 RLC OD CNCL 28 40 27 52 BFP VREF 45 37 62 38 30 67 68 KAPWR PCMRC VPWR VPWR VPWR 5.4L 6.8L 6.8L 5.4L ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH, ABOVE ACCELERATOR PEDAL) BATTERY JUNCTION BOX (BJB) BLK/GRN WIRE BLU/BRN WIRE BLU/GRY WIRE BLU/RED WIRE BLU/WHT WIRE BRAKE FLUID PRESSURE TRANSDUCER BRN/GRN WIRE BRN/RED WIRE BRN/YEL WIRE ENGINE COMPT) ENGINE CONTROLS EXCEPT STRIPPED CHASSIS FUSE 35 FUSE 46 (LEFT FRONT OF ENGINE COMPT) FUSE 76 FUSE 75 FUSE 79 GND GND GND GND GND 22 69 70 50 GRN WIRE GRN/ORG WIRE GRN/WHT WIRE GRY/VIO WIRE HOT AT ALL TIMES HOT IN START OR RUN NCA WIRE OD OFF OVERDRIVE (EXCEPT FLEX FUEL) CANCEL SWITCH PCM POWER RELAY POWERTRAIN CONTROL MODULE (PCM) REVERSING LAMP RELAY RTN STRIPPED CHASSIS SYSTEM VIO/GRN WIRE VIO/ORG WIRE VIO/WHT WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/VIO WIRE

6.8L 6.8L EXCEPT 6.8L ANTI-LOCK BRAKE SYSTEM (ABS) MODULE (LEFT FRONT OF ENGINE COMPT) BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLK/BLU WIRE BLK/GRY (OR BLK/BLU) WIRE BLK/GRY WIRE BLK/YEL WIRE BLU/BRN WIRE BLU/ORG WIRE BPS BRAKE FLUID SW BRAKE FLUID SW RTN BRAKE PEDAL POSITION SWITCH BRN/BLU WIRE BRN/GRN WIRE CAN (+) COMPUTER DATA LINES SYSTEM EXCEPT STRIPPED CHASSIS FUSE 33 FUSE 47 FUSE 53 FUSE 76 GRY/BRN WIRE GRY/VIO WIRE HOT AT ALL TIMES HOT IN START OR RUN ISS LEFT FRONT WHEEL SPEED SENSOR NCA WIRE OSS + OUTPUT SHAFT SPEED (OSS) SENSOR OUTPUT SHAFT SPEED (OSS) SENSOR (TORQSHIFT) (RIGHT REAR OF TRANSMISSION) POWERTRAIN CONTROL MODULE (PCM) (STRIPPED CHASSIS: CENTER REAR OF ENGINE COMPT) RED WIRE RIGHT FRONT WHEEL SPEED SENSOR (RIGHT FRONT WHEEL HUB ASSEMBLY) SIG RTN SMART JUNCTION BOX (SJB) STRIPPED CHASSIS TRANSMISSION TRANSMISSIONS SYSTEM TRGND TSS TURBINE SHAFT SPEED (TSS) SENSOR TURBINE SHAFT SPEED SENSOR VBATT VIO WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/WHT WIRE VPWR ABS ACTIVE VREF WHEEL SPD LF+ WHEEL SPD LF- WHEEL SPD RF+ WHEEL SPD RF- HS CAN + HS CAN - WHT WIRE WHT/BLU WIRE WHT/ORG WIRE WHT/RED WIRE WIRING HARNESS, NEAR BREAKOUT TO TORQSHIFT TRANS- MISSION) YEL WIRE YEL/GRY WIRE YEL/ORG WIRE

1 6 7 TC ON/OFF HS CAN- HS CAN+ 6.8L 6.8L EXCEPT 6.8L ABS TEST CONNECTOR (LEFT FRONT CORNER OF ENGINE COMPT) AUDIO CONTROL MODULE (ACM) BLK WIRE BLK/YEL WIRE BLU WIRE BPS BRAKE PEDAL POSITION SWITCH BRN WIRE BRN/BLU WIRE BRN/GRN WIRE CAN (+) COMPUTER DATA LINES SYSTEM EXCEPT STRIPPED CHASSIS FUSE 53 FUSE 76 GRN/VIO WIRE GRY WIRE GRY/BRN WIRE GRY/VIO WIRE HOT AT ALL TIMES BATTERY JUNCTION FUSE 47 BOX (BJB) (LEFT FRONT OF ENGINE COMPT) HOT IN START OR RUN INSTRUMENT PANEL CLUSTER (IC) ISS OSS + OUTPUT SHAFT SPEED (OSS) SENSOR OUTPUT SHAFT SPEED (OSS) SENSOR (TORQSHIFT) (RIGHT REAR OF TRANSMISSION) POWERTRAIN CONTROL MODULE (PCM) (STRIPPED CHASSIS: CENTER REAR OF ENGINE COMPT) RED WIRE SIG RTN SOLID STATE STEERING POSITION SENSOR (BOTTOM OF STEERING COLUMN) STRIPPED CHASSIS TRACTION CONTROL SWITCH TRANSMISSION TRANSMISSIONS SYSTEM TRGND TSS TURBINE SHAFT SPEED (TSS) SENSOR TURBINE SHAFT SPEED SENSOR VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VREF WHT WIRE WHT/BLU WIRE WHT/ORG WIRE WHT/RED WIRE WIRING HARNESS, NEAR BREAKOUT TO TORQSHIFT TRANS- MISSION) YEL/GRY WIRE YEL/ORG WIRE

6.8L 6.8L EXCEPT 6.8L BATTERY CHARGE TRAILER TOW RELAY BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF FUSE 58 ENGINE COMPT) BLK WIRE BLK/VIO WIRE BLU WIRE BLU/BRN WIRE BPP BPP GND RUN START BPS BRAKE PEDAL POSITION SWITCH BRAKE PEDAL SW BRN WIRE BRN/RED WIRE CLASS I CLASS II COMPUTER DATA LINES SYSTEM CTSY FUSE 30 FUSE 33 FUSE 48 FUSE 57 FUSE 63 FUSE 18 FUSE 76 GRN WIRE GRY WIRE GRY/BRN WIRE GRY/VIO WIRE HIGH MOUNTED STOPLAMP HOT AT ALL TIMES HOT IN RUN HOT IN RUN AND START HOT IN START OR RUN HOT W/ REVERSING LAMP RELAY ENGAGED HS CAN + HS CAN - LEFT TURN/STOP TRAILER TOW RELAY MODIFIED VEHICLE OFF ORG/ WIRE PARKING LAMP TRAILER TOW RELAY POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF ENGINE COMPT) PWR RED WIRE RIGHT TURN/STOP TRAILER TOW RELAY SMART JUNCTION BOX (SJB) (LEFT KICK PANEL) TRAILER BRAKE TRAILER BRAKE CONTROL (TBC) MODULE (TOP CENTER OF DASH) TRAILER TOW CONNECTOR (4-PIN) (IF EQUIPPED) (UNDER REAR BUMPER) TRAILER TOW CONNECTOR (7-PIN) (IF EQUIPPED) (UNDER REAR BUMPER) VIO WIRE VIO/ORG WIRE VIO/WHT WIRE W/ CREW CHIEF WHT WIRE WHT/BLU WIRE WHT/BRN WIRE YEL WIRE YEL/GRN WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 VPWR REAR SOUNDER + MS CAN+ GND BLK/BLU WIRE BLU/GRN WIRE BLU/WHT WIRE BRN/BLU WIRE COMPUTER DATA LINES SYSTEM FUSE 35 GRN/WHT WIRE GRY/ORG WIRE HOT IN START OR RUN INNER LEFT PARKING AID SENSOR (LEFT SIDE OF REAR BUMPER) INNER RIGHT PARKING AID SENSOR (RIGHT SIDE OF REAR BUMPER) MS CAN + OUTER LEFT PARKING AID SENSOR (LEFT SIDE OF REAR BUMPER) OUTER RIGHT PARKING AID SENSOR (RIGHT SIDE OF REAR BUMPER) PARKING AID MODULE (PAM) (UNDER RIGHT SIDE OF DASH) REAR SOUNDER - SENSOR PWR SOLID STATE VIO/ORG WIRE WHT/ORG WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/ORG WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 VPWR REVERSE GND 1 6 VIDEO + VIDEO - 6 5 4 3 2 1 GND VIDEO - VIDEO + AUDIO CONTROL MODULE (ACM) BLK WIRE BLK/GRY WIRE BLU WIRE BLU/WHT WIRE BRN WIRE BRN/YEL WIRE FUSE HOT IN START OR RUN NCA WIRE REAR VIEW CAMERA (CENTER OF RIGHT REAR DOOR) REAR VIEW CAMERA DISPLAY MIRROR VIDEO SHLD VPWR VIDEO+ W/ NAVIGATION W/O NAVIGATION YEL/GRY WIRE

A/C CLUTCH RELAY BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF BLK WIRE BLK/GRY WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/GRY WIRE BLU/ORG WIRE BLU/RED WIRE BRN/BLU WIRE BRN/RED WIRE BRN/VIO WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (FRONT OF LEFT CYLINDER HEAD) CKP CYLINDER HEAD TEMPERATURE SENSOR (FRONT OF LEFT CYLINDER HEAD) ETC REF ETC RTN FUEL POWER MOTOR DIODE FUEL PUMP RELAY FUSE 43 FUSE 54 FUSE 35 FUSE 76 FUSE 79 FUSE 75 FUSE 77 GRN WIRE GRN/BRN WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/VIO WIRE HOT AT ALL TIMES HOT IN RUN OR HOT AT ALL TIMES HOT IN START OR RUN NCA WIRE PCM POWER RELAY RED WIRE REVERSING LAMP ENGINE COMPT) RELAY SHDRTN SIGRTN TACM+ UNIVERSAL HEATED OXYGEN VIO/BRN WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/GRY WIRE YEL/VIO WIRE