Ford Econoline E350 Super Duty (1999-2012) battery junction Wiring diagrams

6 3 TCIL RLC 62 38 34 46 30 22 13 14 23 11 10 KAPWR PCMRC VPWRA VPWRB BATTERY JUNCTION BLK/GRN WIRE BLU/BRN WIRE BLU/RED WIRE BOX (BJB) (RIGHT FRONT OF ENGINE COMPT) BRN/GRN WIRE BRN/RED WIRE BRN/YEL WIRE CAN (+) COMPUTER DATA LINES COMPUTER DATA LINES SYSTEM DK GRN/ORG WIRE ENGINE CONTROLS SYSTEM FUSE 35 FUSE 46 FUSE 75 FUSE 76 FUSE 79 GRY/VIO WIRE HOT AT ALL TIMES HOT IN START OR RUN INSTRUMENT CLUSTER NCA WIRE OD CANCEL VSOUT CAN+ CAN- GND GND GND OD OFF OVERDRIVE CANCEL SWITCH PCM POWER RELAY POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF ENGINE COMPT) REVERSING LAMP RELAY SYSTEM VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/LT GRN WIRE YEL/BLU WIRE YEL/GRY WIRE

1 2 3 4 5 6 7 8 9 10 11 DATA LINK CONN BPP SWITCH INPUT ABS CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) ABS IND. BATTERY JUNCTION BLK WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF DASH) DK GRN WIRE DK GRN/YEL WIRE EXCEPT DIESEL EXCEPT DIESEL, EXCEPT STRIPPED CHASSIS EXCEPT STRIPPED CHASSIS FUSE 1 FUSE 11 GROUND VBATT GROUND VBATT BRAKE IND CTRL HOT AT ALL TIMES HOT IN RUN INSTRUMENT CLUSTER LEFT FRONT SENSOR (LOW) RIGHT FRONT SENSOR (LOW) REAR SENSOR (LOW) LEFT FRONT WHEEL SPEED SENSOR (BEHIND LEFT FRONT WHEEL) LOW BRAKE FLUID LEVEL/ PARK BRAKE IND LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/YEL WIRE MICROPROCESSOR NCA WIRE ORG/YEL WIRE PNK WIRE REAR AXLE SPEED SENSOR (UNDER REAR OF VEHICLE, MOUNTED ON DIFFERENTIAL) RED WIRE RED/PNK WIRE RIGHT FRONT WHEEL SPEED SENSOR (BEHIND RIGHT FRONT WHEEL) STRIPPED CHASSIS STRIPPED CHASSIS DIESEL TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE WHT WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 DATA LINK CONN BPP SWITCH INPUT ABS CONTROL MODULE (AT LEFT SIDE OF ENGINE COMPT) ABS IND. BATTERY JUNCTION BLK WIRE BOX (BJB) (AT LEFT SIDE OF ENGINE COMPARTMENT) BRAKE FLUID LEVEL SWITCH (AT LEFT REAR OF ENGINE COMPT) BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF DASH) DIESEL EXCEPT DIESEL DK GRN WIRE FUSE 1 FUSE 11 FUSE 14 GRN WIRE GROUND VBATT GROUND VBATT BRAKE IND CTRL HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START INSTRUMENT CLUSTER LEFT FRONT SENSOR (LOW) RIGHT FRONT SENSOR (LOW) REAR SENSOR (LOW) LEFT FRONT WHEEL SPEED SENSOR (BEHIND LEFT FRONT WHEEL) LOW BRAKE FLUID LEVEL/ PARK BRAKE IND LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/YEL WIRE MICROPROCESSOR NCA WIRE ORG/YEL WIRE PNK WIRE RED WIRE RED/PNK WIRE RIGHT FRONT WHEEL SPEED SENSOR (BEHIND RIGHT FRONT WHEEL) TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE WHT WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

BATTERY JUNCTION BLK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DIESEL DIGITAL TRANSMISSION RANGE (DTR) SENSOR (A/T) (LEFT SIDE OF TRANSMISSION) DK GRN WIRE ENDS IN HARNESS EXCEPT DIESEL EXCEPT DIESEL, W/ AUXILIARY BATTERY FUSE 12 FUSE 21 HOT AT ALL TIMES HOT IN RUN ORG/ WIRE PNK WIRE RED WIRE REVERSING LAMP TRAILER TOW RELAY VIO WIRE W/ MODIFIED VEHICLE WHT WIRE YEL WIRE YEL/BLK WIRE

BATTERY CHARGE TRAILER TOW RELAY BATTERY JUNCTION BATTERY JUNCTION BOX (BJB) BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLU/RED WIRE BLU/WHT WIRE BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BRN/RED WIRE BRN/YEL WIRE DATA LINK CONNECTOR (DLC) DRIVER SIDE FRONT SEAT CONTROL SWITCH EXCEPT STRIPPED CHASSIS FROM FUSE 27 (DIAGRAM 6 OF 9) FROM FUSE 65 (DIAGRAM 3 OF 9) FUSE 74 FROM RUN/START RELAY (DIAGRAM 2 OF 9) FUSE 13 FUSE 19 FUSE 20 FUSE 36 FUSE 42 FUSE 43 FUSE 44 FUSE 68 FUSE 70 GRN WIRE GRN/RED WIRE GRY WIRE GRY/RED WIRE IGN SW IGNITION SWITCH LEFT SIDE OF DASH) (EXCEPT STRIPPED CHASSIS: LEFT KICK PANEL) LOCK LOCK OFF OFF RUN WIRE RUN/ FUSE 45 RUN/START IGN SW SMART JUNCTION BOX (SJB) (STRIPPED CHASSIS: STARTER RELAY STRIPPED CHASSIS TO SPLICE 132 (DIAGRAM 5 OF 9) TO UPFITTER RELAY 1 (DIAGRAM 9 OF 9) TO UPFITTER RELAY 2 (DIAGRAM 9 OF 9) TO UPFITTER SWITCH (DIAGRAM 9 OF 9) VIO WIRE VIO/GRN WIRE WHT/ORG WIRE WINDSHIELD (NOT USED) WIPER MOTOR WINDSHIELD WIPER RELAY YEL WIRE YEL/RED WIRE

4.6L, 5.4L 6.8L A/C CLUTCH RELAY BATTERY JUNCTION BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLU/BRN WIRE BLU/RED WIRE BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BRAKE PEDAL POSITION SWITCH BRN/RED WIRE COIL ON COIL ON PLUG PLUG (COP) 2 (COP) 1 COIL ON COIL ON PLUG PLUG (COP) 5 (COP) 4 COIL ON COIL ON PLUG PLUG (COP) 7 (COP) 8 COIL ON IGNITION PLUG TRANSFORMER (COP) 6 CAPACITOR 1 (6.8L) COIL ON PLUG (COP) 10 (6.8L) COIL ON PLUG (COP) 3 COIL ON PLUG (COP) 9 (6.8L) EVAP EGR CANISTER SYSTEM PURGE MODULE VALVE (ESM) (4.6L) EXCEPT 6.8L FROM FROM FUSE 35 (DIAGRAM 2 OF 9) FUSE 75 FUSE 76 FUSE 77 FUSE 78 FUSE 79 GRN WIRE GRY WIRE GRY/BLU WIRE GRY/VIO WIRE HEATED OXYGEN SENSOR IGNITION TRANSFORMER CAPACITOR 1 (4.6L, 5.4L) IGNITION TRANSFORMER CAPACITOR 2 (4.6L, 5.4L) MASS AIR FLOW/ INTAKE AIR TEMPERATURE (MAF/IAT) SENSOR OVERDRIVE TRANSMISSION CANCEL SWITCH (IF EQUIPPED) PCM POWER RELAY POWERTRAIN CONTROL MODULE (PCM) POWERTRAIN CONTROL MODULE (PCM) (4.6L, 5.4L) POWERTRAIN CONTROL MODULE (PCM) (6.8L) REVERSING LAMP RELAY SELECTOR NEUTRAL SWITCH WIRING HARNESS, NEAR BREAKOUT TO STRIPPED CHASSIS STRIPPED CHASSIS, CUTAWAY UNIVERSAL UNIVERSAL HEATED OXYGEN HEATED OXYGEN SENSOR SENSOR VIO WIRE VIO/WHT WIRE WHT WIRE YEL/BLU WIRE YEL/GRY WIRE

BATTERY JUNCTION BLK/BLU WIRE BLU WIRE BLU/ORG WIRE BRAKE PEDAL POSITION SWITCH BRAKE PEDAL SW BRAKE SHIFT INTERLOCK (STEERING COLUMN) BRN WIRE BSI CTRL (FET) DIGITAL TRANSMISSION RANGE (DTR) SENSOR FUSE GRN WIRE HOT AT ALL TIMES HOT AT ALL TIMES FUSE 5 HOT IN INSTRUMENT PANEL CLUSTER IPC ORG/ WIRE PARK DETECT SW RED WIRE SMART JUNCTION BOX (SJB) (LEFT KICK PANEL) STARTER BOX (BJB) RELAY (LEFT FRONT OF ENGINE COMPT) DIODE VBATT VIO WIRE WHT WIRE

BATTERY JUNCTION BLK WIRE BLK/BLU WIRE BLU WIRE BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BRN WIRE FRONT WASH 0 1 2 3 4 5 6 7 8 9 FUSE FUSE BOX (SJB) (LEFT SIDE OF DASH) GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR ACC MIST OFF INT 1 INT 2 INT 3 INT 4 INT 5 LOW HIGH WASH MULTI- FUNCTION SWITCH ORG/ WIRE RED WIRE SMART JUNCTION VIO WIRE WHT WIRE WINDSHIELD WIPER RELAY YEL WIRE

BATTERY JUNCTION BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE BLK/VIO WIRE BLU WIRE BLU/GRN WIRE BOX (BJB) (RIGHT FRONT OF ENGINE COMPT) BRN WIRE CMP-O DK BLU WIRE DK BLU/ORG WIRE DK GRN/LT GRN WIRE DK GRN/VIO WIRE FUEL INJECTOR 2 FUEL INJECTOR 3 (TOP OF RIGHT CYLINDER BANK) FUEL INJECTOR 4 FUEL INJECTOR 5 (TOP OF LEFT CYLINDER BANK) FUEL INJECTOR 6 FUEL INJECTOR 8 (TOP OF LEFT CYLINDER BANK) FUEL INJECTOR CONTROL MODULE (FICM) (LEFT REAR OF ENGINE COMPT) FUEL INJECTOR CONTROL MODULE POWER RELAY FUSE 21 FUSE 31 FUSE 81 FUSE FUSE SIG RTN GRN/VIO WIRE GROUND GROUND PCM RLY PCM RLY PCM RLY GRY/RED WIRE HOT AT ALL TIMES INJ + INJ + INJ + INJ + INJ + INJ + INJ + INJ + LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE NCA WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE ORG/YEL WIRE PCM RLY CKP-O PNK/YEL WIRE RED/BLK WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/YEL WIRE SHIELD TAN/LT GRN WIRE TAN/YEL WIRE VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/RED WIRE WHT/VIO WIRE YEL/LT GRN WIRE YEL/WHT WIRE