Ford Econoline E250 (1997-2012) yel/red Wiring diagrams

ABS SYSTEM, WARNING BUZZER MODULE BATTERY JUNCTION BOX BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) FUSE 9 BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BREAKOUT) BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 8 CHT VSS PWR IN GND GND TCIL EPC OSS MAF TPS VREF SIG RTN BPP GND CRUISE CONTROL SYSTEM CYLINDER HEAD TEMPERATURE SENSOR DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) 10 13 DIGITAL TRANSMISSION RANGE SENSOR DK BLU/YEL WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS ENGINE CONTROLS (ENG CONTROL HARN, NEAR BREAKOUT TO EXTERIOR LIGHTS FUSE 11 FUSE 2 FUSE 20 FUSE 4 GEN DATA DATA (-) DATA (+) GND SSA TCS MAF TFT MAF ECT GND TCC KAPWR GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION COIL, RADIO NOISE CAPACITOR INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP MASS AIRFLOW (MAF) SENSOR (TOP CENTER OF ENGINE COMPT) MULTIFUNCTION SWITCH, DEAVTIATOR SWITCH NCA WIRE OD OFF ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) OVERDRIVE CANCEL SWITCH PCM DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE SHIFT SOLENOIDS SPEEDOMETER SSA SSB TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE THROTTLE POSITION SENSOR (TPS) (ON TOP OF ENGINE, NEAR AIR INTAKE) TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/YEL WIRE W/ STRIPPED CHASSIS WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

ABS SYSTEM, WARNING BUZZER MODULE BATTERY JUNCTION BOX BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) FUSE 9 BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 8 CHT VSS PWR IN GND GND EPC OSS MAF TPS VREF SIG RTN BPP GND CRUISE CONTROL SYSTEM CYLINDER HEAD TEMPERATURE SENSOR DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) 10 13 DIGITAL TRANSMISSION RANGE SENSOR DK BLU/YEL WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS ENGINE CONTROLS (4.6L) (5.4L) ENGINE CONTROLS (ENG CONTROL HARN, NEAR BREAKOUT TO A/C PRESSURE CUTOUT SWITCH) EXTERIOR LIGHTS FUSE 11 FUSE 2 FUSE 20 FUSE 4 GND TCC KAPWR GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION COIL, RADIO NOISE CAPACITOR INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MAF TFT MAF ECT MALFUNCTION INDICATOR LAMP MASS AIRFLOW (MAF) SENSOR (TOP CENTER OF ENGINE COMPT) MULTIFUNCTION SWITCH, DEAVTIATOR SWITCH NCA WIRE OD OFF ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) OVERDRIVE CANCEL SWITCH PCM DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE SHIFT SOLENOIDS SPEEDOMETER SSA SSB TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE THROTTLE POSITION SENSOR (TPS) (ON TOP OF ENGINE, NEAR AIR INTAKE) TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

ABS SYSTEM, WARNING BUZZER MODULE BATTERY JUNCTION BOX BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) FUSE 9 BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 8 CHT VSS PWR IN GND GND EPC OSS MAF TPS VREF SIG RTN BPP GND CRUISE CONTROL SYSTEM CYLINDER HEAD TEMPERATURE SENSOR DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) 10 13 DIGITAL TRANSMISSION RANGE SENSOR DK BLU/YEL WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS ENGINE CONTROLS (4.6L) (5.4L) ENGINE CONTROLS (ENG CONTROL HARN, NEAR BREAKOUT TO A/C PRESSURE CUTOUT SWITCH) EXTERIOR LIGHTS FUSE 11 FUSE 2 FUSE 20 FUSE 4 GND TCC KAPWR GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION COIL, RADIO NOISE CAPACITOR INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MAF TFT MAF ECT MALFUNCTION INDICATOR LAMP MASS AIRFLOW (MAF) SENSOR (TOP CENTER OF ENGINE COMPT) MULTIFUNCTION SWITCH, DEAVTIATOR SWITCH NCA WIRE OD OFF ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) OVERDRIVE CANCEL SWITCH PCM DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE SHIFT SOLENOIDS SPEEDOMETER SSA SSB TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE THROTTLE POSITION SENSOR (TPS) (ON TOP OF ENGINE, NEAR AIR INTAKE) TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

ABS SYSTEM, WARNING BUZZER MODULE BATTERY JUNCTION BOX BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) FUSE 9 BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BREAKOUT) BRN/ORG WIRE BRN/WHT WIRE CC SOL TCS MAF TFT IAT ECT CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) CHT VSS PWR IN GND EPC MAF MAF TPS VREF SIG RTN BPP PWR IN GND COAST CLUTCH SOLENOID SHIFT SOLENOID CRUISE CONTROL SYSTEM CYLINDER HEAD TEMPERATURE SENSOR (TOP FRONT OF LEFT CYLINDER HEAD) DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) 10 13 DIGITAL TRANSMISSION RANGE SENSOR DK BLU/YEL WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS ENGINE CONTROLS (ENG CONTROL HARN, NEAR BREAKOUT TO ENGINE CONTROLS (NGV MODULE) EXTERIOR LIGHTS FUSE 11 FUSE 2 FUSE 20 FUSE 4 FUSE 8 GND TCC KAPWR TSS GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM INSTRUMENTATION ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT CENTER OF ENGINE) LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP MULTIFUNCTION SWITCH, DEACTIVATOR SWITCH NCA WIRE NGV TIMER OD OFF ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) OVERDRIVE CANCEL SWITCH PCM DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE SHIFT SOLENOID SPEEDOMETER TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE THROTTLE POSITION SENSOR (TPS) (ON TOP OF ENGINE, NEAR AIR INTAKE) TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED SENSOR (RIGHT SIDE OF TRANSMISSION) VIO WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 DATA LINK CONN BPP SWITCH INPUT 7.3L ABS CONTROL MODULE (AT LEFT SIDE OF ENGINE COMPT) ANTI-LOCK BRAKE INDICATOR BATTERY JUNCTION BOX (BJB) (IN LEFT FRONT OF ENGINE COMPARTMENT) BLK WIRE BRAKE FLUID LEVEL SWITCH (AT LEFT SIDE OF ENGINE COMPT) BRAKE PEDAL POSITION (BPP) SWITCH (ON BRACKET, ABOVE BRAKE PEDAL) BRAKE WARNING INDICATOR DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF DASH) DK GRN WIRE ELECTRONIC CRASH SENSOR (ECS) MODULE (BEHIND RIGHT SIDE OF DASH) FUSE 1 FUSE 11 FUSE 19 GRN WIRE GROUND VBATT GROUND VBATT BRAKE WARNING LAMP LOW HOT AT ALL TIMES HOT IN RUN IGNITION SWITCH INSTRUMENT CLUSTER LEFT FRONT SENSOR (LOW) RIGHT FRONT SENSOR (LOW) REAR SENSOR (LOW) LEFT FRONT WHEEL SPEED SENSOR (BEHIND LEFT FRONT WHEEL) LOCK OFF LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/YEL WIRE NCA WIRE PARKING BRAKE SWITCH (NEAR LEFT KICK PANEL) PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (NEAR BRAKE MASTER CYLINDER) RED WIRE RED/PNK WIRE RIGHT FRONT WHEEL SPEED SENSOR (BEHIND RIGHT FRONT WHEEL) RUN WIRE TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE VACUUM WARNING SWITCH VIO/WHT WIRE WHT WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

15 2 9 8 IND CTRL SW CAN+ CAN- 6 14 DATA LINK CONNECTOR (LEFT SIDE OF DASH) ABS IND. ABS TEST CONNECTOR (LEFT FRONT CORNER OF ENG COMPT) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/YEL WIRE BRAKE PRESSURE SWITCH (LEFT SIDE OF ENG COMPT) BRK PRESS SW CAN 2 HIGH CAN 2 LOW CAN LOW CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) CHASSIS GND COIL B+ CAN HIGH DK GRN WIRE FUSE 11 FUSE 19 FUSE 2 FUSE 22 FUSE 6 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR (BEHIND LEFT FRONT WHEEL) LT BLU/RED WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/YEL WIRE NCA WIRE ORG/ WIRE ORG/YEL WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RED WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT FRONT WHEEL SPEED SENSOR (BEHIND RIGHT FRONT WHEEL) STABILITY CONTROL SENSOR CLUSTER (CENTER OF FLOOR) STABILITY/ TRACTION CONTROL RELAY STABILITY/TRACTION CONTROL SWITCH STEERING ANGLE INPUT STEERING WHEEL ROTATION SENSOR (BOTTOM OF STEERING COLUMN) STOP LAMP SW TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE VBATT VPWR VPWR WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 DATA LINK CONN BPP SWITCH INPUT 7.3L ABS CONTROL MODULE (AT LEFT SIDE OF ENGINE COMPT) ANTI-LOCK BRAKE INDICATOR BATTERY JUNCTION BOX (BJB) (IN LEFT FRONT OF ENGINE COMPARTMENT) BLK WIRE BRAKE FLUID LEVEL SWITCH (AT LEFT SIDE OF ENGINE COMPT) BRAKE PEDAL POSITION (BPP) SWITCH (ON BRACKET, ABOVE BRAKE PEDAL) BRAKE WARNING INDICATOR DK GRN WIRE FUSE 1 FUSE 11 FUSE 19 GRN WIRE GROUND VBATT GROUND VBATT BRAKE WARNING LAMP LOW HOT AT ALL TIMES HOT IN RUN IGNITION SWITCH INSTRUMENT CLUSTER LEFT FRONT SENSOR (LOW) RIGHT FRONT SENSOR (LOW) REAR SENSOR (LOW) LEFT FRONT WHEEL SPEED SENSOR (BEHIND LEFT FRONT WHEEL) LOCK OFF LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/YEL WIRE NCA WIRE PARKING BRAKE SWITCH (NEAR LEFT KICK PANEL) PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (NEAR BRAKE MASTER CYLINDER) RED WIRE RED/PNK WIRE RIGHT FRONT WHEEL SPEED SENSOR (BEHIND RIGHT FRONT WHEEL) RUN WIRE TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE VIO/WHT WIRE WHT WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 (NOT USED) ANTI-THEFT SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM AIR CONDITIONING SYSTEM BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLU WIRE BLU/BRN WIRE BLU/RED WIRE BLU/WHT WIRE BRN/RED WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM DIM SW GND DIMMER SW DIODE DOME LP WHITE LIGHT (FET) EXCEPT STRIPPED CHASSIS FLOOR LAMP (FET) GRN WIRE GRN/BLU WIRE GRN/BRN WIRE GRN/RED WIRE GRN/WHT WIRE GRY WIRE GRY/ORG WIRE GRY/VIO WIRE GRY/YEL WIRE HEADLAMP OFF HAZARD HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM EXTERIOR LIGHTS SYSTEM HIGH BEAM HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN RUN HOT IN START IGNITION SWITCH INSTRUMENT CLUSTER SYSTEM INTERIOR LIGHTING (FET) LOCK NAVIGATION SYSTEM NOT USED NOT USED OFF POWER DISTRIBUTION SYSTEM RUN WIRE RUN/START IGN SW SOUND SYSTEMS SOUND SYSTEMS INSTRUMENT CLUSTER SYSTEM EXTERIOR LIGHTS SYSTEM STRIPPED CHASSIS SYSTEM (ABS) MODULE) TURN RIGHT HEADLAMP ON PARKLAMP ON VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/RED WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE YEL/GRY WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 RUN/START RELAY HIGH BEAM RELAY FOG LAMP RELAY ACCESSORY DELAY RELAY BATTERY PARK SAVER LAMP RELAY RELAY BLU/GRN WIRE BRAKE FLUID SW BRN/BLU WIRE BRN/VIO WIRE DOOR LOCK RELAY DRIVER DOOR UNLOCK RELAY EXTERIOR LIGHTS SYSTEM INSTRUMENT CLUSTER SYSTEM EXTERIOR LIGHTS SYSTEM FOG LAMP RELAY GRY/VIO WIRE HEADLIGHTS SYSTEM HIGH BEAM RELAY HORN RELAY HORN RELAY PARK LAMP RELAY HORNS SYSTEM EXTERIOR LIGHTS SYSTEM HOT AT ALL TIMES INSTRUMENT CLUSTER SYSTEM LEFT LOW BEAM LH CORNER LAMP (FET) LIFTGATE GLASS RELEASE RELAY NOT USED NOT USED POWER DISTRIBUTION SYSTEM POWER DISTRIBUTION SYSTEM WIPER/WASHER SYSTEM RED WIRE RIGHT LOW BEAM TPMS 3 (FET) TPMS 2 (FET) VIO WIRE VIO/WHT WIRE YEL WIRE YEL/GRY WIRE YEL/RED WIRE YEL/VIO WIRE

37 38 MS CAN + MS CAN - 5 6 HS CAN + HS CAN - 6.8L BATTERY JUNCTION BOX (BJB) BLK WIRE BLK/BLU WIRE BRN WIRE DATA LINK CONNECTOR (DLC) (LEFT SIDE OF DASH) EXCEPT 6.8L FEPS FUSE 42 (LEFT FRONT OF ENGINE COMPT) GRY/ORG WIRE HOT AT ALL TIMES HS CAN+ INSTRUMENT PANEL CLUSTER (IPC) MS CAN + POWERTRAIN CONTROL MODULE (PCM) (CENTER REAR OF ENGINE COMPT) SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) VIO/ORG WIRE WHT WIRE WHT/BLU WIRE YEL/RED WIRE