Ford Econoline E250 (1997-2012) tan Wiring diagrams

1 2 4.2L/4.6L 5.4L/6.8L 1 2 7 4 ANTI-LOCK IND RELAY CTRL BRAKE SWITCH BRAKE IND 4 WHEEL ANTI- LOCK BRAKES MODULE (ON LEFT FRONT FRAME RAIL) 45 12 9 ECT SIGNAL FUEL SIGNAL 1 2 AIR BAG IND ANTI-LOCK BRAKE IND ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING IND CHARGE IND CNG GAS CONN A CONN B CONN C CRUISE CONTROL DAYTIME RUNNING LAMPS MODULE (IN RIGHT FRONT OF ENGINE COMPARTMENT, NEAR HORNS) DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE DUAL BRAKE WARNING SWITCH (BOTTOM OF MASTER CYLINDER) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE ENGINE OIL PRESSURE GAUGE FASTEN SEATBELT IND FUEL PUMP MODULE (UNDER VEHICLE, IN FUEL TANK) FUSE 14 FUSE 2 FUSE 36 FUSE 4 GND IGNITION SWITCH GRY/BLK WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT AT ALL TIMES HOT IN PARK OR HEAD HOT IN RUN OR START INSTRUMENT CLUSTER INSTRUMENT ILLUMINATION INSTRUMENTATION ENGINE COOLANT TEMPERATURE SENSOR (ON FRONT OF ENGINE) INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF DASH) LEFT TURN IND LOW OIL PRESS/HI COOLANT TEMP IND LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MALFUNCTION (MIL) IND MIL IND OFF LOCK PARKING BRAKE SWITCH (NEAR LEFT KICK PANEL) PNK/LT GRN WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (NEAR BRAKE MASTER CYLINDER) PPL/WHT WIRE PPL/YEL WIRE RED WIRE RED/WHT WIRE RED/YEL WIRE RELAY (BEHIND CENTER OF DASH) RIGHT TURN IND RUN WIRE SPEEDO- METER STARTING/ CHARGING SYSTEM 608 1044 SUPPLEMENTAL RESTRAINTS SYSTEM TACHO- METER TAN WIRE TAN/LT GRN WIRE VANS, WAGONS CUTAWAYS VEHICLE SPEED SENSOR (UNDER VEHICLE, ON LEFT SIDE OF TRANS) VOLTMETER VSS SIGNAL W/ DRL W/O DRL WARNING SYSTEMS 603 932 WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

1 2 4.2L/4.6L 5.4L/6.8L 1 2 7 4 ANTI-LOCK IND RELAY CTRL BRAKE SWITCH BRAKE IND 4 WHEEL ANTI- LOCK BRAKES MODULE (ON LEFT FRONT FRAME RAIL) 45 12 9 ECT SIGNAL FUEL SIGNAL 1 2 AIR BAG IND ANTI-LOCK BRAKE IND ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING IND CHARGE IND CNG GAS CONN A CONN B CONN C CRUISE CONTROL DAYTIME RUNNING LAMPS MODULE (IN RIGHT FRONT OF ENGINE COMPARTMENT, NEAR HORNS) DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE DUAL BRAKE WARNING SWITCH (BOTTOM OF MASTER CYLINDER) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE ENGINE OIL PRESSURE GAUGE FASTEN SEATBELT IND FUEL PUMP MODULE (UNDER VEHICLE, IN FUEL TANK) FUSE 14 FUSE 2 FUSE 36 FUSE 4 GND IGNITION SWITCH GRY/BLK WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT AT ALL TIMES HOT IN PARK OR HEAD HOT IN RUN OR START INSTRUMENT CLUSTER INSTRUMENT ILLUMINATION INSTRUMENTATION ENGINE COOLANT TEMPERATURE SENSOR (ON FRONT OF ENGINE) INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF DASH) LEFT TURN IND LOW OIL PRESS/HI COOLANT TEMP IND LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MALFUNCTION (MIL) IND MIL IND OFF LOCK PARKING BRAKE SWITCH (NEAR LEFT KICK PANEL) PNK/LT GRN WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (NEAR BRAKE MASTER CYLINDER) PPL/WHT WIRE PPL/YEL WIRE RED WIRE RED/WHT WIRE RED/YEL WIRE RELAY (BEHIND CENTER OF DASH) RIGHT TURN IND RUN WIRE SPEEDO- METER STARTING/ CHARGING SYSTEM 608 1044 SUPPLEMENTAL RESTRAINTS SYSTEM TACHO- METER TAN WIRE TAN/LT GRN WIRE VANS, WAGONS CUTAWAYS VEHICLE SPEED SENSOR (UNDER VEHICLE, ON LEFT SIDE OF TRANS) VOLTMETER VSS SIGNAL W/ DRL W/O DRL WARNING SYSTEMS 603 932 WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

1 2 4.2L/4.6L 5.4L/6.8L 1 2 7 4 ANTI-LOCK IND RELAY CTRL BRAKE SWITCH BRAKE IND 4 WHEEL ANTI- LOCK BRAKES MODULE (ON LEFT FRONT FRAME RAIL) 45 12 9 ECT SIGNAL FUEL SIGNAL 1 2 AIR BAG IND ANTI-LOCK BRAKE IND ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING IND CHARGE IND CNG GAS CONN A CONN B CONN C CRUISE CONTROL DAYTIME RUNNING LAMPS MODULE (IN RIGHT FRONT OF ENGINE COMPARTMENT, NEAR HORNS) DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE DUAL BRAKE WARNING SWITCH (BOTTOM OF MASTER CYLINDER) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE ENGINE OIL PRESSURE GAUGE FASTEN SEATBELT IND FUEL PUMP MODULE (UNDER VEHICLE, IN FUEL TANK) FUSE 14 FUSE 2 FUSE 36 FUSE 4 GND IGNITION SWITCH GRY/BLK WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT AT ALL TIMES HOT IN PARK OR HEAD HOT IN RUN OR START INSTRUMENT CLUSTER INSTRUMENT ILLUMINATION INSTRUMENTATION ENGINE COOLANT TEMPERATURE SENSOR (ON FRONT OF ENGINE) INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF DASH) LEFT TURN IND LOW OIL PRESS/HI COOLANT TEMP IND LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MALFUNCTION (MIL) IND MIL IND OFF LOCK PARKING BRAKE SWITCH (NEAR LEFT KICK PANEL) PNK/LT GRN WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (NEAR BRAKE MASTER CYLINDER) PPL/WHT WIRE PPL/YEL WIRE RED WIRE RED/WHT WIRE RED/YEL WIRE RELAY (BEHIND CENTER OF DASH) RIGHT TURN IND RUN WIRE SPEEDO- METER STARTING/ CHARGING SYSTEM 608 1044 SUPPLEMENTAL RESTRAINTS SYSTEM TACHO- METER TAN WIRE TAN/LT GRN WIRE VANS, WAGONS CUTAWAYS VEHICLE SPEED SENSOR (UNDER VEHICLE, ON LEFT SIDE OF TRANS) VOLTMETER VSS SIGNAL W/ DRL W/O DRL WARNING SYSTEMS 603 932 WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

ANTENNA BLK WIRE BLK/LT GRN WIRE BRN/PNK WIRE BUTTON CONTACT CUTAWAYS DIMMER DK GRN/ORG WIRE FUSE 10 FUSE 22 FUSE 27 FUSE 3 GRY/LT BLU WIRE HINGED DOOR HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC I/P FUSE PANEL I/P FUSE PANEL FUSE 36 LEFT FRONT DOOR SPEAKER LEFT MID SPEAKER (W/ 6 SPEAKERS) LEFT REAR SPEAKER LT BLU WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE MAIN LIGHT SWITCH NCA WIRE NOT USED OFF HEAD PARK ORG/LT GRN WIRE ORG/RED WIRE RADIO RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT SPEAKER RIGHT MID SPEAKER (W/ 6 SPEAKERS) RIGHT MID SPEAKER (W/ 6 SPEAKERS) RIGHT REAR SPEAKER SLIDING DOOR TAN WIRE TAN/LT GRN WIRE TAN/YEL WIRE VANS, WAGONS WHT WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE

694 484 19 137 57 54 GROUND ILLUMINATION ILLUMINATION POWER GROUND MEMORY POWER ANTENNA BLK WIRE BLK/LT GRN WIRE BLK/WHT BLK/WHT WIRE BLK/WHT WIRE BUTTON CONTACT CUT- CUT- AWAYS AWAYS CUTAWAYS DIMMER FUSE 10 FUSE 3 FUSE 4 HINGED DOOR HOT AT ALL TIMES HOT IN RUN OR ACC I/P FUSE PANEL I/P FUSE PANEL FUSE 36 LEFT FRONT DOOR SPEAKER LEFT MID SPEAKER (W/ 6 SPEAKERS) LEFT REAR SPEAKER LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/YEL WIRE MAIN LIGHT SWITCH NCA WIRE NOT USED NOT USED OFF HEAD PARK ORG/BLK WIRE ORG/LT GRN WIRE PNK/LT BLU WIRE PNK/LT GRN PNK/LT GRN WIRE PNK/LT GRN WIRE RADIO RED WIRE RIGHT FRONT DOOR SPEAKER RIGHT REAR SPEAKER (W/ 4/6 SPEAKERS) RIGHT RIGHT SIDE SPEAKER (W/ 6 SPEAKERS) RIGHT SIDE DOOR SPEAKER (W/ 6 SPEAKERS) SLIDING DOOR TAN WIRE VANS, VANS, WAGONS WAGONS VANS, WAGONS WHT WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE

694 484 19 137 57 54 GROUND ILLUMINATION ILLUMINATION POWER GROUND MEMORY POWER ANTENNA BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BUTTON CONTACT DIMMER FUSE 10 FUSE 3 FUSE 36 FUSE 4 GROUND ILLUMINATON HINGED DOOR HOT AT ALL TIMES HOT IN RUN OR ACC I/P FUSE PANEL LEFT FRONT DOOR SPEAKER LEFT REAR SPEAKER LEFT MID SPEAKER LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/YEL WIRE MAIN LIGHT SWITCH NCA WIRE OFF HEAD PARK ORG/BLK WIRE ORG/LT GRN WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE R REAR INPUT L REAR INPUT R REAR INPUT GROUND R REAR SPEAKER L REAR SPEAKER POWER RADIO RADIO RADIO RED WIRE REMOTE RADIO CONTROL RIGHT FRONT DOOR SPEAKER RIGHT REAR SPEAKER RIGHT RIGHT SIDE SPEAKER RIGHT SIDE DOOR SPEAKER SLIDING DOOR TAN WIRE WHT WIRE WHT/LT GRN WIRE WHT/PPL WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/PNK WIRE BRN/WHT WIRE BRN/YEL WIRE DK BLU/YEL WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE EGR VACUUM REGULATOR SOLENOID (ABOVE CENTER OF RIGHT VALVE COVER) ELECTRONIC PRESSURE CONTROL SOLENOID EVAP CANISTER PURGE VALVE (IN CENTER REAR OF ENGINE COMPT) EXCEPT STRIPPED CHASSIS FUEL INJECTORS GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE IDLE AIR CONTROL VALVE (RIGHT SIDE OF ENGINE, NEAR IGNITION COIL) LT BLU/ORG WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT LT NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) PNK/BLK WIRE PNK/WHT WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE SHIFT SOLENOIDS STRIPPED CHASSIS TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/LT GRN WIRE

240 OHMS A/C SYSTEM BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (ON FRONT CENTER OF ENGINE) CENTRAL JUNCTION BOX (BELOW LEFT SIDE OF DASH, NEAR LEFT KICK PANEL) DIGITAL TRANSMISSION RANGE (DTR) SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DPFE INPUT CHT INPUT CANISTER VENT VSS (+) A/C RLY CNTRL EVAPORATIVE EMISSIONS CANISTER VENT SOLENOID (REAR OF VEHICLE, NEAR FUEL TANK) FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 11 GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR 11 HEATED OXYGEN SENSOR 12 HEATED OXYGEN SENSOR 21 HEATED OXYGEN SENSOR 22 HEATER CTRL HOT AT ALL TIMES IAC CTRL OSS (-) CMP SENSOR INJ 5 CTRL INJ 3 CTRL INJ 1 CTRL GND GND IGN COIL TCIL FUEL PUMP CTRL EPC SOL INJ 6 CTRL INJ 4 CTRL INJ 2 CTRL LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE MAF SENS OUT TP SENS IN REF OUTPUT VOLT SIG RTN BRAKE ON/OFF MASS AIR FLOW SENSOR (ON TOP (CENTER OF ENGINE COMPT) NCA WIRE OVER- HEAD CONSOLE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (LEFT REAR OF ENGINE COMPT, NEAR MASTER CYLINDER) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/YEL WIRE TCC SOL KAP B(+) EVAP VALVE KNOCK SENSOR VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

BLK WIRE BLK/YEL WIRE BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/PNK WIRE BRN/WHT WIRE BRN/YEL WIRE DK BLU/YEL WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE EGR SOLENOID (ABOVE LEFT VALVE COVER, ON BRACKET) ELECTRONIC PRESSURE CONTROL SOLENOID EVAP CANISTER PURGE VALVE (IN CENTER REAR OF ENGINE COMPT) FUEL INJECTORS FUEL PUMP MODULE (IN FUEL TANK) GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE IDLE AIR CONTROL VALVE (REAR OF ENGINE, NEAR AIR INTAKE) IN TRANSIT FUEL PUMP MODULE (CUTAWAYS) (UNDER VEHICLE, ON LEFT FRAME RAIL) INERTIA FUEL SHUT-OFF SWITCH (BEHIND RIGHT KICK PANEL) LT BLU WIRE LT BLU/ORG WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT LT LT NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE SHIFT SOLENOIDS TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/WHT WIRE

240 OHMS A/C SYSTEM BLK/LT BLU WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (FRONT OF LEFT CYLINDER HEAD) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH, NEAR LEFT KICK PANEL) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DPFE SENS CYL HEAD TEMP EVAP SOL VSS (+) A/C RELAY CTRL ENDS IN HARNESS FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 11 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEATER CTRL HOT AT ALL TIMES IAC SOL OSS (+) CYLINDER ID LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MAF SENS IN TP SENS IN MASS AIR FLOW SENSOR (TOP CENTER OF ENGINE COMPT) NCA WIRE OVER- HEAD CONSOLE PNK/LT BLU WIRE PNK/WHT WIRE PWR GND COIL ON PLUG 2 RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE SIG RTN BRAKE ON/OFF TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TAN/YEL WIRE VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE