Ford Econoline E250 (1997-2012) (right side of transmission Wiring diagrams

ABS SYSTEM, WARNING BUZZER MODULE BATTERY JUNCTION BOX BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) FUSE 9 BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BREAKOUT) BRN/ORG WIRE BRN/WHT WIRE CC SOL TCS MAF TFT IAT ECT CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) CHT VSS PWR IN GND EPC MAF MAF TPS VREF SIG RTN BPP PWR IN GND COAST CLUTCH SOLENOID SHIFT SOLENOID CRUISE CONTROL SYSTEM CYLINDER HEAD TEMPERATURE SENSOR (TOP FRONT OF LEFT CYLINDER HEAD) DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) 10 13 DIGITAL TRANSMISSION RANGE SENSOR DK BLU/YEL WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS ENGINE CONTROLS (ENG CONTROL HARN, NEAR BREAKOUT TO ENGINE CONTROLS (NGV MODULE) EXTERIOR LIGHTS FUSE 11 FUSE 2 FUSE 20 FUSE 4 FUSE 8 GND TCC KAPWR TSS GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM INSTRUMENTATION ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT CENTER OF ENGINE) LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP MULTIFUNCTION SWITCH, DEACTIVATOR SWITCH NCA WIRE NGV TIMER OD OFF ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) OVERDRIVE CANCEL SWITCH PCM DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE SHIFT SOLENOID SPEEDOMETER TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE THROTTLE POSITION SENSOR (TPS) (ON TOP OF ENGINE, NEAR AIR INTAKE) TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED SENSOR (RIGHT SIDE OF TRANSMISSION) VIO WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

ABS SYSTEM, BRAKE PRESSURE SWITCH ABS SYSTEM, WARNING BUZZER MODULE BATTERY JUNCTION BOX BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) FUSE 9 BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BRN/ORG WIRE BRN/WHT WIRE CC SOL TCS VSS GND MAF TFT IAT CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) CHT PWR IN GND EPC MAF TPS VREF SIG RTN BPP PWR IN GND COAST CLUTCH SOLENOID SHIFT SOLENOID 2 CYLINDER HEAD TEMPERATURE SENSOR (TOP FRONT OF LEFT CYLINDER HEAD) DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) 10 13 DIGITAL TRANSMISSION RANGE SENSOR ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS ENGINE CONTROLS (ENG CONTROL HARN, NEAR BREAKOUT TO RADIO CAPACITOR 1) ENGINE CONTROLS (NGV MODULE) EXTERIOR LIGHTS FUSE 11 FUSE 2 FUSE 20 FUSE 4 FUSE 8 GND TCC KAPWR VSS GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER INTAKE AIR TEMPERATURE SENSOR (CENTER OF ENGINE COMPT, PART OF CLEAN AIR TUBE) LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP NCA WIRE NGV TIMER ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE RED WIRE RED/LT GRN WIRE SHIFT SOLENOID 1 TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL GEN DATA DATA (-) DATA (+) TCIL OD OFF THROTTLE POSITION SENSOR (TPS) (ON TOP OF ENGINE, NEAR AIR INTAKE) TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR VEHICLE SPEED SENSOR (LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE

ABS SYSTEM, WARNING BUZZER MODULE BATTERY JUNCTION BOX BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) FUSE 9 BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BRN/ORG WIRE BRN/WHT WIRE CC SOL TCS MAF TFT IAT ECT CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) CHT VSS PWR IN GND EPC MAF MAF TPS VREF SIG RTN BPP PWR IN GND COAST CLUTCH SOLENOID SHIFT SOLENOID CRUISE CONTROL SYSTEM CYLINDER HEAD TEMPERATURE SENSOR (TOP FRONT OF LEFT CYLINDER HEAD) DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE SENSOR DK BLU/YEL WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS ENGINE CONTROLS (ENG CONTROL HARN, NEAR BREAKOUT TO RADIO CAPACITOR 1) ENGINE CONTROLS (NGV MODULE) EXTERIOR LIGHTS FUSE 11 FUSE 2 FUSE 20 FUSE 4 FUSE 8 GND TCC KAPWR TSS GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM INSTRUMENTATION ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT CENTER OF ENGINE) LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP MULTIFUNCTION SWITCH, DEACTIVATOR SWITCH NCA WIRE NGV TIMER OD OFF ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) OVERDRIVE CANCEL SWITCH PCM DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE SHIFT SOLENOID SPEEDOMETER TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE THROTTLE POSITION SENSOR (TPS) (ON TOP OF ENGINE, NEAR AIR INTAKE) TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED SENSOR (RIGHT SIDE OF TRANSMISSION) VIO WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

2 3 6 11 12 13 15 16 20 24 29 33 34 MIL GND 36 37 39 49 MAF TFT IAT 51 54 55 58 64 66 71 77 81 88 89 90 GND TCC KAPWR VSS ABS SYSTEM, BRAKE PRESSURE SWITCH ABS SYSTEM, WARNING BUZZER MODULE BLK WIRE BLK/WHT WIRE BRN/ORG WIRE BRN/WHT WIRE CHT PWR IN GND EPC MAF TPS VREF SIG RTN BPP PWR IN GND COAST CLUTCH SOLENOID SHIFT SOLENOID 2 CYLINDER HEAD TEMPERATURE SENSOR (TOP FRONT OF LEFT CYLINDER HEAD) DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) 10 13 PPL DIGITAL TRANSMISSION RANGE SENSOR DK BLU/WHT WIRE DK GRN/YEL WIRE ENGINE COMPARTMENT FUSE BOX ENGINE COMPARTMENT FUSE BOX (LEFT FRONT OF ENGINE COMPT) FUSE 9 ENGINE CONTROLS ENGINE CONTROLS (ENG CONTROL HARN, NEAR BREAKOUT TO A/C PRESSURE CUTOUT SWITCH) FUSE 11 FUSE 2 FUSE 20 FUSE 4 GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE PANEL (BEHIND LEFT SIDE OF DASH) FUSE 8 INSTRUMENT CLUSTER INSTRUMENT CLUSTER (1998) INTAKE AIR TEMPERATURE SENSOR (CENTER OF ENGINE COMPT, PART OF CLEAN AIR TUBE) LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE MALFUNCTION INDICATOR LAMP NCA WIRE ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL/ORG WIRE PPL/YEL WIRE RADIO NOISE CAPACITORS, IGNITION COILS RED WIRE RED/LT GRN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL GEN DATA DATA (-) DATA (+) CC SOL GND TCS VSS GND PPL TCIL OD OFF THROTTLE POSITION SENSOR (TPS) (ON TOP OF ENGINE, NEAR AIR INTAKE) TORQUE CONVERTER CLUTCH SOLENOID VEHICLE SPEED SENSOR (LEFT SIDE OF TRANSMISSION) WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/LT GRN WIRE

240 OHMS A/C SYSTEM BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (ON FRONT CENTER OF ENGINE) CENTRAL JUNCTION BOX (BELOW LEFT SIDE OF DASH, NEAR LEFT KICK PANEL) DIGITAL TRANSMISSION RANGE (DTR) SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DPFE INPUT CHT INPUT CANISTER VENT VSS (+) A/C RLY CNTRL EVAPORATIVE EMISSIONS CANISTER VENT SOLENOID (REAR OF VEHICLE, NEAR FUEL TANK) FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 11 GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR 11 HEATED OXYGEN SENSOR 12 HEATED OXYGEN SENSOR 21 HEATED OXYGEN SENSOR 22 HEATER CTRL HOT AT ALL TIMES IAC CTRL OSS (-) CMP SENSOR INJ 5 CTRL INJ 3 CTRL INJ 1 CTRL GND GND IGN COIL TCIL FUEL PUMP CTRL EPC SOL INJ 6 CTRL INJ 4 CTRL INJ 2 CTRL LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE MAF SENS OUT TP SENS IN REF OUTPUT VOLT SIG RTN BRAKE ON/OFF MASS AIR FLOW SENSOR (ON TOP (CENTER OF ENGINE COMPT) NCA WIRE OVER- HEAD CONSOLE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (LEFT REAR OF ENGINE COMPT, NEAR MASTER CYLINDER) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/YEL WIRE TCC SOL KAP B(+) EVAP VALVE KNOCK SENSOR VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

240 OHMS A/C SYSTEM BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (ON FRONT CENTER OF ENGINE) CENTRAL JUNCTION BOX (BELOW LEFT SIDE OF DASH, NEAR LEFT KICK PANEL) DIGITAL TRANSMISSION RANGE (DTR) SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/PNK WIRE DPFE INPUT CHT INPUT CANISTER VENT VSS (+) A/C RLY CNTRL EVAPORATIVE EMISSIONS CANISTER VENT SOLENOID (REAR OF VEHICLE, NEAR FUEL TANK) FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 11 GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR 11 HEATED OXYGEN SENSOR 12 HEATED OXYGEN SENSOR 21 HEATED OXYGEN SENSOR 22 HEATER CTRL HOT AT ALL TIMES IAC CTRL OSS (-) CMP SENSOR INJ 5 CTRL INJ 3 CTRL INJ 1 CTRL GND GND IGN COIL TCIL FUEL PUMP CTRL EPC SOL INJ 6 CTRL INJ 4 CTRL INJ 2 CTRL LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE MAF SENS OUT TP SENS IN REF OUTPUT VOLT SIG RTN BRAKE ON/OFF MASS AIR FLOW SENSOR (ON TOP (CENTER OF ENGINE COMPT) NCA WIRE OVER- HEAD CONSOLE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (LEFT REAR OF ENGINE COMPT, NEAR MASTER CYLINDER) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/YEL WIRE TCC SOL KAP B(+) EVAP VALVE KNOCK SENSOR VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

240 OHMS BLK/LT GRN WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (FRONT OF LEFT CYLINDER HEAD) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DPFE SENS CYL HEAD TEMP EVAP SOL VSS (+) EXCEPT STRIPPED CHASSIS FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS IPS SENSOR FUSE 11 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEATER CTRL HOT AT ALL TIMES IAC SOL OSS (+) CYLINDER ID LT BLU WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MAF SENS IN TP SENS IN MASS AIR FLOW SENSOR (TOP CENTER OF ENGINE COMPT) NCA WIRE OVER- HEAD CONSOLE PNK/LT BLU WIRE PNK/WHT WIRE PWR GND COIL ON PLUG 2 RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE SIG RTN BRAKE ON/OFF STRIPPED CHASSIS TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TAN/YEL WIRE VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

240 OHMS A/C SYSTEM BLK/LT BLU WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (FRONT OF LEFT CYLINDER HEAD) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH, NEAR LEFT KICK PANEL) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DPFE SENS CYL HEAD TEMP EVAP SOL VSS (+) A/C RELAY CTRL ENDS IN HARNESS FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 11 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEATER CTRL HOT AT ALL TIMES IAC SOL OSS (+) CYLINDER ID LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MAF SENS IN TP SENS IN MASS AIR FLOW SENSOR (TOP CENTER OF ENGINE COMPT) NCA WIRE OVER- HEAD CONSOLE PNK/LT BLU WIRE PNK/WHT WIRE PWR GND COIL ON PLUG 2 RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE SIG RTN BRAKE ON/OFF TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TAN/YEL WIRE VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE