Ford Econoline E250 (1997-2012) lt grn Wiring diagrams

1 2 3 4 5 6 7 8 9 10 ON INDICATOR ACCEL SET/ AIR BAG SLIDING CONTACT BATTERY JUNCTION BOX (BJB) (IN LEFT FRONT OF ENGINE COMPARTMENT) BLK WIRE BLK/WHT WIRE BRAKE INPUT GROUND BRAKE PEDAL POSITION (BPP) SWITCH (ON BRACKET, ABOVE BRAKE PEDAL) BRAKE PRESSURE SWITCH (AT LEFT SIDE OF ENGINE COMPARTMENT) CENTRAL JUNCTION BOX (CJB) (LEFT SIDE OF DASH, NEAR KICK PANEL) COAST DK BLU WIRE DK GRN/ORG WIRE EXCEPT STRIPPED CHASSIS FUSE 11 FUSE 27 FUSE 6 GRY WIRE GRY/BLK WIRE HORN RELAY HORN SWITCH HOT AT ALL TIMES HOT IN INSTRUMENT CLUSTER LT BLU/BLK WIRE LT GRN WIRE LT GRN/RED WIRE MICROPROCESSOR NCA WIRE OFF ORG/ WIRE OVERHEAD CONSOLE PNK/ORG WIRE RED WIRE RED/LT GRN WIRE REMOTE KEYLESS ENTRY MODULE (BEHIND LEFT "B" PILLAR) RESUME RUN WIRE SPEED CONTROL INDICATOR SPEED CONTROL SERVO (LEFT SIDE OF ENGINE COMPT, NEAR BRAKE MASTER CYLINDER) SPEED CONTROL SWITCH VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE VSS INPUT BPP SW INPUT SCSA INPUT SCSA GND POWER YEL/LT BLU WIRE

1 2 4.2L/4.6L 5.4L/6.8L 1 2 7 4 ANTI-LOCK IND RELAY CTRL BRAKE SWITCH BRAKE IND 4 WHEEL ANTI- LOCK BRAKES MODULE (ON LEFT FRONT FRAME RAIL) 45 12 9 ECT SIGNAL FUEL SIGNAL 1 2 AIR BAG IND ANTI-LOCK BRAKE IND ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING IND CHARGE IND CNG GAS CONN A CONN B CONN C CRUISE CONTROL DAYTIME RUNNING LAMPS MODULE (IN RIGHT FRONT OF ENGINE COMPARTMENT, NEAR HORNS) DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE DUAL BRAKE WARNING SWITCH (BOTTOM OF MASTER CYLINDER) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE ENGINE OIL PRESSURE GAUGE FASTEN SEATBELT IND FUEL PUMP MODULE (UNDER VEHICLE, IN FUEL TANK) FUSE 14 FUSE 2 FUSE 36 FUSE 4 GND IGNITION SWITCH GRY/BLK WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT AT ALL TIMES HOT IN PARK OR HEAD HOT IN RUN OR START INSTRUMENT CLUSTER INSTRUMENT ILLUMINATION INSTRUMENTATION ENGINE COOLANT TEMPERATURE SENSOR (ON FRONT OF ENGINE) INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF DASH) LEFT TURN IND LOW OIL PRESS/HI COOLANT TEMP IND LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MALFUNCTION (MIL) IND MIL IND OFF LOCK PARKING BRAKE SWITCH (NEAR LEFT KICK PANEL) PNK/LT GRN WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (NEAR BRAKE MASTER CYLINDER) PPL/WHT WIRE PPL/YEL WIRE RED WIRE RED/WHT WIRE RED/YEL WIRE RELAY (BEHIND CENTER OF DASH) RIGHT TURN IND RUN WIRE SPEEDO- METER STARTING/ CHARGING SYSTEM 608 1044 SUPPLEMENTAL RESTRAINTS SYSTEM TACHO- METER TAN WIRE TAN/LT GRN WIRE VANS, WAGONS CUTAWAYS VEHICLE SPEED SENSOR (UNDER VEHICLE, ON LEFT SIDE OF TRANS) VOLTMETER VSS SIGNAL W/ DRL W/O DRL WARNING SYSTEMS 603 932 WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

4 WHEEL ANTI-LOCK BRAKES AIR BAG DIAGNOSTIC MONITOR (BEHIND RIGHT SIDE OF DASH) BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BUS - DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF DASH) FUSE 23 GEN SCAN IN HOT AT ALL TIMES I/P FUSE PANEL LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/RED WIRE ORG/ WIRE PNK/LT BLU WIRE RED WIRE TAN/ORG WIRE VIO WIRE WHT WIRE

1 2 4.2L/4.6L 5.4L/6.8L 1 2 7 4 ANTI-LOCK IND RELAY CTRL BRAKE SWITCH BRAKE IND 4 WHEEL ANTI- LOCK BRAKES MODULE (ON LEFT FRONT FRAME RAIL) 45 12 9 ECT SIGNAL FUEL SIGNAL 1 2 AIR BAG IND ANTI-LOCK BRAKE IND ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING IND CHARGE IND CNG GAS CONN A CONN B CONN C CRUISE CONTROL DAYTIME RUNNING LAMPS MODULE (IN RIGHT FRONT OF ENGINE COMPARTMENT, NEAR HORNS) DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE DUAL BRAKE WARNING SWITCH (BOTTOM OF MASTER CYLINDER) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE ENGINE OIL PRESSURE GAUGE FASTEN SEATBELT IND FUEL PUMP MODULE (UNDER VEHICLE, IN FUEL TANK) FUSE 14 FUSE 2 FUSE 36 FUSE 4 GND IGNITION SWITCH GRY/BLK WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT AT ALL TIMES HOT IN PARK OR HEAD HOT IN RUN OR START INSTRUMENT CLUSTER INSTRUMENT ILLUMINATION INSTRUMENTATION ENGINE COOLANT TEMPERATURE SENSOR (ON FRONT OF ENGINE) INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF DASH) LEFT TURN IND LOW OIL PRESS/HI COOLANT TEMP IND LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MALFUNCTION (MIL) IND MIL IND OFF LOCK PARKING BRAKE SWITCH (NEAR LEFT KICK PANEL) PNK/LT GRN WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (NEAR BRAKE MASTER CYLINDER) PPL/WHT WIRE PPL/YEL WIRE RED WIRE RED/WHT WIRE RED/YEL WIRE RELAY (BEHIND CENTER OF DASH) RIGHT TURN IND RUN WIRE SPEEDO- METER STARTING/ CHARGING SYSTEM 608 1044 SUPPLEMENTAL RESTRAINTS SYSTEM TACHO- METER TAN WIRE TAN/LT GRN WIRE VANS, WAGONS CUTAWAYS VEHICLE SPEED SENSOR (UNDER VEHICLE, ON LEFT SIDE OF TRANS) VOLTMETER VSS SIGNAL W/ DRL W/O DRL WARNING SYSTEMS 603 932 WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

1 2 4.2L/4.6L 5.4L/6.8L 1 2 7 4 ANTI-LOCK IND RELAY CTRL BRAKE SWITCH BRAKE IND 4 WHEEL ANTI- LOCK BRAKES MODULE (ON LEFT FRONT FRAME RAIL) 45 12 9 ECT SIGNAL FUEL SIGNAL 1 2 AIR BAG IND ANTI-LOCK BRAKE IND ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING IND CHARGE IND CNG GAS CONN A CONN B CONN C CRUISE CONTROL DAYTIME RUNNING LAMPS MODULE (IN RIGHT FRONT OF ENGINE COMPARTMENT, NEAR HORNS) DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE DUAL BRAKE WARNING SWITCH (BOTTOM OF MASTER CYLINDER) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE ENGINE OIL PRESSURE GAUGE FASTEN SEATBELT IND FUEL PUMP MODULE (UNDER VEHICLE, IN FUEL TANK) FUSE 14 FUSE 2 FUSE 36 FUSE 4 GND IGNITION SWITCH GRY/BLK WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT AT ALL TIMES HOT IN PARK OR HEAD HOT IN RUN OR START INSTRUMENT CLUSTER INSTRUMENT ILLUMINATION INSTRUMENTATION ENGINE COOLANT TEMPERATURE SENSOR (ON FRONT OF ENGINE) INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF DASH) LEFT TURN IND LOW OIL PRESS/HI COOLANT TEMP IND LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MALFUNCTION (MIL) IND MIL IND OFF LOCK PARKING BRAKE SWITCH (NEAR LEFT KICK PANEL) PNK/LT GRN WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (NEAR BRAKE MASTER CYLINDER) PPL/WHT WIRE PPL/YEL WIRE RED WIRE RED/WHT WIRE RED/YEL WIRE RELAY (BEHIND CENTER OF DASH) RIGHT TURN IND RUN WIRE SPEEDO- METER STARTING/ CHARGING SYSTEM 608 1044 SUPPLEMENTAL RESTRAINTS SYSTEM TACHO- METER TAN WIRE TAN/LT GRN WIRE VANS, WAGONS CUTAWAYS VEHICLE SPEED SENSOR (UNDER VEHICLE, ON LEFT SIDE OF TRANS) VOLTMETER VSS SIGNAL W/ DRL W/O DRL WARNING SYSTEMS 603 932 WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

2 3 6 11 12 13 15 16 20 24 29 33 34 MIL GND 36 37 39 49 MAF TFT IAT 51 54 55 58 64 66 71 77 81 88 89 90 GND TCC KAPWR VSS ABS SYSTEM, BRAKE PRESSURE SWITCH ABS SYSTEM, WARNING BUZZER MODULE BLK WIRE BLK/WHT WIRE BRN/ORG WIRE BRN/WHT WIRE CHT PWR IN GND EPC MAF TPS VREF SIG RTN BPP PWR IN GND COAST CLUTCH SOLENOID SHIFT SOLENOID 2 CYLINDER HEAD TEMPERATURE SENSOR (TOP FRONT OF LEFT CYLINDER HEAD) DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) 10 13 PPL DIGITAL TRANSMISSION RANGE SENSOR DK BLU/WHT WIRE DK GRN/YEL WIRE ENGINE COMPARTMENT FUSE BOX ENGINE COMPARTMENT FUSE BOX (LEFT FRONT OF ENGINE COMPT) FUSE 9 ENGINE CONTROLS ENGINE CONTROLS (ENG CONTROL HARN, NEAR BREAKOUT TO A/C PRESSURE CUTOUT SWITCH) FUSE 11 FUSE 2 FUSE 20 FUSE 4 GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE PANEL (BEHIND LEFT SIDE OF DASH) FUSE 8 INSTRUMENT CLUSTER INSTRUMENT CLUSTER (1998) INTAKE AIR TEMPERATURE SENSOR (CENTER OF ENGINE COMPT, PART OF CLEAN AIR TUBE) LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE MALFUNCTION INDICATOR LAMP NCA WIRE ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL/ORG WIRE PPL/YEL WIRE RADIO NOISE CAPACITORS, IGNITION COILS RED WIRE RED/LT GRN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL GEN DATA DATA (-) DATA (+) CC SOL GND TCS VSS GND PPL TCIL OD OFF THROTTLE POSITION SENSOR (TPS) (ON TOP OF ENGINE, NEAR AIR INTAKE) TORQUE CONVERTER CLUTCH SOLENOID VEHICLE SPEED SENSOR (LEFT SIDE OF TRANSMISSION) WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/LT GRN WIRE

BLK WIRE CENTRAL JUNCTION BOX LEFT SIDE OF DASH, NEAR KICK PANEL) ENTIRE SEAT FRONT DRIVER SIDE SEAT ADJUST SWITCH FRONT OF SEAT FUSE 16 FWD RWD HOT AT ALL TIMES LEFT POWER SEAT MOTOR ASSEMBLY LT BLU WIRE LT GRN WIRE NCA WIRE REAR OF SEAT RED WIRE UP DN WHT WIRE YEL WIRE

ANTENNA BLK WIRE BLK/LT GRN WIRE BRN/PNK WIRE BUTTON CONTACT CUTAWAYS DIMMER DK GRN/ORG WIRE FUSE 10 FUSE 22 FUSE 27 FUSE 3 GRY/LT BLU WIRE HINGED DOOR HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC I/P FUSE PANEL I/P FUSE PANEL FUSE 36 LEFT FRONT DOOR SPEAKER LEFT MID SPEAKER (W/ 6 SPEAKERS) LEFT REAR SPEAKER LT BLU WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE MAIN LIGHT SWITCH NCA WIRE NOT USED OFF HEAD PARK ORG/LT GRN WIRE ORG/RED WIRE RADIO RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT SPEAKER RIGHT MID SPEAKER (W/ 6 SPEAKERS) RIGHT MID SPEAKER (W/ 6 SPEAKERS) RIGHT REAR SPEAKER SLIDING DOOR TAN WIRE TAN/LT GRN WIRE TAN/YEL WIRE VANS, WAGONS WHT WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLU WIRE BRN WIRE BRN/LT BLU WIRE BUCKLE GND PRETEN- SWITCH SIONER CENTRAL JUNCTION BOX LEFT SIDE OF DASH, NEAR KICK PANEL) DK GRN WIRE DK GRN/LT GRN WIRE DRIVER SAFETY BELT RETRACTOR PRETENSIONER FASTEN SAFETY BELT IND FUSE 10 FUSE 2 FUSE 4 GRN WIRE HEAD HEADLAMPS ON DOOR OPEN SEAT BELT KEY IN IGNITION GROUND FASTEN BELTS POWER HOT AT ALL TIMES HOT IN RUN OR START IGNITION KEY SWITCH INSTRUMENT CLUSTER LEFT FRONT DOOR AJAR SWITCH LT GRN WIRE LT GRN/YEL WIRE LT LT LT MAIN LIGHT SWITCH MICRO- PROCESSOR, SAFETY BELT MINDER SPEAKER NCA WIRE OFF PARK PNK WIRE RED WIRE RED/PNK WIRE RED/YEL WIRE SUPPLEMENTAL RESTRAINTS SYSTEM TAN/WHT WIRE WARNING BUZZER/ CHIME MODULE (BEHIND CENTER OF DASH)

240 OHMS A/C SYSTEM BLK/LT BLU WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (FRONT OF LEFT CYLINDER HEAD) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH, NEAR LEFT KICK PANEL) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DPFE SENS CYL HEAD TEMP EVAP SOL VSS (+) A/C RELAY CTRL ENDS IN HARNESS FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 11 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEATER CTRL HOT AT ALL TIMES IAC SOL OSS (+) CYLINDER ID LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MAF SENS IN TP SENS IN MASS AIR FLOW SENSOR (TOP CENTER OF ENGINE COMPT) NCA WIRE OVER- HEAD CONSOLE PNK/LT BLU WIRE PNK/WHT WIRE PWR GND COIL ON PLUG 2 RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE SIG RTN BRAKE ON/OFF TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TAN/YEL WIRE VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE