Ford Econoline E250 (1997-2012) fuse 27 Wiring diagrams

24 45 8 REV LMP CTRL KAPWR BPP SW 27 1 4 5 6 16 17 18 28 47 48 49 50 10 OD CANCEL SW VSS APPA_+ 35 36 VPWR VPWR APPA_- APPB_+ APPB_- AUXILIARY RELAY BOX 1 (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) FUSE 23 BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DK BLU/WHT WIRE DK GRN WIRE DK GRN/ORG WIRE ENDS IN HARNESS ENGINE CONTROLS SYSTEM FUSE 11 FUSE 2 FUSE 21 FUSE 27 FUSE 8 GROUND GROUND GROUND GROUND GROUND GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN OR START LT GRN/RED WIRE NCA WIRE OD OFF OVERDRIVE CANCEL SWITCH OVERHEAD CONSOLE (IF EQUIPPED) PCM POWER DIODE PCM POWER RELAY RED WIRE RED/LT GRN WIRE RED/YEL WIRE REVERSING LAMP RELAY TAN WIRE TAN/WHT WIRE TAN/YEL WIRE W/ ADVANCE TRAC W/ REMOTE KEYLESS ENTRY OR ADVANCE TRAC W/ STRIPPED CHASSIS WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL/BLK WIRE

BATTERY JUNCTION BOX BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BRN/ORG WIRE BRN/WHT WIRE COAST CLUTCH SOLENOID CYLINDER HEAD TEMPERATURE SENSOR (ON TOP FRONT OF LEFT CYLINDER HEAD) DK BLU/YEL WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS SYSTEM FUSE 21 FUSE 27 GASOLINE GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) HOT IN RUN OR START CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 8 IGNITION COIL, RADIO NOISE CAPACITOR LT BLU/RED WIRE LT GRN WIRE NATURAL GAS VEHICLE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) PCM POWER DIODE PCM POWER RELAY RED WIRE SHIFT SOLENOID TAN/LT BLU WIRE THROTTLE POSITION SENSOR (TPS) (ON TOP OF ENGINE, NEAR AIR INTAKE) TORQUE CONVERTER CLUTCH SOLENOID SHIFT SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SENSOR (AT LEFT SIDE OF TRANSMISSION) VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE

35 36 IGNITION (ST/RUN) IGNITION (ST/RUN) 45 8 CLUSTER PWR BPP SW BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DK BLU/WHT WIRE DK GRN WIRE ENDS IN HARNESS ENGINE CONTROLS SYSTEM FUSE 11 FUSE 2 FUSE 21 FUSE 23 FUSE 27 FUSE 8 GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN OR START LT GRN/RED WIRE NCA WIRE OD OFF OVERDRIVE CANCEL SWITCH OVERHEAD CONSOLE (IF EQUIPPED) PCM POWER DIODE PCM POWER RELAY RED WIRE RED/LT GRN WIRE RED/YEL WIRE TAN WIRE TAN/WHT WIRE TAN/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL/BLK WIRE

BLK LT GRN/ WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COIL ON COIL ON COIL ON PLUG PLUG PLUG (COP) 7 (COP) 6 (COP) 8 COIL ON COIL ON PLUG PLUG (COP) 1 (COP) 2 COIL ON COIL ON PLUG PLUG IGNITION (COP) 4 (COP) 3 TRANSFORMER CAPACITOR 1 COIL ON PLUG (COP) 5 DIESEL DIESEL EXCEPT DIESEL DIGITAL TRANSMISSION RANGE (DTR) SENSOR DK GRN WIRE EXCEPT 6.8L 6.8L EXCEPT STRIPPED CHASSIS EXCEPT TORQSHIFT EXCEPT TORQSHIFT TORQSHIFT FROM IGNITION SWITCH (DIAGRAM 4 OF 5) FUEL HEATER FUEL INJECTOR CONTROL MODULE (FICM) FUSE 14 FUSE 2 FUSE 20 FUSE 27 FUSE 3 FUSE 33 FUSE 8 FUSE 9 FUSE 21 FUSE 15 I/P BODY BUILDER CONNECTOR INSTRUMENT CLUSTER LT BLU/PNK WIRE NCA WIRE PCM POWER DIODE PCM POWER RELAY PNK/LT GRN WIRE RADIO RED/BLK WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE RESTRAINTS CONTROL MODULE STRIPPED CHASSIS TAN/RED WIRE TORQSHIFT TOWN/ OVERDRIVE HAUL CANCEL SWITCH SWITCH VIO/ORG WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUM, FEED GROUND AUDIO UNIT BLK WIRE BLK/LT GRN WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CUTAWAY DK GRN/ORG WIRE EXCEPT CUTAWAY FUSE 22 FUSE 27 FUSE 3 GRY/LT BLU WIRE HINGED SIDE DOOR HOT AT ALL TIMES HOT IN HOT W/ ACCESSORY DELAY RELAY ENERGIZED LEFT FRONT SPEAKER LEFT MIDDLE SPEAKER (W/ 6 SPEAKERS) LEFT REAR SPEAKER LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/LT GRN WIRE ORG/RED WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT SPEAKER RIGHT MIDDLE SPEAKER (W/ 6 SPEAKERS) RIGHT REAR SPEAKER RIGHT SLIDING DOOR CONTACT SWITCH (AT RIGHT "B" PILLAR) SLIDING SIDE DOOR TAN/YEL WIRE TWISTED PAIR WIRES W/ 6 SPEAKERS W/ OVERHEAD CONSOLE WHT WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE

ANTENNA BLK WIRE BLK/LT GRN WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) (LEFT SIDE OF DASH, NEAR KICK PANEL) CUTAWAYS DK GRN/ORG WIRE FUSE 22 FUSE 27 FUSE 3 FUSE 36 GRY/LT BLU WIRE HINGED SIDE DOOR HOT AT ALL TIMES HOT IN HOT IN PARK OR HEAD HOT IN RUN OR ACC ILLUMINATION GROUND NOISE REDUCTION LEFT FRONT DOOR SPEAKER LEFT MID SPEAKER (W/ 6 SPEAKERS) LEFT REAR SPEAKER LT BLU WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE NCA WIRE NOT USED ORG/LT GRN WIRE ORG/RED WIRE RADIO RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT SPEAKER RIGHT MID SPEAKER (W/ 6 SPEAKERS) RIGHT MID SPEAKER (W/ 6 SPEAKERS) RIGHT REAR SPEAKER RIGHT SLIDING DOOR CONTACT SWITCH SLIDING SIDE DOOR TAN/YEL WIRE VANS, WAGONS WHT WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE

ANTENNA BARE BARE SHIELD SIGNAL SIGNAL SIGNAL SIGNAL BLK WIRE BLK/LT GRN WIRE BRN WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX LEFT SIDE OF DASH, NEAR KICK PANEL) DK GRN/ORG WIRE FUSE 22 FUSE 27 FUSE 3 FUSE 33 FUSE 36 FUSE 39 GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN HOT IN PARK OR HEAD HOT IN RUN OR ACC ILLUMINATION GROUND NOISE REDUCTION LEFT FRONT DOOR SPEAKER LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/YEL WIRE NCA WIRE ORG/ WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK 1 WIRE POWER POINT CONSOLE 1 POWER POINT CONSOLE 2 RADIO RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT SPEAKER SIGNAL SIGNAL SIGNAL TAN WIRE TAN/YEL WIRE WHT WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUM, FEED GROUND VPWR ANTENNA BLK WIRE BLK/LT GRN WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CUTAWAY DK GRN/ORG WIRE FUSE 22 FUSE 27 FUSE 3 FUSE 36 GRY/LT BLU WIRE HINGED SIDE DOOR HOT AT ALL TIMES HOT IN HOT IN PARK OR HEAD HOT IN RUN OR ACC LEFT FRONT SPEAKER LEFT MIDDLE SPEAKER (W/ 6 SPEAKERS) LEFT REAR SPEAKER LT BLU WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE NCA WIRE OF RIGHT SLIDING DOOR) TWISTED PAIR ORG/LT GRN WIRE ORG/RED WIRE RADIO RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT SPEAKER RIGHT REAR SPEAKER RIGHT RIGHT MIDDLE MIDDLE SPEAKER SPEAKER (W/ 6 (W/ 6 SPEAKERS) SPEAKERS) RIGHT SLIDING DOOR CONTACT SWITCH (IN FRONT SLIDING SIDE DOOR TAN/YEL WIRE TWISTED PAIR W/ OVERHEAD CONSOLE WHT WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUM, FEED GROUND VPWR 17 18 R RSE MODULE TO RADIO (+) R RSE MODULE TO RADIO (-) 19 20 L RSE MODULE TO RADIO (+) L RSE MODULE TO RADIO (-) ANTENNA ASYSON CORPORATE PROTOCOL (A) CORPORATE PROTOCOL (B) BLK WIRE BLK/LT GRN WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DK GRN/ORG WIRE FUSE 22 FUSE 27 FUSE 3 FUSE 36 GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN HOT IN PARK OR HEAD HOT IN RUN OR ACC LEFT FRONT SPEAKER LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE ORG/LT GRN WIRE ORG/RED WIRE PAIR RADIO RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT SPEAKER SHIELD TAN WIRE TAN/LT GRN WIRE TAN/WHT WIRE TAN/YEL WIRE TWISTED W/ OVERHEAD CONSOLE WHT WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE

20 16 6.8L 4.6L, 5.4L 6.8L BATTERY BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/GRY WIRE BLU WIRE BLU/RED WIRE BLU/WHT WIRE BRN/GRN WIRE CHARGING CIRCUIT DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DIODE EXCEPT STRIPPED CHASSIS EXCEPT STRIPPED CHASSIS STRIPPED CHASSIS FUSE 13 FUSE 27 GRN/ORG WIRE GRN/RED WIRE GRN/WHT WIRE GRY/RED WIRE HOT AT ALL TIMES HOT AT ALL TIMES BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) FUSE 36 IGNITION SWITCH LOCK OFF POWER DISTRIBUTION SYSTEM RED WIRE RUN WIRE SMC SMCS SMR STARTER MOTOR STARTER RELAY STRIPPED CHASSIS TORQSHIFT TRANSMISSION TRANSMISSION WHT WIRE YEL WIRE