Ford Econoline E150 (1997-2012) tan Wiring diagrams

24 45 8 REV LMP CTRL KAPWR BPP SW 27 1 4 5 6 16 17 18 28 47 48 49 50 10 OD CANCEL SW VSS APPA_+ 35 36 VPWR VPWR APPA_- APPB_+ APPB_- AUXILIARY RELAY BOX 1 (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) FUSE 23 BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DK BLU/WHT WIRE DK GRN WIRE DK GRN/ORG WIRE ENDS IN HARNESS ENGINE CONTROLS SYSTEM FUSE 11 FUSE 2 FUSE 21 FUSE 27 FUSE 8 GROUND GROUND GROUND GROUND GROUND GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN OR START LT GRN/RED WIRE NCA WIRE OD OFF OVERDRIVE CANCEL SWITCH OVERHEAD CONSOLE (IF EQUIPPED) PCM POWER DIODE PCM POWER RELAY RED WIRE RED/LT GRN WIRE RED/YEL WIRE REVERSING LAMP RELAY TAN WIRE TAN/WHT WIRE TAN/YEL WIRE W/ ADVANCE TRAC W/ REMOTE KEYLESS ENTRY OR ADVANCE TRAC W/ STRIPPED CHASSIS WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL/BLK WIRE

35 36 IGNITION (ST/RUN) IGNITION (ST/RUN) 45 8 CLUSTER PWR BPP SW BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DK BLU/WHT WIRE DK GRN WIRE ENDS IN HARNESS ENGINE CONTROLS SYSTEM FUSE 11 FUSE 2 FUSE 21 FUSE 23 FUSE 27 FUSE 8 GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN OR START LT GRN/RED WIRE NCA WIRE OD OFF OVERDRIVE CANCEL SWITCH OVERHEAD CONSOLE (IF EQUIPPED) PCM POWER DIODE PCM POWER RELAY RED WIRE RED/LT GRN WIRE RED/YEL WIRE TAN WIRE TAN/WHT WIRE TAN/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 DATA LINK CONN BPP SWITCH INPUT 7.3L ABS CONTROL MODULE (AT LEFT SIDE OF ENGINE COMPT) ANTI-LOCK BRAKE INDICATOR BATTERY JUNCTION BOX (BJB) (IN LEFT FRONT OF ENGINE COMPARTMENT) BLK WIRE BRAKE FLUID LEVEL SWITCH (AT LEFT SIDE OF ENGINE COMPT) BRAKE PEDAL POSITION (BPP) SWITCH (ON BRACKET, ABOVE BRAKE PEDAL) BRAKE WARNING INDICATOR DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF DASH) DK GRN WIRE ELECTRONIC CRASH SENSOR (ECS) MODULE (BEHIND RIGHT SIDE OF DASH) FUSE 1 FUSE 11 FUSE 19 GRN WIRE GROUND VBATT GROUND VBATT BRAKE WARNING LAMP LOW HOT AT ALL TIMES HOT IN RUN IGNITION SWITCH INSTRUMENT CLUSTER LEFT FRONT SENSOR (LOW) RIGHT FRONT SENSOR (LOW) REAR SENSOR (LOW) LEFT FRONT WHEEL SPEED SENSOR (BEHIND LEFT FRONT WHEEL) LOCK OFF LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/YEL WIRE NCA WIRE PARKING BRAKE SWITCH (NEAR LEFT KICK PANEL) PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (NEAR BRAKE MASTER CYLINDER) RED WIRE RED/PNK WIRE RIGHT FRONT WHEEL SPEED SENSOR (BEHIND RIGHT FRONT WHEEL) RUN WIRE TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE VACUUM WARNING SWITCH VIO/WHT WIRE WHT WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

1 1034 HORNS SYSTEM INTERIOR LIGHTS SYSTEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 (+/-) 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 VPWR VPWR 120 343 118 517 1205 INTERIOR LIGHTS SYSTEM BLK WIRE BLK/WHT WIRE BRN WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/LT GRN WIRE DOOR JAMP SW DOOR LOCK MOTOR DOOR LOCK SW DOOR LOCK SW RTN SIG DOOR LOCK MOTOR VBATT GND EXCEPT CUTAWAY FRONT PASSENGER WINDOW/DOOR LOCK SWITCH FUSE 10 FUSE 2 FUSE 23 HINGED SIDE DOOR HORN RELAY CTRL DOME LAMP SW HOT AT ALL TIMES HOT IN START OR RUN CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) INSTRUMENT CLUSTER ISO BUS LEFT FRONT DOOR LOCK ACTUATOR (AT REAR OF LEFT FRONT DOOR) LOCK LT BLU/WHT WIRE MASTER WINDOW/ DOOR LOCK/UNLOCK SWITCH NCA WIRE ORG/ WIRE PNK 1 WIRE PNK PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE REAR DOORS DOOR LOCK ACTUATOR (EXCEPT CUTAWAY) (AT LEFT SIDE OF RIGHT REAR DOOR) RED WIRE RED/ORG WIRE RED/PNK WIRE RED/YEL WIRE RIGHT SIDE DOOR LOCK ACTUATOR (AT REAR OF RIGHT SIDE HINGED DOOR) RIGHT SLIDING DOOR AJAR SWITCH (AT RIGHT "B" PILLAR) RIGHT SLIDING DOOR CONTACT SWITCH (AT RIGHT "B" PILLAR) SLIDING DOOR WIRE SLIDING SIDE DOOR TAN WIRE TAN/WHT WIRE UNLOCK VBATT VEHICLE SECURITY MODULE (VSM) (AT RIGHT KICK PANEL) WHT WIRE YEL WIRE

BLK WIRE BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/PNK WIRE BRN/WHT WIRE BRN/YEL WIRE DK BLU/YEL WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE EGR VACUUM REGULATOR SOLENOID (ABOVE CENTER OF RIGHT VALVE COVER) ELECTRONIC PRESSURE CONTROL SOLENOID EVAP CANISTER PURGE VALVE (IN CENTER REAR OF ENGINE COMPT) EXCEPT STRIPPED CHASSIS FUEL INJECTORS GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE IDLE AIR CONTROL VALVE (RIGHT SIDE OF ENGINE, NEAR IGNITION COIL) LT BLU/ORG WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT LT NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) PNK/BLK WIRE PNK/WHT WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE SHIFT SOLENOIDS STRIPPED CHASSIS TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/LT GRN WIRE

240 OHMS A/C SYSTEM BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (ON FRONT CENTER OF ENGINE) CENTRAL JUNCTION BOX (BELOW LEFT SIDE OF DASH, NEAR LEFT KICK PANEL) DIGITAL TRANSMISSION RANGE (DTR) SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DPFE INPUT CHT INPUT CANISTER VENT VSS (+) A/C RLY CNTRL EVAPORATIVE EMISSIONS CANISTER VENT SOLENOID (REAR OF VEHICLE, NEAR FUEL TANK) FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 11 GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR 11 HEATED OXYGEN SENSOR 12 HEATED OXYGEN SENSOR 21 HEATED OXYGEN SENSOR 22 HEATER CTRL HOT AT ALL TIMES IAC CTRL OSS (-) CMP SENSOR INJ 5 CTRL INJ 3 CTRL INJ 1 CTRL GND GND IGN COIL TCIL FUEL PUMP CTRL EPC SOL INJ 6 CTRL INJ 4 CTRL INJ 2 CTRL LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE MAF SENS OUT TP SENS IN REF OUTPUT VOLT SIG RTN BRAKE ON/OFF MASS AIR FLOW SENSOR (ON TOP (CENTER OF ENGINE COMPT) NCA WIRE OVER- HEAD CONSOLE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (LEFT REAR OF ENGINE COMPT, NEAR MASTER CYLINDER) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/YEL WIRE TCC SOL KAP B(+) EVAP VALVE KNOCK SENSOR VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/YEL WIRE BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE BRN/YEL WIRE DK BLU/YEL WIRE DK GRN/YEL WIRE EGR VACUUM REGULATOR SOLENOID (ABOVE LEFT VALVE COVER, ON BRACKET) ELECTRONIC PRESSURE CONTROL SOLENOID EVAP CANISTER PURGE VALVE (CENTER REAR OF ENGINE) EXCEPT STRIPPED CHASSIS FUEL INJECTORS FUEL PUMP FUEL PUMP DRIVER MODULE (UNDER REAR OF VEHICLE, NEAR TANK) GRN WIRE GRY WIRE GRY/RED WIRE GRY/WHT WIRE IDLE AIR CONTROL VALVE (REAR OF ENGINE, NEAR AIR INTAKE) LT BLU WIRE LT BLU/RED WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/YEL WIRE LT LT LT ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE SHIFT SOLENOIDS STRIPPED CHASSIS TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/WHT WIRE

240 OHMS BLK/LT GRN WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (FRONT OF LEFT CYLINDER HEAD) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DPFE SENS CYL HEAD TEMP EVAP SOL VSS (+) EXCEPT STRIPPED CHASSIS FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS IPS SENSOR FUSE 11 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEATER CTRL HOT AT ALL TIMES IAC SOL OSS (+) CYLINDER ID LT BLU WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MAF SENS IN TP SENS IN MASS AIR FLOW SENSOR (TOP CENTER OF ENGINE COMPT) NCA WIRE OVER- HEAD CONSOLE PNK/LT BLU WIRE PNK/WHT WIRE PWR GND COIL ON PLUG 2 RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE SIG RTN BRAKE ON/OFF STRIPPED CHASSIS TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TAN/YEL WIRE VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

BLK WIRE BLK/LT GRN WIRE BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE BRN/YEL WIRE COAST CLUTCH SOLENOID DK BLU/YEL WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL SOLENOID EVAP CANISTER PURGE VALVE (RIGHT REAR OF ENGINE) EXCEPT STRIPPED CHASSIS FUEL INJECTORS GRN WIRE GRY WIRE GRY/RED WIRE GRY/WHT WIRE LT BLU WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT LT LT ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/LT BLU WIRE PNK/WHT WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE SHIFT SOLENOID SHIFT SOLENOID A SHIFT SOLENOID B STRIPPED CHASSIS TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE

240 OHMS BLK/LT GRN WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (FRONT OF LEFT CYLINDER HEAD) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/WHT WIRE DPFE SENS CYL HEAD TEMP EVAP SOL VSS (+) EXCEPT STRIPPED CHASSIS FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS IPS SENSOR FUSE 11 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEATER CTRL HOT AT ALL TIMES IAC SOL OSS (+) CYLINDER ID LT BLU WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MAF SENS IN TP SENS IN MASS AIR FLOW SENSOR (TOP CENTER OF ENGINE COMPT) NCA WIRE OVER- HEAD CONSOLE PNK/LT BLU WIRE PNK/WHT WIRE PWR GND COIL ON PLUG 2 RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE SIG RTN BRAKE ON/OFF STRIPPED CHASSIS TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TAN/YEL WIRE TSS SENSOR VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE