Ford Econoline E150 (1997-2012) pnk/lt grn Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 ABS WARNING LAMP OUTPUT RELAY CTRL OUTPUT 1 2 POWER GROUND 14 15 16 17 18 19 20 21 22 23 24 POWER BPP SWITCH INPUT 4 WHEEL ANTI-LOCK 4-WHEEL ANTI- LOCK BRAKE SYSTEM RELAY (BEHIND CENTER OF DASH) ABS DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF DASH) ACCY ANTI-LOCK BRAKE INDICATOR BATTERY JUNCTION BOX (IN LEFT FRONT OF ENGINE COMPARTMENT) BLK WIRE BRAKE PEDAL POSITION (BPP) SWITCH (ON BRACKET, ABOVE BRAKE PEDAL) BRAKE WARN LAMP HIGH DATA LINK CONN BRAKE WARNING INDICATOR BRAKE WARNING LAMP LOW DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DK GRN WIRE DK GRN/YEL WIRE ELECTRONIC CRASH SENSOR (ECS) MODULE (BEHIND RIGHT SIDE OF DASH) FUSE 1 FUSE 11 FUSE 19 GRN WIRE HOT AT ALL TIMES IGNITION SWITCH INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR LOCK LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE OFF OHM 1600 PNK WIRE PNK/LT GRN WIRE REAR AXLE SPEED SENSOR REAR SENSOR (HIGH) RIGHT FRONT SENSOR (HIGH) LEFT FRONT SENSOR (HIGH) REAR SENSOR (LOW) RIGHT FRONT SENSOR (LOW) LEFT FRONT SENSOR (LOW) RED WIRE RED/PNK WIRE RIGHT FRONT WHEEL SPEED SENSOR RUN WIRE TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE VIO WIRE VIO/YEL WIRE WARNING SYSTEM WHT WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

** (5.4L, 6.8L) * (4.2L, 4.6L) 1 2 7 ANTI-LOCK IND RELAY CTRL BRAKE SWITCH 2 5 MIL IND BRAKE IND 45 ** 9 * 12 ECT SIGNAL FUEL SIGNAL 7.3L DIESEL ONLY AIR BAG ALL EXCEPT 7.3L DIESEL ALL WHEEL ANTI-LOCK BRAKE SYSTEM MODULE ANTI- SLOSH MODULE ANTI-LOCK BRAKE BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING CHARGE CHARGING CONN A CONN B CONN C CRUISE CONTROL DAYTIME RUNNING LAMPS MODULE DIESEL ONLY DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE DUAL BRAKE WARNING SWITCH (NEAR MASTER CYLINDER) ENGINE COOLANT TEMPERATURE GAUGE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF ENGINE) ENGINE OIL PRESSURE SWITCH (FRONT OF ENGINE) ENGINE OIL PRSSURE GAUGE EXTERIOR LIGHTS FASTEN BELTS OUTPUT FASTEN SEATBELT FUEL FILTER FUEL GAUGE FUEL PUMP MODULE (ON FUEL TANK) FUEL PUMP MODULE IN-TRANSIT FUEL PUMP MODULE (ON LEFT FRAME RAIL) FUEL WATER SWITCH (DIESEL) (TOP RIGHT FRONT OF ENGINE) FUSE 14 FUSE 2 FUSE 36 FUSE 4 GND IGNITION SWITCH GRY/BLK WIRE GRY/WHT WIRE HEADLIGHTS HIGH BEAM HOT AT ALL TIMES HOT IN PARK OR HEAD HOT IN RUN OR START INSTRUMENT ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LEFT TURN LOW VACUUM WARNING SWITCH (LEFT FRONT OF ENGINE COMPT) LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE MALFUNCTION (MIL) OFF LOCK PARKING BRAKE SWITCH (ABOVE BRAKE PEDAL) PLUGGED FUEL FILTER VACUUM SWITCH (TOP RIGHT SIDE OF ENG) PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE PPL/WHT WIRE PPL/YEL WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE RED/YEL WIRE RELAY (CENTER OF I/P) RIGHT TURN RUN WIRE SOLID STATE SPEEDOMETER SUPPLEMENTAL RESTRAINTS TAN/LT GRN WIRE VANS, WAGONS CUTAWAYS VEHICLE SPEED SENSOR (ON TRANSAXLE) VSS SIGNAL W/ DRL W/O DRL WAIT TO WAIT TO START WARNING BUZZER MODULE WATER IN FUEL WATER IN FUEL SENSOR (TOP LEFT CENTER OF ENGINE) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/RED WIRE YEL/WHT WIRE

** (5.4L, 6.8L) * (4.2L, 4.6L) 2 5 MIL IND BRAKE IND 45 ** 9 * 12 ECT SIGNAL FUEL SIGNAL 7 2 ANTI-LOCK IND BRAKE SWITCH 7.3L DIESEL ONLY AIR BAG ALL EXCEPT 7.3L DIESEL ANTI- SLOSH MODULE ANTI-LOCK BRAKE BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING CHARGE CHARGING CONN A CONN B CONN C CRUISE CONTROL DAYTIME RUNNING LAMPS MODULE DIESEL ONLY DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE DUAL BRAKE WARNING DIODE/ RESISTOR ASSEMBLY (LEFT SIDE OF I/P) DUAL BRAKE WARNING SWITCH (NEAR MASTER CYLINDER) ENGINE COOLANT TEMPERATURE GAUGE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF ENGINE) ENGINE OIL PRESSURE SWITCH (FRONT OF ENGINE) ENGINE OIL PRSSURE GAUGE EXTERIOR LIGHTS FASTEN BELTS OUTPUT FASTEN SEATBELT FUEL FILTER FUEL GAUGE FUEL PUMP MODULE (ON FUEL TANK) FUEL PUMP MODULE (ON FUEL TANK) IN-TRANSIT FUEL PUMP MODULE (ON LEFT FRAME RAIL) FUEL WATER SWITCH (DIESEL) (TOP RIGHT FRONT OF ENGINE) FUSE 14 FUSE 2 FUSE 36 FUSE 4 GND IGNITION SWITCH GRY/BLK WIRE GRY/WHT WIRE HEADLIGHTS HIGH BEAM HOT AT ALL TIMES HOT IN PARK OR HEAD HOT IN RUN OR START INSTRUMENT ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LEFT TURN LOW VACUUM WARNING SWITCH (LEFT FRONT OF ENGINE COMPT) LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE MALFUNCTION (MIL) OFF LOCK PARKING BRAKE SWITCH (ABOVE BRAKE PEDAL) PLUGGED FUEL FILTER VACUUM SWITCH (TOP RIGHT SIDE OF ENG) PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE PPL/WHT WIRE PPL/YEL WIRE REAR ANTI-LOCK BRAKE SYSTEM MODULE RED WIRE RED/BLK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN RUN WIRE SOLID STATE SPEEDOMETER SUPPLEMENTAL RESTRAINTS TAN/LT GRN WIRE VANS, WAGONS CUTAWAYS VEHICLE SPEED SENSOR (ON TRANSAXLE) VSS SIGNAL W/ DRL W/O DRL WAIT TO WAIT TO START WARNING BUZZER MODULE WATER IN FUEL WATER IN FUEL SENSOR (DIESEL) (TOP LEFT CENTER OF ENGINE) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/RED WIRE YEL/WHT WIRE

ABS DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF DASH) ACCY ANTI-LOCK BRAKE INDICATOR BLK WIRE BLK/ORG WIRE BRAKE PEDAL POSITION (BPP) SWITCH (ON BRACKET, ABOVE BRAKE PEDAL) BRAKE WARNING DIODE (MAIN HARNESS, BEHIND INSTRUMENT CLUSTER) CENTRAL JUNCTION BOX LEFT SIDE OF DASH, NEAR KICK PANEL) DK GRN WIRE DK GRN/YEL WIRE DUMP SOLENOID 1-3 OHMS FUSE 1 FUSE 11 FUSE 2 HOT AT ALL TIMES HOT IN RUN HOT IN START OR RUN IGNITION SWITCH INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM ISOLATION SOLENOID 3-6 OHMS LOCK LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/YEL WIRE OFF ORG/ WIRE PNK WIRE PNK/LT GRN WIRE RABS DIAGNOSTIC CONNECTOR (BELOW RIGHT SIDE OF DASH) REAR ANTI-LOCK BRAKE SYSTEM (RABS) MODULE (BEHIND CENTER OF DASH) REAR AXLE SPEED SENSOR (UNDER REAR OF VEHICLE, MOUNTED ON DIFFERENTIAL) RED WIRE RED/PNK WIRE RUN WIRE TAN WIRE TAN/LT GRN WIRE VALVE RESET SWITCH VIO/WHT WIRE YEL WIRE YEL/LT GRN WIRE

360 648 1145 1146 570 527 (ENDS IN HARNESS) AIR CONDITIONING SYSTEM BATTERY JUNCTION BLK/LT BLU WIRE BLK/WHT WIRE BLK/YEL WIRE BOX (LEFT FRONT OF ENGINE COMPT) BRN/PNK WIRE CENTRAL JUNCTION BOX (BELOW LEFT SIDE OF DASH, NEAR LEFT KICK PANEL) DATA LINK CONNECTOR (PARTIAL) (LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/YEL WIRE DK GRN/PNK WIRE DK GRN/YEL WIRE EGR SOL CTRL NOT USED F GAUGE SENDER PRGRM SIGNAL FUSE 20 FUSE 8 FUSE 4 FUSE 9 GROUND GROUND IGN COIL 1 TCIL GROUND IGN COIL GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START IAT INPUT FUEL PUMP OUT A/C ON SIG IMRC IGNITION COIL (LEFT FRONT OF ENGINE) IMRC MONITOR INSTRUMENT CLUSTER SYSTEM 29 107 KS + LT BLU/BLK WIRE LT GRN/RED WIRE MAF RTN TFTS INPUT NCA WIRE OD CANCEL SW OD OFF ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE RADIO CAPACITOR 1 (ATTACHED TO IGNITION COIL) RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE SCP BUS SCP BUS SPARK PLUGS SPARK PLUGS SPARK PLUGS TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL INDICATOR LAMP VIO WIRE VIO/ORG WIRE WATER TEMP SENS WHT/LT GRN WIRE WHT/PNK WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/WHT WIRE

BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BRN/LT GRN WIRE BRN/PNK WIRE BRN/WHT WIRE CRANKSHAFT POSITION SENSOR (LOWER RIGHT FRONT OF ENGINE) DIFFERENTIAL PRESSURE FEEDBACK EGR SENSOR (TOP RIGHT FRONT OF ENGINE) DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/YEL WIRE DK GRN/PNK WIRE DK GRN/YEL WIRE ENGINE COOLANT TEMPERATURE GAUGE ENGINE COOLANT TEMPERATURE SENDER (TOP FRONT CENTER OF ENGINE) EXCEPT STRIPPED CHASSIS FUEL PUMP RELAY FUEL TANK PRESSURE TRANSDUCER SENSOR (UNDER LEFT CENTER OF VEHICLE) FUSE 17 GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES INSTRUMENT CLUSTER INTAKE MANIFOLD RUNNER CONTROL MODULE (ON REAR OF INTAKE) LT BLU/ORG WIRE MALFUNCTION INDICATOR ORG/BLK WIRE ORG/YEL WIRE PNK/LT GRN WIRE PNK/WHT WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE STRIPPED CHASSIS TAN/LT BLU WIRE THROTTLE POSITION SENSOR (ON TOP OF ENGINE, NEAR AIR INTAKE) VIO/ORG WIRE WHT/LT GRN WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

A/C SYSTEM A/C SYSTEM (ENGINE CONTROL HARNESS, NEAR BREAKOUT TO MASS AIRFLOW SENSOR) BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/ WHT WIRE BLK/LT BLU WIRE BLK/WHT WIRE BRN WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH, NEAR LEFT KICK PANEL) COIL ON PLUG COIL ON PLUG 6 MIL PWR GND DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (PARTIAL) (LEFT SIDE OF DASH) 10 2 DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE ECT AIR CTRL SENS EVR SOL TACH SIG ENDS IN HARNESS FUEL PUMP/ SENDER FUSE 20 FUSE 8 FUSE 4 GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START KNOCK SENSOR LT BLU/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE MAF FUEL PUMP MON A/C ON SIG MAF TFT MISFIRE SENS (+) MISFIRE SENS (-) NCA WIRE OD OFF ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY FUSE 9 PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE PWR GND COIL ON PLUG 3 PWR GND GND COIL ON PLUG 1 COIL ON PLUG 5 RED WIRE RED/LT GRN WIRE SHIFT SOL A SHIFT SOL B TCIL IND FEPS (EPROM) TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL LAMP TCS TO DTR SENSOR (DIAGRAM 4 OF 4) VIO WIRE VIO/ORG WIRE WHT WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/WHT WIRE

BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) BLK/WHT WIRE BRN WIRE BRN/LT GRN WIRE BRN/PNK WIRE BRN/WHT WIRE CRANKSHAFT POSITION SENSOR (LOWER RIGHT FRONT OF ENGINE) DIFFERENTIAL PRESSURE FEEDBACK EGR SENSOR (TOP LEFT REAR OF ENGINE) DK BLU WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE ENGINE COOLANT TEMPERATURE GAUGE FUEL LEVEL GAUGE FUEL PUMP RELAY FUEL TANK PRESSURE TRANSDUCER (UNDER LEFT CENTER OF VEHICLE) FUSE 17 GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES INLET MANIFOLD RUNNER CONTROL MODULE (LEFT FRONT OF ENGINE) INSTRUMENT CLUSTER INSTRUMENTATION ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT CENTER OF ENGINE) LT BLU/ORG WIRE MALFUNCTION INDICATOR ORG/BLK WIRE ORG/YEL WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE POWER RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE TAN/LT BLU WIRE THROTTLE POSITION SENSOR (ON TOP OF ENGINE, NEAR AIR INTAKE) VIO/ORG WIRE WHT/RED WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

360 648 1145 1146 570 1028 (ENDS IN HARNESS) AIR CONDITIONING SYSTEM BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRN/ORG WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH, NEAR LEFT KICK PANEL) COAST CLUTCH SW CKP SENS + CKP SENS - COIL ON PLUG DATA LINK CONNECTOR (PARTIAL) (LEFT SIDE OF DASH) 10 2 DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE ECT EGR SOL NOT USED ENDS IN HARNESS FP SENDER FUSE 20 FUSE 8 FUSE 4 FUSE 9 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER SYSTEM KS SENSOR LT BLU/BLK WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE LT LT LT LT LT LT LT LT LT MAF FUEL PUMP MON A/C ON SIG MAF TFT NCA WIRE OD OFF ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY PNK LT WIRE PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE PWR GND COIL ON PLUG 3 PWR GND GND COIL ON PLUG 1 COIL ON PLUG 5 RADIO CAPACITOR 1 (UPPER LEFT REAR OF ENGINE) RADIO CAPACITOR 2 (RIGHT REAR OF ENGINE) RED WIRE RED/LT GRN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCS TO DTR SENSOR (DIAGRAM 4 OF 4) TRANS CTRL SW GEN SCAN TOOL IN 4 LOW SWITCH BUS - BUS + TRANSMISSION CONTROL INDICATOR LAMP VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE WHT WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/WHT WIRE

BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) BLK/WHT WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE CRANKSHAFT POSITION SENSOR (LOWER CENTER FRONT OF ENGINE) DK BLU WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ENGINE COOLANT TEMPERATURE GAUGE FUEL PUMP RELAY FUEL TANK PRESSURE TRANSDUCER SENSOR (NEAR FUEL TANK) FUSE 17 GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES INSTRUMENT CLUSTER KNOCK SENSOR (TOP RIGHT REAR OF ENGINE) LT BLU WIRE LT BLU/ORG WIRE MALFUNCTION INDICATOR NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE POWER RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE TAN/LT BLU WIRE THROTTLE POSITION SENSOR (TOP OF ENGINE, NEAR AIR INTAKE) TRANSMISSION) (RIGHT SIDE OF TRANS) TURBINE SHAFT SPEED SENSOR VIO/ORG WIRE WHT/RED WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE