Ford Econoline E150 (1997-2012) pcm power relay Wiring diagrams

ABS SYSTEM, WARNING BUZZER MODULE BATTERY JUNCTION BOX BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) FUSE 9 BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BREAKOUT) BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 8 CHT VSS PWR IN GND GND TCIL EPC OSS MAF TPS VREF SIG RTN BPP GND CRUISE CONTROL SYSTEM CYLINDER HEAD TEMPERATURE SENSOR DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) 10 13 DIGITAL TRANSMISSION RANGE SENSOR DK BLU/YEL WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS ENGINE CONTROLS (ENG CONTROL HARN, NEAR BREAKOUT TO EXTERIOR LIGHTS FUSE 11 FUSE 2 FUSE 20 FUSE 4 GEN DATA DATA (-) DATA (+) GND SSA TCS MAF TFT MAF ECT GND TCC KAPWR GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION COIL, RADIO NOISE CAPACITOR INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP MASS AIRFLOW (MAF) SENSOR (TOP CENTER OF ENGINE COMPT) MULTIFUNCTION SWITCH, DEAVTIATOR SWITCH NCA WIRE OD OFF ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) OVERDRIVE CANCEL SWITCH PCM DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE SHIFT SOLENOIDS SPEEDOMETER SSA SSB TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE THROTTLE POSITION SENSOR (TPS) (ON TOP OF ENGINE, NEAR AIR INTAKE) TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/YEL WIRE W/ STRIPPED CHASSIS WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

A/C CLUTCH CYCLING PRESSURE SWITCH (IN RIGHT FRONT OF ENGINE COMPARTMENT) A/C CLUTCH RELAY A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH DIODE A/C PRESSURE CUT-OUT SWITCH (IN RIGHT FRONT OF ENGINE COMPARTMENT) BATTERY JUNCTION BOX (IN LEFT FRONT OF ENGINE COMPARTMENT) BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH, ON A/C-HEATER PLENUM) BLK WIRE CENTRAL JUNCTION BOX LEFT SIDE OF DASH, NEAR KICK PANEL) FUNCTION SELECTOR SWITCH FUSE 13 FUSE 26 FUSE 9 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN LT LT MAX A/C DEF/FLR OFF DEFROST NORM A/C FLOOR VENT MAX A/C DEF/FLR OFF DEFROST NOTE: PCM POWER RELAY ENERGIZED W/IGNITION SWITCH IN RUN OR START POSITION PCM POWER RELAY PNK WIRE RED WIRE TEMPERATURE CONTROL SWITCH TO BLOWER MOTOR RELAY (DIAGRAM 2 OF 2) VENT NORM A/C FLOOR VIO WIRE WHT WIRE YEL WIRE

A/C CLUTCH CYCLING PRESSURE SWITCH (IN RIGHT FRONT OF ENGINE COMPARTMENT) A/C CLUTCH RELAY A/C HIGH PRESSURE SWITCH (IN RIGHT FRONT OF ENGINE COMPARTMENT) A/C CLUTCH SOLENOID (ON LEFT FRONT OF ENGINE) A/C COMPRESSOR CLUTCH DIODE (NEAR FRONT OF ENGINE) A/C ON INPUT SIGNAL A/C RELAY CONTROL BATTERY JUNCTION BOX (BJB) (IN LEFT FRONT OF ENGINE COMPARTMENT) BLK WIRE BLK/YEL WIRE CENTRAL JUNCTION BOX (CJB) (LEFT SIDE OF DASH, NEAR KICK PANEL) FRONT FUNCTION SELECTOR SWITCH ASSEMBLY FUSE 13 FUSE 26 FUSE 9 GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN START OR RUN LT GRN WIRE MAX A/C MIX OFF DEFROST MODE SWITCH NORM A/C FLOOR VENT MAX A/C MIX DEFROST OFF MODE SWITCH PCM POWER RELAY PNK WIRE PNK/BLK WIRE PNK/YEL WIRE RED WIRE TO BLOWER MOTOR RELAY (DIAGRAM 2 OF 2) VENT NORM A/C FLOOR VIO WIRE WHT WIRE YEL WIRE

A/C CLUTCH RELAY A/C CLUTCH SOLENOID A/C COMPRESSOR CLUTCH DIODE A/C DEMAND SIGNAL A/C ON INPUT SIGNAL A/C RELAY CONTROL A/C SWITCH BATTERY JUNCTION BOX (IN LEFT FRONT OF ENGINE COMPARTMENT) BLK WIRE BLK/YEL WIRE BLOWER MOTOR BLOWER MOTOR RELAY CENTRAL JUNCTION BOX LEFT SIDE OF DASH, NEAR KICK PANEL) FUSE 13 FUSE 26 FUSE 9 FUSED BLOWER MOTOR FEED GRY WIRE HOT AT ALL TIMES HOT IN NOTE: PCM POWER RELAY ENERGIZED W/IGNITION SWITCH IN RUN OR START POSITION ORG/RED WIRE PCM POWER RELAY PNK WIRE PNK/YEL WIRE RED WIRE RED/YEL WIRE RUN WIRE VIO WIRE WHT WIRE YEL WIRE YEL/RED WIRE

ABS SYSTEM, WARNING BUZZER MODULE BATTERY JUNCTION BOX BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) FUSE 9 BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 8 CHT VSS PWR IN GND GND EPC OSS MAF TPS VREF SIG RTN BPP GND CRUISE CONTROL SYSTEM CYLINDER HEAD TEMPERATURE SENSOR DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) 10 13 DIGITAL TRANSMISSION RANGE SENSOR DK BLU/YEL WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS ENGINE CONTROLS (4.6L) (5.4L) ENGINE CONTROLS (ENG CONTROL HARN, NEAR BREAKOUT TO A/C PRESSURE CUTOUT SWITCH) EXTERIOR LIGHTS FUSE 11 FUSE 2 FUSE 20 FUSE 4 GND TCC KAPWR GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION COIL, RADIO NOISE CAPACITOR INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MAF TFT MAF ECT MALFUNCTION INDICATOR LAMP MASS AIRFLOW (MAF) SENSOR (TOP CENTER OF ENGINE COMPT) MULTIFUNCTION SWITCH, DEAVTIATOR SWITCH NCA WIRE OD OFF ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) OVERDRIVE CANCEL SWITCH PCM DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE SHIFT SOLENOIDS SPEEDOMETER SSA SSB TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE THROTTLE POSITION SENSOR (TPS) (ON TOP OF ENGINE, NEAR AIR INTAKE) TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

A/C CLUTCH CYCLING PRESSURE SWITCH (IN RIGHT FRONT OF ENGINE COMPARTMENT) A/C CLUTCH RELAY A/C CLUTCH SOLENOID (ON LOWER RIGHT FRONT OF ENGINE) A/C COMPRESSOR CLUTCH DIODE (NEAR FRONT OF ENGINE) A/C HIGH PRESSURE SWITCH (IN RIGHT FRONT OF ENGINE COMPARTMENT) A/C ON INPUT SIG A/C RELAY CTRL BATTERY JUNCTION BOX (BJB) (IN LEFT FRONT OF ENGINE COMPARTMENT) BLK WIRE BLK/YEL WIRE CENTRAL JUNCTION BOX (CJB) (LEFT SIDE OF DASH, NEAR KICK PANEL) FRONT FUNCTION SELECTOR SWITCH ASSEMBLY FRONT FUNCTION SELECTOR SWITCH ASSEMBLY (1: TEMPERATURE CONTROL POTENTIOMETER) FUSE 13 FUSE 9 GRN WIRE HOT AT ALL TIMES HOT IN RUN HOT IN START OR RUN LT GRN WIRE LT LT MAX A/C MIX OFF DEFROST MODE SWITCH NORM A/C FLOOR VENT MAX A/C MIX OFF DEFROST MODE SWITCH PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE RED WIRE TAN/LT GRN WIRE TO BLOWER MOTOR RELAY (DIAGRAM 2 OF 2) VENT NORM A/C FLOOR VIO WIRE WHT WIRE YEL WIRE

A/C CLUTCH CYCLING PRESSURE SWITCH (IN RIGHT FRONT OF ENGINE COMPARTMENT) A/C CLUTCH RELAY A/C CLUTCH SOLENOID A/C COMPRESSOR CLUTCH DIODE A/C HIGH PRESSURE SWITCH (IN RIGHT FRONT OF ENGINE COMPARTMENT) A/C ON INPUT SIGNAL A/C RELAY CONTROL BATTERY JUNCTION BOX (IN LEFT FRONT OF ENGINE COMPARTMENT) BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH, ON A/C-HEATER PLENUM) BLK WIRE BLK/YEL WIRE CENTRAL JUNCTION BOX LEFT SIDE OF DASH, NEAR KICK PANEL) FRONT FUNCTION SELECTOR SWITCH ASSEMBLY FUSE 13 FUSE 9 GRN WIRE HOT AT ALL TIMES HOT IN RUN LT LT MAX A/C MIX OFF DEFROST NORM A/C FLOOR VENT MAX A/C MIX OFF DEFROST NOTE: PCM POWER RELAY ENERGIZED W/IGNITION SWITCH IN RUN OR START POSITION PCM POWER RELAY PNK WIRE PNK/ (BEHIND CENTER OF DASH) WIRE PNK/LT BLU WIRE RED WIRE TAN/LT GRN WIRE TO BLOWER MOTOR RELAY (DIAGRAM 2 OF 2) VENT NORM A/C FLOOR VIO WIRE WHT WIRE YEL WIRE

ABS SYSTEM, WARNING BUZZER MODULE BATTERY JUNCTION BOX BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) FUSE 9 BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 8 CHT VSS PWR IN GND GND EPC OSS MAF TPS VREF SIG RTN BPP GND CRUISE CONTROL SYSTEM CYLINDER HEAD TEMPERATURE SENSOR DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) 10 13 DIGITAL TRANSMISSION RANGE SENSOR DK BLU/YEL WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS ENGINE CONTROLS (4.6L) (5.4L) ENGINE CONTROLS (ENG CONTROL HARN, NEAR BREAKOUT TO A/C PRESSURE CUTOUT SWITCH) EXTERIOR LIGHTS FUSE 11 FUSE 2 FUSE 20 FUSE 4 GND TCC KAPWR GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION COIL, RADIO NOISE CAPACITOR INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MAF TFT MAF ECT MALFUNCTION INDICATOR LAMP MASS AIRFLOW (MAF) SENSOR (TOP CENTER OF ENGINE COMPT) MULTIFUNCTION SWITCH, DEAVTIATOR SWITCH NCA WIRE OD OFF ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) OVERDRIVE CANCEL SWITCH PCM DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE SHIFT SOLENOIDS SPEEDOMETER SSA SSB TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE THROTTLE POSITION SENSOR (TPS) (ON TOP OF ENGINE, NEAR AIR INTAKE) TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

14 6 22 46 FAN CLU CTRL FAN SPD SIG SPD SIG RTN VREF 41 58 CHT SIGRTN BLK WIRE BRN/LT GRN WIRE BRN/PNK WIRE DIESEL DK BLU WIRE ECT ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE (ECT) SENSOR (UPPER LEFT FRONT OF ENGINE) EXCEPT DIESEL FAN CLUTCH 4 1 2 6 FUSE 21 GRY/RED WIRE HOT AT ALL TIMES NCA WIRE PCM POWER RELAY POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF ENGINE COMPT) RED WIRE RED/ORG WIRE SIG RTN SPEED SENSOR ELECTRONIC FAN CLUTCH (TOP FRONT OF ENGINE) YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/WHT WIRE

360 648 1145 1146 570 527 (ENDS IN HARNESS) AIR CONDITIONING SYSTEM BATTERY JUNCTION BLK/LT BLU WIRE BLK/WHT WIRE BLK/YEL WIRE BOX (LEFT FRONT OF ENGINE COMPT) BRN/PNK WIRE CENTRAL JUNCTION BOX (BELOW LEFT SIDE OF DASH, NEAR LEFT KICK PANEL) DATA LINK CONNECTOR (PARTIAL) (LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/YEL WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE EGR SOL CTRL NOT USED F GAUGE SENDER PRGRM SIGNAL FUSE 20 FUSE 8 FUSE 4 FUSE 9 GROUND GROUND IGN COIL 1 TCIL GROUND IGN COIL GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START IAT INPUT FUEL PUMP OUT A/C ON SIG IMRC IGNITION COIL (LEFT FRONT OF ENGINE) IGNITION TRANSFORMER CAPACITOR 1 (ATTACHED TO IGNITION COIL) IMRC MONITOR INSTRUMENT CLUSTER SYSTEM 29 107 KS + LT BLU/BLK WIRE LT GRN/RED WIRE MAF RTN TFTS INPUT NCA WIRE OD CANCEL SW OD OFF ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE SCP BUS SCP BUS SPARK PLUGS SPARK PLUGS SPARK PLUGS TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL INDICATOR LAMP VIO WIRE VIO/ORG WIRE WATER TEMP SENS WHT/LT GRN WIRE WHT/PNK WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/WHT WIRE