Ford Econoline E150 (1997-2012) pcm power diode Wiring diagrams

24 45 8 REV LMP CTRL KAPWR BPP SW 27 1 4 5 6 16 17 18 28 47 48 49 50 10 OD CANCEL SW VSS APPA_+ 35 36 VPWR VPWR APPA_- APPB_+ APPB_- AUXILIARY RELAY BOX 1 (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) FUSE 23 BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DK BLU/WHT WIRE DK GRN WIRE DK GRN/ORG WIRE ENDS IN HARNESS ENGINE CONTROLS SYSTEM FUSE 11 FUSE 2 FUSE 21 FUSE 27 FUSE 8 GROUND GROUND GROUND GROUND GROUND GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN OR START LT GRN/RED WIRE NCA WIRE OD OFF OVERDRIVE CANCEL SWITCH OVERHEAD CONSOLE (IF EQUIPPED) PCM POWER DIODE PCM POWER RELAY RED WIRE RED/LT GRN WIRE RED/YEL WIRE REVERSING LAMP RELAY TAN WIRE TAN/WHT WIRE TAN/YEL WIRE W/ ADVANCE TRAC W/ REMOTE KEYLESS ENTRY OR ADVANCE TRAC W/ STRIPPED CHASSIS WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL/BLK WIRE

BATTERY JUNCTION BOX BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BRN/ORG WIRE BRN/WHT WIRE COAST CLUTCH SOLENOID CYLINDER HEAD TEMPERATURE SENSOR (ON TOP FRONT OF LEFT CYLINDER HEAD) DK BLU/YEL WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS SYSTEM FUSE 21 FUSE 27 GASOLINE GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) HOT IN RUN OR START CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 8 IGNITION COIL, RADIO NOISE CAPACITOR LT BLU/RED WIRE LT GRN WIRE NATURAL GAS VEHICLE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) PCM POWER DIODE PCM POWER RELAY RED WIRE SHIFT SOLENOID TAN/LT BLU WIRE THROTTLE POSITION SENSOR (TPS) (ON TOP OF ENGINE, NEAR AIR INTAKE) TORQUE CONVERTER CLUTCH SOLENOID SHIFT SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SENSOR (AT LEFT SIDE OF TRANSMISSION) VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE

35 36 IGNITION (ST/RUN) IGNITION (ST/RUN) 45 8 CLUSTER PWR BPP SW BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DK BLU/WHT WIRE DK GRN WIRE ENDS IN HARNESS ENGINE CONTROLS SYSTEM FUSE 11 FUSE 2 FUSE 21 FUSE 23 FUSE 27 FUSE 8 GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN OR START LT GRN/RED WIRE NCA WIRE OD OFF OVERDRIVE CANCEL SWITCH OVERHEAD CONSOLE (IF EQUIPPED) PCM POWER DIODE PCM POWER RELAY RED WIRE RED/LT GRN WIRE RED/YEL WIRE TAN WIRE TAN/WHT WIRE TAN/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL/BLK WIRE

6.8L 4.6L, 5.8L AUXILIARY POWERTRAIN CONTROL MODULE (APCM) BATTERY JUNCTION BOX (BJB) (DIESEL: AT RIGHT REAR OF ENGINE COMPT) BLK LT GRN/ WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF OF DASH) COIL ON COIL ON COIL ON PLUG PLUG PLUG (COP) 4 (COP) 3 (COP) 5 COIL ON HEATED PLUG POSITIVE (COP) 1 CRANKCASE VENTILATION ELEMENT (4.6L, 6.8L) COIL ON PLUG (COP) 2 COIL ON PLUG (COP) 6 DIESEL DIGITAL TRANSMISSION RANGE (DTR) SENSOR DK GRN WIRE EXCEPT 6.8L 6.8L EXCEPT DIESEL EXCEPT DIESEL DIESEL EXCEPT STRIPPED CHASSIS EXCEPT STRIPPED CHASSIS STRIPPED CHASSIS FROM IGNITION SWITCH (DIAGRAM 3 OF 4) FUEL HEATER FUEL INJECTOR CONTROL MODULE (FICM) FUSE 14 FUSE 15 FUSE 2 FUSE 20 FUSE 21 FUSE 27 FUSE 3 FUSE 9 FUSE 33 FUSE 8 IGN FEED IGNITION TRANSFORMER CAPACITOR 1 IGNITION TRANSFORMER CAPACITOR 2 INSTRUMENT CLUSTER LT BLU WIRE LT BLU/PNK WIRE LT GRN RED/ WIRE NATURAL GAS VEHICLE NCA WIRE PCM POWER DIODE PCM POWER RELAY PNK WIRE PNK/LT GRN WIRE RADIO RED/ LT GRN WIRE RED/BLK WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE RESTRAINTS CONTROL MODULE STRIPPED CHASSIS STRIPPED EXCEPT CHASSIS STRIPPED CHASSIS TAN/RED WIRE VIO/ORG WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/YEL WIRE YEL BLK/ WIRE

360 648 1145 1146 570 527 (ENDS IN HARNESS) AIR CONDITIONING SYSTEM BATTERY JUNCTION BLK/LT BLU WIRE BLK/WHT WIRE BLK/YEL WIRE BOX (LEFT FRONT OF ENGINE COMPT) BRN/PNK WIRE CENTRAL JUNCTION BOX (BELOW LEFT SIDE OF DASH, NEAR LEFT KICK PANEL) DATA LINK CONNECTOR (PARTIAL) (LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/YEL WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE EGR SOL CTRL NOT USED F GAUGE SENDER PRGRM SIGNAL FUSE 20 FUSE 8 FUSE 4 FUSE 9 GROUND GROUND IGN COIL 1 TCIL GROUND IGN COIL GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START IAT INPUT FUEL PUMP OUT A/C ON SIG IMRC IGNITION COIL (LEFT FRONT OF ENGINE) IGNITION TRANSFORMER CAPACITOR 1 (ATTACHED TO IGNITION COIL) IMRC MONITOR INSTRUMENT CLUSTER SYSTEM 29 107 KS + LT BLU/BLK WIRE LT GRN/RED WIRE MAF RTN TFTS INPUT NCA WIRE OD CANCEL SW OD OFF ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE SCP BUS SCP BUS SPARK PLUGS SPARK PLUGS SPARK PLUGS TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL INDICATOR LAMP VIO WIRE VIO/ORG WIRE WATER TEMP SENS WHT/LT GRN WIRE WHT/PNK WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/WHT WIRE

360 648 1145 1146 570 527 (ENDS IN HARNESS) AIR CONDITIONING SYSTEM BATTERY JUNCTION BLK/LT BLU WIRE BLK/WHT WIRE BLK/YEL WIRE BOX (LEFT FRONT OF ENGINE COMPT) BRN/PNK WIRE CENTRAL JUNCTION BOX (BELOW LEFT SIDE OF DASH, NEAR LEFT KICK PANEL) DATA LINK CONNECTOR (PARTIAL) (LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/YEL WIRE DK GRN/PNK WIRE DK GRN/YEL WIRE EGR SOL CTRL NOT USED F GAUGE SENDER PRGRM SIGNAL FUSE 20 FUSE 8 FUSE 4 FUSE 9 GROUND GROUND IGN COIL 1 TCIL GROUND IGN COIL GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START IAT INPUT FUEL PUMP OUT A/C ON SIG IMRC IGNITION COIL (LEFT FRONT OF ENGINE) IMRC MONITOR INSTRUMENT CLUSTER SYSTEM 29 107 KS + LT BLU/BLK WIRE LT GRN/RED WIRE MAF RTN TFTS INPUT NCA WIRE OD CANCEL SW OD OFF ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE RADIO CAPACITOR 1 (ATTACHED TO IGNITION COIL) RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE SCP BUS SCP BUS SPARK PLUGS SPARK PLUGS SPARK PLUGS TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL INDICATOR LAMP VIO WIRE VIO/ORG WIRE WATER TEMP SENS WHT/LT GRN WIRE WHT/PNK WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/WHT WIRE

A/C SYSTEM AIR CTRL SENS EVR SOL TACH SIG BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK/ WHT WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/PNK WIRE CAPACITOR 2 CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 2 COIL ON PLUG COIL ON PLUG 6 DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (LEFT SIDE OF DASH) 10 2 DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK GRN/VIO WIRE ENDS IN HARNESS EXCEPT STRIPPED CHASSIS FUSE 27 FUSE 8 GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION TRANSFORMER KNOCK SENSOR LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE MAF TFT MAF VPWR A/C ON SIG MISFIRE SENS (+) MISFIRE SENS (-) NCA WIRE OD OFF ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY FUSE 21 PNK/LT BLU WIRE PNK/WHT WIRE PWR GND COIL ON PLUG 3 COIL ON PLUG 4 PWR GND GND COIL ON PLUG 1 COIL ON PLUG 5 RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHIFT SOL A SHIFT SOL B TCIL IND FEPS (EPROM) STRIPPED CHASSIS TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL LAMP TCS TO DTR SENSOR (DIAGRAM 4 OF 4) VIO WIRE VIO/ORG WIRE WHT/ BLK WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE

A/C SYSTEM A/C SYSTEM (ENGINE CONTROL HARNESS, NEAR BREAKOUT TO MASS AIRFLOW SENSOR) BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/ WHT WIRE BLK/LT BLU WIRE BLK/WHT WIRE BRN WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH, NEAR LEFT KICK PANEL) COIL ON PLUG COIL ON PLUG 6 MIL PWR GND DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (PARTIAL) (LEFT SIDE OF DASH) 10 2 DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE ECT AIR CTRL SENS EVR SOL TACH SIG ENDS IN HARNESS FUEL PUMP/ SENDER FUSE 20 FUSE 8 FUSE 4 GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START KNOCK SENSOR LT BLU/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE MAF FUEL PUMP MON A/C ON SIG MAF TFT MISFIRE SENS (+) MISFIRE SENS (-) NCA WIRE OD OFF ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY FUSE 9 PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE PWR GND COIL ON PLUG 3 PWR GND GND COIL ON PLUG 1 COIL ON PLUG 5 RED WIRE RED/LT GRN WIRE SHIFT SOL A SHIFT SOL B TCIL IND FEPS (EPROM) TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL LAMP TCS TO DTR SENSOR (DIAGRAM 4 OF 4) VIO WIRE VIO/ORG WIRE WHT WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/WHT WIRE

A/C SYSTEM BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK/ WHT WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/ORG WIRE BRN/PNK WIRE CAPACITOR 2 CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 2 COAST SOL MISFIRE SENS (+) MISFIRE SENS (-) COIL ON PLUG COIL ON PLUG 6 DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (LEFT SIDE OF DASH) 10 2 DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK GRN/VIO WIRE ENDS IN HARNESS EVR SOL TACH SIG EXCEPT STRIPPED CHASSIS FUSE 27 FUSE 8 GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION TRANSFORMER KNOCK SENSOR LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE MAF TFT MAF VPWR A/C ON SIG NCA WIRE OD OFF ORG/BLK WIRE ORG/LT BLU WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY FUSE 21 PNK/LT BLU WIRE PNK/WHT WIRE PWR GND PWR GND COIL ON PLUG 3 COIL ON PLUG 4 PWR GND GND COIL ON PLUG 1 COIL ON PLUG 5 RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHIFT SOL A SHIFT SOL B TCIL IND FEPS (EPROM) STRIPPED CHASSIS TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL LAMP TCS TO DTR SENSOR (DIAGRAM 4 OF 4) VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE WHT/ BLK WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE

360 648 1145 1146 570 1028 (ENDS IN HARNESS) AIR CONDITIONING SYSTEM BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRN/ORG WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH, NEAR LEFT KICK PANEL) COAST CLUTCH SW CKP SENS + CKP SENS - COIL ON PLUG DATA LINK CONNECTOR (PARTIAL) (LEFT SIDE OF DASH) 10 2 DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE ECT EGR SOL NOT USED ENDS IN HARNESS FP SENDER FUSE 20 FUSE 8 FUSE 4 FUSE 9 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER SYSTEM KS SENSOR LT BLU/BLK WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE LT LT LT LT LT LT LT LT LT MAF FUEL PUMP MON A/C ON SIG MAF TFT NCA WIRE OD OFF ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY PNK LT WIRE PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE PWR GND COIL ON PLUG 3 PWR GND GND COIL ON PLUG 1 COIL ON PLUG 5 RADIO CAPACITOR 1 (UPPER LEFT REAR OF ENGINE) RADIO CAPACITOR 2 (RIGHT REAR OF ENGINE) RED WIRE RED/LT GRN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCS TO DTR SENSOR (DIAGRAM 4 OF 4) TRANS CTRL SW GEN SCAN TOOL IN 4 LOW SWITCH BUS - BUS + TRANSMISSION CONTROL INDICATOR LAMP VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE WHT WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/WHT WIRE