Ford Econoline E150 (1997-2012) instrument cluster Wiring diagrams

ABS SYSTEM, WARNING BUZZER MODULE BATTERY JUNCTION BOX BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) FUSE 9 BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BREAKOUT) BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 8 CHT VSS PWR IN GND GND TCIL EPC OSS MAF TPS VREF SIG RTN BPP GND CRUISE CONTROL SYSTEM CYLINDER HEAD TEMPERATURE SENSOR DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) 10 13 DIGITAL TRANSMISSION RANGE SENSOR DK BLU/YEL WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS ENGINE CONTROLS (ENG CONTROL HARN, NEAR BREAKOUT TO EXTERIOR LIGHTS FUSE 11 FUSE 2 FUSE 20 FUSE 4 GEN DATA DATA (-) DATA (+) GND SSA TCS MAF TFT MAF ECT GND TCC KAPWR GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION COIL, RADIO NOISE CAPACITOR INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP MASS AIRFLOW (MAF) SENSOR (TOP CENTER OF ENGINE COMPT) MULTIFUNCTION SWITCH, DEAVTIATOR SWITCH NCA WIRE OD OFF ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) OVERDRIVE CANCEL SWITCH PCM DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE SHIFT SOLENOIDS SPEEDOMETER SSA SSB TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE THROTTLE POSITION SENSOR (TPS) (ON TOP OF ENGINE, NEAR AIR INTAKE) TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/YEL WIRE W/ STRIPPED CHASSIS WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

ABS SYSTEM, WARNING BUZZER MODULE BATTERY JUNCTION BOX BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) FUSE 9 BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 8 CHT VSS PWR IN GND GND EPC OSS MAF TPS VREF SIG RTN BPP GND CRUISE CONTROL SYSTEM CYLINDER HEAD TEMPERATURE SENSOR DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) 10 13 DIGITAL TRANSMISSION RANGE SENSOR DK BLU/YEL WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS ENGINE CONTROLS (4.6L) (5.4L) ENGINE CONTROLS (ENG CONTROL HARN, NEAR BREAKOUT TO A/C PRESSURE CUTOUT SWITCH) EXTERIOR LIGHTS FUSE 11 FUSE 2 FUSE 20 FUSE 4 GND TCC KAPWR GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION COIL, RADIO NOISE CAPACITOR INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MAF TFT MAF ECT MALFUNCTION INDICATOR LAMP MASS AIRFLOW (MAF) SENSOR (TOP CENTER OF ENGINE COMPT) MULTIFUNCTION SWITCH, DEAVTIATOR SWITCH NCA WIRE OD OFF ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) OVERDRIVE CANCEL SWITCH PCM DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE SHIFT SOLENOIDS SPEEDOMETER SSA SSB TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE THROTTLE POSITION SENSOR (TPS) (ON TOP OF ENGINE, NEAR AIR INTAKE) TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

15 3 41 16 17 27 28 29 13 42 43 46 TSS SENSOR OSS SIG SIG RETURN 23 44 11 CAN- FEPS CAN+ 4.6L 5.4L BLK/WHT WIRE DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DK BLU/YEL WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ELECTRONIC THROTTLE CONTROL MOTOR (TOP FRONT OF ENGINE) ENGINE CONTROLS SYSTEM GRY WIRE GRY/RED WIRE GRY/WHT WIRE INSTRUMENT CLUSTER LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/RED WIRE MASS AIR FLOW (MAF) SENSOR (AT CENTER OF ENGINE COMPT) ORG/BLK WIRE ORG/LT BLU WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED (OSS) SENSOR (LEFT SIDE OF TRANSMISSION) PNK/LT GRN WIRE PNK/ORG WIRE RED WIRE RED/LT GRN WIRE SHIFT SOLENOIDS TAN/LT BLU WIRE TAN/LT GRN WIRE TFT SENSOR SIG EPC SOL SHIFT SOL A SHIFT SOL B TCC SOL THROTTLE POSITION SENSOR (TOP OF ENGINE, NEAR AIR INTAKE) TORQUE CONVERTER CLUTCH SOLENOID TPS POW TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED (TSS) SENSOR (LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/ORG WIRE VIO/YEL WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/WHT WIRE

ABS SYSTEM, WARNING BUZZER MODULE BATTERY JUNCTION BOX BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) FUSE 9 BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 8 CHT VSS PWR IN GND GND EPC OSS MAF TPS VREF SIG RTN BPP GND CRUISE CONTROL SYSTEM CYLINDER HEAD TEMPERATURE SENSOR DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) 10 13 DIGITAL TRANSMISSION RANGE SENSOR DK BLU/YEL WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS ENGINE CONTROLS (4.6L) (5.4L) ENGINE CONTROLS (ENG CONTROL HARN, NEAR BREAKOUT TO A/C PRESSURE CUTOUT SWITCH) EXTERIOR LIGHTS FUSE 11 FUSE 2 FUSE 20 FUSE 4 GND TCC KAPWR GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION COIL, RADIO NOISE CAPACITOR INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MAF TFT MAF ECT MALFUNCTION INDICATOR LAMP MASS AIRFLOW (MAF) SENSOR (TOP CENTER OF ENGINE COMPT) MULTIFUNCTION SWITCH, DEAVTIATOR SWITCH NCA WIRE OD OFF ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) OVERDRIVE CANCEL SWITCH PCM DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE SHIFT SOLENOIDS SPEEDOMETER SSA SSB TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE THROTTLE POSITION SENSOR (TPS) (ON TOP OF ENGINE, NEAR AIR INTAKE) TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

15 3 41 16 17 27 28 29 13 42 43 46 TSS SENSOR OSS SIG TR-P GROUND 23 44 11 CAN - PROG SIG CAN + BLK/WHT WIRE DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DK BLU/YEL WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ELECTRONIC THROTTLE CONTROL (ETC) MOTOR (TOP RIGHT FRONT OF ENGINE) ENGINE CONTROLS SYSTEM GRY WIRE GRY/RED WIRE GRY/WHT WIRE INSTRUMENT CLUSTER LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/RED WIRE MASS AIR FLOW (MAF) SENSOR (AT CENTER OF ENGINE COMPT) ORG/BLK WIRE ORG/LT BLU WIRE ORG/YEL WIRE PNK/LT GRN WIRE PNK/ORG WIRE RED WIRE RED/LT GRN WIRE SHIFT SOLENOIDS TAN/LT BLU WIRE TAN/LT GRN WIRE TFT SENSOR SIG EPC SOL SHIFT SOL A SHIFT SOL B TCC SOL THROTTLE POSITION SENSOR (TOP OF ENGINE, NEAR AIR INTAKE) TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/YEL WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/WHT WIRE

16 17 15 DRIVER DOOR AJAR SLIDING DOOR AJAR DOORS AJAR 23 22 MS CAN+ MS CAN- 5 10 RUN/START PWR GROUND BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM FRONT PASSENGER WINDOW/DOOR LOCK SWITCH FUSE 14 FUSE 22 HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER LEFT FRONT DOOR AJAR SWITCH (AT LEFT KICK PANEL) LOCK LOGIC GROUND LR GRN WIRE LT BLU WIRE LT GRN WIRE MASTER WINDOW/ DOOR LOCK/UNLOCK SWITCH NCA WIRE PNK PNK WIRE PNK WIRE PNK/LT GRN WIRE PNK/YEL WIRE REAR DOORS DOOR AJAR RED WIRE RED/PNK WIRE RED/WHT WIRE RIGHT FRONT DOOR AJAR SWITCH (AT RIGHT KICK PANEL) RIGHT SIDE DOOR AJAR SWITCH (IN FRONT OF RIGHT SIDE DOOR) RIGHT SLIDING DOOR AJAR SWITCH (AT RIGHT "B" PILLAR) SWITCH (EXCEPT CUTAWAY) UNLOCK W/ HINGED CARGO DOOR W/ SLIDING CARGO DOOR WHT WIRE WHT/BLK WIRE WHT/YEL WIRE YEL WIRE

1 1034 HORNS SYSTEM INTERIOR LIGHTS SYSTEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 (+/-) 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 VPWR VPWR 120 343 118 517 1205 INTERIOR LIGHTS SYSTEM BLK WIRE BLK/WHT WIRE BRN WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/LT GRN WIRE DOOR JAMP SW DOOR LOCK MOTOR DOOR LOCK SW DOOR LOCK SW RTN SIG DOOR LOCK MOTOR VBATT GND EXCEPT CUTAWAY FRONT PASSENGER WINDOW/DOOR LOCK SWITCH FUSE 10 FUSE 2 FUSE 23 HINGED SIDE DOOR HORN RELAY CTRL DOME LAMP SW HOT AT ALL TIMES HOT IN START OR RUN CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) INSTRUMENT CLUSTER ISO BUS LEFT FRONT DOOR LOCK ACTUATOR (AT REAR OF LEFT FRONT DOOR) LOCK LT BLU/WHT WIRE MASTER WINDOW/ DOOR LOCK/UNLOCK SWITCH NCA WIRE ORG/ WIRE PNK 1 WIRE PNK PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE REAR DOORS DOOR LOCK ACTUATOR (EXCEPT CUTAWAY) (AT LEFT SIDE OF RIGHT REAR DOOR) RED WIRE RED/ORG WIRE RED/PNK WIRE RED/YEL WIRE RIGHT SIDE DOOR LOCK ACTUATOR (AT REAR OF RIGHT SIDE HINGED DOOR) RIGHT SLIDING DOOR AJAR SWITCH (AT RIGHT "B" PILLAR) RIGHT SLIDING DOOR CONTACT SWITCH (AT RIGHT "B" PILLAR) SLIDING DOOR WIRE SLIDING SIDE DOOR TAN WIRE TAN/WHT WIRE UNLOCK VBATT VEHICLE SECURITY MODULE (VSM) (AT RIGHT KICK PANEL) WHT WIRE YEL WIRE

BLK WIRE BLU WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FUSE 39 DK BLU WIRE DK GRN WIRE ELECTRONIC FLASHER MODULE (BEHIND LEFT SIDE OF DASH) ENDS IN HARNESS FUSE 10 FUSE 11 FUSE 7 GRN WIRE HAZARD SWITCH HEAD OFF HOT AT ALL TIMES HOT IN RUN INSTRUMENT CLUSTER LEFT TURN LEFT TURN IND LEFT TURN SIGNAL LT BLU WIRE LT GRN WIRE LT GRN/WHT WIRE MAIN LIGHT SWITCH MICROPROCESSOR MULTI- FUNCTION SWITCH ORG/ WIRE PARK RED WIRE RESISTOR RIGHT TURN RIGHT TURN IND RIGHT TURN SIGNAL SIDE MARKER STOP LAMPS TAN WIRE TO PARKING LAMP TRAILER TOW RELAY (DIAGRAM 2 OF 2) TO RIGHT TURN TRAILER TOW RELAY (DIAGRAM 2 OF 2) W/ REAR LIGHTS W/O REAR LIGHTS WHT WIRE WHT/LT BLU WIRE YEL WIRE

1 2 3 4 5 6 LO BEAM VBATT VPWR GND FPPWR BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FUSE 30 DAYTIME RUNNING LAMPS (DRL) MODULE (RIGHT FRONT OF ENGINE COMPARTMENT) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/ORG WIRE DRL EXCEPT DIESEL DIESEL FUSE 10 FUSE 15 FUSE 25 FUSE 3 FUSE 31 FUSE 6 GRY WIRE GRY/WHT WIRE HI FTP LO HI-BEAM IND HIGH BEAM, DRL HOT AT ALL TIMES HOT IN INSTRUMENT CLUSTER LOGIC GROUND LOW BEAM LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE MAIN LIGHT SWITCH MULTI- FUNCTION SWITCH OFF HEAD PARK ORG/ WIRE PARK BR SW PARKING BRAKE SWITCH (NEAR LEFT KICK PANEL) RED WIRE RED/BLK WIRE RUN WIRE STRIPPED CHASSIS CONNECTIONS TAN WIRE W/ PARKING AID WHT WIRE WHT/LT BLU WIRE YEL WIRE

BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE BUS (-) BUS (+) CRANKSHAFT POSITION SENSOR (LOWER CENTER FRONT OF ENGINE) DIFFERENTIAL PRESSURE FEEDBACK EGR SENSOR (CALIFORNIA) (TOP LEFT SIDE OF ENGINE) DK BLU WIRE DK GRN/YEL WIRE EXCEPT STRIPPED CHASSIS FUEL LEVEL VREF FUEL PUMP FUEL PUMP DRIVER MODULE (UNDER REAR OF VEHICLE, NEAR TANK) FUEL PUMP RELAY FUEL TANK PRESSURE TRANSDUCER (IN FUEL TANK) FUSE 13 GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES INJECTION PRESSURE SENSOR (FRONT OF LEFT CYLINDER BANK) INSTRUMENT CLUSTER LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN/YEL WIRE MALFUNCTION INDICATOR LAMP ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE STRIPPED CHASSIS TAN/LT BLU WIRE TAN/ORG WIRE THROTTLE POSITION SENSOR (ON TOP OF ENGINE, NEAR AIR INTAKE) VIO/ORG WIRE WHT WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE