Ford Econoline E150 (1997-2012) hot in run or start Wiring diagrams

ABS SYSTEM, WARNING BUZZER MODULE BATTERY JUNCTION BOX BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) FUSE 9 BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 8 CHT VSS PWR IN GND GND EPC OSS MAF TPS VREF SIG RTN BPP GND CRUISE CONTROL SYSTEM CYLINDER HEAD TEMPERATURE SENSOR DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) 10 13 DIGITAL TRANSMISSION RANGE SENSOR DK BLU/YEL WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS ENGINE CONTROLS (4.6L) (5.4L) ENGINE CONTROLS (ENG CONTROL HARN, NEAR BREAKOUT TO A/C PRESSURE CUTOUT SWITCH) EXTERIOR LIGHTS FUSE 11 FUSE 2 FUSE 20 FUSE 4 GND TCC KAPWR GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION COIL, RADIO NOISE CAPACITOR INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MAF TFT MAF ECT MALFUNCTION INDICATOR LAMP MASS AIRFLOW (MAF) SENSOR (TOP CENTER OF ENGINE COMPT) MULTIFUNCTION SWITCH, DEAVTIATOR SWITCH NCA WIRE OD OFF ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) OVERDRIVE CANCEL SWITCH PCM DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE SHIFT SOLENOIDS SPEEDOMETER SSA SSB TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE THROTTLE POSITION SENSOR (TPS) (ON TOP OF ENGINE, NEAR AIR INTAKE) TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

24 45 8 REV LMP CTRL KAPWR BPP SW 27 1 4 5 6 16 17 18 28 47 48 49 50 10 OD CANCEL SW VSS APPA_+ 35 36 VPWR VPWR APPA_- APPB_+ APPB_- AUXILIARY RELAY BOX 1 (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) FUSE 23 BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DK BLU/WHT WIRE DK GRN WIRE DK GRN/ORG WIRE ENDS IN HARNESS ENGINE CONTROLS SYSTEM FUSE 11 FUSE 2 FUSE 21 FUSE 27 FUSE 8 GROUND GROUND GROUND GROUND GROUND GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN OR START LT GRN/RED WIRE NCA WIRE OD OFF OVERDRIVE CANCEL SWITCH OVERHEAD CONSOLE (IF EQUIPPED) PCM POWER DIODE PCM POWER RELAY RED WIRE RED/LT GRN WIRE RED/YEL WIRE REVERSING LAMP RELAY TAN WIRE TAN/WHT WIRE TAN/YEL WIRE W/ ADVANCE TRAC W/ REMOTE KEYLESS ENTRY OR ADVANCE TRAC W/ STRIPPED CHASSIS WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL/BLK WIRE

35 36 IGNITION (ST/RUN) IGNITION (ST/RUN) 45 8 CLUSTER PWR BPP SW BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DK BLU/WHT WIRE DK GRN WIRE ENDS IN HARNESS ENGINE CONTROLS SYSTEM FUSE 11 FUSE 2 FUSE 21 FUSE 23 FUSE 27 FUSE 8 GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN OR START LT GRN/RED WIRE NCA WIRE OD OFF OVERDRIVE CANCEL SWITCH OVERHEAD CONSOLE (IF EQUIPPED) PCM POWER DIODE PCM POWER RELAY RED WIRE RED/LT GRN WIRE RED/YEL WIRE TAN WIRE TAN/WHT WIRE TAN/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL/BLK WIRE

ABS SYSTEM, WARNING BUZZER MODULE BATTERY JUNCTION BOX BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) FUSE 9 BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 8 CHT VSS PWR IN GND GND EPC OSS MAF TPS VREF SIG RTN BPP GND CRUISE CONTROL SYSTEM CYLINDER HEAD TEMPERATURE SENSOR DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) 10 13 DIGITAL TRANSMISSION RANGE SENSOR DK BLU/YEL WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS ENGINE CONTROLS (4.6L) (5.4L) ENGINE CONTROLS (ENG CONTROL HARN, NEAR BREAKOUT TO A/C PRESSURE CUTOUT SWITCH) EXTERIOR LIGHTS FUSE 11 FUSE 2 FUSE 20 FUSE 4 GND TCC KAPWR GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION COIL, RADIO NOISE CAPACITOR INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MAF TFT MAF ECT MALFUNCTION INDICATOR LAMP MASS AIRFLOW (MAF) SENSOR (TOP CENTER OF ENGINE COMPT) MULTIFUNCTION SWITCH, DEAVTIATOR SWITCH NCA WIRE OD OFF ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) OVERDRIVE CANCEL SWITCH PCM DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE SHIFT SOLENOIDS SPEEDOMETER SSA SSB TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE THROTTLE POSITION SENSOR (TPS) (ON TOP OF ENGINE, NEAR AIR INTAKE) TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

35 36 IGNITION (ST/RUN) IGNITION (ST/RUN) 45 8 CLUSTER PWR BPP SW BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DK BLU/WHT WIRE DK GRN WIRE ENDS IN HARNESS ENGINE CONTROLS SYSTEM FUSE 11 FUSE 2 FUSE 21 FUSE 23 FUSE 27 FUSE 8 GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN OR START LT GRN/RED WIRE NCA WIRE OD OFF OVERDRIVE CANCEL SWITCH OVERHEAD CONSOLE (IF EQUIPPED) PCM POWER DIODE PCM POWER RELAY RED WIRE RED/LT GRN WIRE RED/YEL WIRE TAN WIRE TAN/WHT WIRE TAN/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL/BLK WIRE

24 45 8 REV LMP CTRL KAPWR BPP SW 27 1 4 5 6 16 17 18 28 47 48 49 50 10 OD CANCEL SW VSS APPA_+ 35 36 VPWR VPWR APPA_- APPB_+ APPB_- AUXILIARY RELAY BOX 1 (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) FUSE 23 BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DK BLU/WHT WIRE DK GRN WIRE DK GRN/ORG WIRE ENDS IN HARNESS ENGINE CONTROLS SYSTEM FUSE 11 FUSE 2 FUSE 21 FUSE 27 FUSE 8 GROUND GROUND GROUND GROUND GROUND GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN OR START LT GRN/RED WIRE NCA WIRE OD OFF OVERDRIVE CANCEL SWITCH OVERHEAD CONSOLE (IF EQUIPPED) PCM POWER DIODE PCM POWER RELAY RED WIRE RED/LT GRN WIRE RED/YEL WIRE REVERSING LAMP RELAY TAN WIRE TAN/WHT WIRE TAN/YEL WIRE W/ ADVANCE TRAC W/ REMOTE KEYLESS ENTRY OR ADVANCE TRAC W/ STRIPPED CHASSIS WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 +/- 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 MS CAN + MS CAN - B+ GROUND GROUND BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DK BLU WIRE EXCEPT CUTAWAY FUSE 10 FUSE 15 FUSE 2 FUSE 23 HEAD HINGED SIDE DOOR HORNS SYSTEM HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN RUN OR START LEFT FRONT DOOR LOCK ACTUATOR (AT REAR OF LEFT FRONT DOOR) LT BLU WIRE LT BLU/PNK WIRE MAIN LIGHT SWITCH OFF ORG/ WIRE PARK PARK/HEAD PNK 1 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE REAR DOORS DOOR LOCK ACTUATOR (EXCEPT CUTAWAY) (AT LEFT SIDE OF RIGHT REAR DOOR) RED WIRE RED/ORG WIRE RED/YEL WIRE RIGHT FRONT DOOR LOCK ACTUATOR (AT REAR OF RIGHT FRONT DOOR) RIGHT SIDE DOOR LOCK ACTUATOR (AT REAR OF RIGHT SIDE HINGED DOOR) RIGHT SIDE DOOR LOCK ACTUATOR (IN FRONT OF RIGHT SIDE SLIDING DOOR) RIGHT SLIDING DOOR CONTACT SWITCH (AT RIGHT "B" PILLAR) RUN/ACC RUN/START B+ SLIDING SIDE DOOR TAN WIRE TAN/WHT WIRE UNLOCK LOCK HORN RELAY VEHICLE SECURITY MODULE (VSM) (BEHIND RIGHT END OF DASH) WHT WIRE WHT/BLK WIRE YEL WIRE

16 17 15 DRIVER DOOR AJAR SLIDING DOOR AJAR DOORS AJAR 23 22 MS CAN+ MS CAN- 5 10 RUN/START PWR GROUND BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM FRONT PASSENGER WINDOW/DOOR LOCK SWITCH FUSE 14 FUSE 22 HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER LEFT FRONT DOOR AJAR SWITCH (AT LEFT KICK PANEL) LOCK LOGIC GROUND LR GRN WIRE LT BLU WIRE LT GRN WIRE MASTER WINDOW/ DOOR LOCK/UNLOCK SWITCH NCA WIRE PNK PNK WIRE PNK WIRE PNK/LT GRN WIRE PNK/YEL WIRE REAR DOORS DOOR AJAR RED WIRE RED/PNK WIRE RED/WHT WIRE RIGHT FRONT DOOR AJAR SWITCH (AT RIGHT KICK PANEL) RIGHT SIDE DOOR AJAR SWITCH (IN FRONT OF RIGHT SIDE DOOR) RIGHT SLIDING DOOR AJAR SWITCH (AT RIGHT "B" PILLAR) SWITCH (EXCEPT CUTAWAY) UNLOCK W/ HINGED CARGO DOOR W/ SLIDING CARGO DOOR WHT WIRE WHT/BLK WIRE WHT/YEL WIRE YEL WIRE

BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM CONTROL DK BLU WIRE DOOR LOCK RELAY DRIVER DOOR UNLOCK RELAY EXCEPT CUTAWAY FUSE 10 FUSE 15 FUSE 2 FUSE 23 GND GND HEAD HINGED SIDE DOOR HORNS SYSTEM HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN RUN OR START LEFT FRONT DOOR LOCK ACTUATOR (REAR OF LEFT FRONT DOOR) LT BLU WIRE LT BLU/PNK WIRE MAIN LIGHT SWITCH MS CAN - MS CAN + OFF ORG/ WIRE PARK PARK LAMP RELAY PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE REAR DOORS DOOR LOCK ACTUATOR (EXCEPT CUTAWAY) (LEFT SIDE OF RIGHT REAR DOOR) RED WIRE RED/ORG WIRE RED/YEL WIRE RIGHT FRONT DOOR LOCK ACTUATOR (REAR OF RIGHT FRONT DOOR) RIGHT SLIDING DOOR CONTACT SWITCH (AT RIGHT "B" PILLAR) RUN/ACC RUN/START B+ SLIDING SIDE DOOR SWITCH HARNESS, NEAR BREAKOUT TO RESTRAINTS CONTROL MODULE) TAN WIRE TAN/WHT WIRE UNLOCK LOCK HORN RLY CONTROL CONTROL CONTROL VEHICLE SECURITY MODULE (VSM) (BEHIND RIGHT END OF DASH) WHT WIRE WHT/BLK WIRE YEL WIRE

10 5 PWR GROUND RUN/START 16 17 15 DRIVER DOOR AJAR SLIDING DOOR AJAR DOORS AJAR 23 22 MS CAN+ MS CAN- BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM FRONT PASSENGER WINDOW/DOOR LOCK SWITCH FUSE 14 FUSE 22 HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER (IC) LEFT FRONT DOOR AJAR SWITCH (BEHIND LEFT KICK PANEL) LOCK UNLOCK LOGIC GROUND LT BLU WIRE LT GRN WIRE MASTER WINDOW/ DOOR LOCK/UNLOCK SWITCH NCA WIRE PNK PNK WIRE PNK WIRE PNK/LT GRN WIRE PNK/YEL WIRE REAR DOORS DOOR AJAR RED WIRE RED/PNK WIRE RED/WHT WIRE RIGHT FRONT DOOR AJAR SWITCH (BEHIND RIGHT KICK PANEL) RIGHT SIDE DOOR AJAR SWITCH (FRONT OF RIGHT SIDE FRONT HINGED DOOR) RIGHT SLIDING DOOR AJAR SWITCH (AT RIGHT "B" PILLAR) SWITCH (EXCEPT CUTAWAY) UNLOCK LOCK W/ HINGED CARGO DOOR W/ SLIDING CARGO DOOR W/ STRIPPED CHASSIS WHT WIRE WHT/BLK WIRE WHT/YEL WIRE YEL WIRE