Ford Econoline E150 (1997-2012) hot in park or head Wiring diagrams

1 2 4.2L/4.6L 5.4L/6.8L 1 2 7 4 ANTI-LOCK IND RELAY CTRL BRAKE SWITCH BRAKE IND 4 WHEEL ANTI- LOCK BRAKES MODULE (ON LEFT FRONT FRAME RAIL) 45 12 9 ECT SIGNAL FUEL SIGNAL 1 2 AIR BAG IND ANTI-LOCK BRAKE IND ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING IND CHARGE IND CNG GAS CONN A CONN B CONN C CRUISE CONTROL DAYTIME RUNNING LAMPS MODULE (IN RIGHT FRONT OF ENGINE COMPARTMENT, NEAR HORNS) DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE DUAL BRAKE WARNING SWITCH (BOTTOM OF MASTER CYLINDER) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE ENGINE OIL PRESSURE GAUGE FASTEN SEATBELT IND FUEL PUMP MODULE (UNDER VEHICLE, IN FUEL TANK) FUSE 14 FUSE 2 FUSE 36 FUSE 4 GND IGNITION SWITCH GRY/BLK WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT AT ALL TIMES HOT IN PARK OR HEAD HOT IN RUN OR START INSTRUMENT CLUSTER INSTRUMENT ILLUMINATION INSTRUMENTATION ENGINE COOLANT TEMPERATURE SENSOR (ON FRONT OF ENGINE) INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF DASH) LEFT TURN IND LOW OIL PRESS/HI COOLANT TEMP IND LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MALFUNCTION (MIL) IND MIL IND OFF LOCK PARKING BRAKE SWITCH (NEAR LEFT KICK PANEL) PNK/LT GRN WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (NEAR BRAKE MASTER CYLINDER) PPL/WHT WIRE PPL/YEL WIRE RED WIRE RED/WHT WIRE RED/YEL WIRE RELAY (BEHIND CENTER OF DASH) RIGHT TURN IND RUN WIRE SPEEDO- METER STARTING/ CHARGING SYSTEM 608 1044 SUPPLEMENTAL RESTRAINTS SYSTEM TACHO- METER TAN WIRE TAN/LT GRN WIRE VANS, WAGONS CUTAWAYS VEHICLE SPEED SENSOR (UNDER VEHICLE, ON LEFT SIDE OF TRANS) VOLTMETER VSS SIGNAL W/ DRL W/O DRL WARNING SYSTEMS 603 932 WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

1 2 4.2L/4.6L 5.4L/6.8L 1 2 7 4 ANTI-LOCK IND RELAY CTRL BRAKE SWITCH BRAKE IND 4 WHEEL ANTI- LOCK BRAKES MODULE (ON LEFT FRONT FRAME RAIL) 45 12 9 ECT SIGNAL FUEL SIGNAL 1 2 AIR BAG IND ANTI-LOCK BRAKE IND ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING IND CHARGE IND CNG GAS CONN A CONN B CONN C CRUISE CONTROL DAYTIME RUNNING LAMPS MODULE (IN RIGHT FRONT OF ENGINE COMPARTMENT, NEAR HORNS) DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE DUAL BRAKE WARNING SWITCH (BOTTOM OF MASTER CYLINDER) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE ENGINE OIL PRESSURE GAUGE FASTEN SEATBELT IND FUEL PUMP MODULE (UNDER VEHICLE, IN FUEL TANK) FUSE 14 FUSE 2 FUSE 36 FUSE 4 GND IGNITION SWITCH GRY/BLK WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT AT ALL TIMES HOT IN PARK OR HEAD HOT IN RUN OR START INSTRUMENT CLUSTER INSTRUMENT ILLUMINATION INSTRUMENTATION ENGINE COOLANT TEMPERATURE SENSOR (ON FRONT OF ENGINE) INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF DASH) LEFT TURN IND LOW OIL PRESS/HI COOLANT TEMP IND LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MALFUNCTION (MIL) IND MIL IND OFF LOCK PARKING BRAKE SWITCH (NEAR LEFT KICK PANEL) PNK/LT GRN WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (NEAR BRAKE MASTER CYLINDER) PPL/WHT WIRE PPL/YEL WIRE RED WIRE RED/WHT WIRE RED/YEL WIRE RELAY (BEHIND CENTER OF DASH) RIGHT TURN IND RUN WIRE SPEEDO- METER STARTING/ CHARGING SYSTEM 608 1044 SUPPLEMENTAL RESTRAINTS SYSTEM TACHO- METER TAN WIRE TAN/LT GRN WIRE VANS, WAGONS CUTAWAYS VEHICLE SPEED SENSOR (UNDER VEHICLE, ON LEFT SIDE OF TRANS) VOLTMETER VSS SIGNAL W/ DRL W/O DRL WARNING SYSTEMS 603 932 WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

1 2 4.2L/4.6L 5.4L/6.8L 1 2 7 4 ANTI-LOCK IND RELAY CTRL BRAKE SWITCH BRAKE IND 4 WHEEL ANTI- LOCK BRAKES MODULE (ON LEFT FRONT FRAME RAIL) 45 12 9 ECT SIGNAL FUEL SIGNAL 1 2 AIR BAG IND ANTI-LOCK BRAKE IND ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING IND CHARGE IND CNG GAS CONN A CONN B CONN C CRUISE CONTROL DAYTIME RUNNING LAMPS MODULE (IN RIGHT FRONT OF ENGINE COMPARTMENT, NEAR HORNS) DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE DUAL BRAKE WARNING SWITCH (BOTTOM OF MASTER CYLINDER) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE ENGINE OIL PRESSURE GAUGE FASTEN SEATBELT IND FUEL PUMP MODULE (UNDER VEHICLE, IN FUEL TANK) FUSE 14 FUSE 2 FUSE 36 FUSE 4 GND IGNITION SWITCH GRY/BLK WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT AT ALL TIMES HOT IN PARK OR HEAD HOT IN RUN OR START INSTRUMENT CLUSTER INSTRUMENT ILLUMINATION INSTRUMENTATION ENGINE COOLANT TEMPERATURE SENSOR (ON FRONT OF ENGINE) INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF DASH) LEFT TURN IND LOW OIL PRESS/HI COOLANT TEMP IND LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MALFUNCTION (MIL) IND MIL IND OFF LOCK PARKING BRAKE SWITCH (NEAR LEFT KICK PANEL) PNK/LT GRN WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (NEAR BRAKE MASTER CYLINDER) PPL/WHT WIRE PPL/YEL WIRE RED WIRE RED/WHT WIRE RED/YEL WIRE RELAY (BEHIND CENTER OF DASH) RIGHT TURN IND RUN WIRE SPEEDO- METER STARTING/ CHARGING SYSTEM 608 1044 SUPPLEMENTAL RESTRAINTS SYSTEM TACHO- METER TAN WIRE TAN/LT GRN WIRE VANS, WAGONS CUTAWAYS VEHICLE SPEED SENSOR (UNDER VEHICLE, ON LEFT SIDE OF TRANS) VOLTMETER VSS SIGNAL W/ DRL W/O DRL WARNING SYSTEMS 603 932 WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

** (5.4L, 6.8L) * (4.2L, 4.6L) 1 2 7 ANTI-LOCK IND RELAY CTRL BRAKE SWITCH 2 5 MIL IND BRAKE IND 45 ** 9 * 12 ECT SIGNAL FUEL SIGNAL 7.3L DIESEL ONLY AIR BAG ALL EXCEPT 7.3L DIESEL ALL WHEEL ANTI-LOCK BRAKE SYSTEM MODULE ANTI- SLOSH MODULE ANTI-LOCK BRAKE BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING CHARGE CHARGING CONN A CONN B CONN C CRUISE CONTROL DAYTIME RUNNING LAMPS MODULE DIESEL ONLY DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE DUAL BRAKE WARNING SWITCH (NEAR MASTER CYLINDER) ENGINE COOLANT TEMPERATURE GAUGE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF ENGINE) ENGINE OIL PRESSURE SWITCH (FRONT OF ENGINE) ENGINE OIL PRSSURE GAUGE EXTERIOR LIGHTS FASTEN BELTS OUTPUT FASTEN SEATBELT FUEL FILTER FUEL GAUGE FUEL PUMP MODULE (ON FUEL TANK) FUEL PUMP MODULE IN-TRANSIT FUEL PUMP MODULE (ON LEFT FRAME RAIL) FUEL WATER SWITCH (DIESEL) (TOP RIGHT FRONT OF ENGINE) FUSE 14 FUSE 2 FUSE 36 FUSE 4 GND IGNITION SWITCH GRY/BLK WIRE GRY/WHT WIRE HEADLIGHTS HIGH BEAM HOT AT ALL TIMES HOT IN PARK OR HEAD HOT IN RUN OR START INSTRUMENT ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LEFT TURN LOW VACUUM WARNING SWITCH (LEFT FRONT OF ENGINE COMPT) LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE MALFUNCTION (MIL) OFF LOCK PARKING BRAKE SWITCH (ABOVE BRAKE PEDAL) PLUGGED FUEL FILTER VACUUM SWITCH (TOP RIGHT SIDE OF ENG) PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE PPL/WHT WIRE PPL/YEL WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE RED/YEL WIRE RELAY (CENTER OF I/P) RIGHT TURN RUN WIRE SOLID STATE SPEEDOMETER SUPPLEMENTAL RESTRAINTS TAN/LT GRN WIRE VANS, WAGONS CUTAWAYS VEHICLE SPEED SENSOR (ON TRANSAXLE) VSS SIGNAL W/ DRL W/O DRL WAIT TO WAIT TO START WARNING BUZZER MODULE WATER IN FUEL WATER IN FUEL SENSOR (TOP LEFT CENTER OF ENGINE) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/RED WIRE YEL/WHT WIRE

** (5.4L, 6.8L) * (4.2L, 4.6L) 2 5 MIL IND BRAKE IND 45 ** 9 * 12 ECT SIGNAL FUEL SIGNAL 7 2 ANTI-LOCK IND BRAKE SWITCH 7.3L DIESEL ONLY AIR BAG ALL EXCEPT 7.3L DIESEL ANTI- SLOSH MODULE ANTI-LOCK BRAKE BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING CHARGE CHARGING CONN A CONN B CONN C CRUISE CONTROL DAYTIME RUNNING LAMPS MODULE DIESEL ONLY DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE DUAL BRAKE WARNING DIODE/ RESISTOR ASSEMBLY (LEFT SIDE OF I/P) DUAL BRAKE WARNING SWITCH (NEAR MASTER CYLINDER) ENGINE COOLANT TEMPERATURE GAUGE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF ENGINE) ENGINE OIL PRESSURE SWITCH (FRONT OF ENGINE) ENGINE OIL PRSSURE GAUGE EXTERIOR LIGHTS FASTEN BELTS OUTPUT FASTEN SEATBELT FUEL FILTER FUEL GAUGE FUEL PUMP MODULE (ON FUEL TANK) FUEL PUMP MODULE (ON FUEL TANK) IN-TRANSIT FUEL PUMP MODULE (ON LEFT FRAME RAIL) FUEL WATER SWITCH (DIESEL) (TOP RIGHT FRONT OF ENGINE) FUSE 14 FUSE 2 FUSE 36 FUSE 4 GND IGNITION SWITCH GRY/BLK WIRE GRY/WHT WIRE HEADLIGHTS HIGH BEAM HOT AT ALL TIMES HOT IN PARK OR HEAD HOT IN RUN OR START INSTRUMENT ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LEFT TURN LOW VACUUM WARNING SWITCH (LEFT FRONT OF ENGINE COMPT) LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE MALFUNCTION (MIL) OFF LOCK PARKING BRAKE SWITCH (ABOVE BRAKE PEDAL) PLUGGED FUEL FILTER VACUUM SWITCH (TOP RIGHT SIDE OF ENG) PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE PPL/WHT WIRE PPL/YEL WIRE REAR ANTI-LOCK BRAKE SYSTEM MODULE RED WIRE RED/BLK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN RUN WIRE SOLID STATE SPEEDOMETER SUPPLEMENTAL RESTRAINTS TAN/LT GRN WIRE VANS, WAGONS CUTAWAYS VEHICLE SPEED SENSOR (ON TRANSAXLE) VSS SIGNAL W/ DRL W/O DRL WAIT TO WAIT TO START WARNING BUZZER MODULE WATER IN FUEL WATER IN FUEL SENSOR (DIESEL) (TOP LEFT CENTER OF ENGINE) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/RED WIRE YEL/WHT WIRE

ANTENNA BLK WIRE BLK/LT GRN WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) (LEFT SIDE OF DASH, NEAR KICK PANEL) CUTAWAYS DK GRN/ORG WIRE FUSE 22 FUSE 27 FUSE 3 FUSE 36 GRY/LT BLU WIRE HINGED SIDE DOOR HOT AT ALL TIMES HOT IN HOT IN PARK OR HEAD HOT IN RUN OR ACC ILLUMINATION GROUND NOISE REDUCTION LEFT FRONT DOOR SPEAKER LEFT MID SPEAKER (W/ 6 SPEAKERS) LEFT REAR SPEAKER LT BLU WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE NCA WIRE NOT USED ORG/LT GRN WIRE ORG/RED WIRE RADIO RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT SPEAKER RIGHT MID SPEAKER (W/ 6 SPEAKERS) RIGHT MID SPEAKER (W/ 6 SPEAKERS) RIGHT REAR SPEAKER RIGHT SLIDING DOOR CONTACT SWITCH SLIDING SIDE DOOR TAN/YEL WIRE VANS, WAGONS WHT WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE

ANTENNA BARE BARE SHIELD SIGNAL SIGNAL SIGNAL SIGNAL BLK WIRE BLK/LT GRN WIRE BRN WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX LEFT SIDE OF DASH, NEAR KICK PANEL) DK GRN/ORG WIRE FUSE 22 FUSE 27 FUSE 3 FUSE 33 FUSE 36 FUSE 39 GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN HOT IN PARK OR HEAD HOT IN RUN OR ACC ILLUMINATION GROUND NOISE REDUCTION LEFT FRONT DOOR SPEAKER LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/YEL WIRE NCA WIRE ORG/ WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK 1 WIRE POWER POINT CONSOLE 1 POWER POINT CONSOLE 2 RADIO RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT SPEAKER SIGNAL SIGNAL SIGNAL TAN WIRE TAN/YEL WIRE WHT WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUM, FEED GROUND VPWR ANTENNA BLK WIRE BLK/LT GRN WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CUTAWAY DK GRN/ORG WIRE FUSE 22 FUSE 27 FUSE 3 FUSE 36 GRY/LT BLU WIRE HINGED SIDE DOOR HOT AT ALL TIMES HOT IN HOT IN PARK OR HEAD HOT IN RUN OR ACC LEFT FRONT SPEAKER LEFT MIDDLE SPEAKER (W/ 6 SPEAKERS) LEFT REAR SPEAKER LT BLU WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE NCA WIRE OF RIGHT SLIDING DOOR) TWISTED PAIR ORG/LT GRN WIRE ORG/RED WIRE RADIO RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT SPEAKER RIGHT REAR SPEAKER RIGHT RIGHT MIDDLE MIDDLE SPEAKER SPEAKER (W/ 6 (W/ 6 SPEAKERS) SPEAKERS) RIGHT SLIDING DOOR CONTACT SWITCH (IN FRONT SLIDING SIDE DOOR TAN/YEL WIRE TWISTED PAIR W/ OVERHEAD CONSOLE WHT WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUM, FEED GROUND VPWR 17 18 R RSE MODULE TO RADIO (+) R RSE MODULE TO RADIO (-) 19 20 L RSE MODULE TO RADIO (+) L RSE MODULE TO RADIO (-) ANTENNA ASYSON CORPORATE PROTOCOL (A) CORPORATE PROTOCOL (B) BLK WIRE BLK/LT GRN WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DK GRN/ORG WIRE FUSE 22 FUSE 27 FUSE 3 FUSE 36 GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN HOT IN PARK OR HEAD HOT IN RUN OR ACC LEFT FRONT SPEAKER LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE ORG/LT GRN WIRE ORG/RED WIRE PAIR RADIO RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT SPEAKER SHIELD TAN WIRE TAN/LT GRN WIRE TAN/WHT WIRE TAN/YEL WIRE TWISTED W/ OVERHEAD CONSOLE WHT WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE