Ford Econoline E150 (1997-2012) fuse 27 Wiring diagrams

1 2 3 4 5 6 7 8 9 10 ON INDICATOR ACCEL SET/ AIR BAG SLIDING CONTACT BATTERY JUNCTION BOX (BJB) (IN LEFT FRONT OF ENGINE COMPARTMENT) BLK WIRE BLK/WHT WIRE BRAKE INPUT GROUND BRAKE PEDAL POSITION (BPP) SWITCH (ON BRACKET, ABOVE BRAKE PEDAL) BRAKE PRESSURE SWITCH (AT LEFT SIDE OF ENGINE COMPARTMENT) CENTRAL JUNCTION BOX (CJB) (LEFT SIDE OF DASH, NEAR KICK PANEL) COAST DK BLU WIRE DK GRN/ORG WIRE EXCEPT STRIPPED CHASSIS FUSE 11 FUSE 27 FUSE 6 GRY WIRE GRY/BLK WIRE HORN RELAY HORN SWITCH HOT AT ALL TIMES HOT IN INSTRUMENT CLUSTER LT BLU/BLK WIRE LT GRN WIRE LT GRN/RED WIRE MICROPROCESSOR NCA WIRE OFF ORG/ WIRE OVERHEAD CONSOLE PNK/ORG WIRE RED WIRE RED/LT GRN WIRE REMOTE KEYLESS ENTRY MODULE (BEHIND LEFT "B" PILLAR) RESUME RUN WIRE SPEED CONTROL INDICATOR SPEED CONTROL SERVO (LEFT SIDE OF ENGINE COMPT, NEAR BRAKE MASTER CYLINDER) SPEED CONTROL SWITCH VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE VSS INPUT BPP SW INPUT SCSA INPUT SCSA GND POWER YEL/LT BLU WIRE

1 2 3 HI BEAM IN OUT 507/13 527/12 ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/ORG WIRE BRAKE IND OUT 6 7 8 LO BEAMS IN BATTERY PWR IN BRAKE WARNING INDICATOR HIGH BEAM INDICATOR DAYTIME RUNNING LAMPS (DRL) MODULE (LOWER RIGHT FRONT OF ENGINE, NEAR HORNS) DIESEL DIESEL (W/ RABS) DIESEL ONLY DK BLU WIRE DRL DISABLE ENGINE COMPARTMENT FUSE BOX (IN LEFT FRONT OF ENGINE COMPARTMENT) FLASH TO PASS FUSE 10 FUSE 15 FUSE 2 FUSE 27 FUSE 30 FUSE 6 GASOLINE W/ RABS GRY WIRE GRY/WHT WIRE HEAD PARK HI PASS LO HOT AT ALL TIMES HOT IN RUN HOT IN START OR RUN I/P FUSE PANEL (BEHIND LEFT SIDE OF DASH) I/P FUSE PANEL (BEHIND LEFT SIDE OF DASH) FUSE 25 FUSE 31 IGN INPUT INSTRUMENT CLUSTER LEFT HEADLAMP RIGHT HEADLAMP LOW VACUUM WARNING SWITCH (IN LEFT FRONT OF ENGINE COMPARTMENT) LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MAIN LIGHT SWITCH MULTI- FUNCTION SWITCH (DIMMER) DIMMER OFF ORG/ WIRE PARK BK ON IN PARKING BRAKE SWITCH (NEAR LEFT KICK PANEL) PPL PPL/ORG WIRE PPL/WHT WIRE PPL/YEL WIRE PULSED OUTPUT RED WIRE RED/BLK WIRE RED/YEL WIRE REMOTE KEYLESS ENTRY MODULE (BEHIND "B" PILLAR) TAN WIRE WHT WIRE YEL WIRE YEL/LT BLU WIRE

1 2 3 4 5 6 LO BEAM OUT BATT IGN IN GROUND HI BEAM IN PARK BRAKE BATTERY JUNCTION BOX BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE CENTRAL JUNCTION BOX CENTRAL JUNCTION BOX FUSE 25 FUSE 31 DK BLU WIRE FLASH TO PASS FUSE 10 FUSE 15 FUSE 27 FUSE 30 FUSE 6 HEAD PARK HI PASS LO HOT AT ALL TIMES HOT IN INSTRUMENT CLUSTER HI BEAM IND. LEFT HEADLAMP LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MAIN LIGHT SWITCH MULTI- FUNCTION SWITCH DIMMER OFF ORG/ WIRE PARKING BRAKE SWITCH (NEAR LEFT KICK PANEL) PASS HI LO RED WIRE RED/BLK WIRE RED/YEL WIRE RIGHT HEADLAMP RUN WIRE TAN WIRE VIO WIRE VIO/ORG WIRE WARNING SYSTEM WHT WIRE YEL WIRE YEL/LT BLU WIRE

AUXILIARY BATTERY RELAY AUXILIARY RELAY BOX 2 (BEHIND CENTER OF DASH) BATTERY CHARGE TRAILER TOW RELAY BATTERY II BATTERY SAVER RELAY BLK/LT BLU WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COURTESY SW FEED DIESEL AND ALL W/O AUXILIARY BATTERY DK GRN WIRE DK GRN/YEL WIRE DRIVER SIDE FRONT SEAT ADJUST SWITCH ENGINE COMPT) EXCEPT CUTAWAY EXCEPT CUTAWAY CUTAWAY EXCEPT MODIFIED VEHICLES EXCEPT STRIPPED CHASSIS FROM FUSE 18 (DIAGRAM 1 OF 4) FROM FUSE 4 (DIAGRAM 2 OF 4) FROM FUSE 5 (DIAGRAM 2 OF 4) FUSE FUSE 10 FUSE 11 FUSE 14 FUSE 16 (EXCEPT DIESEL) FUSE 20 FUSE 22 FUSE 23 FUSE 17 FUSE 24 FUSE 27 FUSE 5 FUSE 8 FUSE FUSE FUSE FUSE 21 FUSE FUSE 4 FUSE FUSE FUSE FUSE FUSE FUSE 22 GASOLINE W/ AUXILIARY BATTERY GASOLINE W/ AUXILIARY BATTERY JUMPER GRN/ LT WIRE LT BLU PNK/ WIRE LT GRN PNK/ WIRE LT GRN/ BLK WIRE LT GRN/RED WIRE LT GRN/YEL WIRE MAIN LIGHT SWITCH INSTRUMENT CLUSTER MASTER FRONT WINDOW/ PASSENGER DOOR LOCK/ WINDOW/ UNLOCK DOOR LOCK SWITCH SWITCH MULTI- FUNCTION SWITCH NCA WIRE NOT USED NOT USED OF DASH) CENTRAL JUNCTION BOX (CJB) ORG/LT GRN (OR LT GRN/YEL) WIRE ORG/LT GRN WIRE PARKING LAMP TRAILER TOW RELAY PNK/ LT GRN WIRE POWER CHOKE 1 POWERTRAIN CONTROL MODULE (PCM) RADIO INSTRUMENT CLUSTER MULTI- BRAKE FUNCTION PEDAL SWITCH POSITION SWITCH REAR A/C BLOWER SPEED RELAY 1 ENDS IN HARNESS STRIPPED CHASSIS REAR DOORS DOOR LOCK SWITCH REAR SEAT ENTERTAINMENT (RSE) MODULE RED WIRE RED/WHT WIRE RED/YEL WIRE REVERSING LAMP TRAILER TOW RELAY SIDE OF ENGINE COMPT) STRIPPED EXCEPT CHASSIS STRIPPED CHASSIS TAN/ WHT WIRE TAN/BLK WIRE TAN/WHT WIRE TO ACCESSORY DELAY RELAY (DIAGRAM 3 OF 4) TO FUSE 15 (DIAGRAM 3 OF 4) TO FUSE 17 (DIAGRAM 2 OF 4) TO FUSE 10 (DIAGRAM 2 OF 4) VEHICLE EXTERIOR SECURITY REAR MODULE VIEW (VSM) MIRROR SWITCH VEHICLE MAIN SECURITY LIGHT MODULE SWITCH (VSM) (W/ REMOTE KEYLESS ENTRY) VIDEO CASSETTE PLAYER W/ AUXILIARY A/C W/ POWER LOCKS, W/O REMOTE KEYLESS ENTRY W/ REMOTE KEYLESS ENTRY WHT RED/ WIRE WHT WIRE WHT/ VIO WIRE WHT/VIO WIRE YEL BLK/ WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/WHT WIRE

16-WAY STRIPPED CHASSIS CONNECTOR AUXILIARY BATTERY RELAY AUXILIARY RELAY BOX 2 (BEHIND CENTER OF DASH) BATTERY CHARGE TRAILER TOW RELAY BATTERY II BATTERY INTERIOR INSTRUMENT RADIO SAVER LAMP CLUSTER RELAY RELAY BATTERY SAVER RELAY BLK LT GRN/ WIRE BLK/LT BLU WIRE BLK/WHT WIRE BLK/YEL WIRE C.B. 44 CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CONVERSION VAN DIESEL AND ALL W/O AUXILIARY BATTERY DK GRN WIRE DK GRN/YEL WIRE DRIVER SIDE FRONT SEAT ADJUST SWITCH ENGINE COMPT) EVAP CANISTER VENT VALVE (GAS) POWERTRAIN CONTROL MODULE (PCM) EXCEPT CUTAWAY EXCEPT CUTAWAY CUTAWAY EXCEPT STRIPPED CHASSIS FROM FUSE 18 (DIAGRAM 2 OF 5) FUSE FUSE 10 FUSE 14 FUSE 20 FUSE 22 FUSE 22 C.B. 44 FUSE 23 FUSE 17 FUSE 11 FUSE 24 FUSE 27 FUSE 5 FUSE 8 FUSE FUSE FUSE FUSE 21 FUSE FUSE 4 FUSE FUSE FUSE GASOLINE W/ AUXILIARY BATTERY GASOLINE W/ AUXILIARY BATTERY JUMPER I/P BODY BUILDER CONNECTOR INSTRUMENT CLUSTER LT BLU PNK/ WIRE LT GRN/RED WIRE LT GRN/YEL WIRE MULTI- BRAKE MAIN LIGHT SWITCH FUNCTION PEDAL SWITCH POSITION SWITCH MULTI- FUNCTION SWITCH NCA WIRE ORG/LT GRN WIRE PARKING LAMP TRAILER TOW RELAY REAR A/C BLOWER SPEED RELAY 1 ENDS IN HARNESS REAR DOORS DOOR LOCK SWITCH RED WIRE RED/WHT WIRE RED/YEL WIRE REVERSING LAMP TRAILER TOW RELAY STRIPPED CHASSIS TAN/ WHT WIRE TAN/BLK WIRE TAN/WHT WIRE TO ACCESSORY DELAY RELAY (DIAGRAM 4 OF 5) TO FUSE 15 (DIAGRAM 4 OF 5) W/ AUXILIARY A/C WHT TAN/ WIRE WHT/ VIO WIRE WHT/BLK WIRE WHT/VIO (OR RED/YEL) WIRE WHT/VIO WIRE WINDSHIELD WIPER MOTOR YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE

6.8L 4.6L, 5.8L AUXILIARY POWERTRAIN CONTROL MODULE (APCM) BATTERY JUNCTION BOX (BJB) (DIESEL: AT RIGHT REAR OF ENGINE COMPT) BLK LT GRN/ WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF OF DASH) COIL ON COIL ON COIL ON PLUG PLUG PLUG (COP) 4 (COP) 3 (COP) 5 COIL ON HEATED PLUG POSITIVE (COP) 1 CRANKCASE VENTILATION ELEMENT (4.6L, 6.8L) COIL ON PLUG (COP) 2 COIL ON PLUG (COP) 6 DIESEL DIGITAL TRANSMISSION RANGE (DTR) SENSOR DK GRN WIRE EXCEPT 6.8L 6.8L EXCEPT DIESEL EXCEPT DIESEL DIESEL EXCEPT STRIPPED CHASSIS EXCEPT STRIPPED CHASSIS STRIPPED CHASSIS FROM IGNITION SWITCH (DIAGRAM 3 OF 4) FUEL HEATER FUEL INJECTOR CONTROL MODULE (FICM) FUSE 14 FUSE 15 FUSE 2 FUSE 20 FUSE 21 FUSE 27 FUSE 3 FUSE 9 FUSE 33 FUSE 8 IGN FEED IGNITION TRANSFORMER CAPACITOR 1 IGNITION TRANSFORMER CAPACITOR 2 INSTRUMENT CLUSTER LT BLU WIRE LT BLU/PNK WIRE LT GRN RED/ WIRE NATURAL GAS VEHICLE NCA WIRE PCM POWER DIODE PCM POWER RELAY PNK WIRE PNK/LT GRN WIRE RADIO RED/ LT GRN WIRE RED/BLK WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE RESTRAINTS CONTROL MODULE STRIPPED CHASSIS STRIPPED EXCEPT CHASSIS STRIPPED CHASSIS TAN/RED WIRE VIO/ORG WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/YEL WIRE YEL BLK/ WIRE

BLK LT GRN/ WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COIL ON COIL ON COIL ON PLUG PLUG PLUG (COP) 7 (COP) 6 (COP) 8 COIL ON COIL ON PLUG PLUG (COP) 1 (COP) 2 COIL ON COIL ON PLUG PLUG IGNITION (COP) 4 (COP) 3 TRANSFORMER CAPACITOR 1 COIL ON PLUG (COP) 5 DIESEL DIESEL EXCEPT DIESEL DIGITAL TRANSMISSION RANGE (DTR) SENSOR DK GRN WIRE EXCEPT 6.8L 6.8L EXCEPT STRIPPED CHASSIS EXCEPT TORQSHIFT EXCEPT TORQSHIFT TORQSHIFT FROM IGNITION SWITCH (DIAGRAM 4 OF 5) FUEL HEATER FUEL INJECTOR CONTROL MODULE (FICM) FUSE 14 FUSE 2 FUSE 20 FUSE 27 FUSE 3 FUSE 33 FUSE 8 FUSE 9 FUSE 21 FUSE 15 I/P BODY BUILDER CONNECTOR INSTRUMENT CLUSTER LT BLU/PNK WIRE NCA WIRE PCM POWER DIODE PCM POWER RELAY PNK/LT GRN WIRE RADIO RED/BLK WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE RESTRAINTS CONTROL MODULE STRIPPED CHASSIS TAN/RED WIRE TORQSHIFT TOWN/ OVERDRIVE HAUL CANCEL SWITCH SWITCH VIO/ORG WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUM, FEED GROUND AUDIO UNIT BLK WIRE BLK/LT GRN WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CUTAWAY DK GRN/ORG WIRE EXCEPT CUTAWAY FUSE 22 FUSE 27 FUSE 3 GRY/LT BLU WIRE HINGED SIDE DOOR HOT AT ALL TIMES HOT IN HOT W/ ACCESSORY DELAY RELAY ENERGIZED LEFT FRONT SPEAKER LEFT MIDDLE SPEAKER (W/ 6 SPEAKERS) LEFT REAR SPEAKER LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/LT GRN WIRE ORG/RED WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT SPEAKER RIGHT MIDDLE SPEAKER (W/ 6 SPEAKERS) RIGHT REAR SPEAKER RIGHT SLIDING DOOR CONTACT SWITCH (AT RIGHT "B" PILLAR) SLIDING SIDE DOOR TAN/YEL WIRE TWISTED PAIR WIRES W/ 6 SPEAKERS W/ OVERHEAD CONSOLE WHT WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE

ANTENNA BLK WIRE BLK/LT GRN WIRE BRN/PNK WIRE BUTTON CONTACT CUTAWAYS DIMMER DK GRN/ORG WIRE FUSE 10 FUSE 22 FUSE 27 FUSE 3 GRY/LT BLU WIRE HINGED DOOR HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC I/P FUSE PANEL I/P FUSE PANEL FUSE 36 LEFT FRONT DOOR SPEAKER LEFT MID SPEAKER (W/ 6 SPEAKERS) LEFT REAR SPEAKER LT BLU WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE MAIN LIGHT SWITCH NCA WIRE NOT USED OFF HEAD PARK ORG/LT GRN WIRE ORG/RED WIRE RADIO RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT SPEAKER RIGHT MID SPEAKER (W/ 6 SPEAKERS) RIGHT MID SPEAKER (W/ 6 SPEAKERS) RIGHT REAR SPEAKER SLIDING DOOR TAN WIRE TAN/LT GRN WIRE TAN/YEL WIRE VANS, WAGONS WHT WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE

20 16 6.8L 4.6L, 5.4L 6.8L BATTERY BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/GRY WIRE BLU WIRE BLU/RED WIRE BLU/WHT WIRE BRN/GRN WIRE CHARGING CIRCUIT DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DIODE EXCEPT STRIPPED CHASSIS EXCEPT STRIPPED CHASSIS STRIPPED CHASSIS FUSE 13 FUSE 27 GRN/ORG WIRE GRN/RED WIRE GRN/WHT WIRE GRY/RED WIRE HOT AT ALL TIMES HOT AT ALL TIMES BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) FUSE 36 IGNITION SWITCH LOCK OFF POWER DISTRIBUTION SYSTEM RED WIRE RUN WIRE SMC SMCS SMR STARTER MOTOR STARTER RELAY STRIPPED CHASSIS TORQSHIFT TRANSMISSION TRANSMISSION WHT WIRE YEL WIRE