Ford Econoline E150 (1997-2012) fuse 19 Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 ABS WARNING LAMP OUTPUT RELAY CTRL OUTPUT 1 2 POWER GROUND 14 15 16 17 18 19 20 21 22 23 24 POWER BPP SWITCH INPUT 4 WHEEL ANTI-LOCK 4-WHEEL ANTI- LOCK BRAKE SYSTEM RELAY (BEHIND CENTER OF DASH) ABS DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF DASH) ACCY ANTI-LOCK BRAKE INDICATOR BATTERY JUNCTION BOX (IN LEFT FRONT OF ENGINE COMPARTMENT) BLK WIRE BRAKE PEDAL POSITION (BPP) SWITCH (ON BRACKET, ABOVE BRAKE PEDAL) BRAKE WARN LAMP HIGH DATA LINK CONN BRAKE WARNING INDICATOR BRAKE WARNING LAMP LOW DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DK GRN WIRE DK GRN/YEL WIRE ELECTRONIC CRASH SENSOR (ECS) MODULE (BEHIND RIGHT SIDE OF DASH) FUSE 1 FUSE 11 FUSE 19 GRN WIRE HOT AT ALL TIMES IGNITION SWITCH INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR LOCK LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE OFF OHM 1600 PNK WIRE PNK/LT GRN WIRE REAR AXLE SPEED SENSOR REAR SENSOR (HIGH) RIGHT FRONT SENSOR (HIGH) LEFT FRONT SENSOR (HIGH) REAR SENSOR (LOW) RIGHT FRONT SENSOR (LOW) LEFT FRONT SENSOR (LOW) RED WIRE RED/PNK WIRE RIGHT FRONT WHEEL SPEED SENSOR RUN WIRE TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE VIO WIRE VIO/YEL WIRE WARNING SYSTEM WHT WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 ABS WARNING LAMP OUTPUT RELAY CTRL OUTPUT 1 2 GROUND POWER 14 15 16 17 18 19 20 21 22 23 24 POWER BPP SWITCH INPUT ABS CONTROL MODULE (AT LEFT SIDE OF ENGINE COMPT) ABS RELAY (BEHIND CENTER OF DASH) ACCY ANTI-LOCK BRAKE INDICATOR BATTERY JUNCTION BOX (IN LEFT FRONT OF ENGINE COMPARTMENT) BLK WIRE BRAKE FLUID LEVEL SWITCH (AT LEFT SIDE OF ENGINE COMPT) BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BRAKE WARN LAMP HIGH DATA LINK CONN BRAKE WARNING INDICATOR BRAKE WARNING LAMP LOW DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DIESEL DK GRN WIRE DK GRN/YEL WIRE ELECTRONIC CRASH SENSOR (ECS) MODULE (BEHIND RIGHT SIDE OF DASH) ENGINE CONTROLS SYSTEM FUSE 1 FUSE 11 FUSE 19 HOT AT ALL TIMES HOT IN RUN IGNITION SWITCH INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM LEFT FRONT WHEEL SPEED SENSOR LOCK OFF LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE NCA WIRE OHM 1600 PNK WIRE PNK/LT GRN WIRE REAR AXLE SPEED SENSOR REAR SENSOR (HIGH) RIGHT FRONT SENSOR (HIGH) LEFT FRONT SENSOR (HIGH) REAR SENSOR (LOW) RIGHT FRONT SENSOR (LOW) LEFT FRONT SENSOR (LOW) RED WIRE RED/BLK WIRE RIGHT FRONT WHEEL SPEED SENSOR RUN WIRE TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE VIO WIRE VIO/YEL WIRE WHT WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 ABS WARNING LAMP OUTPUT RELAY CTRL OUTPUT 1 2 GROUND POWER 14 15 16 17 18 19 20 21 22 23 24 POWER BPP SWITCH INPUT ABS CONTROL MODULE (AT LEFT SIDE OF ENGINE COMPT) ABS RELAY (BEHIND CENTER OF DASH) ACCY ANTI-LOCK BRAKE INDICATOR BATTERY JUNCTION BOX (IN LEFT FRONT OF ENGINE COMPARTMENT) BLK WIRE BRAKE FLUID LEVEL SWITCH (AT LEFT SIDE OF ENGINE COMPT) BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BRAKE WARN LAMP HIGH DATA LINK CONN BRAKE WARNING INDICATOR BRAKE WARNING LAMP LOW DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DK GRN WIRE FUSE 1 FUSE 11 FUSE 19 HOT AT ALL TIMES HOT IN RUN IGNITION SWITCH INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM LEFT FRONT WHEEL SPEED SENSOR LOCK OFF LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE NCA WIRE OHM 1600 PNK WIRE PNK/LT GRN WIRE REAR AXLE SPEED SENSOR REAR SENSOR (HIGH) RIGHT FRONT SENSOR (HIGH) LEFT FRONT SENSOR (HIGH) REAR SENSOR (LOW) RIGHT FRONT SENSOR (LOW) LEFT FRONT SENSOR (LOW) RED WIRE RED/BLK WIRE RIGHT FRONT WHEEL SPEED SENSOR RUN WIRE TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE VIO WIRE VIO/YEL WIRE WHT WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 DATA LINK CONN BPP SWITCH INPUT 7.3L ABS CONTROL MODULE (AT LEFT SIDE OF ENGINE COMPT) ANTI-LOCK BRAKE INDICATOR BATTERY JUNCTION BOX (BJB) (IN LEFT FRONT OF ENGINE COMPARTMENT) BLK WIRE BRAKE FLUID LEVEL SWITCH (AT LEFT SIDE OF ENGINE COMPT) BRAKE PEDAL POSITION (BPP) SWITCH (ON BRACKET, ABOVE BRAKE PEDAL) BRAKE WARNING INDICATOR DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF DASH) DK GRN WIRE ELECTRONIC CRASH SENSOR (ECS) MODULE (BEHIND RIGHT SIDE OF DASH) FUSE 1 FUSE 11 FUSE 19 GRN WIRE GROUND VBATT GROUND VBATT BRAKE WARNING LAMP LOW HOT AT ALL TIMES HOT IN RUN IGNITION SWITCH INSTRUMENT CLUSTER LEFT FRONT SENSOR (LOW) RIGHT FRONT SENSOR (LOW) REAR SENSOR (LOW) LEFT FRONT WHEEL SPEED SENSOR (BEHIND LEFT FRONT WHEEL) LOCK OFF LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/YEL WIRE NCA WIRE PARKING BRAKE SWITCH (NEAR LEFT KICK PANEL) PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (NEAR BRAKE MASTER CYLINDER) RED WIRE RED/PNK WIRE RIGHT FRONT WHEEL SPEED SENSOR (BEHIND RIGHT FRONT WHEEL) RUN WIRE TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE VACUUM WARNING SWITCH VIO/WHT WIRE WHT WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

15 2 9 8 IND CTRL SW CAN+ CAN- 6 14 DATA LINK CONNECTOR (LEFT SIDE OF DASH) ABS IND. ABS TEST CONNECTOR (LEFT FRONT CORNER OF ENG COMPT) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/YEL WIRE BRAKE PRESSURE SWITCH (LEFT SIDE OF ENG COMPT) BRK PRESS SW CAN 2 HIGH CAN 2 LOW CAN LOW CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) CHASSIS GND COIL B+ CAN HIGH DK GRN WIRE FUSE 11 FUSE 19 FUSE 2 FUSE 22 FUSE 6 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR (BEHIND LEFT FRONT WHEEL) LT BLU/RED WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/YEL WIRE NCA WIRE ORG/ WIRE ORG/YEL WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RED WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT FRONT WHEEL SPEED SENSOR (BEHIND RIGHT FRONT WHEEL) STABILITY CONTROL SENSOR CLUSTER (CENTER OF FLOOR) STABILITY/ TRACTION CONTROL RELAY STABILITY/TRACTION CONTROL SWITCH STEERING ANGLE INPUT STEERING WHEEL ROTATION SENSOR (BOTTOM OF STEERING COLUMN) STOP LAMP SW TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE VBATT VPWR VPWR WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

AT LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (BJB) BATTERY BATTERY II (DIESEL) BATTERY JUNCTION BOX (BJB) BATTERY JUNCTION BOX (BJB) (DIESEL: AT RIGHT REAR BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLU DK WIRE BREAKOUT W/ SINGLE GENERATORS (DIESEL: NEAR BREAKOUT TO STARTER RELAY) BRN/PNK WIRE DIESEL DIESEL EXCEPT DIESEL DK BLU WIRE DK GRN WIRE ENDS IN (NOT HARNESS USED) ENDS IN HARNESS CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) EXCEPT 4.6L, 5.4L STRIPPED CHASSIS 4.6L, 5.4L STRIPPED CHASSIS EXCEPT DIESEL EXCEPT MODIFIED CUTAWAY CUTAWAY VEHICLE EXCEPT STRIPPED CHASSIS EXCEPT STRIPPED CHASSIS (EXCEPT DIESEL: NEAR BREAKOUT FROM FUSE 19 (DIAGRAM 1 OF 4) FUEL FUSE 12 FUSE 13 FUSE 17 FUSE 18 FUSE 19 FUSE 23 FUSE 26 FUSE 29 FUSE 41 FUSE 34 FUSE 38 FUSE 3 FUSE 5 FUSE 9 FUSE FUSE 40 FUSE 34 FUSE 26 FUSIBLE LINK A (12 GA- FUSIBLE LINK B (12 GA- FUSIBLE LINK D (12 GA- FUSIBLE LINK E (12 GA- FUSIBLE LINK F (12 GA- FUSIBLE LINK G (12 GA- FUSIBLE LINK H (12 GA- FUSIBLE LINK I (12 GA- FUSIBLE LINK J (12 GA- FUSIBLE LINK K (12 GA- FUSIBLE LINK L (12 GA- FUSIBLE LINK M FUSIBLE LINK N GENERATOR GLOW PLUG CONTROL MODULE (GPCM) GRN DK WIRE GRY WIRE GRY/WHT WIRE LT BLU/ ORG WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE NCA WIRE NEAR BREAKOUT TO RIGHT SIDE OF ENGINE) DIESEL ORG/BLK WIRE ORG/LT BLU WIRE RED WIRE RED/WHT WIRE REMOTE JUMP START TERMINAL (DIESEL) SECONDARY GENERATOR STARTER MOTOR STARTER RELAY STARTER RELAY (DIESEL) STRIPPED CHASSIS TO FUSE 9 (DIAGRAM 1 OF 4) VIO/ORG WIRE VIO/YEL WIRE W/ DUAL GENERATORS W/ DUAL GENERATORS (NEAR BREAKOUT TO TOP LEFT REAR OF ENGINE) WHT LT BLU/ WIRE WHT/RED WIRE YEL WIRE YEL/LT BLU WIRE

AT LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (BJB) BATTERY BATTERY II BLK/LT GRN WIRE BLK/ORG WIRE BLOWER MOTOR RELAY BRN WIRE DIESEL EXCEPT DIESEL FUEL INJECTOR CONTROL MODULE (FICM) POWER RELAY FUEL PUMP RELAY FUSE 13 FUSE 17 FUSE 19 FUSIBLE LINK A (12 GA- FUSIBLE LINK B (12 GA- FUSIBLE LINK D (12 GA- FUSIBLE LINK E (12 GA- FUSIBLE LINK F (12 GA- FUSIBLE LINK G (12 GA- FUSIBLE LINK H (12 GA- FUSIBLE LINK I (12 GA- FUSIBLE LINK J (12 GA- FUSIBLE LINK K (12 GA- FUSIBLE LINK L (12 GA- FUSIBLE LINK M FUSIBLE LINK N FUSIBLE LINK P (12 GA- GENERATOR GLOW PLUG CONTROL MODULE (GPCM) GRY WIRE LT BLU/ORG WIRE NCA WIRE ORG/LT BLU WIRE PNK/YEL WIRE RED WIRE REMOTE JUMP START TERMINAL SECONDARY GENERATOR STARTER MOTOR TO FUSE 9 (DIAGRAM 2 OF 5) W/ DUAL GENERATORS (NEAR BREAKOUT TO TOP LEFT REAR OF ENGINE) YEL WIRE

ABS TEST CONNECTOR BATTERY BATTERY 2 BATTERY JUNCTION BOX (BJB) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (BJB) (RIGHT FRONT OF ENGINE COMPT) BLK/LT GRN WIRE BLK/ORG WIRE BLOWER FUEL MOTOR PUMP RELAY RELAY BLOWER MOTOR RELAY BRN WIRE DIESEL EXCEPT DIESEL FUEL INJECTOR CONTROL MODULE (FICM) POWER RELAY FUEL PUMP RELAY FUSE 13 FUSE 13 FUSE 17 FUSE 19 FUSE 19 FUSE 17 FUSIBLE LINK A (12 GA- FUSIBLE LINK B (12 GA- FUSIBLE LINK D (12 GA- FUSIBLE LINK E (12 GA- FUSIBLE LINK F (12 GA- FUSIBLE LINK G (12 GA- FUSIBLE LINK H (12 GA- FUSIBLE LINK I (12 GA- FUSIBLE LINK J (12 GA- FUSIBLE LINK K (12 GA- FUSIBLE LINK L (12 GA- FUSIBLE LINK M FUSIBLE LINK N FUSIBLE LINK P (12 GA- GENERATOR GLOW PLUG CONTROL MODULE (GPCM) GRY WIRE JUNCTION BOX (BJB)) LT BLU/ORG WIRE ORG/LT BLU WIRE RED WIRE REMOTE JUMP START TERMINAL SECONDARY GENERATOR STARTER MOTOR TAN/LT GRN WIRE TO FUSE 9 (DIAGRAM 2 OF 6) VIO/YEL WIRE W/ ADVANCE TRAC W/ DUAL GENERATORS YEL WIRE

4.6L, 5.4L STRIPPED CHASSIS A/C SWITCH ACCESSORY DELAY RELAY AUXILIARY DIGITAL BATTERY TRANSMISSION RANGE RELAY (DTR) SENSOR BLK WIRE BLK/ YEL WIRE BLK/LT GRN WIRE BRAKE PRESSURE SWITCH BRAKE SHIFT INTERLOCK CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CIRCUIT BREAKER 43 DIESEL DK BLU/ LT GRN WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE ENGINE COMPT) EXCEPT DIESEL EXCEPT STRIPPED CHASSIS FROM FUSE 14 (DIAGRAM 2 OF 4) FRONT FUNCTION SELECTOR SWITCH ASSEMBLY FRONT PASSENGER WINDOW/DOOR LOCK SWITCH FUSE 1 FUSE 7 FUSE 12 FUSE 18 FUSE 13 FUSE 15 FUSE 11 FUSE 10 FUSE 19 FUSE 24 FUSE 3 FUSE 6 FUSE 7 GRY/YEL WIRE IGN IGNITION SWITCH INSTRUMENT CLUSTER LEFT RIGHT VIDEO VIDEO DISPLAY DISPLAY LOCK OFF LT BLU RED/ WIRE LT BLU/ WHT WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT GRN PNK/ WIRE LT GRN/VIO WIRE LT GRN/YEL WIRE MAIN ABS CONTROL LIGHT MODULE SWITCH MASTER WINDOW/DOOR LOCK/UNLOCK SWITCH MULTI- ABS CONTROL FUNCTION MODULE SWITCH ORG/YEL WIRE OVERHEAD CONSOLE PNK/ LT GRN WIRE PNK/BLK WIRE RADIO RED WIRE RED/LT BLU WIRE RED/WHT WIRE RUN WIRE SIDE OF DASH) SPEED CONTROL SERVO STRIPPED CHASSIS TO FUSE 14 (DIAGRAM 4 OF 4) TO FUSE 33 (DIAGRAM 4 OF 4) TO FUSE 9 (DIAGRAM 4 OF 4) TRAILER ELECTRONIC BRAKE CONTROL CONNECTOR EXCEPT 4.6L, 5.4L STRIPPED CHASSIS VIDEO CASSETTE PLAYER W/ OVERHEAD CONSOLE W/ POWER DOOR LOCKS WHT LT BLU/ WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/VIO WIRE YEL BLK/ WIRE YEL WIRE YEL/BLK WIRE

BATTERY CHARGE TRAILER TOW RELAY BATTERY JUNCTION BATTERY JUNCTION BOX (BJB) BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLU/RED WIRE BLU/WHT WIRE BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BRN/RED WIRE BRN/YEL WIRE DATA LINK CONNECTOR (DLC) DRIVER SIDE FRONT SEAT CONTROL SWITCH EXCEPT STRIPPED CHASSIS FROM FUSE 27 (DIAGRAM 6 OF 9) FROM FUSE 65 (DIAGRAM 3 OF 9) FUSE 74 FROM RUN/START RELAY (DIAGRAM 2 OF 9) FUSE 13 FUSE 19 FUSE 20 FUSE 36 FUSE 42 FUSE 43 FUSE 44 FUSE 68 FUSE 70 GRN WIRE GRN/RED WIRE GRY WIRE GRY/RED WIRE IGN SW IGNITION SWITCH LEFT SIDE OF DASH) (EXCEPT STRIPPED CHASSIS: LEFT KICK PANEL) LOCK LOCK OFF OFF RUN WIRE RUN/ FUSE 45 RUN/START IGN SW SMART JUNCTION BOX (SJB) (STRIPPED CHASSIS: STARTER RELAY STRIPPED CHASSIS TO SPLICE 132 (DIAGRAM 5 OF 9) TO UPFITTER RELAY 1 (DIAGRAM 9 OF 9) TO UPFITTER RELAY 2 (DIAGRAM 9 OF 9) TO UPFITTER SWITCH (DIAGRAM 9 OF 9) VIO WIRE VIO/GRN WIRE WHT/ORG WIRE WINDSHIELD (NOT USED) WIPER MOTOR WINDSHIELD WIPER RELAY YEL WIRE YEL/RED WIRE