Ford Econoline E150 (1997-2012) fuse 11 Wiring diagrams

4.2L 4.6L 51 54 55 58 64 71 76 77 79 81 84 88 89 90 GND TCC KAPWR VSS ABS SYSTEM, BRAKE PRESSURE SWITCH ABS SYSTEM, WARNING BUZZER MODULE BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) 10 13 PPL DIGITAL TRANSMISSION RANGE SENSOR DK BLU/WHT WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENG OIL IAT ENGINE COMPARTMENT FUSE BOX ENGINE COMPARTMENT FUSE BOX (LEFT FRONT OF ENGINE COMPT) FUSE 9 ENGINE CONTROLS ENGINE COOLANT TEMPERATURE SENSOR (4.2L) (TOP LEFT FRONT OF ENGINE) FUSE 11 FUSE 2 FUSE 20 FUSE 4 GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE PANEL (BEHIND LEFT SIDE OF DASH) FUSE 8 IGNITION COIL, RADIO NOISE CAPACITOR INSTRUMENT CLUSTER INSTRUMENT CLUSTER (1998) INTAKE AIR TEMPERATURE SENSOR (CENTER OF ENGINE COMPT, PART OF CLEAN AIR TUBE) LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP MASS AIR FLOW (MAF) SENSOR (TOP CENTER OF ENGINE COMPT) NCA WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) OVERDRIVE CANCEL SWITCH PCM DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL 13 15 16 24 27 29 33 36 37 38 39 49 GEN DATA DATA (-) DATA (+) GND PPL/ORG WIRE PPL/YEL WIRE PWR IN GND GND TCIL EPC OSS MAF TPS VREF SIG RTN BPP PWR IN GND RED WIRE RED/LT GRN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL OD OFF TCS VSS GND MAF TFT THROTTLE POSITION SENSOR (TPS) (ON TOP OF ENGINE, NEAR AIR INTAKE) TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR SHIFT SOLENOIDS VEHICLE SPEED SENSOR (LEFT SIDE OF TRANSMISSION) WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/LT GRN WIRE

1 2 3 4 5 6 7 8 9 10 11 ABS WARNING LAMP OUTPUT RELAY CTRL OUTPUT 1 2 POWER GROUND 14 15 16 17 18 19 20 21 22 23 24 POWER BPP SWITCH INPUT 4 WHEEL ANTI-LOCK 4-WHEEL ANTI- LOCK BRAKE SYSTEM RELAY (BEHIND CENTER OF DASH) ABS DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF DASH) ACCY ANTI-LOCK BRAKE INDICATOR BATTERY JUNCTION BOX (IN LEFT FRONT OF ENGINE COMPARTMENT) BLK WIRE BRAKE PEDAL POSITION (BPP) SWITCH (ON BRACKET, ABOVE BRAKE PEDAL) BRAKE WARN LAMP HIGH DATA LINK CONN BRAKE WARNING INDICATOR BRAKE WARNING LAMP LOW DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DK GRN WIRE DK GRN/YEL WIRE ELECTRONIC CRASH SENSOR (ECS) MODULE (BEHIND RIGHT SIDE OF DASH) FUSE 1 FUSE 11 FUSE 19 GRN WIRE HOT AT ALL TIMES IGNITION SWITCH INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR LOCK LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE OFF OHM 1600 PNK WIRE PNK/LT GRN WIRE REAR AXLE SPEED SENSOR REAR SENSOR (HIGH) RIGHT FRONT SENSOR (HIGH) LEFT FRONT SENSOR (HIGH) REAR SENSOR (LOW) RIGHT FRONT SENSOR (LOW) LEFT FRONT SENSOR (LOW) RED WIRE RED/PNK WIRE RIGHT FRONT WHEEL SPEED SENSOR RUN WIRE TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE VIO WIRE VIO/YEL WIRE WARNING SYSTEM WHT WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

ACCEL SET/ BLK WIRE BLK/LT BLU WIRE BLU WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL BRACKET) BRAKE PRES- SURE SWITCH (BOTTOM OF BRAKE MASTER CYL- INDER) CLOCK SPRING ASSEMBLY (TOP OF STEERING COLUMN) COAST DK (ENGINE HARN, LEFT REAR OF ENG COMPT) DK DK DOOR LOCKS SYSTEM ENGINE COMP- ARTMENT FUSE BOX FUSE 27 FUSE 11 GRN WIRE GRY WIRE GRY/BLK WIRE HORN RELAY (ENGINE COMPT FUSE BOX) HORN SWITCH HOT AT ALL TIMES HOT IN I/P FUSE PANEL ILLUMINATION INSTRUMENT CLUSTER LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/RED WIRE NCA WIRE OFF OHMS 120 OHMS 2200 OHMS 680 ORG/ WIRE ORG/YEL WIRE PNK WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF ENGINE COMPT) RED WIRE RED/LT GRN WIRE RESUME RUN WIRE SPEED CONTROL SWITCH ASSEMBLY (TOP OF STEERING COLUMN) SPEEDO YEL WIRE

ACCEL SET/ BLK WIRE BLK/WHT WIRE BLU WIRE BRAKE INPUT GROUND BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL BRACKET) BRAKE PRES- SURE SWITCH (BOTTOM OF BRAKE MASTER CYL- INDER) CLOCK SPRING ASSEMBLY (TOP OF STEERING COLUMN) COAST DK (ENGINE HARN, LEFT REAR OF ENG COMPT) DK DK DOOR LOCKS SYSTEM DK GRN/ORG WIRE ENGINE COMP- ARTMENT FUSE BOX FUSE 27 FUSE 11 FUSE 6 GRN WIRE GRY WIRE GRY/BLK WIRE HORN RELAY (ENGINE COMPT FUSE BOX) HORN SWITCH HOT AT ALL TIMES HOT IN I/P FUSE PANEL ILLUMINATION INSTRUMENT CLUSTER LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/RED WIRE NCA WIRE OFF OHMS 120 OHMS 2200 OHMS 680 ORG/ WIRE PNK WIRE PNK/ORG WIRE PPL PPL/ORG WIRE RED WIRE RED/LT GRN WIRE RESUME RUN WIRE SPEED CONTROL SERVO/AMPLIFIER ASSEMBLY (LEFT SIDE OF ENGINE COMPT) SPEED CONTROL SWITCH ASSEMBLY (TOP OF STEERING COLUMN) SPEEDO VSS INPUT BOO SW INPUT SCSA INPUT SCSA GND POWER YEL WIRE

ALL OTHERS BLK WIRE BLU WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BRN WIRE CENTRAL JUNCTION BOX LEFT SIDE OF DASH, NEAR KICK PANEL) CUT- AWAYS ELECTRONIC FLASHER (BEHIND LEFT SIDE OF DASH) FUSE 10 FUSE 11 FUSE 7 HAZARD HAZARD SWITCH HEAD OFF HIGH MOUNTED STOP/ CARGO LAMP HOT AT ALL TIMES HOT IN RUN IGN MULTI- FUNCTION SWITCH INSTRUMENT CLUSTER INSTRUMENT CLUSTER RIGHT TURN INDICATOR LEFT FRONT PARK/ TURN LAMP LEFT STOP/ PARK/ TURN LAMP LEFT TURN INDICATOR LICENSE LAMP LT BLU WIRE LT BLU/ WHT WIRE LT GRN WIRE LT GRN/RED WIRE MAIN LIGHT SWITCH NORMAL ORG/ WIRE PARK PPL RED WIRE RED/LT GRN WIRE RIGHT FRONT PARK/ TURN LAMP RIGHT STOP/ PARK/ TURN LAMP SOLID STATE TAN WIRE TO TRAILER/ CAMPER ADAPTER CIRCUIT (ELECTRONIC BRAKE) TO TRAILER/CAMPER ADAPTER CIRCUIT (BATTERY JUNCTION BOX) (FUSES 5, 6) TO TRAILER/CAMPER ADAPTER CIRCUIT (ELECTRONIC BRAKE) TURN LEFT TURN RIGHT WHT LT GRN/ WIRE WHT WIRE WHT/LT BLU WIRE

AUXILIARY BATTERY RELAY AUXILIARY RELAY BOX 2 (BEHIND CENTER OF DASH) BATTERY CHARGE TRAILER TOW RELAY BATTERY II BATTERY SAVER RELAY BLK/LT BLU WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COURTESY SW FEED DIESEL AND ALL W/O AUXILIARY BATTERY DK GRN WIRE DK GRN/YEL WIRE DRIVER SIDE FRONT SEAT ADJUST SWITCH ENGINE COMPT) EXCEPT CUTAWAY EXCEPT CUTAWAY CUTAWAY EXCEPT MODIFIED VEHICLES EXCEPT STRIPPED CHASSIS FROM FUSE 18 (DIAGRAM 1 OF 4) FROM FUSE 4 (DIAGRAM 2 OF 4) FROM FUSE 5 (DIAGRAM 2 OF 4) FUSE FUSE 10 FUSE 11 FUSE 14 FUSE 16 (EXCEPT DIESEL) FUSE 20 FUSE 22 FUSE 23 FUSE 17 FUSE 24 FUSE 27 FUSE 5 FUSE 8 FUSE FUSE FUSE FUSE 21 FUSE FUSE 4 FUSE FUSE FUSE FUSE FUSE FUSE 22 GASOLINE W/ AUXILIARY BATTERY GASOLINE W/ AUXILIARY BATTERY JUMPER GRN/ LT WIRE LT BLU PNK/ WIRE LT GRN PNK/ WIRE LT GRN/ BLK WIRE LT GRN/RED WIRE LT GRN/YEL WIRE MAIN LIGHT SWITCH INSTRUMENT CLUSTER MASTER FRONT WINDOW/ PASSENGER DOOR LOCK/ WINDOW/ UNLOCK DOOR LOCK SWITCH SWITCH MULTI- FUNCTION SWITCH NCA WIRE NOT USED NOT USED OF DASH) CENTRAL JUNCTION BOX (CJB) ORG/LT GRN (OR LT GRN/YEL) WIRE ORG/LT GRN WIRE PARKING LAMP TRAILER TOW RELAY PNK/ LT GRN WIRE POWER CHOKE 1 POWERTRAIN CONTROL MODULE (PCM) RADIO INSTRUMENT CLUSTER MULTI- BRAKE FUNCTION PEDAL SWITCH POSITION SWITCH REAR A/C BLOWER SPEED RELAY 1 ENDS IN HARNESS STRIPPED CHASSIS REAR DOORS DOOR LOCK SWITCH REAR SEAT ENTERTAINMENT (RSE) MODULE RED WIRE RED/WHT WIRE RED/YEL WIRE REVERSING LAMP TRAILER TOW RELAY SIDE OF ENGINE COMPT) STRIPPED EXCEPT CHASSIS STRIPPED CHASSIS TAN/ WHT WIRE TAN/BLK WIRE TAN/WHT WIRE TO ACCESSORY DELAY RELAY (DIAGRAM 3 OF 4) TO FUSE 15 (DIAGRAM 3 OF 4) TO FUSE 17 (DIAGRAM 2 OF 4) TO FUSE 10 (DIAGRAM 2 OF 4) VEHICLE EXTERIOR SECURITY REAR MODULE VIEW (VSM) MIRROR SWITCH VEHICLE MAIN SECURITY LIGHT MODULE SWITCH (VSM) (W/ REMOTE KEYLESS ENTRY) VIDEO CASSETTE PLAYER W/ AUXILIARY A/C W/ POWER LOCKS, W/O REMOTE KEYLESS ENTRY W/ REMOTE KEYLESS ENTRY WHT RED/ WIRE WHT WIRE WHT/ VIO WIRE WHT/VIO WIRE YEL BLK/ WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/WHT WIRE

ABS DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF DASH) ACCY ANTI-LOCK BRAKE INDICATOR BLK WIRE BLK/ORG WIRE BRAKE PEDAL POSITION (BPP) SWITCH (ON BRACKET, ABOVE BRAKE PEDAL) BRAKE WARNING DIODE (MAIN HARNESS, BEHIND INSTRUMENT CLUSTER) CENTRAL JUNCTION BOX LEFT SIDE OF DASH, NEAR KICK PANEL) DK GRN WIRE DK GRN/YEL WIRE DUMP SOLENOID 1-3 OHMS FUSE 1 FUSE 11 FUSE 2 HOT AT ALL TIMES HOT IN RUN HOT IN START OR RUN IGNITION SWITCH INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM ISOLATION SOLENOID 3-6 OHMS LOCK LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/YEL WIRE OFF ORG/ WIRE PNK WIRE PNK/LT GRN WIRE RABS DIAGNOSTIC CONNECTOR (BELOW RIGHT SIDE OF DASH) REAR ANTI-LOCK BRAKE SYSTEM (RABS) MODULE (BEHIND CENTER OF DASH) REAR AXLE SPEED SENSOR (UNDER REAR OF VEHICLE, MOUNTED ON DIFFERENTIAL) RED WIRE RED/PNK WIRE RUN WIRE TAN WIRE TAN/LT GRN WIRE VALVE RESET SWITCH VIO/WHT WIRE YEL WIRE YEL/LT GRN WIRE

240 OHMS A/C SYSTEM BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (ON FRONT CENTER OF ENGINE) CENTRAL JUNCTION BOX (BELOW LEFT SIDE OF DASH, NEAR LEFT KICK PANEL) DIGITAL TRANSMISSION RANGE (DTR) SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/PNK WIRE DPFE INPUT CHT INPUT CANISTER VENT VSS (+) A/C RLY CNTRL EVAPORATIVE EMISSIONS CANISTER VENT SOLENOID (REAR OF VEHICLE, NEAR FUEL TANK) FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 11 GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR 11 HEATED OXYGEN SENSOR 12 HEATED OXYGEN SENSOR 21 HEATED OXYGEN SENSOR 22 HEATER CTRL HOT AT ALL TIMES IAC CTRL OSS (-) CMP SENSOR INJ 5 CTRL INJ 3 CTRL INJ 1 CTRL GND GND IGN COIL TCIL FUEL PUMP CTRL EPC SOL INJ 6 CTRL INJ 4 CTRL INJ 2 CTRL LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE MAF SENS OUT TP SENS IN REF OUTPUT VOLT SIG RTN BRAKE ON/OFF MASS AIR FLOW SENSOR (ON TOP (CENTER OF ENGINE COMPT) NCA WIRE OVER- HEAD CONSOLE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (LEFT REAR OF ENGINE COMPT, NEAR MASTER CYLINDER) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/YEL WIRE TCC SOL KAP B(+) EVAP VALVE KNOCK SENSOR VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

240 OHMS A/C SYSTEM BLK/LT BLU WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (FRONT OF LEFT CYLINDER HEAD) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH, NEAR LEFT KICK PANEL) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DPFE SENS CYL HEAD TEMP EVAP SOL VSS (+) A/C RELAY CTRL ENDS IN HARNESS FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 11 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEATER CTRL HOT AT ALL TIMES IAC SOL OSS (+) CYLINDER ID LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MAF SENS IN TP SENS IN MASS AIR FLOW SENSOR (TOP CENTER OF ENGINE COMPT) NCA WIRE OVER- HEAD CONSOLE PNK/LT BLU WIRE PNK/WHT WIRE PWR GND COIL ON PLUG 2 RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE SIG RTN BRAKE ON/OFF TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TAN/YEL WIRE VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

270 OHMS BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (ON FRONT OF LEFT CYLINDER HEAD) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH, NEAR KICK PANEL) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DPFE SENS CYL HEAD TEMP EVAP SOL VSS (+) FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 11 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEGO 11 HEGO 21 HEGO 22 HEATER CTRL HEGO 21 MAF SENS IN TP SENS IN REF VOLTAGE SIG RTN BRAKE ON/OFF HOT AT ALL TIMES IDLE AIR CTRL OSS CMP LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MASS AIR FLOW SENSOR (TOP CENTER OF ENGINE) NCA WIRE OUTPUT SHAFT SPEED SENSOR OVERHEAD CONSOLE PNK/LT BLU WIRE PNK/WHT WIRE PWR GND COIL ON PLUG 2 RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TRANSMISSION) (ON LEFT SIDE OF TRANSMISSION) TSS SENSOR HEGO 11 VIO/WHT WIRE VIO/YEL WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE