Ford Econoline E150 (1997-2012) except stripped chassis Wiring diagrams

1 2 3 4 5 6 7 8 9 10 ON INDICATOR ACCEL SET/ AIR BAG SLIDING CONTACT BATTERY JUNCTION BOX (BJB) (IN LEFT FRONT OF ENGINE COMPARTMENT) BLK WIRE BLK/WHT WIRE BRAKE INPUT GROUND BRAKE PEDAL POSITION (BPP) SWITCH (ON BRACKET, ABOVE BRAKE PEDAL) BRAKE PRESSURE SWITCH (AT LEFT SIDE OF ENGINE COMPARTMENT) CENTRAL JUNCTION BOX (CJB) (LEFT SIDE OF DASH, NEAR KICK PANEL) COAST DK BLU WIRE DK GRN/ORG WIRE EXCEPT STRIPPED CHASSIS FUSE 11 FUSE 27 FUSE 6 GRY WIRE GRY/BLK WIRE HORN RELAY HORN SWITCH HOT AT ALL TIMES HOT IN INSTRUMENT CLUSTER LT BLU/BLK WIRE LT GRN WIRE LT GRN/RED WIRE MICROPROCESSOR NCA WIRE OFF ORG/ WIRE OVERHEAD CONSOLE PNK/ORG WIRE RED WIRE RED/LT GRN WIRE REMOTE KEYLESS ENTRY MODULE (BEHIND LEFT "B" PILLAR) RESUME RUN WIRE SPEED CONTROL INDICATOR SPEED CONTROL SERVO (LEFT SIDE OF ENGINE COMPT, NEAR BRAKE MASTER CYLINDER) SPEED CONTROL SWITCH VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE VSS INPUT BPP SW INPUT SCSA INPUT SCSA GND POWER YEL/LT BLU WIRE

34 51 60 45 44 59 34 51 59 60 61 66 34 51 60 45 44 59 TACM + TACM - ETC RTN 4.6L 40 2 SIG RTN OSS VREF OSS TR GND 41 18 17 4 6 5 16 28 19 30 RTN APPRTN 44 29 45 60 28 61 44 29 45 60 28 61 5.4L, 4.6L 5.4L, 6.8L 52 27 VREF BFP 6.8L 6.8L 4.6L 5.4L 64 48 64 48 SCCS SCCSRTN 8 45 10 13 62 50 BPP KAPWR POWER GND APPVREF BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/BLU WIRE BLK/GRN WIRE BLU WIRE BLU/BLK WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/GRY WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BPS BRAKE PEDAL POSITION SWITCH BRN WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/RED WIRE BRN/WHT WIRE CLOCKSPRING (STEERING WHEEL) COAST ELECTRONIC THROTTLE CONTROL (ETC) MOTOR ENGINE CONTROLS SYSTEM ETC REF EXCEPT STRIPPED CHASSIS FUSE 30 FUSE 46 FUSE 76 GRN WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY/VIO WIRE HORN SWITCH HOT AT ALL TIMES HOT IN START OR RUN INTERIOR LIGHTS HORNS SYSTEM SYSTEM LEFT STEERING WHEEL SWITCH NCA WIRE OFF ON OUTPUT SHAFT SPEED (OSS) SENSOR RES+ RIGHT STEERING WHEEL SWITCH SET/ACCEL SOLID STATE SOUND SYSTEM STRIPPED CHASSIS THROTTLE POSITION SENSOR (TPS) (TOP OF ENGINE, NEAR AIR INTAKE) TOP OF ENGINE) TRANS- MISSIONS SYSTEM TRANSMISSIONS SYSTEM VIO WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/VIO WIRE YEL WIRE YEL/GRN WIRE YEL/ORG WIRE YEL/VIO WIRE

34 51 60 45 44 59 34 51 59 60 61 66 34 51 60 45 44 59 TACM + TACM - ETC RTN 4.6L 40 2 SIG RTN OSS VREF OSS TR GND 41 18 17 4 6 5 16 28 19 30 RTN APPRTN 44 29 45 60 28 61 44 29 45 60 28 61 5.4L, 4.6L 5.4L, 6.8L 52 27 VREF BFP 6.8L 6.8L 4.6L 5.4L 64 48 64 48 SCCS SCCSRTN 8 45 10 13 62 50 BPP KAPWR POWER GND APPVREF BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/BLU WIRE BLK/GRN WIRE BLU WIRE BLU/BLK WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/GRY WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BPS BRAKE PEDAL POSITION SWITCH BRN WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/RED WIRE BRN/WHT WIRE CLOCKSPRING (STEERING WHEEL) COAST ELECTRONIC THROTTLE CONTROL (ETC) MOTOR ENGINE CONTROLS SYSTEM ETC REF EXCEPT STRIPPED CHASSIS FUSE 30 FUSE 46 FUSE 76 GRN WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY/VIO WIRE HORN SWITCH HOT AT ALL TIMES HOT IN START OR RUN INTERIOR LIGHTS HORNS SYSTEM SYSTEM LEFT STEERING WHEEL SWITCH NCA WIRE OFF ON OUTPUT SHAFT SPEED (OSS) SENSOR RES+ RIGHT STEERING WHEEL SWITCH SET/ACCEL SOLID STATE SOUND SYSTEM STRIPPED CHASSIS THROTTLE POSITION SENSOR (TPS) (TOP OF ENGINE, NEAR AIR INTAKE) TOP OF ENGINE) TRANS- MISSIONS SYSTEM TRANSMISSIONS SYSTEM VIO WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/VIO WIRE YEL WIRE YEL/GRN WIRE YEL/ORG WIRE YEL/VIO WIRE

34 51 60 45 44 59 34 51 59 60 61 66 34 51 60 45 44 59 TACM + TACM - ETC RTN 4.6L 40 2 1 35 47 40 2 SIG RTN OSS VREF OSS TR GND 41 18 17 4 6 5 16 28 19 30 SIGRTN APPRTN 44 29 45 60 28 61 44 29 45 60 28 61 5.4L, 4.6L 5.4L, 6.8L 52 27 VREF BFP 6.8L 6.8L 4.6L 5.4L 64 48 64 48 SCCS SCCSRTN 8 65 45 10 13 46 62 50 BPP BPS KAPWR GROUND APP APPVREF BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/BLU WIRE BLK/GRN WIRE BLU WIRE BLU/BLK WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/GRY WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BRN WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/RED WIRE BRN/WHT WIRE CLOCKSPRING (STEERING WHEEL) COAST ELECTRONIC THROTTLE CONTROL (ETC) MOTOR ENGINE CONTROLS SYSTEM ETC REF EXCEPT STRIPPED CHASSIS FUSE 30 FUSE 46 FUSE 76 GRN WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY/VIO WIRE HORN SWITCH HOT AT ALL TIMES HOT IN START OR RUN INTERIOR LIGHTS HORNS SYSTEM SYSTEM LEFT STEERING WHEEL SWITCH NAVIGATION SYSTEM NCA WIRE OFF ON OUTPUT SHAFT SPEED (OSS) SENSOR POWER DISTRIBUTION SYSTEM RED WIRE RES+ RIGHT STEERING WHEEL SWITCH SET/ACCEL SOLID STATE STOPLAMP SWITCH (UNDER LEFT SIDE OF DASH) STRIPPED CHASSIS THROTTLE POSITION SENSOR (TPS) (TOP OF ENGINE, NEAR AIR INTAKE) TOP OF ENGINE) TRANS- MISSIONS SYSTEM TRANSMISSIONS SYSTEM VIO WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/VIO WIRE YEL WIRE YEL/GRN WIRE YEL/ORG WIRE YEL/VIO WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 TC ON/OFF 6 2 COMPASS+ COMPASS- AUTO DIMMING INTERIOR MIRROR BLK WIRE BLK/BLU WIRE BLK/GRY WIRE BLU/BRN WIRE BLU/GRY WIRE BRAKE FLUID LEVEL SWITCH (LEFT REAR OF ENGINE COMPT) BRAKE SHIFT INTERLOCK (STEERING COLUMN) BRK FLUID SW RTN COMPASS+ COMPASS- COMPUTER DATA LINES SYSTEM DIMMING INTERIOR DISPLAY MIRROR W/O NAVI EXCEPT STRIPPED CHASSIS FLUID SW BRAKE FUEL PUMP MODULE (UNDER REAR OF VEHICLE, NEAR FUEL TANK) FUSE 26 FUSE 29 FUSE 80 GRN WIRE GRN/BLU WIRE GRN/VIO WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/VIO WIRE HOT AT ALL TIMES HOT AT ALL TIMES BATTERY JUNCTION FUSE 31 BOX (BJB) (LEFT FRONT OF ENGINE COMPT) HOT IN HOT IN START OR RUN HOT IN START OR RUN MICRO FUSE 36 HS CAN - HS CAN + PWR GND MS CAN - MS CAN + INSTRUMENT PANEL CLUSTER (IPC) KEY-IN IGN KEY-IN IGNITION SWITCH LEFT FRONT DOOR AJAR SWITCH (LEFT KICK PANEL) LF DOOR AJAR MIRROR MS CAN + NCA WIRE OIL PRESSURE SWITCH (LOWER LEFT FRONT OF ENGINE) OIL SW SENDER RTN 1 SENDER 1 OR RUN PARK BRAKE PARKING BRAKE SWITCH (NEAR LEFT KICK PANEL) PASSIVE ANTI-THEFT TRANSCEIVER REAR DOOR AJAR REAR DOORS DOOR AJAR SWITCH REAR VIEW CAMERA DISPLAY MIRROR RF DOOR AJAR RIGHT FRONT DOOR AJAR SWITCH (RIGHT KICK PANEL) RIGHT SIDE DOOR AJAR SWITCH (FRONT OF RIGHT SIDE FRONT HINGED DOOR) RIGHT SLIDING DOOR AJAR SWITCH (RIGHT "B" PILLAR) RR DOOR AJAR RUN/START STRIPPED CHASSIS TRACTION CONTROL SWITCH VBATT PARK SW TX RX VIEW CAMERA VIO/GRY WIRE VIO/ORG WIRE W/ AUTO W/ HINGED SIDE DOOR W/ REAR W/ SLIDING SIDE DOOR WHT WIRE WHT/BLU WIRE WHT/RED WIRE WHT/VIO WIRE YEL WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/RED WIRE YEL/VIO WIRE

A/C CLUTCH RELAY ALL OTHERS BATTERY FEED BATTERY JUNCTION BOX (BJB) (DIESEL: AT RIGHT FRONT OF ENGINE COMPT) (EXCEPT BLK WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CONVERSION VAN CUTAWAY DATA LINK CONNECTOR (DLC) DAYTIME RUNNING LAMPS (DRL) MODULE (IF EQUIPPED) DIESEL DIESEL: AT LEFT SIDE OF ENGINE COMPT) DK BLU WIRE DK GRN WIRE ENDS IN HARNESS EXCEPT STRIPPED CHASSIS FROM FUSE 13 (DIAGRAM 1 OF 5) FRONT CIGAR LIGHTER FUSE FUSE 12 FUSE 18 FUSE 23 FUSE 26 FUSE 29 FUSE 41 FUSE 3 FUSE 34 FUSE 35 FUSE 34 FUSE 40 FUSE 5 FUSE 9 GRY/WHT WIRE HORN RELAY I/P BODY BUILDER CONNECTOR LEFT TURN TRAILER TOW RELAY LT BLU/WHT WIRE ORG-LT BLU WIRE ORG/LT BLU WIRE POWER POINT (BEHIND CENTER OF DASH) POWER POINT (BEHIND LEFT "B" PILLAR) RED WIRE RED/WHT WIRE RIGHT TURN TRAILER TOW RELAY SECONDARY GENERATOR STARTER RELAY STRIPPED CHASSIS TO FUSE 21 (DIAGRAM 3 OF 5) VIO/ORG WIRE W/ DUAL GENERATORS W/ SINGLE GENERATORS WHT/RED WIRE YEL/LT BLU WIRE

16-WAY STRIPPED CHASSIS CONNECTOR AUXILIARY BATTERY RELAY AUXILIARY RELAY BOX 2 (BEHIND CENTER OF DASH) BATTERY CHARGE TRAILER TOW RELAY BATTERY II BATTERY INTERIOR INSTRUMENT RADIO SAVER LAMP CLUSTER RELAY RELAY BATTERY SAVER RELAY BLK LT GRN/ WIRE BLK/LT BLU WIRE BLK/WHT WIRE BLK/YEL WIRE C.B. 44 CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CONVERSION VAN DIESEL AND ALL W/O AUXILIARY BATTERY DK GRN WIRE DK GRN/YEL WIRE DRIVER SIDE FRONT SEAT ADJUST SWITCH ENGINE COMPT) EVAP CANISTER VENT VALVE (GAS) POWERTRAIN CONTROL MODULE (PCM) EXCEPT CUTAWAY EXCEPT CUTAWAY CUTAWAY EXCEPT STRIPPED CHASSIS FROM FUSE 18 (DIAGRAM 2 OF 5) FUSE FUSE 10 FUSE 14 FUSE 20 FUSE 22 FUSE 22 C.B. 44 FUSE 23 FUSE 17 FUSE 11 FUSE 24 FUSE 27 FUSE 5 FUSE 8 FUSE FUSE FUSE FUSE 21 FUSE FUSE 4 FUSE FUSE FUSE GASOLINE W/ AUXILIARY BATTERY GASOLINE W/ AUXILIARY BATTERY JUMPER I/P BODY BUILDER CONNECTOR INSTRUMENT CLUSTER LT BLU PNK/ WIRE LT GRN/RED WIRE LT GRN/YEL WIRE MULTI- BRAKE MAIN LIGHT SWITCH FUNCTION PEDAL SWITCH POSITION SWITCH MULTI- FUNCTION SWITCH NCA WIRE ORG/LT GRN WIRE PARKING LAMP TRAILER TOW RELAY REAR A/C BLOWER SPEED RELAY 1 ENDS IN HARNESS REAR DOORS DOOR LOCK SWITCH RED WIRE RED/WHT WIRE RED/YEL WIRE REVERSING LAMP TRAILER TOW RELAY STRIPPED CHASSIS TAN/ WHT WIRE TAN/BLK WIRE TAN/WHT WIRE TO ACCESSORY DELAY RELAY (DIAGRAM 4 OF 5) TO FUSE 15 (DIAGRAM 4 OF 5) W/ AUXILIARY A/C WHT TAN/ WIRE WHT/ VIO WIRE WHT/BLK WIRE WHT/VIO (OR RED/YEL) WIRE WHT/VIO WIRE WINDSHIELD WIPER MOTOR YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE

ABS CONTROL MODULE ACCESSORY DELAY RELAY BLK/LT GRN WIRE BRAKE SHIFT INTERLOCK CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DAYTIME RUNNING LIGHTS MODULE DIGITAL AUXILIARY TRANSMISSION BATTERY RANGE RELAY (IF EQUIPPED) (DTR) SENSOR DK BLU/ LT GRN WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE EXCEPT STRIPPED CHASSIS EXCEPT TORQSHIFT FROM FUSE 14 (DIAGRAM 3 OF 5) FRONT PASSENGER WINDOW/DOOR LOCK SWITCH FUSE 1 FUSE 10 FUSE 11 FUSE 12 FUSE 13 FUSE 19 FUSE 15 FUSE 18 FUSE 24 FUSE 3 FUSE 42 FUSE 6 FUSE 7 GRY/YEL WIRE I/P BODY BUILDER CONNECTOR IGNITION SWITCH INSTRUMENT CLUSTER LOCK LOCK OFF LT BLU/PNK WIRE LT BLU/RED WIRE LT GRN/VIO WIRE MAIN LIGHT SWITCH MASTER WINDOW/DOOR LOCK/UNLOCK SWITCH MULTI- FUNCTION SWITCH OFF ORG/YEL WIRE OVERHEAD CONSOLE PNK/BLK WIRE PNK/LT GRN WIRE RADIO RED WIRE RED/ LT BLU WIRE RED/LT BLU WIRE RED/WHT WIRE REVERSING LAMP RELAY RUN WIRE SIDE OF DASH) STRIPPED CHASSIS TEMPERATURE FUNCTION SELECTOR SWITCH ASSEMBLY BLEND DOOR ACTUATOR TO FUSE 14 (DIAGRAM 5 OF 5) TO FUSE 33 (DIAGRAM 5 OF 5) TO FUSE 9 (DIAGRAM 5 OF 5) TORQSHIFT TRAILER ELECTRONIC BRAKE CONTROL CONNECTOR W/ AUXILIARY BATTERY W/ OVERHEAD CONSOLE W/ POWER DOOR LOCKS WHT/LT BLU WIRE WHT/PNK WIRE WHT/VIO WIRE YEL/BLK WIRE

BLK LT GRN/ WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COIL ON COIL ON COIL ON PLUG PLUG PLUG (COP) 7 (COP) 6 (COP) 8 COIL ON COIL ON PLUG PLUG (COP) 1 (COP) 2 COIL ON COIL ON PLUG PLUG IGNITION (COP) 4 (COP) 3 TRANSFORMER CAPACITOR 1 COIL ON PLUG (COP) 5 DIESEL DIESEL EXCEPT DIESEL DIGITAL TRANSMISSION RANGE (DTR) SENSOR DK GRN WIRE EXCEPT 6.8L 6.8L EXCEPT STRIPPED CHASSIS EXCEPT TORQSHIFT EXCEPT TORQSHIFT TORQSHIFT FROM IGNITION SWITCH (DIAGRAM 4 OF 5) FUEL HEATER FUEL INJECTOR CONTROL MODULE (FICM) FUSE 14 FUSE 2 FUSE 20 FUSE 27 FUSE 3 FUSE 33 FUSE 8 FUSE 9 FUSE 21 FUSE 15 I/P BODY BUILDER CONNECTOR INSTRUMENT CLUSTER LT BLU/PNK WIRE NCA WIRE PCM POWER DIODE PCM POWER RELAY PNK/LT GRN WIRE RADIO RED/BLK WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE RESTRAINTS CONTROL MODULE STRIPPED CHASSIS TAN/RED WIRE TORQSHIFT TOWN/ OVERDRIVE HAUL CANCEL SWITCH SWITCH VIO/ORG WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/YEL WIRE YEL/BLK WIRE

20 16 6.8L 4.6L, 5.4L 6.8L BATTERY BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/GRY WIRE BLU WIRE BLU/RED WIRE BLU/WHT WIRE BRN/GRN WIRE CHARGING CIRCUIT DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DIODE EXCEPT STRIPPED CHASSIS EXCEPT STRIPPED CHASSIS STRIPPED CHASSIS FUSE 13 FUSE 27 GRN/ORG WIRE GRN/RED WIRE GRN/WHT WIRE GRY/RED WIRE HOT AT ALL TIMES HOT AT ALL TIMES BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) FUSE 36 IGNITION SWITCH LOCK OFF POWER DISTRIBUTION SYSTEM RED WIRE RUN WIRE SMC SMCS SMR STARTER MOTOR STARTER RELAY STRIPPED CHASSIS TORQSHIFT TRANSMISSION TRANSMISSION WHT WIRE YEL WIRE