Ford Econoline E150 (1997-2012) battery junction Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 DATA LINK CONN BPP SWITCH INPUT ABS CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) ABS IND. BATTERY JUNCTION BLK WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF DASH) DK GRN WIRE DK GRN/YEL WIRE EXCEPT DIESEL EXCEPT DIESEL, EXCEPT STRIPPED CHASSIS EXCEPT STRIPPED CHASSIS FUSE 1 FUSE 11 GROUND VBATT GROUND VBATT BRAKE IND CTRL HOT AT ALL TIMES HOT IN RUN INSTRUMENT CLUSTER LEFT FRONT SENSOR (LOW) RIGHT FRONT SENSOR (LOW) REAR SENSOR (LOW) LEFT FRONT WHEEL SPEED SENSOR (BEHIND LEFT FRONT WHEEL) LOW BRAKE FLUID LEVEL/ PARK BRAKE IND LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/YEL WIRE MICROPROCESSOR NCA WIRE ORG/YEL WIRE PNK WIRE REAR AXLE SPEED SENSOR (UNDER REAR OF VEHICLE, MOUNTED ON DIFFERENTIAL) RED WIRE RED/PNK WIRE RIGHT FRONT WHEEL SPEED SENSOR (BEHIND RIGHT FRONT WHEEL) STRIPPED CHASSIS STRIPPED CHASSIS DIESEL TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE WHT WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

BATTERY CHARGE TRAILER TOW RELAY BATTERY JUNCTION BATTERY JUNCTION BOX (BJB) BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLU/RED WIRE BLU/WHT WIRE BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BRN/RED WIRE BRN/YEL WIRE DATA LINK CONNECTOR (DLC) DRIVER SIDE FRONT SEAT CONTROL SWITCH EXCEPT STRIPPED CHASSIS FROM FUSE 27 (DIAGRAM 6 OF 9) FROM FUSE 65 (DIAGRAM 3 OF 9) FUSE 74 FROM RUN/START RELAY (DIAGRAM 2 OF 9) FUSE 13 FUSE 19 FUSE 20 FUSE 36 FUSE 42 FUSE 43 FUSE 44 FUSE 68 FUSE 70 GRN WIRE GRN/RED WIRE GRY WIRE GRY/RED WIRE IGN SW IGNITION SWITCH LEFT SIDE OF DASH) (EXCEPT STRIPPED CHASSIS: LEFT KICK PANEL) LOCK LOCK OFF OFF RUN WIRE RUN/ FUSE 45 RUN/START IGN SW SMART JUNCTION BOX (SJB) (STRIPPED CHASSIS: STARTER RELAY STRIPPED CHASSIS TO SPLICE 132 (DIAGRAM 5 OF 9) TO UPFITTER RELAY 1 (DIAGRAM 9 OF 9) TO UPFITTER RELAY 2 (DIAGRAM 9 OF 9) TO UPFITTER SWITCH (DIAGRAM 9 OF 9) VIO WIRE VIO/GRN WIRE WHT/ORG WIRE WINDSHIELD (NOT USED) WIPER MOTOR WINDSHIELD WIPER RELAY YEL WIRE YEL/RED WIRE

4.6L, 5.4L 6.8L A/C CLUTCH RELAY BATTERY JUNCTION BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLU/BRN WIRE BLU/RED WIRE BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BRAKE PEDAL POSITION SWITCH BRN/RED WIRE COIL ON COIL ON PLUG PLUG (COP) 2 (COP) 1 COIL ON COIL ON PLUG PLUG (COP) 5 (COP) 4 COIL ON COIL ON PLUG PLUG (COP) 7 (COP) 8 COIL ON IGNITION PLUG TRANSFORMER (COP) 6 CAPACITOR 1 (6.8L) COIL ON PLUG (COP) 10 (6.8L) COIL ON PLUG (COP) 3 COIL ON PLUG (COP) 9 (6.8L) EVAP EGR CANISTER SYSTEM PURGE MODULE VALVE (ESM) (4.6L) EXCEPT 6.8L FROM FROM FUSE 35 (DIAGRAM 2 OF 9) FUSE 75 FUSE 76 FUSE 77 FUSE 78 FUSE 79 GRN WIRE GRY WIRE GRY/BLU WIRE GRY/VIO WIRE HEATED OXYGEN SENSOR IGNITION TRANSFORMER CAPACITOR 1 (4.6L, 5.4L) IGNITION TRANSFORMER CAPACITOR 2 (4.6L, 5.4L) MASS AIR FLOW/ INTAKE AIR TEMPERATURE (MAF/IAT) SENSOR OVERDRIVE TRANSMISSION CANCEL SWITCH (IF EQUIPPED) PCM POWER RELAY POWERTRAIN CONTROL MODULE (PCM) POWERTRAIN CONTROL MODULE (PCM) (4.6L, 5.4L) POWERTRAIN CONTROL MODULE (PCM) (6.8L) REVERSING LAMP RELAY SELECTOR NEUTRAL SWITCH WIRING HARNESS, NEAR BREAKOUT TO STRIPPED CHASSIS STRIPPED CHASSIS, CUTAWAY UNIVERSAL UNIVERSAL HEATED OXYGEN HEATED OXYGEN SENSOR SENSOR VIO WIRE VIO/WHT WIRE WHT WIRE YEL/BLU WIRE YEL/GRY WIRE

BATTERY JUNCTION BLK/BLU WIRE BLU WIRE BLU/ORG WIRE BRAKE PEDAL POSITION SWITCH BRAKE PEDAL SW BRAKE SHIFT INTERLOCK (STEERING COLUMN) BRN WIRE BSI CTRL (FET) DIGITAL TRANSMISSION RANGE (DTR) SENSOR FUSE GRN WIRE HOT AT ALL TIMES HOT AT ALL TIMES FUSE 5 HOT IN INSTRUMENT PANEL CLUSTER IPC ORG/ WIRE PARK DETECT SW RED WIRE SMART JUNCTION BOX (SJB) (LEFT KICK PANEL) STARTER BOX (BJB) RELAY (LEFT FRONT OF ENGINE COMPT) DIODE VBATT VIO WIRE WHT WIRE

360 648 1145 1146 570 527 (ENDS IN HARNESS) AIR CONDITIONING SYSTEM BATTERY JUNCTION BLK/LT BLU WIRE BLK/WHT WIRE BLK/YEL WIRE BOX (LEFT FRONT OF ENGINE COMPT) BRN/PNK WIRE CENTRAL JUNCTION BOX (BELOW LEFT SIDE OF DASH, NEAR LEFT KICK PANEL) DATA LINK CONNECTOR (PARTIAL) (LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/YEL WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE EGR SOL CTRL NOT USED F GAUGE SENDER PRGRM SIGNAL FUSE 20 FUSE 8 FUSE 4 FUSE 9 GROUND GROUND IGN COIL 1 TCIL GROUND IGN COIL GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START IAT INPUT FUEL PUMP OUT A/C ON SIG IMRC IGNITION COIL (LEFT FRONT OF ENGINE) IGNITION TRANSFORMER CAPACITOR 1 (ATTACHED TO IGNITION COIL) IMRC MONITOR INSTRUMENT CLUSTER SYSTEM 29 107 KS + LT BLU/BLK WIRE LT GRN/RED WIRE MAF RTN TFTS INPUT NCA WIRE OD CANCEL SW OD OFF ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE SCP BUS SCP BUS SPARK PLUGS SPARK PLUGS SPARK PLUGS TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL INDICATOR LAMP VIO WIRE VIO/ORG WIRE WATER TEMP SENS WHT/LT GRN WIRE WHT/PNK WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/WHT WIRE

360 648 1145 1146 570 527 (ENDS IN HARNESS) AIR CONDITIONING SYSTEM BATTERY JUNCTION BLK/LT BLU WIRE BLK/WHT WIRE BLK/YEL WIRE BOX (LEFT FRONT OF ENGINE COMPT) BRN/PNK WIRE CENTRAL JUNCTION BOX (BELOW LEFT SIDE OF DASH, NEAR LEFT KICK PANEL) DATA LINK CONNECTOR (PARTIAL) (LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/YEL WIRE DK GRN/PNK WIRE DK GRN/YEL WIRE EGR SOL CTRL NOT USED F GAUGE SENDER PRGRM SIGNAL FUSE 20 FUSE 8 FUSE 4 FUSE 9 GROUND GROUND IGN COIL 1 TCIL GROUND IGN COIL GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START IAT INPUT FUEL PUMP OUT A/C ON SIG IMRC IGNITION COIL (LEFT FRONT OF ENGINE) IMRC MONITOR INSTRUMENT CLUSTER SYSTEM 29 107 KS + LT BLU/BLK WIRE LT GRN/RED WIRE MAF RTN TFTS INPUT NCA WIRE OD CANCEL SW OD OFF ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE RADIO CAPACITOR 1 (ATTACHED TO IGNITION COIL) RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE SCP BUS SCP BUS SPARK PLUGS SPARK PLUGS SPARK PLUGS TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL INDICATOR LAMP VIO WIRE VIO/ORG WIRE WATER TEMP SENS WHT/LT GRN WIRE WHT/PNK WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/WHT WIRE