Ford Cutaway E350 Super Duty (1999-2012) sig rtn Wiring diagrams

BLK WIRE BRN/LT GRN WIRE BRN/PNK WIRE COOLING FAN SPEED SIG DK BLU WIRE ELECTRONIC FAN CLUTCH (LEFT TOP FRONT OF ENGINE) ELECTRONIC FAN CLUTCH CONTROL ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE (ECT) SENSOR (ON UPPER LEFT FRONT OF ENGINE) FUSE 21 GRY/RED WIRE HOT AT ALL TIMES NCA WIRE RED WIRE RED/ORG WIRE SIG RTN VREF YEL WIRE YEL/WHT WIRE

6.8L 6.8L EXCEPT 6.8L ANTI-LOCK BRAKE SYSTEM (ABS) MODULE (LEFT FRONT OF ENGINE COMPT) BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLK/BLU WIRE BLK/GRY (OR BLK/BLU) WIRE BLK/GRY WIRE BLK/YEL WIRE BLU/BRN WIRE BLU/ORG WIRE BPS BRAKE FLUID SW BRAKE FLUID SW RTN BRAKE PEDAL POSITION SWITCH BRN/BLU WIRE BRN/GRN WIRE CAN (+) COMPUTER DATA LINES SYSTEM EXCEPT STRIPPED CHASSIS FUSE 33 FUSE 47 FUSE 53 FUSE 76 GRY/BRN WIRE GRY/VIO WIRE HOT AT ALL TIMES HOT IN START OR RUN ISS LEFT FRONT WHEEL SPEED SENSOR NCA WIRE OSS + OUTPUT SHAFT SPEED (OSS) SENSOR OUTPUT SHAFT SPEED (OSS) SENSOR (TORQSHIFT) (RIGHT REAR OF TRANSMISSION) POWERTRAIN CONTROL MODULE (PCM) (STRIPPED CHASSIS: CENTER REAR OF ENGINE COMPT) RED WIRE RIGHT FRONT WHEEL SPEED SENSOR (RIGHT FRONT WHEEL HUB ASSEMBLY) SIG RTN SMART JUNCTION BOX (SJB) STRIPPED CHASSIS TRANSMISSION TRANSMISSIONS SYSTEM TRGND TSS TURBINE SHAFT SPEED (TSS) SENSOR TURBINE SHAFT SPEED SENSOR VBATT VIO WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/WHT WIRE VPWR ABS ACTIVE VREF WHEEL SPD LF+ WHEEL SPD LF- WHEEL SPD RF+ WHEEL SPD RF- HS CAN + HS CAN - WHT WIRE WHT/BLU WIRE WHT/ORG WIRE WHT/RED WIRE WIRING HARNESS, NEAR BREAKOUT TO TORQSHIFT TRANS- MISSION) YEL WIRE YEL/GRY WIRE YEL/ORG WIRE

1 6 7 TC ON/OFF HS CAN- HS CAN+ 6.8L 6.8L EXCEPT 6.8L ABS TEST CONNECTOR (LEFT FRONT CORNER OF ENGINE COMPT) AUDIO CONTROL MODULE (ACM) BLK WIRE BLK/YEL WIRE BLU WIRE BPS BRAKE PEDAL POSITION SWITCH BRN WIRE BRN/BLU WIRE BRN/GRN WIRE CAN (+) COMPUTER DATA LINES SYSTEM EXCEPT STRIPPED CHASSIS FUSE 53 FUSE 76 GRN/VIO WIRE GRY WIRE GRY/BRN WIRE GRY/VIO WIRE HOT AT ALL TIMES BATTERY JUNCTION FUSE 47 BOX (BJB) (LEFT FRONT OF ENGINE COMPT) HOT IN START OR RUN INSTRUMENT PANEL CLUSTER (IC) ISS OSS + OUTPUT SHAFT SPEED (OSS) SENSOR OUTPUT SHAFT SPEED (OSS) SENSOR (TORQSHIFT) (RIGHT REAR OF TRANSMISSION) POWERTRAIN CONTROL MODULE (PCM) (STRIPPED CHASSIS: CENTER REAR OF ENGINE COMPT) RED WIRE SIG RTN SOLID STATE STEERING POSITION SENSOR (BOTTOM OF STEERING COLUMN) STRIPPED CHASSIS TRACTION CONTROL SWITCH TRANSMISSION TRANSMISSIONS SYSTEM TRGND TSS TURBINE SHAFT SPEED (TSS) SENSOR TURBINE SHAFT SPEED SENSOR VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VREF WHT WIRE WHT/BLU WIRE WHT/ORG WIRE WHT/RED WIRE WIRING HARNESS, NEAR BREAKOUT TO TORQSHIFT TRANS- MISSION) YEL/GRY WIRE YEL/ORG WIRE

14 6 22 46 VDF VSS SPD SIG RTN VREF BLU/BRN WIRE BRN/LT GRN WIRE BRN/PNK WIRE DK BLU WIRE ECT ENGINE COMPT) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE (ECT) SENSOR FAN CLUTCH GRY/RED WIRE NCA WIRE RED WIRE RED/ORG WIRE SIG RTN SPEED SENSOR ELECTRONIC FAN CLUTCH (TOP FRONT OF ENGINE) YEL/WHT WIRE

A/C A/C ON SIG A/C PRESS SW ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH, ABOVE ACCEL PEDAL) ACCL POS SENS BARO BAROMETRIC PRESSURE (BARO) SENSOR (1999) (BELOW LEFT SIDE OF DASH) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BOO SW BRN/ORG WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR (FRONT CENTER OF ENGINE) CHARGE IND CID SIG CMP RTN CRUISE CONTROL DK BLU/LT GRN WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/WHT WIRE ECT SENS EPC SOL EPR EXHAUST BACK PRESSURE (EBP) SENSOR (TOP CENTER OF ENGINE) EXHAUST PRESSURE REGULATOR (TOP LEFT REAR OF ENGINE) FUEL DELIV SIG FUEL PUMP RLY FUEL SENDER GEN PWR SW GLOW PLUG CTRL GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE ICP SENS IDM ENABLE OUT IDM SIG IN INJECTION CONTROL PRESSURE (ICP) SENSOR (ON TOP OF ENGINE) INSTRUMENT CLUSTER IPR SENS KAPWR LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (TOP RIGHT SIDE OF ENGINE COMPT) MAP SENS MIA HTR RELAY NCA WIRE NOT USED ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PNK WIRE PNK/ORG WIRE PWR GND RED WIRE RED/YEL WIRE SIG RTN SPEED CTRL SIG SPEEDOMETER STARTING/ CHARGING TAN/LT GRN WIRE TAN/WHT WIRE TCC TCIL TCS TSS SENS TURBINE SHAFT SPEED SENSOR (RIGHT SIDE OF TRANS) VEHICLE SPEED SENSOR (LEFT SIDE OF TRANS) VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE VIO/YEL WIRE VPWR VREF VS SENS VSS IN WAIT TO START WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/VIO WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

58 AMP HEATER BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX FUSE 11 CID SIG IN DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK GRN WIRE DK GRN/LT GRN WIRE ELECTRONIC COAST PRESSURE CLUTCH CONTROL SOLENOID SOLENOID ENGINE BLOCK) FUEL DELIVERY SIG FUEL INJ FEED LEFT FUEL INJ FEED RIGHT FUEL INJECTORS/ GLOW PLUGS FUSE 8 FUSE LINK (20 GA- FUSE LINK D (14 GA- FUSE LINK E (14 GA- GLOW PLUG RELAY (TOP RIGHT SIDE OF ENGINE) GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START IDM FEEDBACK SIG INJ SHIELD GND INJECTOR DRIVER MODULE LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MANIFOLD AIR INTAKE HEATER RELAY (TOP OF ENGINE) NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE P, 2, 1 P, N, 1 P, R, 2 P, R, N PNK/YEL WIRE PWR GND RED WIRE RED/LT GRN WIRE RED/YEL WIRE SIG RTN SIGNAL RETURN SOLENOID TAN WIRE TAN/BLK WIRE TAN/RED WIRE TORQUE SOLENOID CONVERTER CLUTCH SOLENOID TRANSMISSION TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/YEL WIRE VPWR WHT WIRE WHT/LT GRN WIRE WHT/VIO WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/WHT WIRE

A/C A/C ON SIG A/C PRESS SW ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH, ABOVE ACCEL PEDAL) ACCL POS SENS BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BOO SW BRN/ORG WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR (FRONT CENTER OF ENGINE) CHARGE IND CID SIG CMP RTN CRUISE CONTROL DK BLU/LT GRN WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/WHT WIRE EPC SOL EPR EXHAUST BACK PRESSURE (EBP) SENSOR (TOP CENTER OF ENGINE) EXHAUST PRESSURE REGULATOR (TOP LEFT REAR OF ENGINE) FUEL DELIV SIG FUEL PUMP RLY FUEL SENDER GEN PWR SW GLOW PLUG CTRL GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE ICP SENS IDM ENABLE OUT IDM SIG IN INDICATOR CTRL INJECTION CONTROL PRESSURE (ICP) SENSOR (ON TOP OF ENGINE) INSTRUMENT CLUSTER IPR SENS KAPWR LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (TOP RIGHT SIDE OF ENGINE COMPT) MAP SENS MIA HTR RELAY NCA WIRE NOT USED ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH OVERHEAD CONSOLE (EXCEPT CUTAWAY) PNK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PWR GND RED WIRE RED/YEL WIRE SIG RTN SPEED CTRL SIG SPEEDOMETER STARTING/ CHARGING TAN/LT GRN WIRE TAN/WHT WIRE TCC TCIL TCS TSS SENS TURBINE SHAFT SPEED SENSOR (RIGHT SIDE OF TRANS) VEHICLE SPEED SENSOR (LEFT SIDE OF TRANS) VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE VIO/YEL WIRE VPWR VREF VS SENS VSS IN WAIT TO START WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 GL PLUG 5 GL PLUG 7 POWER 1 2 3 4 5 6 7 8 9 GL PLUG 6 GL PLUG 8 POWER AIR INTAKE HEATER GRID BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BRN/BLU WIRE BRN/GRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/RED WIRE BRN/WHT WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX FUSE 11 CID SIG IN DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK GRN/LT GRN WIRE ELECTRONIC COAST PRESSURE CLUTCH CONTROL SOLENOID SOLENOID ENGINE BLOCK) FUEL DELIVERY SIG FUEL INJ FEED LEFT FUEL INJ FEED RIGHT FUSE LINK D (12 GA- FUSE LINK E (12 GA- FUSE LINK H (20 GA- GL PLUG 1 GL PLUG 3 CTRL OUT GPCM GL PLUG 2 GL PLUG 4 GLOW PLUG CONTROL MODULE (TOP RIGHT SIDE OF ENGINE) GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES IDM FEEDBACK SIG INJ SHIELD GND INJECTOR DRIVER MODULE LEFT VALVE COVER ASSEMBLY LT BLU WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MANIFOLD AIR INTAKE HEATER RELAY (TOP OF ENGINE) NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE P, 2, 1 P, N, 1 P, R, 2 P, R, N PNK/YEL WIRE POWER PWR GND RED WIRE RED/YEL WIRE RIGHT VALVE COVER ASSEMBLY SHIFT SOLENOID SHIFT TORQUE SOLENOID CONVERTER CLUTCH SOLENOID SIG RTN SIGNAL RETURN TAN WIRE TAN/BLK WIRE TAN/RED WIRE TRANSMISSION TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/YEL WIRE VPWR WHT WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

A/C A/C ON SIG A/C PRESS SW ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH, ABOVE ACCEL PEDAL) ACCL POS SENS BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BOO SW BRN/ORG WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR (FRONT CENTER OF ENGINE) CHARGE IND CID SIG CMP RTN CRUISE CONTROL DK BLU/LT GRN WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/WHT WIRE EPC SOL EPR EXHAUST BACK PRESSURE (EBP) SENSOR (TOP CENTER OF ENGINE) EXHAUST PRESSURE REGULATOR (TOP LEFT REAR OF ENGINE) FUEL DELIV SIG FUEL PUMP RLY FUEL SENDER GEN PWR SW GLOW PLUG CTRL GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE ICP SENS IDM ENABLE OUT IDM SIG IN INDICATOR CRTL INJECTION CONTROL PRESSURE (ICP) SENSOR (ON TOP OF ENGINE) INSTRUMENT CLUSTER IPR SENS KAPWR LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (TOP RIGHT SIDE OF ENGINE COMPT) MAP SENS MIA HTR RELAY NCA WIRE NOT USED ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH OVERHEAD CONSOLE (EXCEPT CUTAWAY) PNK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PWR GND RED WIRE RED/YEL WIRE SIG RTN SPEED CTRL SIG SPEEDOMETER STARTING/ CHARGING TAN/LT GRN WIRE TAN/WHT WIRE TCC TCIL TCS TSS SENS TURBINE SHAFT SPEED SENSOR (RIGHT SIDE OF TRANS) VEHICLE SPEED SENSOR (LEFT SIDE OF TRANS) VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE VIO/YEL WIRE VPWR VREF VS SENS VSS IN WAIT TO START WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/VIO WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

AIR INTAKE HEATER GRID BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX FUSE 11 CID SIG IN DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK GRN/LT GRN WIRE ELECTRONIC COAST PRESSURE CLUTCH CONTROL SOLENOID SOLENOID ENGINE BLOCK) FUEL DELIVERY SIG FUEL INJ FEED LEFT FUEL INJ FEED RIGHT FUSE LINK (20 GA- FUSE LINK D (12 GA- FUSE LINK E (12 GA- FUSE LINK H (20 GA- GLOW PLUG RELAY (TOP RIGHT SIDE OF ENGINE) GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES IDM FEEDBACK SIG INJ SHIELD GND INJECTOR DRIVER MODULE LEFT VALVE COVER ASSEMBLY LT BLU WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MANIFOLD AIR INTAKE HEATER RELAY (TOP OF ENGINE) NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE P, 2, 1 P, N, 1 P, R, 2 P, R, N PNK/YEL WIRE PWR GND RED WIRE RED/YEL WIRE RIGHT VALVE COVER ASSEMBLY SHIFT SOLENOID SHIFT TORQUE SOLENOID CONVERTER CLUTCH SOLENOID SIG RTN SIGNAL RETURN TAN WIRE TAN/BLK WIRE TAN/RED WIRE TRANSMISSION TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/YEL WIRE VPWR WHT WIRE WHT/PNK WIRE WHT/VIO WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/WHT WIRE