Ford Cutaway E350 Super Duty (1999-2012) hot at all times Wiring diagrams

35 36 IGNITION (ST/RUN) IGNITION (ST/RUN) 45 8 CLUSTER PWR BPP SW BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DK BLU/WHT WIRE DK GRN WIRE ENDS IN HARNESS ENGINE CONTROLS SYSTEM FUSE 11 FUSE 2 FUSE 21 FUSE 23 FUSE 27 FUSE 8 GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN OR START LT GRN/RED WIRE NCA WIRE OD OFF OVERDRIVE CANCEL SWITCH OVERHEAD CONSOLE (IF EQUIPPED) PCM POWER DIODE PCM POWER RELAY RED WIRE RED/LT GRN WIRE RED/YEL WIRE TAN WIRE TAN/WHT WIRE TAN/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL/BLK WIRE

APP_B+ BATTERY JUNCTION BOX (RIGHT FRONT OF ENGINE COMPT) BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DK GRN WIRE ENDS IN HARNESS ENGINE CONTROLS SYSTEM FUSE 11 FUSE 21 FUSE 27 FUSE 8 GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER LT BLU/RED WIRE LT GRN/RED WIRE MASS AIR FLOW SENSOR (LEFT FRONT OF ENGINE COMPT) OVERHEAD CONSOLE (IF EQUIPPED) PCM POWER DIODE PCM POWER RELAY PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (LEFT REAR OF ENGINE COMPT) RED WIRE RED/LT GRN WIRE SIG RTN COWL TAN WIRE TAN/LT BLU WIRE TAN/WHT WIRE TAN/YEL WIRE VIO WIRE VREF COWL WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL/BLK WIRE

BATTERY JUNCTION BOX (BJB) (RIGHT FRONT OF ENGINE COMPT) BLK WIRE BLU/RED WIRE BLU/WHT WIRE BRN/GRN WIRE CHARGING SYSTEM FUSE 27 GRN/WHT WIRE GRY/RED WIRE HOT AT ALL TIMES IGNITION SWITCH LOCK OFF POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF ENGINE COMPT) PRIMARY BATTERY RED WIRE RUN WIRE SECONDARY BATTERY SMC STARTER MOTOR STARTER RELAY YEL WIRE

24 45 8 REV LMP CTRL KAPWR BPP SW 27 1 4 5 6 16 17 18 28 47 48 49 50 10 OD CANCEL SW VSS APPA_+ 35 36 VPWR VPWR APPA_- APPB_+ APPB_- AUXILIARY RELAY BOX 1 (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) FUSE 23 BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DK BLU/WHT WIRE DK GRN WIRE DK GRN/ORG WIRE ENDS IN HARNESS ENGINE CONTROLS SYSTEM FUSE 11 FUSE 2 FUSE 21 FUSE 27 FUSE 8 GROUND GROUND GROUND GROUND GROUND GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN OR START LT GRN/RED WIRE NCA WIRE OD OFF OVERDRIVE CANCEL SWITCH OVERHEAD CONSOLE (IF EQUIPPED) PCM POWER DIODE PCM POWER RELAY RED WIRE RED/LT GRN WIRE RED/YEL WIRE REVERSING LAMP RELAY TAN WIRE TAN/WHT WIRE TAN/YEL WIRE W/ ADVANCE TRAC W/ REMOTE KEYLESS ENTRY OR ADVANCE TRAC W/ STRIPPED CHASSIS WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 +/- 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 MS CAN + MS CAN - B+ GROUND GROUND BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DK BLU WIRE EXCEPT CUTAWAY FUSE 10 FUSE 15 FUSE 2 FUSE 23 HEAD HINGED SIDE DOOR HORNS SYSTEM HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN RUN OR START LEFT FRONT DOOR LOCK ACTUATOR (AT REAR OF LEFT FRONT DOOR) LT BLU WIRE LT BLU/PNK WIRE MAIN LIGHT SWITCH OFF ORG/ WIRE PARK PARK/HEAD PNK 1 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE REAR DOORS DOOR LOCK ACTUATOR (EXCEPT CUTAWAY) (AT LEFT SIDE OF RIGHT REAR DOOR) RED WIRE RED/ORG WIRE RED/YEL WIRE RIGHT FRONT DOOR LOCK ACTUATOR (AT REAR OF RIGHT FRONT DOOR) RIGHT SIDE DOOR LOCK ACTUATOR (AT REAR OF RIGHT SIDE HINGED DOOR) RIGHT SIDE DOOR LOCK ACTUATOR (IN FRONT OF RIGHT SIDE SLIDING DOOR) RIGHT SLIDING DOOR CONTACT SWITCH (AT RIGHT "B" PILLAR) RUN/ACC RUN/START B+ SLIDING SIDE DOOR TAN WIRE TAN/WHT WIRE UNLOCK LOCK HORN RELAY VEHICLE SECURITY MODULE (VSM) (BEHIND RIGHT END OF DASH) WHT WIRE WHT/BLK WIRE YEL WIRE

16 17 15 DRIVER DOOR AJAR SLIDING DOOR AJAR DOORS AJAR 23 22 MS CAN+ MS CAN- 5 10 RUN/START PWR GROUND BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM FRONT PASSENGER WINDOW/DOOR LOCK SWITCH FUSE 14 FUSE 22 HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER LEFT FRONT DOOR AJAR SWITCH (AT LEFT KICK PANEL) LOCK LOGIC GROUND LR GRN WIRE LT BLU WIRE LT GRN WIRE MASTER WINDOW/ DOOR LOCK/UNLOCK SWITCH NCA WIRE PNK PNK WIRE PNK WIRE PNK/LT GRN WIRE PNK/YEL WIRE REAR DOORS DOOR AJAR RED WIRE RED/PNK WIRE RED/WHT WIRE RIGHT FRONT DOOR AJAR SWITCH (AT RIGHT KICK PANEL) RIGHT SIDE DOOR AJAR SWITCH (IN FRONT OF RIGHT SIDE DOOR) RIGHT SLIDING DOOR AJAR SWITCH (AT RIGHT "B" PILLAR) SWITCH (EXCEPT CUTAWAY) UNLOCK W/ HINGED CARGO DOOR W/ SLIDING CARGO DOOR WHT WIRE WHT/BLK WIRE WHT/YEL WIRE YEL WIRE

11 1 DOME REQ BATTERY SVR 16 13 15 17 LF AJAR SW SIG CRTSY LAMP DR AJAR SW SIG SLIDING DOOR AJAR SW SIG AUXILIARY CARGO LAMP AUXILIARY RELAY BOX 2 (BEHIND CENTER OF DASH) INTERIOR LAMP RELAY BATTERY SAVER RELAY BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/WHT WIRE CARGO LAMP CARGO LAMP 1 CARGO LAMP 2 CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DOME DOOR AJAR SWITCH (LEFT FRONT) (BEHIND LEFT KICK PANEL) MAIN LIGHT SWITCH DOOR AJAR SWITCH (REAR DOORS) (EXCEPT CUTAWAY) FUSE 22 FUSE 4 HIGH MOUNTED STOPLAMP HOT AT ALL TIMES INSTRUMENT CLUSTER INTERIOR LAMP INTERIOR/ MAP LAMPS ASSEMBLY (FRONT) LT BLU WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/YEL WIRE NCA WIRE OFF ORG/ WIRE ORG/LT GRN WIRE REAR INTERIOR LAMP RED WIRE RED/PNK WIRE RIGHT FRONT DOOR AJAR SWITCH (BEHIND RIGHT KICK PANEL) RIGHT SIDE DOOR AJAR SWITCH (FRONT OF RIGHT SIDE FRONT HINGED DOOR) RIGHT SLIDING DOOR AJAR SWITCH (AT RIGHT "B" PILLAR) VANITY MIRROR LAMP (LEFT) VANITY MIRROR LAMP (RIGHT) VIO WIRE VIO/ORG WIRE W/ FULL HEADLINER W/ HINGED W/ SLIDING CARGO DOOR CARGO DOOR W/ SPEAKER W/O SPEAKER WHT WIRE YEL WIRE

BLK WIRE BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FRONT PASSENGER WINDOW/ DOOR LOCK SWITCH FUSE 5 HOT AT ALL TIMES LEFT FRONT DOOR LOCK ACTUATOR (AT REAR OF LEFT FRONT DOOR) LOCK MASTER WINDOW/ DOOR LOCK/ UNLOCK SWITCH ORG/ WIRE PNK PNK WIRE PNK WIRE RED WIRE RIGHT FRONT DOOR LOCK ACTUATOR (AT REAR OF RIGHT FRONT DOOR) UNLK WHT WIRE YEL WIRE

1 PNK/ WIRE 5 PNK/ WIRE BLK WIRE BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FRONT PASSENGER WINDOW/ DOOR LOCK SWITCH FUSE 5 HOT AT ALL TIMES LEFT FRONT DOOR LOCK ACTUATOR (AT REAR OF LEFT FRONT DOOR) LOCK MASTER WINDOW/ DOOR LOCK/ UNLOCK SWITCH ORG/ WIRE PNK PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE PNK/LT GRN WIRE PNK/YEL WIRE REAR DOORS DOOR LOCK SWITCH (AT LOWER RIGHT SIDE OF RIGHT REAR DOOR) RED WIRE RIGHT FRONT DOOR LOCK ACTUATOR (AT REAR OF RIGHT FRONT DOOR) UNLK WHT WIRE YEL WIRE

1 PNK/ WIRE BLK WIRE BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FRONT PASSENGER WINDOW/ DOOR LOCK SWITCH FUSE 5 HOT AT ALL TIMES LEFT FRONT DOOR LOCK ACTUATOR (AT REAR OF LEFT FRONT DOOR) LOCK MASTER WINDOW/ DOOR LOCK/ UNLOCK SWITCH ORG/ WIRE PNK PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE PNK/YEL WIRE REAR DOORS DOOR LOCK SWITCH (AT LOWER RIGHT SIDE OF RIGHT REAR DOOR) RED WIRE RIGHT FRONT DOOR LOCK ACTUATOR (AT REAR OF RIGHT FRONT DOOR) RIGHT SLIDING DOOR CONTACT SWITCH (AT RIGHT "B" PILLAR) UNLK WHT WIRE YEL WIRE