Ford Cutaway E350 Super Duty (1999-2012) engine controls system Wiring diagrams

BATTERY JUNCTION BOX BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BRN/ORG WIRE BRN/WHT WIRE COAST CLUTCH SOLENOID CYLINDER HEAD TEMPERATURE SENSOR (ON TOP FRONT OF LEFT CYLINDER HEAD) DK BLU/YEL WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS SYSTEM FUSE 21 FUSE 27 GASOLINE GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) HOT IN RUN OR START CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 8 IGNITION COIL, RADIO NOISE CAPACITOR LT BLU/RED WIRE LT GRN WIRE NATURAL GAS VEHICLE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) PCM POWER DIODE PCM POWER RELAY RED WIRE SHIFT SOLENOID TAN/LT BLU WIRE THROTTLE POSITION SENSOR (TPS) (ON TOP OF ENGINE, NEAR AIR INTAKE) TORQUE CONVERTER CLUTCH SOLENOID SHIFT SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SENSOR (AT LEFT SIDE OF TRANSMISSION) VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE

15 3 41 16 17 27 28 29 13 42 43 46 TSS SENSOR OSS SIG TR-P GROUND 23 44 11 CAN - PROG SIG CAN + BLK/WHT WIRE DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DK BLU/YEL WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ELECTRONIC THROTTLE CONTROL (ETC) MOTOR (TOP RIGHT FRONT OF ENGINE) ENGINE CONTROLS SYSTEM GRY WIRE GRY/RED WIRE GRY/WHT WIRE INSTRUMENT CLUSTER LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/RED WIRE MASS AIR FLOW (MAF) SENSOR (AT CENTER OF ENGINE COMPT) ORG/BLK WIRE ORG/LT BLU WIRE ORG/YEL WIRE PNK/LT GRN WIRE PNK/ORG WIRE RED WIRE RED/LT GRN WIRE SHIFT SOLENOIDS TAN/LT BLU WIRE TAN/LT GRN WIRE TFT SENSOR SIG EPC SOL SHIFT SOL A SHIFT SOL B TCC SOL THROTTLE POSITION SENSOR (TOP OF ENGINE, NEAR AIR INTAKE) TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/YEL WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/WHT WIRE

35 36 IGNITION (ST/RUN) IGNITION (ST/RUN) 45 8 CLUSTER PWR BPP SW BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DK BLU/WHT WIRE DK GRN WIRE ENDS IN HARNESS ENGINE CONTROLS SYSTEM FUSE 11 FUSE 2 FUSE 21 FUSE 23 FUSE 27 FUSE 8 GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN OR START LT GRN/RED WIRE NCA WIRE OD OFF OVERDRIVE CANCEL SWITCH OVERHEAD CONSOLE (IF EQUIPPED) PCM POWER DIODE PCM POWER RELAY RED WIRE RED/LT GRN WIRE RED/YEL WIRE TAN WIRE TAN/WHT WIRE TAN/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL/BLK WIRE

34 51 60 45 44 59 34 51 59 60 61 66 34 51 60 45 44 59 TACM + TACM - ETC RTN 4.6L 40 2 SIG RTN OSS VREF OSS TR GND 41 18 17 4 6 5 16 28 19 30 RTN APPRTN 44 29 45 60 28 61 44 29 45 60 28 61 5.4L, 4.6L 5.4L, 6.8L 52 27 VREF BFP 6.8L 6.8L 4.6L 5.4L 64 48 64 48 SCCS SCCSRTN 8 45 10 13 62 50 BPP KAPWR POWER GND APPVREF BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/BLU WIRE BLK/GRN WIRE BLU WIRE BLU/BLK WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/GRY WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BPS BRAKE PEDAL POSITION SWITCH BRN WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/RED WIRE BRN/WHT WIRE CLOCKSPRING (STEERING WHEEL) COAST ELECTRONIC THROTTLE CONTROL (ETC) MOTOR ENGINE CONTROLS SYSTEM ETC REF EXCEPT STRIPPED CHASSIS FUSE 30 FUSE 46 FUSE 76 GRN WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY/VIO WIRE HORN SWITCH HOT AT ALL TIMES HOT IN START OR RUN INTERIOR LIGHTS HORNS SYSTEM SYSTEM LEFT STEERING WHEEL SWITCH NCA WIRE OFF ON OUTPUT SHAFT SPEED (OSS) SENSOR RES+ RIGHT STEERING WHEEL SWITCH SET/ACCEL SOLID STATE SOUND SYSTEM STRIPPED CHASSIS THROTTLE POSITION SENSOR (TPS) (TOP OF ENGINE, NEAR AIR INTAKE) TOP OF ENGINE) TRANS- MISSIONS SYSTEM TRANSMISSIONS SYSTEM VIO WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/VIO WIRE YEL WIRE YEL/GRN WIRE YEL/ORG WIRE YEL/VIO WIRE

1 28 22 VREF OSS TR GND 10 28 40 31 24 GROUND BRAKE PRESS SW KAPWR SCCS SCCSRTN 20 37 29 25 33 26 45 APPRTN ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH, ABOVE ACCELERATOR PEDAL) APPVREF BLK WIRE BLK/BLU WIRE BLK/GRN WIRE BLU WIRE BLU/BLK WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BLU/YEL WIRE BPP BRAKE PRESSURE SWITCH (LEFT REAR OF ENGINE COMPT) BRN WIRE BRN/BLU WIRE BRN/LT GRN WIRE BRN/RED WIRE BRN/WHT WIRE CHARGE, NEAR BREAKOUT TO POWERTRAIN CONTROL MODULE (PCM)) CLOCKSPRING (STEERING WHEEL) COAST ELECTRONIC FAN CLUTCH (TOP FRONT OF ENGINE) ENGINE CONTROLS SYSTEM EXCEPT STRIPPED CHASSIS FUSE 30 GRN WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY/YEL WIRE HORN SWITCH HOT AT ALL TIMES INTERIOR HORNS LIGHTS SYSTEM SYSTEM LEFT STEERING WHEEL SWITCH NAVIGATION SYSTEM NCA WIRE OFF OUTPUT SHAFT SPEED (OSS) SENSOR (RIGHT SIDE OF TRANSMISSION) POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF ENGINE COMPT) RES+ RIGHT STEERING WHEEL SWITCH SET/ACCEL SIG RTN COWL APP VREF STOPLAMP SWITCH (UNDER LEFT SIDE OF DASH) TAN/LT GRN WIRE TRANS- MISSIONS SYSTEM TRANSMISSIONS SYSTEM VIO WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/WHT WIRE VREF WHT WIRE WHT/GRN WIRE WHT/VIO WIRE YEL/ORG WIRE YEL/VIO WIRE

34 51 60 45 44 59 34 51 59 60 61 66 34 51 60 45 44 59 TACM + TACM - ETC RTN 4.6L 40 2 SIG RTN OSS VREF OSS TR GND 41 18 17 4 6 5 16 28 19 30 RTN APPRTN 44 29 45 60 28 61 44 29 45 60 28 61 5.4L, 4.6L 5.4L, 6.8L 52 27 VREF BFP 6.8L 6.8L 4.6L 5.4L 64 48 64 48 SCCS SCCSRTN 8 45 10 13 62 50 BPP KAPWR POWER GND APPVREF BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/BLU WIRE BLK/GRN WIRE BLU WIRE BLU/BLK WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/GRY WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BPS BRAKE PEDAL POSITION SWITCH BRN WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/RED WIRE BRN/WHT WIRE CLOCKSPRING (STEERING WHEEL) COAST ELECTRONIC THROTTLE CONTROL (ETC) MOTOR ENGINE CONTROLS SYSTEM ETC REF EXCEPT STRIPPED CHASSIS FUSE 30 FUSE 46 FUSE 76 GRN WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY/VIO WIRE HORN SWITCH HOT AT ALL TIMES HOT IN START OR RUN INTERIOR LIGHTS HORNS SYSTEM SYSTEM LEFT STEERING WHEEL SWITCH NCA WIRE OFF ON OUTPUT SHAFT SPEED (OSS) SENSOR RES+ RIGHT STEERING WHEEL SWITCH SET/ACCEL SOLID STATE SOUND SYSTEM STRIPPED CHASSIS THROTTLE POSITION SENSOR (TPS) (TOP OF ENGINE, NEAR AIR INTAKE) TOP OF ENGINE) TRANS- MISSIONS SYSTEM TRANSMISSIONS SYSTEM VIO WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/VIO WIRE YEL WIRE YEL/GRN WIRE YEL/ORG WIRE YEL/VIO WIRE

14 6 22 46 VDF VSS SPD SIG RTN VREF BLU/BRN WIRE BRN/LT GRN WIRE BRN/PNK WIRE DK BLU WIRE ECT ENGINE COMPT) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE (ECT) SENSOR FAN CLUTCH GRY/RED WIRE NCA WIRE RED WIRE RED/ORG WIRE SIG RTN SPEED SENSOR ELECTRONIC FAN CLUTCH (TOP FRONT OF ENGINE) YEL/WHT WIRE

4 3 ACCS ACCR 4.6L, 5.4L 6.8L 41 58 CHT SIGRTN 6.8L A/C CLUTCH RELAY A/C COMPRESSOR CLUTCH FIELD COIL (LOWER RIGHT BATTERY JUNCTION BOX (BJB) BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLOWER MOTOR (RIGHT SIDE OF ENGINE COMPT) BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR (RIGHT SIDE OF ENGINE COMPT) BLU WIRE BLU/GRY WIRE BRN WIRE CYLINDER HEAD TEMPERATURE SENSOR (FRONT OF LEFT ENGINE CONTROLS SYSTEM EXCEPT 5.4L FUSE 29 FUSE 32 FUSE 35 FUSE 46 FUSE 77 GRN WIRE GRN/WHT WIRE GRY WIRE GRY/BRN WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES ORG/ WIRE PCM POWER RELAY PCMRC POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF ENGINE COMPT) RED WIRE RESISTOR THERMAL LIMITER VIO WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/BRN WIRE YEL WIRE YEL/BLU WIRE

4 3 ACCS ACCR 4.6L, 5.4L 41 58 CHT SIGRTN 6.8L A/C CLUTCH RELAY A/C COMPRESSOR CLUTCH FIELD COIL (LOWER RIGHT FRONT OF ENGINE) BATTERY JUNCTION BOX (BJB) BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLU WIRE BLU/GRY WIRE BRN WIRE CUSTOMER ACCESS CYLINDER HEAD TEMPERATURE SENSOR (FRONT OF LEFT CYLINDER HEAD) ENGINE CONTROLS SYSTEM EXCEPT 5.4L FUSE 29 FUSE 32 FUSE 35 FUSE 37 FUSE 46 FUSE 77 GRN WIRE GRN/WHT WIRE GRY WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT AT ALL TIMES BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) HOT IN START OR RUN PCM POWER RELAY PCMRC POWERTRAIN CONTROL MODULE (PCM) (CENTER REAR OF ENGINE COMPT) RED WIRE SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) VIO WIRE VIO/WHT WIRE WHT WIRE WHT/BRN WIRE YEL WIRE YEL/BLU WIRE

1 1 FEED RETURN 1 2 3 4 5 6 7 8 9 PS AB FD 1 PS AB RET 1 DR AB RTN 1 DR AB FD 1 1 1 1 34 35 36 37 38 39 40 SAFETY BELT 7 6 HS CAN+ HS CAN- ANTI-LOCK BRAKE SYSTEM (ABS) MODULE (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/GRY WIRE BLU/ORG WIRE BRN WIRE BRN/GRN WIRE CASE GROUNDED CLOCKSPRING (STEERING WHEEL) COMPUTER DATA LINES SYSTEM DRIVER AIR BAG MODULE DRIVER SAFETY BELT BUCKLE SWITCH/PRETENSIONER (UNDER LEFT SIDE OF DRIVER'S SEAT) ENGINE COMPT) ENGINE CONTROLS SYSTEM ENS AB CUTOFF SW 20 21 22 23 24 FUSE 32 FUSE 46 GRN/BLU WIRE GRN/VIO WIRE GRN/WHT WIRE GRY/BLU WIRE HOT IN START OR RUN HS CAN + HS CAN - INSTRUMENT CLUSTER (IC) LEFT FRONTAL RESTRAINTS SENSOR (FRONT CENTER OF NCA WIRE PAD IND PASSENGER AIR BAG DEACTIVATION (PAD) SWITCH PASSENGER AIR BAG MODULE (IF EQUIPPED) (RIGHT SIDE OF DASH) RESTRAINTS CONTROL MODULE (RCM) (UNDER DRIVER'S SEAT) RUN/START SHORTING BAR VIO/BRN WIRE VIO/GRN WIRE VREF SIG RTN WHT WIRE WHT/BLU WIRE WHT/ORG WIRE YEL WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/VIO WIRE