Ford Club Wagon E350 (1996-1998) torque converter clutch solenoid Wiring diagrams

2 3 6 11 12 13 15 16 20 24 29 33 34 MIL GND 36 37 39 49 MAF TFT IAT 51 54 55 58 64 66 71 77 81 88 89 90 GND TCC KAPWR VSS ABS SYSTEM, BRAKE PRESSURE SWITCH ABS SYSTEM, WARNING BUZZER MODULE BLK WIRE BLK/WHT WIRE BRN/ORG WIRE BRN/WHT WIRE CHT PWR IN GND EPC MAF TPS VREF SIG RTN BPP PWR IN GND COAST CLUTCH SOLENOID SHIFT SOLENOID 2 CYLINDER HEAD TEMPERATURE SENSOR (TOP FRONT OF LEFT CYLINDER HEAD) DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) 10 13 PPL DIGITAL TRANSMISSION RANGE SENSOR DK BLU/WHT WIRE DK GRN/YEL WIRE ENGINE COMPARTMENT FUSE BOX ENGINE COMPARTMENT FUSE BOX (LEFT FRONT OF ENGINE COMPT) FUSE 9 ENGINE CONTROLS ENGINE CONTROLS (ENG CONTROL HARN, NEAR BREAKOUT TO A/C PRESSURE CUTOUT SWITCH) FUSE 11 FUSE 2 FUSE 20 FUSE 4 GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE PANEL (BEHIND LEFT SIDE OF DASH) FUSE 8 INSTRUMENT CLUSTER INSTRUMENT CLUSTER (1998) INTAKE AIR TEMPERATURE SENSOR (CENTER OF ENGINE COMPT, PART OF CLEAN AIR TUBE) LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE MALFUNCTION INDICATOR LAMP NCA WIRE ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL/ORG WIRE PPL/YEL WIRE RADIO NOISE CAPACITORS, IGNITION COILS RED WIRE RED/LT GRN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL GEN DATA DATA (-) DATA (+) CC SOL GND TCS VSS GND PPL TCIL OD OFF THROTTLE POSITION SENSOR (TPS) (ON TOP OF ENGINE, NEAR AIR INTAKE) TORQUE CONVERTER CLUTCH SOLENOID VEHICLE SPEED SENSOR (LEFT SIDE OF TRANSMISSION) WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/LT GRN WIRE

2 3 6 11 13 15 16 20 23 28 29 33 34 MIL GND 36 37 39 49 MAF TFT IAT 51 54 55 58 64 66 71 76 77 81 88 89 90 GND TCC KAPWR VSS ABS SYSTEM, BRAKE PRESSURE SWITCH ABS SYSTEM, WARNING BUZZER MODULE BLK WIRE BLK/WHT WIRE BRN/ORG WIRE BRN/WHT WIRE CHT PWR IN GND GND EPC MAF TPS VREF SIG RTN BPP PWR IN GND COAST CLUTCH SOLENOID SHIFT SOLENOID 2 CYLINDER HEAD TEMPERATURE SENSOR (TOP FRONT OF LEFT CYLINDER HEAD) DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) 10 13 PPL DIGITAL TRANSMISSION RANGE SENSOR DK BLU/WHT WIRE DK GRN/YEL WIRE ELECTRONIC PRESSURE CONTROL SOLENOID SHIFT SOLENOID 1 ENGINE COMPARTMENT FUSE BOX ENGINE COMPARTMENT FUSE BOX (LEFT FRONT OF ENGINE COMPT) FUSE 9 ENGINE CONTROLS ENGINE CONTROLS (ENG CONTROL HARN, NEAR BREAKOUT TO A/C PRESSURE CUTOUT SWITCH) FUSE 11 FUSE 2 FUSE 20 FUSE 4 GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE PANEL (BEHIND LEFT SIDE OF DASH) FUSE 8 INSTRUMENT CLUSTER INSTRUMENT CLUSTER (1998) INTAKE AIR TEMPERATURE SENSOR (CENTER OF ENGINE COMPT, PART OF CLEAN AIR TUBE) LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE MALFUNCTION INDICATOR LAMP NCA WIRE ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL GEN DATA DATA (-) DATA (+) CC SOL GND TCIL TCS VSS GND PPL/ORG WIRE PPL/YEL WIRE RADIO NOISE CAPACITORS, IGNITION COILS RED WIRE RED/LT GRN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL OD OFF THROTTLE POSITION SENSOR (TPS) (ON TOP OF ENGINE, NEAR AIR INTAKE) TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR VEHICLE SPEED SENSOR (LEFT SIDE OF TRANSMISSION) WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/LT GRN WIRE

BAROMETRIC PRESSURE (BARO) SENSOR (BEHIND LEFT SIDE OF I/P) BLK ORG/ WIRE BLK WIRE BLK/WHT WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL BRACKET) BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR (FRONT OF ENGINE) CHECK ENGINE LIGHT CHK ENG GEN DATA DATA (-) DATA (+) GND PPL DATA LINK CONNECTOR (DLC) (PARTIAL) (BELOW LEFT SIDE OF I/P) PPL DIODE (PLUG- IN) DK BLU/LT GRN WIRE DK GRN WIRE ELECTRONIC PRESSURE CONTROL SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR ENGINE COMPARTMENT FUSE PANEL ENGINE OIL TEMPERATURE (EOT) SENSOR (CENTER LEFT SIDE OF ENGINE) FUSE 18 FUSE 5 FUSE LINK E 20 GA- GRY RED/ WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN HOT IN START OR RUN HOT IN START OR RUN ENGINE COMPARTMENT FUSE PANEL FUSE INSTRUMENT CLUSTER INTAKE AIR TEMPERATURE (IAT) SENSOR (CENTER OF ENGINE COMPARTMENT) INTERIOR FUSE PANEL FUSE 1 LT BLU WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (RIGHT SIDE OF ENGINE COMPARTMENT) NCA WIRE ORG YEL/ WIRE ORG/ BRN WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL/ ORG WIRE PPL/ YEL WIRE PPL/ORG WIRE PPL/YEL WIRE PROGRAMMABLE SPEEDOMETER/ ODOMETER MODULE (PSOM) (BEHIND LEFT SIDE OF I/P) RED WIRE RUN WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 TAN/ORG WIRE TAN/WHT WIRE TCC TCS VSS GND MAP TFT TCIL OD OFF TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION CONTROL SWITCH/INDICATOR LAMP TRANSMISSION RANGE (TR) SENSOR (LEFT SIDE OF TRANSMISSION) VSS OUTPUT WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/ WHT WIRE

BLK WIRE BLK/LT BLU WIRE BLU WIRE BRN WIRE BRN/ORG WIRE BRN/WHT WIRE COAST CLUTCH SOLENOID DK BLU/LT GRN WIRE DK GRN/YEL WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE COMPARTMENT FUSE BOX (LEFT FRONT OF ENGINE COMPT) FORWARD AFT-AXLE FUEL TANK VALVE (NEAR AFT- AXLE FUEL TANK ASSY) FUEL RAIL CUT-OFF VALVE (RIGHT SIDE OF ENGINE, ON FUEL RAIL) FUEL TANK SENDER (UNDER LEFT CENTER OF VEHICLE) FUSE 25 GRN WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES LT BLU WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT LT MIDSHIP FUEL TANK VALVE (UNDER LEFT CENTER OF VEHICLE) NGV TIMER (LEFT REAR OF ENGINE COMPT) ORG/BLK WIRE ORG/YEL WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PPL/ORG WIRE PPL/YEL WIRE REAR AFT-AXLE FUEL TANK VALVE (NEAR AFT- AXLE FUEL TANK ASSY) RED WIRE RED/LT GRN WIRE RED/PNK WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 STARTING/ CHARGING SYSTEM TAN/LT BLU WIRE TAN/ORG WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR WHT WIRE WHT/PNK WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/WHT WIRE

BLK WIRE BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE BRN/YEL WIRE COAST CLUTCH SOLENOID DK BLU/LT GRN WIRE DK GRN WIRE DK GRN/YEL WIRE ELECTRONIC PRESSURE CONTROL SOLENOID FUEL INJECTORS GRN WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE INLET AIR CONTROL SENSOR (LEFT FRONT OF ENGINE) LT BLU WIRE LT BLU/ORG WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT LT NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PPL/ORG WIRE PPL/YEL WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION TRANSMISSION FLUID TEMPERATURE SENSOR VAPOR MANAGEMENT VALVE (CENTER REAR OF ENGINE COMPT) WHT WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/RED WIRE

AIRD SOLENOID (REAR OF LEFT VALVE COVER, ON BRACKET) ALL CUTAWAYS ALL VANS AND WAGONS BLK WIRE BLK/WHT WIRE BRN WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE COAST CLUTCH SOLENOID DK GRN WIRE DK GRN/YEL WIRE EGR SOLENOID (REAR OF LEFT VALVE COVER, ON BRACKET) ELECTRONIC PRESSURE (EPC) CONTROL SOLENOID SHIFT SOLENOID NO.2 ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) FUEL PUMP RELAY FUEL INJECTORS FUEL PUMP/ SENDER (BELOW VEHICLE IN FUEL TANK) FUSE H GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HEATED OXYGEN SENSOR HOT AT ALL TIMES HOT AT ALL TIMES IGNITION SWITCH HOT IN RUN INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) FUSE 5 IDLE AIR CONTROL (IAC) VALVE (FRONT OF ENGINE, NEAR DISTRIBUTOR) IN-TRANSIT FUEL PUMP/SENDER (BELOW VEHICLE, ALONG LEFT FRAME RAIL) INERTIA FUEL SHUT OFF (IFS) SWITCH (BEHIND RIGHT COWL PANEL) LOCK OFF LT BLU/ORG WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE NCA WIRE NO.1 NO.2 NO.3 NO.4 NO.5 NO.6 NO.7 NO.8 OD OFF ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PPL PPL/ORG WIRE PPL/YEL WIRE REAR FUEL PUMP/ SENDER (MOUNTED ON LEFT REAR FRAME CROSSMEMBER) RED WIRE RED/ GRY WIRE RUN WIRE SHIFT SOLENOID NO.1 TAN WIRE TAN/WHT WIRE THROTTLE POSITION (TP) SENSOR (RIGHT FRONT OF ENGINE) TORQUE CONVERTER CLUTCH SOLENOID TRANS- MISSION FLUID TEMPER- ATURE SENSOR TRANSMISSION CONTROL SWITCH/ INDICATOR LAMP TCIL WHT BRN WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE

BLK WIRE BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE BRN/YEL WIRE COAST CLUTCH SOLENOID DK BLU/LT GRN WIRE DK GRN WIRE DK GRN/PPL WIRE DK GRN/YEL WIRE EGR SOLENOID (TOP LEFT REAR OF ENGINE) ELECTRONIC PRESSURE CONTROL SOLENOID FUEL INJECTORS GRN WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE IDLE AIR CONTROL VALVE (TOP CENTER REAR OF ENGINE, NEAR AIR INTAKE) LT BLU WIRE LT BLU/ORG WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/WHT WIRE LT LT LT NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PPL LT PPL PPL/LT GRN WIRE PPL/ORG WIRE PPL/YEL WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR VAPOR MANAGEMENT VALVE (CENTER REAR OF ENGINE COMPT) WHT WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/RED WIRE

#1 SHIFT SOLENOID #2 SHIFT SOLENOID BLK/LT BLU WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE ON/OFF SWITCH (BRAKE PEDAL SUPPORT) BRAKE PRESSURE SWITCH BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/YEL WIRE CID SIG IN DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK GRN WIRE DK GRN/LT GRN WIRE ELECTRONIC PRESSURE CONTROL SOLENOID COAST CLUTCH SOLENOID FUEL DELIVERY SIG FUEL INJ FEED LEFT FUEL INJ FEED RIGHT FUEL INJECTOR 1 FUEL INJECTOR 2 FUEL INJECTOR 3 FUEL INJECTOR 4 FUEL INJECTOR 5 FUEL INJECTOR 6 FUEL INJECTOR 7 FUEL INJECTOR 8 FUEL INJECTORS/ GLOW PLUGS FUEL LINE HEATER (TOP CENTER OF ENGINE) FUSE 8 FUSE LINK (20 GA- FUSE LINK D (14 GA- FUSE LINK E (14 GA- GLOW PLUG RELAY (TOP RIGHT SIDE OF ENGINE) GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE PANEL FUSE 11 IDM FEEDBACK SIG INJ SHIELD GND INJECTOR DRIVER MODULE LT BLU WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE P, 2, 1 P, N, 1 P, R, 2 P, R, N PNK/YEL WIRE PPL/ORG WIRE PPL/YEL WIRE PWR GND RED WIRE RED/LT GRN WIRE SIG RTN SIGNAL RETURN TAN WIRE TAN/BLK WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION TRANSMISSION FLUID TEMPERATURE SENSOR VPWR WHT WIRE WHT/PNK WIRE WHT/YEL WIRE YEL/LT BLU WIRE

BLK/LT BLU WIRE BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRAKE PRESSURE SWITCH BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/YEL WIRE CID SIG IN DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE ELECTRONIC PRESSURE CONTROL SOLENOID COAST CLUTCH SOLENOID FUEL DELIVERY SIG FUEL INJ FEED LEFT FUEL INJ FEED RIGHT FUEL INJECTORS/ GLOW PLUGS FUSE 11 FUSE 8 FUSE LINK (20 GA- FUSE LINK E (14 GA- FUSE LINK D (14 GA- GLOW PLUG RELAY (TOP RIGHT SIDE OF ENGINE) GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE PANEL IDM FEEDBACK SIG INJ SHIELD GND INJECTOR DRIVER MODULE LT BLU WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE P, 2, 1 P, N, 1 P, R, 2 P, R, N PNK/ORG WIRE PNK/YEL WIRE PPL/ORG WIRE PPL/YEL WIRE PWR GND RED WIRE RED/LT GRN WIRE SIG RTN SIGNAL RETURN SOLENOID TAN WIRE TAN/BLK WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION TRANSMISSION FLUID TEMPERATURE SENSOR VPWR WHT WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/WHT WIRE

BLK/LT BLU WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BRAKE PRESSURE SWITCH BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/YEL WIRE CID SIG IN COAST CLUTCH SOLENOID ELECTRONIC PRESSURE CONTROL SOLENOID DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE FUEL DELIVERY SIG FUEL INJ FEED LEFT FUEL INJ FEED RIGHT FUEL INJECTORS/ GLOW PLUGS FUEL LINE HEATER (TOP CENTER OF ENGINE) FUSE 8 FUSE LINK (20 GA- FUSE LINK D (14 GA- FUSE LINK E (14 GA- GLOW PLUG RELAY (TOP RIGHT SIDE OF ENGINE) GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE PANEL FUSE 11 IDM FEEDBACK SIG INJ SHIELD GND INJECTOR DRIVER MODULE LT BLU WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE P, 2, 1 P, N, 1 P, R, 2 P, R, N PNK/ORG WIRE PNK/YEL WIRE PPL/ORG WIRE PPL/YEL WIRE PWR GND RED WIRE RED/LT GRN WIRE SIG RTN SIGNAL RETURN SOLENOID TAN WIRE TAN/BLK WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION TRANSMISSION FLUID TEMPERATURE SENSOR VPWR WHT WIRE WHT/YEL WIRE YEL/LT BLU WIRE