Ford Club Wagon E350 (1996-1998) tan/blk Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 IND OUTPUT RELAY CTRL OUTPUT 1 2 BATTERY GROUND 14 15 16 17 18 19 20 21 22 23 24 POWER BOO SW INPUT 1995 VFTC 4 WHEEL ANTI-LOCK BRAKE SYSTEM (LOWER LEFT REAR OF ENGINE COMPARTMENT) ABS DATALINK CONNECTOR (DLC) (BELOW LEFT SIDE OF DASH) ACCY AIR BAG DIAGNOSTIC MONITOR (BELOW RIGHT SIDE OF DASH) ANTI-LOCK BRAKE INDICATOR BLK WIRE BRAKE FLUID LVL SW INPUT BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL BRACKET) BRAKE WARN LAMP HIGH DATA LINK CONN BRAKE WARNING INDICATOR DATALINK CONNECTOR (BELOW LEFT SIDE OF DASH) DK GRN WIRE DK GRN/YEL WIRE ENGINE COMPARTMENT FUSE BOX FUSE 1 FUSE 11 FUSE 19 GRN WIRE HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE PANEL FUSE 2 IGNITION SWITCH INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR LOCK LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE OFF PNK WIRE PNK/LT GRN WIRE PPL PPL/YEL WIRE REAR AXLE SPEED SENSOR REAR SENS LOW RIGHT FRONT SENSOR LOW LEFT FRONT SENSOR LOW REAR SENSOR (HIGH) RIGHT FRONT SENSOR (HIGH) LEFT FRONT SENSOR (HIGH) RED WIRE RED/PNK WIRE RELAY (BEHIND CENTER OF DASH) RIGHT FRONT WHEEL SPEED SENSOR RUN WIRE TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE WARNING INDICATORS WHT WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

BLK WIRE BLK/LT BLU WIRE BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/WHT WIRE BRN/YEL WIRE DATA DK BLU/LT GRN WIRE FUEL GAUGE FUEL INJECTOR FUEL PRESS FUEL TANK PRESSURE SENSOR (UNDER LEFT CENTER OF VEHICLE, NEAR FUEL TANK) FUEL TANK TEMPERATURE SENSOR (UNDER LEFT CENTER OF VEHICLE) FUEL TEMP GRN WIRE GROUND GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE IGNITION INLET AIR CONTROL SENSOR (LEFT FRONT OF ENGINE) LT BLU WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN/ORG WIRE NGV MODULE (ON LEFT REAR OF ENGINE COMPT, NEAR BRAKE MASTER CYLINDER) ORG/ WIRE ORG/LT GRN WIRE ORG/YEL WIRE PNK/LT BLU WIRE POWER PPL/YEL WIRE RED WIRE RED/PNK WIRE SIG RETURN TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/RED WIRE TIMER TRANS.) WHT WIRE WHT/PNK WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/WHT WIRE

270 OHMS BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (ON FRONT OF LEFT CYLINDER HEAD) CAMSHAFT POSITION SENSOR SHIELD CMP SENSOR DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU/LT GRN WIRE DK BLU/ORG WIRE FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TEMP INJ PRESS FUSE 11 GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HOT AT ALL TIMES I/P FUSE PANEL (BEHIND LEFT SIDE OF DASH) IDLE AIR CONTROL VALVE (TOP CENTER REAR OF ENGINE, NEAR AIR INTAKE) IDLE AIR CTRL LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN LT GRN WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MAF SENS IN TP SENS IN MASS AIR FLOW SENSOR (TOP CENTER OF ENGINE) NCA WIRE NOT USED NOT USED CYL HEAD TEMP NOT USED VSS (+) ORG/YEL WIRE PNK/ORG WIRE PPL/YEL WIRE PWR GND IGN COIL 2 PWR GND IGN COIL 7 IGN COIL 8 FUEL PUMP CTRL EPC SOL RED WIRE RED/BLK WIRE RED/PNK WIRE RED/WHT WIRE SIG RTN BRAKE ON/OFF TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE VPWR FUEL INJ 7 FUEL INJ 5 FUEL INJ 3 FUEL INJ 1 VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 VSS INPUT WHT WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

BLK WIRE BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE BRN/YEL WIRE COAST CLUTCH SOLENOID DK BLU/LT GRN WIRE DK GRN WIRE DK GRN/YEL WIRE ELECTRONIC PRESSURE CONTROL SOLENOID FUEL INJECTORS GRN WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE INLET AIR CONTROL SENSOR (LEFT FRONT OF ENGINE) LT BLU WIRE LT BLU/ORG WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT LT NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PPL/ORG WIRE PPL/YEL WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION TRANSMISSION FLUID TEMPERATURE SENSOR VAPOR MANAGEMENT VALVE (CENTER REAR OF ENGINE COMPT) WHT WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/RED WIRE

270 OHMS BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (ON FRONT OF LEFT CYLINDER HEAD) CAMSHAFT POSITION SENSOR SHIELD CYLINDER ID DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU/LT GRN WIRE DK BLU/ORG WIRE DPFE SENS CYL HEAD TEMP EVAP SOL FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 11 GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATER CTRL HOT AT ALL TIMES I/P FUSE PANEL (BEHIND LEFT SIDE OF DASH) IDLE AIR CTRL LEFT FRONT HEATED OXYGEN SENSOR LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MAF SENS IN TP SENS IN MASS AIR FLOW SENSOR (TOP CENTER OF ENGINE) NCA WIRE ORG/YEL WIRE PNK/ORG WIRE PPL/WHT WIRE PPL/YEL WIRE PWR GND IGN COIL 2 PWR GND IGN COIL 7 IGN COIL 8 FUEL PUMP CTRL EPC SOL REAR HEATED OXYGEN SENSOR RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RIGHT FRONT HEATED OXYGEN SENSOR SIG RTN BRAKE ON/OFF TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE VPWR FUEL INJ 7 FUEL INJ 5 FUEL INJ 3 FUEL INJ 1 VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

BLK WIRE BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE BRN/YEL WIRE COAST CLUTCH SOLENOID DK BLU/LT GRN WIRE DK GRN WIRE DK GRN/PPL WIRE DK GRN/YEL WIRE EGR SOLENOID (TOP LEFT REAR OF ENGINE) ELECTRONIC PRESSURE CONTROL SOLENOID FUEL INJECTORS GRN WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE IDLE AIR CONTROL VALVE (TOP CENTER REAR OF ENGINE, NEAR AIR INTAKE) LT BLU WIRE LT BLU/ORG WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/WHT WIRE LT LT LT NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PPL LT PPL PPL/LT GRN WIRE PPL/ORG WIRE PPL/YEL WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR VAPOR MANAGEMENT VALVE (CENTER REAR OF ENGINE COMPT) WHT WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/RED WIRE

270 OHMS BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (LEFT FRONT OF ENGINE) CAMSHAFT POSITION SENSOR SHIELD CMP SENSOR DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK GRN/PPL WIRE DPFE SENS CYL HEAD TEMP EVAP SOL FUEL INJ 9 FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 11 GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR (NO 11) (RIGHT REAR OF ENGINE) HEATED OXYGEN SENSOR (NO 21) (LEFT REAR OF ENGINE) HEATED OXYGEN SENSOR (NO 22) (UNDER CENTER OF VEHICLE) HEATER CTRL HOT AT ALL TIMES I/P FUSE PANEL (BEHIND LEFT SIDE OF DASH) LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MAF SENS IN TP SENS IN MASS AIR FLOW SENSOR (TOP CENTER OF ENGINE COMPT) NCA WIRE ORG/YEL WIRE PNK/ORG WIRE PPL/LT GRN WIRE PPL/WHT WIRE PPL/YEL WIRE RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE SIG RTN BRAKE ON/OFF TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 IGN COIL 4 PWR GND IGN COIL 3 VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

BLK/LT BLU WIRE BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRAKE PRESSURE SWITCH BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/YEL WIRE CID SIG IN DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE ELECTRONIC PRESSURE CONTROL SOLENOID COAST CLUTCH SOLENOID FUEL DELIVERY SIG FUEL INJ FEED LEFT FUEL INJ FEED RIGHT FUEL INJECTORS/ GLOW PLUGS FUSE 11 FUSE 8 FUSE LINK (20 GA- FUSE LINK E (14 GA- FUSE LINK D (14 GA- GLOW PLUG RELAY (TOP RIGHT SIDE OF ENGINE) GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE PANEL IDM FEEDBACK SIG INJ SHIELD GND INJECTOR DRIVER MODULE LT BLU WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE P, 2, 1 P, N, 1 P, R, 2 P, R, N PNK/ORG WIRE PNK/YEL WIRE PPL/ORG WIRE PPL/YEL WIRE PWR GND RED WIRE RED/LT GRN WIRE SIG RTN SIGNAL RETURN SOLENOID TAN WIRE TAN/BLK WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION TRANSMISSION FLUID TEMPERATURE SENSOR VPWR WHT WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/WHT WIRE

BLK/LT BLU WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BRAKE PRESSURE SWITCH BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/YEL WIRE CID SIG IN COAST CLUTCH SOLENOID ELECTRONIC PRESSURE CONTROL SOLENOID DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE FUEL DELIVERY SIG FUEL INJ FEED LEFT FUEL INJ FEED RIGHT FUEL INJECTORS/ GLOW PLUGS FUEL LINE HEATER (TOP CENTER OF ENGINE) FUSE 8 FUSE LINK (20 GA- FUSE LINK D (14 GA- FUSE LINK E (14 GA- GLOW PLUG RELAY (TOP RIGHT SIDE OF ENGINE) GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE PANEL FUSE 11 IDM FEEDBACK SIG INJ SHIELD GND INJECTOR DRIVER MODULE LT BLU WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE P, 2, 1 P, N, 1 P, R, 2 P, R, N PNK/ORG WIRE PNK/YEL WIRE PPL/ORG WIRE PPL/YEL WIRE PWR GND RED WIRE RED/LT GRN WIRE SIG RTN SIGNAL RETURN SOLENOID TAN WIRE TAN/BLK WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION TRANSMISSION FLUID TEMPERATURE SENSOR VPWR WHT WIRE WHT/YEL WIRE YEL/LT BLU WIRE

AIRB SOLENOID (REAR OF LEFT VALVE COVER, ON BRACKET) BLK WIRE BLK/WHT WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL BRACKET) BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE BRY/YEL WIRE CATALYST MONITOR SENSOR (CMS) (LOWER MIDDLE SIDE OF VEHICLE) DELTA PRESSURE FEEDBACK EGR (DPFE) SENSOR (TOP OF ENGINE NEAR THROTTLE BODY) DK BLU WIRE FUSE I GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED EXHAUST GAS OXYGEN SENSOR (HEGO) NO.21 (LOWER LEFT SIDE OF TRANSMISSION) HEGO MN NO.11 HEGO MN NO.21 CMS SENSOR HOT AT ALL TIMES IAC VALVE INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE NCA WIRE POWER DISTRIBUTION SYSTEM POWER INPUT FUEL INJ. NO.8 FUEL INJ. NO.6 FUEL INJ. NO.4 FUEL INJ. NO.2 PPL/YEL WIRE PROGRAMMABLE SPEEDOMETER/ ODOMETER MODULE (PSOM) (BEHIND LEFT SIDE OF I/P) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/WHT WIRE SOLID STATE TAN WIRE TAN/BLK WIRE TAN/RED WIRE TCIL IND. LP. FUEL PMP RLY CTRL EPC SOLENOID THROTTLE POSITION (TP) SENSOR (TOP LEFT SIDE OF ENGINE) TRANS RNG SENSOR DPFE SENSOR VAPOR MANAGEMENT VALVE (CENTER OF ENGINE COMPARTMENT) VEHICLE SPD SENS. MISFIRE SENS. HEGO NO.11 VSS INPUT VSS OUTPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE