Ford Club Wagon E350 (1996-1998) red/blk Wiring diagrams

"ANTI-THEFT" INDICATOR ALARM INDICATOR ANTI-THEFT MODULE (LEFT SIDE OF VEHICLE, BEHIND "B" PILLAR) BATTERY BLK WIRE BLU WIRE BRN WIRE BRN/WHT WIRE CIRCUIT BREAKER 12 COURTESY LP SWITCHES DIODE B (IN WINDOW REG. RELAY SWITCH HARNESS) DISARM SWITCH DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK DK DK GRN WIRE DK GRN/PPL WIRE DK GRN/WHT WIRE DOOR LOCK CONTROL DOOR LOCK CONTROL DRIVER'S DOOR LOCK CONTROL DOOR LOCKS SYSTEM (KEYLESS ENTRY CIRCUIT) FUSE 7 FUSE 8 GROUND HEADLIGHTS SYSTEM HOOD TAMPER DET. INPUT HORN RELAY OUTPUT HORNS SYSTEM HOT AT ALL TIMES HOT IN ACCY OR RUN HOT IN START IGN KEY CYL SENSOR INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) FUSE 6 INTERIOR LIGHTS SYSTEM (COURTESY LIGHTS) LEFT COURTESY LAMP SWITCH (MOUNTED IN LEFT DOOR JAMB) LEFT DOOR LOCK CYLINDER SWITCH (LOWER LEFT CORNER OF LEFT DOOR) LOCK ALL DOORS LOW BEAM HDLPS OUTPUT LT BLU WIRE LT GRN WIRE LT GRN/YEL WIRE NCA WIRE ORG/ WIRE PANIC ACTIVATE OUT COURTESY LAMP SWITCH INPUT PANIC ALARM INPUT PARKING LAMPS OUTPUT PNK WIRE PNK/BLK WIRE PNK/ORG WIRE PPL PPL (RIGHT REAR CORNER OF ENGINE COMPARTMENT) ANTI-THEFT HOOD SWITCH REAR COURTESY LAMP SWITCH (IN RIGHT REAR DOOR JAMB) REAR DOOR LOCK CYLINDER SWITCH (BELOW LICENSE PLATE) RED WIRE RED/BLK WIRE RED/ORG WIRE RED/PNK WIRE REMOTE KEYLESS ENTRY MODULE (BEHIND LEFT "B" PILLAR) RIGHT COURTESY LAMP SWITCH (MOUNTED IN RIGHT DOOR JAMB) RIGHT DOOR KEY CYLINDER SWITCH (LOWER RIGHT SIDE OF DOOR) RIGHT DOOR KEY CYLINDER SWITCH IN RUN/ACCY INPUT SIDE DOOR COURTESY LAMP SWITCH (BEHIND RIGHT "B" PILLAR) SIDE DOOR LOCK CTRL STARTER INTERRUPT IN STARTER INTERRUPT OUT STARTING/ CHARGING SYSTEM (STARTER CIRCUIT) STEERING COLUMN ASSEMBLY IGNITION KEY CYLINDER SENSOR TAN WIRE TAN/LT GRN WIRE UNLOCK DRIVER'S DOOR UNLOCK SENSE WARNING BUZZER MODULE (BELOW LEFT SIDE OF I/P) PNK DOOR OPEN INPUT WIRE WHT WIRE WHT/PNK WIRE WHT/PPL WIRE YEL WIRE YEL/LT GRN WIRE

1 2 3 HI BEAM IN OUT 507/13 527/12 ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/ORG WIRE BRAKE IND OUT 6 7 8 LO BEAMS IN BATTERY PWR IN BRAKE WARNING INDICATOR HIGH BEAM INDICATOR DAYTIME RUNNING LAMPS (DRL) MODULE (LOWER RIGHT FRONT OF ENGINE, NEAR HORNS) DIESEL DIESEL (W/ RABS) DIESEL ONLY DK BLU WIRE DRL DISABLE ENGINE COMPARTMENT FUSE BOX (IN LEFT FRONT OF ENGINE COMPARTMENT) FLASH TO PASS FUSE 10 FUSE 15 FUSE 2 FUSE 27 FUSE 30 FUSE 6 GASOLINE W/ RABS GRY WIRE GRY/WHT WIRE HEAD PARK HI PASS LO HOT AT ALL TIMES HOT IN RUN HOT IN START OR RUN I/P FUSE PANEL (BEHIND LEFT SIDE OF DASH) I/P FUSE PANEL (BEHIND LEFT SIDE OF DASH) FUSE 25 FUSE 31 IGN INPUT INSTRUMENT CLUSTER LEFT HEADLAMP RIGHT HEADLAMP LOW VACUUM WARNING SWITCH (IN LEFT FRONT OF ENGINE COMPARTMENT) LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MAIN LIGHT SWITCH MULTI- FUNCTION SWITCH (DIMMER) DIMMER OFF ORG/ WIRE PARK BK ON IN PARKING BRAKE SWITCH (NEAR LEFT KICK PANEL) PPL PPL/ORG WIRE PPL/WHT WIRE PPL/YEL WIRE PULSED OUTPUT RED WIRE RED/BLK WIRE RED/YEL WIRE REMOTE KEYLESS ENTRY MODULE (BEHIND "B" PILLAR) TAN WIRE WHT WIRE YEL WIRE YEL/LT BLU WIRE

BLK WIRE BLK/ORG WIRE DK BLU WIRE ENGINE COMPARTMENT FUSE BOX (IN LEFT FRONT OF ENGINE COMPARTMENT) FLASH TO PASS FUSE 10 FUSE 15 GRY WIRE HEAD PARK HI BEAM INDICATOR HI PASS LO HOT AT ALL TIMES I/P FUSE PANEL (BEHIND LEFT SIDE OF DASH) I/P FUSE PANEL (BEHIND LEFT SIDE OF DASH) FUSE 31 FUSE 25 INSTRUMENT CLUSTER LEFT HEADLAMP LT GRN WIRE LT GRN/BLK WIRE MAIN LIGHT SWITCH MULTI- FUNCTION SWITCH (DIMMER) DIMMER OFF ORG/ WIRE RED WIRE RED/BLK WIRE RED/YEL WIRE REMOTE KEYLESS ENTRY MODULE RIGHT HEADLAMP TAN WIRE WHT WIRE

** (5.4L, 6.8L) * (4.2L, 4.6L) 1 2 7 ANTI-LOCK IND RELAY CTRL BRAKE SWITCH 2 5 MIL IND BRAKE IND 45 ** 9 * 12 ECT SIGNAL FUEL SIGNAL 7.3L DIESEL ONLY AIR BAG ALL EXCEPT 7.3L DIESEL ALL WHEEL ANTI-LOCK BRAKE SYSTEM MODULE ANTI- SLOSH MODULE ANTI-LOCK BRAKE BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING CHARGE CHARGING CONN A CONN B CONN C CRUISE CONTROL DAYTIME RUNNING LAMPS MODULE DIESEL ONLY DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE DUAL BRAKE WARNING SWITCH (NEAR MASTER CYLINDER) ENGINE COOLANT TEMPERATURE GAUGE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF ENGINE) ENGINE OIL PRESSURE SWITCH (FRONT OF ENGINE) ENGINE OIL PRSSURE GAUGE EXTERIOR LIGHTS FASTEN BELTS OUTPUT FASTEN SEATBELT FUEL FILTER FUEL GAUGE FUEL PUMP MODULE (ON FUEL TANK) FUEL PUMP MODULE IN-TRANSIT FUEL PUMP MODULE (ON LEFT FRAME RAIL) FUEL WATER SWITCH (DIESEL) (TOP RIGHT FRONT OF ENGINE) FUSE 14 FUSE 2 FUSE 36 FUSE 4 GND IGNITION SWITCH GRY/BLK WIRE GRY/WHT WIRE HEADLIGHTS HIGH BEAM HOT AT ALL TIMES HOT IN PARK OR HEAD HOT IN RUN OR START INSTRUMENT ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LEFT TURN LOW VACUUM WARNING SWITCH (LEFT FRONT OF ENGINE COMPT) LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE MALFUNCTION (MIL) OFF LOCK PARKING BRAKE SWITCH (ABOVE BRAKE PEDAL) PLUGGED FUEL FILTER VACUUM SWITCH (TOP RIGHT SIDE OF ENG) PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE PPL/WHT WIRE PPL/YEL WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE RED/YEL WIRE RELAY (CENTER OF I/P) RIGHT TURN RUN WIRE SOLID STATE SPEEDOMETER SUPPLEMENTAL RESTRAINTS TAN/LT GRN WIRE VANS, WAGONS CUTAWAYS VEHICLE SPEED SENSOR (ON TRANSAXLE) VSS SIGNAL W/ DRL W/O DRL WAIT TO WAIT TO START WARNING BUZZER MODULE WATER IN FUEL WATER IN FUEL SENSOR (TOP LEFT CENTER OF ENGINE) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/RED WIRE YEL/WHT WIRE

ANTI-THEFT SYSTEM ANTI-THEFT SYSTEM (SIDE DOOR COURTESY LAMP SWITCH) ANTI-THEFT SYSTEM HEADLIGHTS SYSTEM BATTERY SIDE/REAR DOOR LOCK CTRL BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BUTTON CONTACT (ATTACHED TO REAR OF "B" PILLAR) DK BLU WIRE DOOR LOCK CONTROL SIDE DOOR LOCK CTRL INTERIOR LAMPS OUTPUT DOOR LOCK CONTROL SWITCH EXTERIOR LIGHTS SYSTEM (MAIN LIGHT SWITCH) FUSE 4 FUSE 5 FUSE 3 GROUND BATTERY GROUND UNLOCK INPUT LOCK INPUT HEADLAMPS BATTERY RIGHT FRONT DOOR LOCK HEADLIGHTS SYSTEM HORNS SYSTEM HOT AT ALL TIMES HOT AT ALL TIMES ENGINE COMPARTMENT FUSE BOX FUSE 16 HOT IN ACCY OR RUN HOT AT ALL TIMES I/P FUSE PANEL KICK PANEL) LEFT DOOR HANDLE SWITCH LEFT FRONT DOOR LOCK MOTOR LOCK LT BLU WIRE LT GRN WIRE MASTER WINDOW ORG/ WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE PPL REAR DOOR LOCK MOTOR REAR POWER DOOR LOCK SWITCH RED WIRE RED/BLK WIRE RED/ORG WIRE REMOTE KEYLESS ENTRY MODULE (BEHIND LEFT "B" PILLAR) RIGHT DOOR HANDLE SWITCH RIGHT FRONT DOOR LOCK MOTOR RIGHT POWER DOOR LOCK/ WINDOW SWITCH RKE DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) SIDE DOOR COURTESY SW IN SIDE DOOR LOCK MOTOR UNLOCK UNLOCK LOCK W/ SLIDING DOOR W/O SLIDING DOOR WHT WIRE WHT/LT BLU WIRE WHT/PPL WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLK/WHT WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE BRY/YEL WIRE CATALYST MONITOR SENSOR (CMS) (NEAR LOWER RIGHT SIDE OF TRANSMISSION) DELTA PRESSURE FEEDBACK EGR (DPFE) SENSOR (RIGHT SIDE OF ENGINE) DK BLU WIRE FUEL INJECTOR #5 FUEL INJECTOR #3 FUEL INJECTOR #1 GROUND GROUND FUEL INJECTOR 6 FUEL INJECTOR 4 FUEL INJECTOR 2 GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEGO SNS MN #11 HEGO SNS MN #21 CMS SENSOR IAC VALVE KNOCK SENSOR (KS) (LEFT SIDE OF ENGINE, NEAR IGNITION COIL) LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE NCA WIRE PNK/YEL WIRE POWER INPUT PPL/YEL WIRE PROGRAMMABLE SPEEDOMETER/ ODOMETER MODULE (PSOM) (BEHIND LEFT SIDE OF I/P) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/WHT WIRE TAN WIRE TAN/BLK WIRE TCIL IND. LP. FUEL PMP RLY CTRL EPC SOLENOID THROTTLE POSITION (TP) SENSOR (TOP LEFT SIDE OF ENGINE) TRANS RNG SENSOR VAPOR MANAGEMENT VALVE (CENTER OF ENGINE COMPARTMENT) VSS INPUT VSS OUTPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/YEL WIRE WIDE OPEN THROT. AIRB SOLENOID POWER INPUT YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE

270 OHMS BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (ON FRONT OF LEFT CYLINDER HEAD) CAMSHAFT POSITION SENSOR SHIELD CYLINDER ID DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU/LT GRN WIRE DK BLU/ORG WIRE DPFE SENS CYL HEAD TEMP EVAP SOL FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 11 GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATER CTRL HOT AT ALL TIMES I/P FUSE PANEL (BEHIND LEFT SIDE OF DASH) IDLE AIR CTRL LEFT FRONT HEATED OXYGEN SENSOR LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MAF SENS IN TP SENS IN MASS AIR FLOW SENSOR (TOP CENTER OF ENGINE) NCA WIRE ORG/YEL WIRE PNK/ORG WIRE PPL/WHT WIRE PPL/YEL WIRE PWR GND IGN COIL 2 PWR GND IGN COIL 7 IGN COIL 8 FUEL PUMP CTRL EPC SOL REAR HEATED OXYGEN SENSOR RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RIGHT FRONT HEATED OXYGEN SENSOR SIG RTN BRAKE ON/OFF TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE VPWR FUEL INJ 7 FUEL INJ 5 FUEL INJ 3 FUEL INJ 1 VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

BLK WIRE BLK/WHT WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL BRACKET) BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE BRY/YEL WIRE CATALYST MONITOR SENSOR (CMS) (LOWER MIDDLE SIDE OF VEHICLE) DELTA PRESSURE FEEDBACK EGR (DPFE) SENSOR (RIGHT SIDE OF ENGINE) DK BLU WIRE FUSE I GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN HEGO MN NO.11 HEGO MN NO.21 CMS SENSOR HOT AT ALL TIMES IAC VALVE INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE NCA WIRE NO.11 (BENEATH CENTER OF VEHICLE) NO.21 (LOWER LEFT SIDE OF TRANSMISSION) POWER DISTRIBUTION SYSTEM POWER INPUT FUEL INJ. NO.8 FUEL INJ. NO.6 FUEL INJ. NO.4 FUEL INJ. NO.2 PPL/YEL WIRE PROGRAMMABLE SPEEDOMETER/ ODOMETER MODULE (PSOM) (BEHIND LEFT SIDE OF I/P) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/WHT WIRE TAN WIRE TAN/BLK WIRE TAN/RED WIRE TCIL IND. LP. FUEL PMP RLY CTRL EPC SOLENOID THROTTLE POSITION (TP) SENSOR (RIGHT FRONT OF ENGINE) TRANS RNG SENSOR DPFE SENSOR VAPOR MANAGEMENT VALVE (CENTER OF ENGINE COMPARTMENT) VEHICLE SPD SENS. MISFIRE SENS. HEGO NO.11 VSS INPUT VSS OUTPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE

270 OHMS BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (LEFT FRONT OF ENGINE) CAMSHAFT POSITION SENSOR SHIELD CMP SENSOR DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK GRN/PPL WIRE DPFE SENS CYL HEAD TEMP EVAP SOL FUEL INJ 9 FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 11 GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR (NO 11) (RIGHT REAR OF ENGINE) HEATED OXYGEN SENSOR (NO 21) (LEFT REAR OF ENGINE) HEATED OXYGEN SENSOR (NO 22) (UNDER CENTER OF VEHICLE) HEATER CTRL HOT AT ALL TIMES I/P FUSE PANEL (BEHIND LEFT SIDE OF DASH) LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MAF SENS IN TP SENS IN MASS AIR FLOW SENSOR (TOP CENTER OF ENGINE COMPT) NCA WIRE ORG/YEL WIRE PNK/ORG WIRE PPL/LT GRN WIRE PPL/WHT WIRE PPL/YEL WIRE RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE SIG RTN BRAKE ON/OFF TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 IGN COIL 4 PWR GND IGN COIL 3 VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

AIRB SOLENOID (REAR OF LEFT VALVE COVER, ON BRACKET) BLK WIRE BLK/WHT WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL BRACKET) BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE BRY/YEL WIRE CATALYST MONITOR SENSOR (CMS) (LOWER MIDDLE SIDE OF VEHICLE) DELTA PRESSURE FEEDBACK EGR (DPFE) SENSOR (TOP OF ENGINE NEAR THROTTLE BODY) DK BLU WIRE FUSE I GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED EXHAUST GAS OXYGEN SENSOR (HEGO) NO.21 (LOWER LEFT SIDE OF TRANSMISSION) HEGO MN NO.11 HEGO MN NO.21 CMS SENSOR HOT AT ALL TIMES IAC VALVE INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE NCA WIRE POWER DISTRIBUTION SYSTEM POWER INPUT FUEL INJ. NO.8 FUEL INJ. NO.6 FUEL INJ. NO.4 FUEL INJ. NO.2 PPL/YEL WIRE PROGRAMMABLE SPEEDOMETER/ ODOMETER MODULE (PSOM) (BEHIND LEFT SIDE OF I/P) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/WHT WIRE SOLID STATE TAN WIRE TAN/BLK WIRE TAN/RED WIRE TCIL IND. LP. FUEL PMP RLY CTRL EPC SOLENOID THROTTLE POSITION (TP) SENSOR (TOP LEFT SIDE OF ENGINE) TRANS RNG SENSOR DPFE SENSOR VAPOR MANAGEMENT VALVE (CENTER OF ENGINE COMPARTMENT) VEHICLE SPD SENS. MISFIRE SENS. HEGO NO.11 VSS INPUT VSS OUTPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE