Ford Club Wagon E350 (1996-1998) powertrain control module Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 BAT GND IGN (RUN) DSS INPUT DSS RETURN 115 OHMS 92 OHMS ABS DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF I/P) AIR BAG IND AIR BAG MODULE (BEHIND LEFT SIDE OF I/P) ALL CUTAWAYS ALL VANS/WAGONS ANTI- LOCK BRAKE IND. BRAKE WARNING IND. ANTI- SLOSH MODULE SOLID STATE B(+) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE CHARGE IND CHECK ENGINE LIGHT COOLANT TEMP DAYTIME RUNNING LAMPS (DRL) MODULE (LOWER RIGHT FRONT OF ENGINE COMPT) DIESEL WARNING LAMPS DISPLAY MODULE DIODE DIODE A (IN ENGINE CONTROL SENSOR HARNESS) LT LT DK GRN WIRE DK GRN/LT GRN WIRE DUAL BRAKE WARNING DIODE/ RESISTOR ASSEMBLY ENGINE COMPT FUSE PANEL LT ENGINE COOLANT TEMP. GAUGE ENGINE COOLANT TEMPERATURE SENDER (LOWER LEFT SIDE OF ENGINE) ENGINE OIL PRESS GAUGE ENGINE OIL PRESSURE SWITCH (FRONT OF ENGINE, NEAR A/C COMPRESSOR) EXTERIOR LIGHTS EXTERIOR LIGHTS IGNITION SWITCH SYSTEM FASTEN SEAT BELT IND FUEL GAUGE FUEL LEVEL FUEL WATER SWITCH FUSE FUSE 13 GENERATOR/ REGULATOR GND IGN GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT IN HOT IN HOT AT ALL TIMES OR RUN FUSE 1 FUSE 18 HOT IN RUN HOT W/MAIN LIGHT SWITCH IN PARK OR HEAD IGN ILLUM IND INSTRUMENT CLUSTER IGN INSTRUMENT LAMPS ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) FUSE 17 LOCK OFF LOW VACUUM WARNING SWITCH LT (NOT USED) LT DUAL BRAKE WARNING SWITCH LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE NCA WIRE OHMS OIL PRESS OR RUN OVER- HEAT IND. OVERHEAT WARNING SWITCH PARKING BRAKE SWITCH (ABOVE LEFT COWL PANEL) PLUGGED FUEL FILTER IND. PLUGGED FUEL FILTER VACUUM SWITCH (TOP LEFT REAR OF ENGINE) PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE POWERTRAIN CONTROL MODULE (PCM) (NEAR BRAKE MASTER CYLINDER) PPL PPL/ 1000 OHMS PPL/ W/ DRL PPL/ W/O DRL PPL/WHT WIRE PPL/YEL WIRE PROGRAMMING ENABLE PSOM DATA LINK CONNECTOR REAR ANTI-LOCK BRAKE SYSTEM (RABS) MODULE (BEHIND RIGHT SIDE OF I/P) 2 7 REAR AXLE SPEED SENSOR (MOUNTED ON DIFFERENTIAL) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN IND LEFT TURN IND RUN WIRE SOLID STATE SYSTEM TAN WIRE TAN/LT GRN WIRE VOLT- METER VSS OUTPUT WARNING BUZZER MODULE (BELOW LEFT SIDE OF I/P) WATER -IN- FUEL IND. WAIT TO WATER IN FUEL SENSOR (TOP LEFT SIDE OF ENGINE) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

4 WHEEL ANTI- LOCK BRAKE SYSTEM MODULE 4.2L, 4.6L 5.4L NGV ONLY 5.4L, 6.8L 7.3L DIESEL AIR BAG DIAGNOSTIC MONITOR WIPER CONTROL MODULE BLK WIRE BLOWER MOTOR RELAY CAMSHAFT POSITION SENSOR SHIELD CRANKSHAFT POSITION SENSOR SHIELD CUTAWAY, STRIPPED CHASSIS CUTAWAY, STRIPPED CHASSIS EXCEPT 5.4L NGV DIESEL ONLY ENGINE COMPARTMENT FUSE BOX EXCEPT 5.4L NGV FORWARD AFT- AXLE FUEL TANK VALVE FUEL INJECTOR SHIELD FUEL PUMP FUEL PUMP MODULE GRY/RED WIRE ILLUMINATED ENTRY MODULE IN-TRANSIT FUEL PUMP MODULE INJECTOR DRIVER MODULE INSTRUMENT CLUSTER INSTRUMENTATION ENGINE COOLANT TEMPERATURE SENSOR LEFT FRONT PARK/TURN SIGNAL LAMP LEFT HEADLAMP LOW VACUUM WARNING SWITCH LT BLU WIRE MIDSHIP FUEL TANK VALVE FUEL TANK SENDER NGV MODULE NGV TIMER ORG/ WIRE PNK PNK PNK WIRE PNK WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE POWERTRAIN CONTROL MODULE IN-TRANSIT FUEL PUMP MODULE REAR AFT- AXLE FUEL TANK VALVE RED WIRE RIGHT FRONT PARK/TURN SIGNAL LAMP RIGHT HEADLAMP TRAILER BACKUP LAMP RELAY TRAILER BATTERY CHARGE RELAY TRAILER RUNNING LAMP RELAY TRAILER/CAMPER ADAPTER CONNECTOR VEHICLE SPEED SENSOR WHT WIRE YEL WIRE

5.8L 49 STATES OVER 8600 GVW, 7.5L EXCEPT CALIFORNIA 7.3L DI TURBO DIESEL MODEL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH DIODE ALL CUTAWAY ALL VANS/ WAGONS W/ TRAILER ADAPTER ALL VANS/ WAGONS W/O TRAILER ADAPTER AMBULANCE PACKAGE ONLY ANTI-THEFT HOOD SWITCH BLK WIRE BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR CLASS 1 TRAILER ADAPTER CLASS 2 TRAILER ADAPTER DATA LINK CONNECTOR (DLC) DUAL BRAKE WARNING SWITCH FROM GASOLINE MODEL ENGINES (ON SCHEMATIC PAGE 1) FUEL PUMP/ SENDER GASOLINE MODELS GENERATOR/ REGULATOR IN-TRANSIT FUEL-PUMP/ SENDER INJECTOR DRIVER MODULE (IDM) LEFT BATTERY LOWER RIGHT FRONT OF ENGINE) NCA WIRE POWERTRAIN CONTROL MODULE POWERTRAIN CONTROL MODULE (PCM) REAR FUEL PUMP/ SENDER RIGHT BATTERY TRAILER BACKUP LAMP RELAY TRAILER BATTERY CHARGE RELAY TRAILER RUNNING LAMP RELAY TRAILER/CAMPER ADAPTER CONNECTOR W/ ANTI- THEFT W/CLASS 2 TRAILER ADAPTER W/TRAILER ADAPTER WASHER PUMP MOTOR WHT WIRE WINDSHIELD WIPER MOTOR

** (5.4L, 6.8L) * (4.2L, 4.6L) 1 2 7 ANTI-LOCK IND RELAY CTRL BRAKE SWITCH 2 5 MIL IND BRAKE IND 45 ** 9 * 12 ECT SIGNAL FUEL SIGNAL 7.3L DIESEL ONLY AIR BAG ALL EXCEPT 7.3L DIESEL ALL WHEEL ANTI-LOCK BRAKE SYSTEM MODULE ANTI- SLOSH MODULE ANTI-LOCK BRAKE BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING CHARGE CHARGING CONN A CONN B CONN C CRUISE CONTROL DAYTIME RUNNING LAMPS MODULE DIESEL ONLY DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE DUAL BRAKE WARNING SWITCH (NEAR MASTER CYLINDER) ENGINE COOLANT TEMPERATURE GAUGE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF ENGINE) ENGINE OIL PRESSURE SWITCH (FRONT OF ENGINE) ENGINE OIL PRSSURE GAUGE EXTERIOR LIGHTS FASTEN BELTS OUTPUT FASTEN SEATBELT FUEL FILTER FUEL GAUGE FUEL PUMP MODULE (ON FUEL TANK) FUEL PUMP MODULE IN-TRANSIT FUEL PUMP MODULE (ON LEFT FRAME RAIL) FUEL WATER SWITCH (DIESEL) (TOP RIGHT FRONT OF ENGINE) FUSE 14 FUSE 2 FUSE 36 FUSE 4 GND IGNITION SWITCH GRY/BLK WIRE GRY/WHT WIRE HEADLIGHTS HIGH BEAM HOT AT ALL TIMES HOT IN PARK OR HEAD HOT IN RUN OR START INSTRUMENT ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LEFT TURN LOW VACUUM WARNING SWITCH (LEFT FRONT OF ENGINE COMPT) LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE MALFUNCTION (MIL) OFF LOCK PARKING BRAKE SWITCH (ABOVE BRAKE PEDAL) PLUGGED FUEL FILTER VACUUM SWITCH (TOP RIGHT SIDE OF ENG) PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE PPL/WHT WIRE PPL/YEL WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE RED/YEL WIRE RELAY (CENTER OF I/P) RIGHT TURN RUN WIRE SOLID STATE SPEEDOMETER SUPPLEMENTAL RESTRAINTS TAN/LT GRN WIRE VANS, WAGONS CUTAWAYS VEHICLE SPEED SENSOR (ON TRANSAXLE) VSS SIGNAL W/ DRL W/O DRL WAIT TO WAIT TO START WARNING BUZZER MODULE WATER IN FUEL WATER IN FUEL SENSOR (TOP LEFT CENTER OF ENGINE) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/RED WIRE YEL/WHT WIRE

** (5.4L, 6.8L) * (4.2L, 4.6L) 2 5 MIL IND BRAKE IND 45 ** 9 * 12 ECT SIGNAL FUEL SIGNAL 7 2 ANTI-LOCK IND BRAKE SWITCH 7.3L DIESEL ONLY AIR BAG ALL EXCEPT 7.3L DIESEL ANTI- SLOSH MODULE ANTI-LOCK BRAKE BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING CHARGE CHARGING CONN A CONN B CONN C CRUISE CONTROL DAYTIME RUNNING LAMPS MODULE DIESEL ONLY DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE DUAL BRAKE WARNING DIODE/ RESISTOR ASSEMBLY (LEFT SIDE OF I/P) DUAL BRAKE WARNING SWITCH (NEAR MASTER CYLINDER) ENGINE COOLANT TEMPERATURE GAUGE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF ENGINE) ENGINE OIL PRESSURE SWITCH (FRONT OF ENGINE) ENGINE OIL PRSSURE GAUGE EXTERIOR LIGHTS FASTEN BELTS OUTPUT FASTEN SEATBELT FUEL FILTER FUEL GAUGE FUEL PUMP MODULE (ON FUEL TANK) FUEL PUMP MODULE (ON FUEL TANK) IN-TRANSIT FUEL PUMP MODULE (ON LEFT FRAME RAIL) FUEL WATER SWITCH (DIESEL) (TOP RIGHT FRONT OF ENGINE) FUSE 14 FUSE 2 FUSE 36 FUSE 4 GND IGNITION SWITCH GRY/BLK WIRE GRY/WHT WIRE HEADLIGHTS HIGH BEAM HOT AT ALL TIMES HOT IN PARK OR HEAD HOT IN RUN OR START INSTRUMENT ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LEFT TURN LOW VACUUM WARNING SWITCH (LEFT FRONT OF ENGINE COMPT) LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE MALFUNCTION (MIL) OFF LOCK PARKING BRAKE SWITCH (ABOVE BRAKE PEDAL) PLUGGED FUEL FILTER VACUUM SWITCH (TOP RIGHT SIDE OF ENG) PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE PPL/WHT WIRE PPL/YEL WIRE REAR ANTI-LOCK BRAKE SYSTEM MODULE RED WIRE RED/BLK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN RUN WIRE SOLID STATE SPEEDOMETER SUPPLEMENTAL RESTRAINTS TAN/LT GRN WIRE VANS, WAGONS CUTAWAYS VEHICLE SPEED SENSOR (ON TRANSAXLE) VSS SIGNAL W/ DRL W/O DRL WAIT TO WAIT TO START WARNING BUZZER MODULE WATER IN FUEL WATER IN FUEL SENSOR (DIESEL) (TOP LEFT CENTER OF ENGINE) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/RED WIRE YEL/WHT WIRE

5.4L CNG 7.3L DIESEL 7.3L DIESEL W/ ELEC FUEL PUMP 7.3L DIESEL W/O ELEC FUEL PUMP 7.4L DIESEL W/ ELECTRIC FUEL PUMP ALL EXCEPT 7.3L DIESEL AUXILIARY BATTERY RELAY AUXILIARY BLOWER MOTOR RELAY BLK WIRE BLK/ORG WIRE BLK/RED WIRE BLOWER MOTOR RELAY BRN WIRE DIESEL ONLY DK GRN WIRE ENGINE COMPARTMENT BATTERY ENGINE COMPARTMENT FUSE BOX ENGINE COMPT. FUSE BOX FRAME BATTERY (DIESEL ONLY) FROM ENG COMPT FUSE FUSE BOX (FUSE 16) (DIAGRAM FROM ENG COMPT FUSE FUSE BOX (FUSE 17) (DIAGRAM FROM ENGINE COMPARTMENT FUSE BOX (DIAGRAM 1 OF 4) FUEL PUMP RELAY FUSE 10 FUSE 11 FUSE 12 FUSE 13 FUSE 14 FUSE 15 FUSE 16 FUSE 17 FUSE 19 FUSE 18 FUSE 20 FUSE 22 FUSE 23 FUSE 21 FUSE 26 FUSE 25 FUSE 27 FUSE 4 FUSE 8 FUSE 9 FUSIBLE LINK A FUSIBLE LINK B FUSIBLE LINK C FUSIBLE LINK D (14 GA- FUSIBLE LINK E (14 GA- FUSIBLE LINK F (12 GA- FUSIBLE LINK G (12 GA- GASOLINE GENERATOR GENERATOR, VOLTAGE REGULATOR GENERATOR/ VOLTAGE REGULATOR NGV MODULE GLOW PLUG RELAY GRY WIRE HORN RELAY DAYTIME RUNNING LAMPS ENGINE COMPARTMENT FUSE BOX IDM RELAY INSTRUMENT CLUSTER LT BLU WIRE MAIN LIGHT SWITCH ONLY ORG/ WIRE ORG/LT BLU WIRE PCM POWER RELAY POWERTRAIN CONTROL MODULE RED WIRE RED/WHT WIRE REMOTE KEYLESS ENTRY MODULE (W/ REMOTE KEYLESS ENTRY) STARTER MOTOR STARTER MOTOR RELAY TO ENG COMPT FUSE BOX (FUSE 13) (DIAGRAM 1 OF 4) TO ENG COMPT FUSE BOX (FUSE 8) (DIAGRAM 1 OF 4) TO ENGINE COMPT FUSE BOX (FUSE 9)(DIAGRAM 1 OF 4) TO SPLICE TO SPLICE 4 WHEEL ANTI-LOCK BRAKES MODULE (DIAGRAM 2 OF 4) TO SPLICE MODIFIED VEHICLE POWER (DIAGRAM 3 OF 4) TRAILER BACKUP LAMP RELAY TRAILER BATTERY CHARGE RELAY TRAILER RUNNING LAMP RELAY TRAILER/ CAMPER ADAPTER (ELECTRONIC BRAKE) W AUX HEAT OR A/C W/ AUX BATTERY W/ AUX BATTERY JUMPER W/ DRL ONLY W/O AUX BATTERY WIRES END IN HARNESS YEL WIRE YEL/LT BLU WIRE