Ford Club Wagon E350 (1996-1998) pcm power relay Wiring diagrams

A/C CLUTCH CYCLING PRESSURE SWITCH A/C CLUTCH DIODE A/C COMPRESSOR CLUTCH A/C CONTROL ASSEMBLY A/C PRESSURE CUT OUT SWITCH AUXILIARY BLOWER MOTOR AUXILIARY BLOWER MOTOR RESISTOR REAR AUXILIARY BLOWER SWITCH AUXILIARY BLOWER SWITCH BLEND DOOR ACTUATOR BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR BLU WIRE BRN WIRE DK LT OFF ENGINE COMPARTMENT FUSE PANEL FLOOR VENT MAX OFF FRONT BLOWER SWITCH FUSE 9 FUSE A FUSE F GRN WIRE GRN/WHT WIRE HOT AT ALL TIMES HOT IN RUN INTERIOR FUSE PANEL LO HI LT BLU/ORG WIRE LT PNK WIRE MIX DEF NORM OFF HI AUX- ILIARY LT LO/ REAR HIGH BLOWER MOTOR RELAY ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE PCM POWER RELAY PNK WIRE PNK/BLK WIRE POWER- TRAIN CONTROL MODULE PPL RED WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE TEMPER- ATURE CONTROL SWITCH VENT FLOOR NORM MIX MAX OFF DEF W/ REAR CONTROL W/O REAR CON- TROL WHT WIRE WIDE OPEN THROTTLE RELAY (LOWER LEFT SIDE OF ENGINE COMPARTMENT) YEL WIRE YEL/BLK WIRE YEL/RED WIRE

BLK WIRE BLK/WHT WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL BRACKET) BRN ORG/ WIRE BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CHECK ENGINE LIGHT "MALFUNCTION INDICATOR LAMP (MIL)" COAST CLUTCH SOLENOID (BACK UP LAMP SWITCH TO REAR LAMP FEED HARNESS, IN DATA LINK CONNECTOR (DLC) (PARTIAL) (BELOW LEFT SIDE OF I/P) DIODE (PLUG- IN) ELECTRONIC PRESSURE CONTROL SOLENOID SHIFT SOLENOID 1 ENGINE COMPARTMENT FUSE PANEL ENGINE COMPARTMENT FUSE PANEL FUSE FUSE FUSE 18 FUSE 5 GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN HOT IN START OR RUN INSTRUMENT CLUSTER INTERIOR FUSE PANEL FUSE 1 LT BLU WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MASS AIR FLOW (MAF) SENSOR (CENTER OF ENGINE COMPARTMENT) MIL GEN SCAN BUS - BUS + GND GND PPL NCA WIRE ORG BLK WIRE ORG PPL/ WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL/ORG WIRE PPL/YEL WIRE PROGRAMMABLE SPEEDOMETER/ ODOMETER MODULE (PSOM) (BEHIND LEFT SIDE OF I/P) RED WIRE RED/ GRY WIRE RUN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL OD OFF THROTTLE POSITION (TP) SENSOR (TOP LEFT SIDE OF ENGINE) TORQUE CONVERTER CLUTCH SOLENOID SHIFT SOLENOID 2 TRANSMISSION TRANSMISSION CONTROL SWITCH/INDICATOR LAMP TRANSMISSION FLUID TEMPERATURE SENSOR TRANSMISSION RANGE (TR) SENSOR (LEFT SIDE OF TRANSMISSION) VSS INPUT VSS OUTPUT WHT WIRE WHT YEL/ WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL PPL WIRE YEL WIRE YEL/ ORG WIRE

1/1 4 WHEEL ANTI-LOCK 4.9L 5.0L 5.8L 49 STATES OVER 8600 GVW, 7.5L EXCEPT CALIFORNIA 7.5L 5.8L ALL MODELS BLK WIRE DATA LINK CONNECTOR ENGINE COMPARTMENT FUSE PANEL GASOLINE MODELS HEATED OXYGEN INSTRUMENT CLUSTER LEFT BATTERY LEFT FRONT PARK/TURN SIGNAL LAMP LEFT HEADLAMP MASS AIRFLOW (MAF) SENSOR MODULE NCA WIRE ONLY PCM POWER RELAY POWERTRAIN CONTROL MODULE (PCM) REAR ANTI-LOCK BRAKE SYSTEM (RABS) VALVE ASSEMBLY RIGHT FRONT PARK/TURN SIGNAL LAMP RIGHT HEADLAMP TO GASOLINE MODEL COMPONENTS (SCHEMATIC PAGE 2) W/REAR ABS ONLY WHT WIRE

4 WHEEL ANTI-LOCK 7.3L DI TURBO DIESEL MODEL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH DIODE BLK WIRE BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR CLASS 1 TRAILER ADAPTER CLASS 2 TRAILER ADAPTER DUAL BRAKE WARNING SWITCH ENGINE COMPARTMENT FUSE PANEL EXHAUST PRESSURE REGULATOR (EPR) EXTERNAL FUEL PUMP INSTRUMENT CLUSTER LOW VACUUM WARNING SWITCH ONLY PCM POWER RELAY PNK WIRE POWERTRAIN CONTROL MODULE (PCM) REAR ANTI-LOCK BRAKE SYSTEM (RABS) VALVE ASSEMBLY TRAILER BACKUP LAMP RELAY TRAILER BATTERY CHARGE RELAY TRAILER RUNNING LAMP RELAY TRAILER/CAMPER ADAPTER CONNECTOR VANS/ WAGONS W/TRAILER ADAPTER W/RABS ONLY WASHER PUMP MOTOR WHT WIRE WINDSHIELD WIPER MOTOR

5.4L CNG 7.3L DIESEL 7.3L DIESEL W/ ELEC FUEL PUMP 7.3L DIESEL W/O ELEC FUEL PUMP 7.4L DIESEL W/ ELECTRIC FUEL PUMP ALL EXCEPT 7.3L DIESEL AUXILIARY BATTERY RELAY AUXILIARY BLOWER MOTOR RELAY BLK WIRE BLK/ORG WIRE BLK/RED WIRE BLOWER MOTOR RELAY BRN WIRE DIESEL ONLY DK GRN WIRE ENGINE COMPARTMENT BATTERY ENGINE COMPARTMENT FUSE BOX ENGINE COMPT. FUSE BOX FRAME BATTERY (DIESEL ONLY) FROM ENG COMPT FUSE FUSE BOX (FUSE 16) (DIAGRAM FROM ENG COMPT FUSE FUSE BOX (FUSE 17) (DIAGRAM FROM ENGINE COMPARTMENT FUSE BOX (DIAGRAM 1 OF 4) FUEL PUMP RELAY FUSE 10 FUSE 11 FUSE 12 FUSE 13 FUSE 14 FUSE 15 FUSE 16 FUSE 17 FUSE 19 FUSE 18 FUSE 20 FUSE 22 FUSE 23 FUSE 21 FUSE 26 FUSE 25 FUSE 27 FUSE 4 FUSE 8 FUSE 9 FUSIBLE LINK A FUSIBLE LINK B FUSIBLE LINK C FUSIBLE LINK D (14 GA- FUSIBLE LINK E (14 GA- FUSIBLE LINK F (12 GA- FUSIBLE LINK G (12 GA- GASOLINE GENERATOR GENERATOR, VOLTAGE REGULATOR GENERATOR/ VOLTAGE REGULATOR NGV MODULE GLOW PLUG RELAY GRY WIRE HORN RELAY DAYTIME RUNNING LAMPS ENGINE COMPARTMENT FUSE BOX IDM RELAY INSTRUMENT CLUSTER LT BLU WIRE MAIN LIGHT SWITCH ONLY ORG/ WIRE ORG/LT BLU WIRE PCM POWER RELAY POWERTRAIN CONTROL MODULE RED WIRE RED/WHT WIRE REMOTE KEYLESS ENTRY MODULE (W/ REMOTE KEYLESS ENTRY) STARTER MOTOR STARTER MOTOR RELAY TO ENG COMPT FUSE BOX (FUSE 13) (DIAGRAM 1 OF 4) TO ENG COMPT FUSE BOX (FUSE 8) (DIAGRAM 1 OF 4) TO ENGINE COMPT FUSE BOX (FUSE 9)(DIAGRAM 1 OF 4) TO SPLICE TO SPLICE 4 WHEEL ANTI-LOCK BRAKES MODULE (DIAGRAM 2 OF 4) TO SPLICE MODIFIED VEHICLE POWER (DIAGRAM 3 OF 4) TRAILER BACKUP LAMP RELAY TRAILER BATTERY CHARGE RELAY TRAILER RUNNING LAMP RELAY TRAILER/ CAMPER ADAPTER (ELECTRONIC BRAKE) W AUX HEAT OR A/C W/ AUX BATTERY W/ AUX BATTERY JUMPER W/ DRL ONLY W/O AUX BATTERY WIRES END IN HARNESS YEL WIRE YEL/LT BLU WIRE

BLK WIRE BLK/WHT WIRE BRN WIRE BRN/ORG WIRE BRN/PNK WIRE COAST CLUTCH SOLENOID DIODE (PLUG- IN) DK BLU WIRE DK GRN WIRE DK GRN/YEL WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) FUEL PUMP RELAY FUSE C FUSE G FUSE H FUSE U GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN START OR RUN IGNITION SWITCH LOCK OFF LT BLU WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MISFIRE SENSOR (LOWER RIGHT FRONT OF ENGINE) ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER RELAY PNK WIRE PPL PPL/ORG WIRE PPL/YEL WIRE RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RUN WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 STARTER MOTOR RELAY (LEFT FRONT CORNER OF ENGINE COMPARTMENT) TAN/LT BLU WIRE TORQUE CONVERTER CLUTCH (TCC) SOLENOID TRANS.) TRANSMISSION TRANSMISSION FLUID TEMPERATURE SENSOR TRANSMISSION RANGE (TR) SENSOR (LEFT SIDE OF TRANSMISSION) WHT WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/YEL WIRE YEL WIRE

BLK WIRE BLK/WHT WIRE BRN WIRE BRN/ORG WIRE BRN/PNK WIRE COAST CLUTCH SOLENOID DIODE (PLUG- IN) DK BLU WIRE DK GRN WIRE DK GRN/YEL WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) FUEL PUMP RELAY FUSE C FUSE G FUSE H FUSE U GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN START OR RUN IGNITION SWITCH LOCK OFF LT BLU WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MISFIRE SENSOR (LOWER RIGHT FRONT OF ENGINE) ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER RELAY PNK WIRE PPL PPL/ORG WIRE PPL/YEL WIRE RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RUN WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 STARTER MOTOR RELAY (LEFT FRONT CORNER OF ENGINE COMPARTMENT) TAN/LT BLU WIRE TORQUE CONVERTER CLUTCH (TCC) SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TRANSMISSION TRANSMISSION RANGE (TR) SENSOR (LEFT SIDE OF TRANSMISSION) WHT WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/YEL WIRE YEL WIRE

"WAIT TO START" INDICATOR MALFUNCTION INDICATOR LAMP APP REF VOLT RTN AUX TACH FEED AUXILIARY POWERTRAIN CONTROL CONNECTOR (PARTIAL) (BEHIND LEFT SIDE OF I/P) BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE ON/OFF SWITCH BRAKE PRESS SW BRAKE PRESSURE SWITCH (NEAR LEFT FRONT RAIL) BRAKE WARNING IND BRN/ORG WIRE BUS - CAM POS SENS CRUISE CONTROL SYSTEM DK GRN WIRE DK GRN/LT GRN WIRE DLC EBP ENGINE COMPARTMENT FUSE BOX ENGINE OIL TEMPERATURE SENSOR (FRONT TOP OF ENGINE) EOT FUSE 17 FUSE 2 LT FUSE 20 FUSE 4 FUSE 8 FUSE 9 GLOW PLUG RELAY GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE HORN/SPEED CTRL HOT AT ALL TIMES HOT AT ALL TIMES ENGINE COMPARTMENT FUSE BOX FUSE 11 HOT IN RUN OR START HOT IN RUN OR START I/P FUSE PANEL FUSE 8 I/P FUSE PANEL IAT IDLE VALIDATION SW IDLE VALIDATION SWITCH (OPEN AT IDLE) (NEAR ACCELE- RATOR PEDAL) IDM RELAY INJECTION PRESSURE REGULATOR (TOP CENTER OF ENGINE) INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM INTAKE AIR TEMPERATURE SENSOR (TOP CENTER OF ENGINE) LT GRN WIRE LT GRN/RED WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM DLC PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL 13 10 2 DATA LINK CONNECTOR (PARTIAL) (BELOW LEFT SIDE OF I/P) PPL/LT BLU WIRE PPL/ORG WIRE RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/YEL WIRE SHIELD GND SW GND TAN/ORG WIRE TAN/WHT WIRE TCIL TCS TFT VSS GND WHT/LT GRN WIRE WHT/PNK WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

BLK WIRE BLK/WHT WIRE BRN WIRE BRN/ORG WIRE BRN/PNK WIRE COAST CLUTCH SOLENOID COIL DIODE (PLUG- IN) DK BLU WIRE DK GRN WIRE DK GRN/YEL WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP FRONT OF ENGINE, NEAR DISTRIBUTOR FUEL PUMP RELAY FUSE C FUSE G FUSE H FUSE U GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN START OR RUN IGNITION SWITCH LOCK OFF LT BLU WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MISFIRE SENSOR (LOWER RIGHT FRONT OF ENGINE) ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER RELAY PNK WIRE PPL PPL/ORG WIRE PPL/YEL WIRE RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RUN WIRE SHIFT SOLENOID NO.1 SHIFT SOLENOID NO.2 STARTER MOTOR RELAY (LEFT FRONT CORNER OF ENGINE COMPARTMENT) TAN/LT BLU WIRE TORQUE CONVERTER CLUTCH (TCC) SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TRANSMISSION TRANSMISSION RANGE (TR) SENSOR (LEFT SIDE OF TRANSMISSION) WHT WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/YEL WIRE YEL WIRE YEL/WHT WIRE

1 2 3 4 5 6 PIP SPOUT IDM PWR COIL GND PNK WIRE 190 237 AIRB 570 224 923 GND TCS TFT ACD 924 395 CCS PIP IGNITION INJ 1,4,5,8 OUT INJ 2,3,6,7 OUT GND AIR CONDITIONING SYSTEM AIR CONDITIONING SYSTEM PPL BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL SUPPORT) BRN WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE COIL WIRE DATA LINK CONNECTOR (DLC) (LEFT FRONT CORNER OF ENGINE COMPARTMENT) DATA LINK CONNECTOR (DLC) (LEFT FRONT OF ENGINE COMPT) DIODE (PLUG-IN) (ENGINE COMPARTMENT FUSE PANEL) DISTRIBUTOR DISTRIBUTOR SHIELD DK GRN/YEL WIRE ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) FUSE 1 FUSE 18 FUSE C FUSE U GND IAC FP ENABLE GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN IAT VREF EGR VALVE DATA (+) IGN GND MIL IGNITION COIL (LEFT REAR OF ENGINE) IGNITION CONTROL MODULE (ICM) SHIELD IGNITION CONTROL MODULE (LEFT REAR OF ENGINE COMPARTMENT) INSTRUMENT CLUSTER INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) KAPWR BOO PSOM (+) IDM LT BLU WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN RED/ WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP (MIL) MAP SENSOR SIG RTN TP DATA 359 355 209 NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE ORG/YEL WIRE PCM POWER RELAY PNK 929 361 SPOUT IGNITION EPC WIRE PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL/ORG WIRE PPL/YEL WIRE RADIO CAPACITOR (ATTACHED TO IGNITION COIL) RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHORTING BAR (LEFT REAR OF ENGINE COMPARTMENT) TAN WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE TCC TR SENSOR EVAP TCIL EGR TRANSMISSION CONTROL SWITCH/ INDICATOR LAMP TRANSMISSION RANGE (TR) SENSOR (LEFT SIDE OF TRANSMISSION) VEHICLE SPEED INPUT VSS (-) ECT FPM DATA (-) A/C ON AIRD WHT WIRE WHT/ BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/PNK WIRE WHT/PPL WIRE WHT/YEL WIRE YEL WIRE YEL/RED WIRE