Ford Club Wagon E350 (1996-1998) instrument cluster system Wiring diagrams

AIR CONDITIONING SYSTEM BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRN WIRE BRN/ORG WIRE BRN/PNK WIRE DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (PARTIAL) (LEFT SIDE OF DASH) 915 914 10 2 DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN/YEL WIRE ECT INLET AIR CTRL EVR SOL NOT USED ENDS IN HARNESS ENGINE COMPARTMENT FUSE BOX (LEFT FRONT OF ENGINE COMPT) FP SENDING UNIT FUSE 20 FUSE 8 FUSE 4 FUSE 9 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE PANEL (BEHIND LEFT SIDE OF DASH) IAT FUEL PUMP MON A/C ON SIG IGNITION COILS INSTRUMENT CLUSTER SYSTEM LT GRN WIRE LT GRN/WHT WIRE LT LT LT LT LT LT LT LT PNK WIRE MAF TFT MISFIRE SENS (+) MISFIRE SENS (-) NCA WIRE OD OFF OD OFF IND FEPS (EPROM) ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY PNK LT WIRE PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/WHT WIRE PPL PPL/ORG WIRE PWR GND GND IGN COIL 1 IGN COIL 5 PWR GND IGN COIL 3 RADIO CAPACITOR NO 1 (UPPER LEFT REAR OF ENGINE RADIO CAPACITOR NO 2 (RIGHT REAR OF ENGINE) RED WIRE RED/LT GRN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCS TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL INDICATOR LAMP VSS WHT WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/WHT WIRE

360 648 1145 1143 570 1026 (ENDS IN HARNESS) AIR CONDITIONING SYSTEM BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRN/ORG WIRE BRN/PNK WIRE DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (PARTIAL) (BEHIND LEFT SIDE OF DASH) 915 914 10 2 DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN/PPL WIRE DK GRN/YEL WIRE ECT ENDS IN HARNESS ENGINE COMPARTMENT FUSE BOX (LEFT FRONT OF ENGINE COMPT) EVR SOL NOT USED FEPS (EPROM) FP SEND UNIT FUSE 20 FUSE 8 FUSE 4 FUSE 9 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE PANEL (BEHIND LEFT SIDE OF DASH) IGNITION COILS INSTRUMENT CLUSTER SYSTEM LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT LT LT LT LT LT LT LT LT LT PNK WIRE MAF TFT NOT USED IAT FUEL PUMP MON A/C ON SIG FUEL INJ 10 NCA WIRE NOT USED OD OFF ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY PNK WIRE PNK/ LT DK LT WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/WHT WIRE PPL PPL/LT BLU WIRE PPL/ORG WIRE PPL/YEL WIRE PWR GND IGN COIL 5 RADIO NOISE CAPACITOR RED WIRE RED/LT GRN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL INDICATOR LAMP VSS WHT WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/WHT WIRE

"WAIT TO START" INDICATOR MALFUNCTION INDICATOR LAMP APP REF VOLT RTN AUX TACH FEED AUXILIARY POWERTRAIN CONTROL CONNECTOR (PARTIAL) (BEHIND LEFT SIDE OF I/P) BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE ON/OFF SWITCH BRAKE PRESS SW BRAKE PRESSURE SWITCH (NEAR LEFT FRONT RAIL) BRAKE WARNING IND BRN/ORG WIRE BUS - CAM POS SENS CRUISE CONTROL SYSTEM DK GRN WIRE DK GRN/LT GRN WIRE DLC EBP ENGINE COMPARTMENT FUSE BOX ENGINE OIL TEMPERATURE SENSOR (FRONT TOP OF ENGINE) EOT FUSE 17 FUSE 2 LT FUSE 20 FUSE 4 FUSE 8 FUSE 9 GLOW PLUG RELAY GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE HORN/SPEED CTRL HOT AT ALL TIMES HOT AT ALL TIMES ENGINE COMPARTMENT FUSE BOX FUSE 11 HOT IN RUN OR START HOT IN RUN OR START I/P FUSE PANEL FUSE 8 I/P FUSE PANEL IAT IDLE VALIDATION SW IDLE VALIDATION SWITCH (OPEN AT IDLE) (NEAR ACCELE- RATOR PEDAL) IDM RELAY INJECTION PRESSURE REGULATOR (TOP CENTER OF ENGINE) INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM INTAKE AIR TEMPERATURE SENSOR (TOP CENTER OF ENGINE) LT GRN WIRE LT GRN/RED WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM DLC PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL 13 10 2 DATA LINK CONNECTOR (PARTIAL) (BELOW LEFT SIDE OF I/P) PPL/LT BLU WIRE PPL/ORG WIRE RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/YEL WIRE SHIELD GND SW GND TAN/ORG WIRE TAN/WHT WIRE TCIL TCS TFT VSS GND WHT/LT GRN WIRE WHT/PNK WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

A/C ON SIG ACCELERATOR PEDAL POSITION SENSOR (UNDER LEFT SIDE OF I/P) ACCL PDL POS SENS AIR CONDITIONING SYSTEM BARO BAROMETRIC PRESSURE (BARO) SENSOR (BELOW I/P, AT BASE OF STEERING COLUMN) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BOO BRN/ORG WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR (FRONT CENTER OF ENGINE) CID SIG CMP RTN CRUISE CONTROL SYSTEM DK BLU/LT GRN WIRE DK GRN WIRE DK GRN/LT GRN WIRE ECT EPC EPR EXHAUST BACK PRESSURE (EBP) SENSOR (RIGHT SIDE OF ENGINE) EXHAUST PRESSURE REGULATOR (TOP CENTER OF ENGINE) FUEL DELIVERY SIG GLOW PLUG CTRL GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE ICP+ IDM ENABLE OUT IDM SIG IN INJECTION CONTROL PRESSURE (ICP) SENSOR (TOP LEFT SIDE OF ENGINE) INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM IPR KAPWR LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (TOP RIGHT SIDE OF SAFETY WALL) MAP NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH TCS PNK WIRE PNK/ORG WIRE PPL/LT BLU WIRE PPL/ORG WIRE PPL/YEL WIRE PWR GND RED WIRE SIG RTN SPEED CTRL SIG SPEEDOMETER TAN/WHT WIRE TCC TCIL VEHICLE SPEED SENSOR (LEFT SIDE OF TRANSMISSION) VPWR VREF VSS VSS IN WAIT TO START IND WHT/LT GRN WIRE WHT/PNK WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

APP SENS AUX TACH FEED AUXILIARY POWERTRAIN CONTROL CONNECTOR (BEHIND LEFT SIDE OF DASH) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE ON/OFF SWITCH I/P FUSE PANEL BRAKE PRESS SW BRAKE PRESSURE SWITCH (LEFT SIDE OF ENGINE COMPT, BOTTOM OF MASTER CYL) BRAKE WARNING IND BRN/ORG WIRE BUS - CAM POS SENS CCS SOL DK GRN WIRE DK GRN/ LT GRN WIRE DK GRN/YEL WIRE DLC DRIVELINE DISCONN DRIVELINE DISCONNECT SWITCH (BEHIND LEFT SIDE OF DASH) EBP SENS ENGINE OIL TEMPERATURE SENSOR (CENTER LEFT SIDE OF ENGINE) EOT FUEL LINE HEATER (TOP CENTER OF ENGINE) FUEL LINE HTR FUEL PUMP (LEFT REAR OF ENGINE COMPT) FUEL PUMP RELAY FUSE 11 FUSE 17 FUSE 2 FUSE 20 FUSE 4 FUSE 9 GEN PWR SW GLOW PLUG RELAY GRN WIRE GRY WIRE GRY/RED WIRE HORN/SPEED CTRL HOT AT ALL TIMES HOT AT ALL TIMES ENGINE COMPARTMENT FUSE BOX FUSE 11 HOT IN RUN OR START HOT IN RUN OR START I/P FUSE PANEL FUSE 8 I/P FUSE PANEL FUSE 8 IAT IDLE VALIDATION SW IDLE VALIDATION SWITCH (OPEN AT IDLE) (LEFT SIDE OF DASH) IDM RELAY INDICATOR INERTIA FUEL SHUTOFF SWITCH (BEHIND RIGHT KICK PANEL) INJECTION PRESSURE REGULATOR (TOP OF ENGINE) INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM INTAKE AIR TEMPERATURE SENSOR (CENTER OF ENGINE COMPT, PART OF CLEAN AIR TUBE) LT BLU/ORG WIRE LT GRN WIRE LT GRN/RED WIRE MAL/ FUNCTION INDICATOR MIL DLC NOT USED ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL/LT BLU WIRE PPL/ORG WIRE RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE SHIELD GND STARTING/ CHARGING SYSTEM SW GND TAN/ORG WIRE TAN/WHT WIRE TCIL TCS SENS TFT VSS GND WAIT TO WATER IN FUEL IND WATER IN FUEL INDICATOR WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/PPL WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

A/C ON SIG ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH, ABOVE ACCEL PEDAL) ACCL POS SENS AIR COND- ITIONING SYSTEM BARO BAROMETRIC PRESSURE (BARO) SENSOR (BELOW LEFT SIDE OF DASH) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BOO SW BRN/ORG WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR (FRONT CENTER OF ENGINE) CHARGE IND CID SIG CMP RTN CRUISE CONTROL SYSTEM DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ECT SENS EPC SOL EPR EXHAUST BACK PRESSURE (EBP) SENSOR (TOP CENTER OF ENGINE) EXHAUST PRESSURE REGULATOR (TOP REAR OF ENGINE) FUEL DELIV SIG FUEL PUMP RLY FUEL PUMP/ SENDER GEN PWR SW GLOW PLUG CTRL GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE ICP SENS IDM ENABLE OUT IDM SIG IN INJECTION CONTROL PRESSURE (ICP) SENSOR (ON TOP OF ENGINE) INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM IPR SENS KAPWR LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (TOP RIGHT SIDE OF ENGINE COMPT) MAP SENS NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PNK WIRE PNK/ORG WIRE PPL/LT BLU WIRE PPL/ORG WIRE PPL/YEL WIRE PWR GND RED WIRE SIG RTN SPEED CTRL SIG SPEEDOMETER STARTING/ CHARGING SYSTEM TAN/WHT WIRE TCC TCIL TCS TSS SENS TURBINE SHAFT SPEED SENSOR (RIGHT SIDE OF TRANS) VEHICLE SPEED SENSOR (LEFT SIDE OF TRANS) VPWR VREF VS SENS VSS IN WAIT TO START IND WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/PPL WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

APP REF VOLT RTN AUX TACH FEED AUXILIARY POWERTRAIN CONTROL CONNECTOR (PARTIAL) (BEHIND LEFT SIDE OF DASH) BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE ON/OFF SWITCH BRAKE PRESS SW BRAKE PRESSURE SWITCH (LEFT SIDE OF ENGINE COMPT, BOTTOM OF MASTER CYL) BRAKE WARNING IND BRN/ORG WIRE BUS - CAM POS SENS CRUISE CONTROL SYSTEM DK GRN WIRE DK GRN/LT GRN WIRE DLC EBP ENGINE OIL TEMPERATURE SENSOR (CENTER LEFT SIDE OF ENGINE) EOT FUSE 17 FUSE 20 FUSE 2 FUSE 4 FUSE 8 FUSE 9 GLOW PLUG RELAY GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE HORN/SPEED CTRL HOT AT ALL TIMES HOT AT ALL TIMES ENGINE COMPARTMENT FUSE BOX FUSE 11 HOT IN RUN OR START HOT IN RUN OR START I/P FUSE PANEL FUSE 8 I/P FUSE PANEL IAT IDLE VALIDATION SW IDLE VALIDATION SWITCH (OPEN AT IDLE) (LEFT SIDE OF DASH) IDM RELAY INJECTION PRESSURE REGULATOR (TOP OF ENGINE) INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM INTAKE AIR TEMPERATURE SENSOR (CENTER OF ENGINE COMPT, PART OF CLEAN AIR TUBE) LT GRN DK GRN/ WIRE LT GRN WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM DLC PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL 13 10 2 DATA LINK CONNECTOR (PARTIAL) (BELOW LEFT SIDE OF DASH) PPL/LT BLU WIRE PPL/ORG WIRE RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE SHIELD GND SW GND TAN/ORG WIRE TAN/WHT WIRE TCIL TCS TFT VSS GND WAIT TO START INDICATOR WHT/LT GRN WIRE WHT/PNK WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

A/C ON SIG ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH, ABOVE ACCEL PEDAL) ACCL POS SENS AIR COND- ITIONING SYSTEM BARO BAROMETRIC PRESSURE (BARO) SENSOR (BELOW LEFT SIDE OF DASH) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BOO BRN/ORG WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR (FRONT CENTER OF ENGINE) CID SIG CMP RTN CRUISE CONTROL SYSTEM DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE ECT EPC EPR EXHAUST BACK PRESSURE (EBP) SENSOR (TOP CENTER OF ENGINE) EXHAUST PRESSURE REGULATOR (TOP REAR OF ENGINE) FUEL DELIV SIG GLOW PLUG CTRL GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE ICP+ IDM ENABLE OUT IDM SIG IN INJECTION CONTROL PRESSURE (ICP) SENSOR (ON TOP OF ENGINE) INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM IPR KAPWR LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (TOP RIGHT SIDE OF ENGINE COMPT) MAP NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH TCS PNK WIRE PNK/ORG WIRE PPL/LT BLU WIRE PPL/ORG WIRE PPL/YEL WIRE PWR GND RED WIRE SIG RTN SPEED CTRL SIG SPEEDOMETER TAN/WHT WIRE TCC TCIL VEHICLE SPEED SENSOR (LEFT SIDE OF TRANSMISSION) VPWR VREF VSS VSS IN WAIT TO START IND WHT/LT GRN WIRE WHT/PNK WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE