Ford Club Wagon E350 (1996-1998) instrument cluster ign Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 BAT 397 489 523 GND IGN (RUN) DSS INPUT DSS RETURN 115 OHMS 20 OHMS 4.9L, 5.0L, 5.8L FEDERAL UNDER 8600 GVW, 7.5L CALIF. ONLY 5.8L FED. OVER 8600 GVW, 7.5L EXCEPT CALIF. 5.8L FEDERAL OVER 8600 GVW, 7.5L EXCEPT CALIF. 92 OHMS AIR BAG IND AIR BAG MODULE (LEFT SIDE OF I/P) ALL CUTAWAYS ALL OTHER MODELS ALL VANS/WAGONS ANTI- SLOSH MODULE SOLID STATE ANTI-LOCK BRAKE IND B(+) BASE MODELS W/RABS LT BASE MODELS: W/RABS BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE CHARGE IND COOLANT TEMP DATA LINK CONNECTOR (DLC) (LEFT FRONT CORNER OF ENGINE COMPARTMENT) PNK/ WIRE DIODE C (IN MAIN HARNESS, NEAR PSOM) DK GRN WIRE DK GRN/LT GRN WIRE DK LT LT DUAL BRAKE WARNING DIODE/ RESISTOR ASSEMBLY DUAL BRAKE WARNING SWITCH ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) ENGINE COOLANT TEMP. GAUGE ENGINE OIL PRESS GAUGE EXCEPT BASE MODELS EXCEPT BASE MODELS: 5.8L FED OVER 8600 GVW, 7.5L EXCEPT CALIF. FASTEN SEAT BELT IND FUEL GAUGE FUEL LEVEL FUSE U GENERATOR/ REGULATOR GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT AT ALL TIMES HOT IN HOT IN HOT IN START OR RUN HOT W/MAIN LIGHT SWITCH IN PARK OR HEAD IGN IGNITION SWITCH ILLUM INSTRUMENT CLUSTER IGN INSTRUMENT LAMPS ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) FUSE 17 FUSE 1 LOCK LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT LT MALFUNCTION IND. "CHECK ENGINE LIGHT" BRAKE WARNING IND. NCA WIRE OFF OHMS OIL PRESS OR RUN FUSE 13 FUSE 18 PARKING BRAKE SWITCH (ABOVE LEFT COWL PANEL) PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) PPL/ 1000 OHMS PPL/ W/ DRL PPL/WHT WIRE PPL/YEL (OR LT GRN/RED) WIRE PPL/YEL WIRE PSOM DATA LINK CONNECTOR PROGRAMMING ENABLE (BEHIND LEFT SIDE OF I/P) REAR ANTI-LOCK BRAKE (RABS) SYSTEM MODULE (BEHIND RIGHT SIDE OF I/P) REAR AXLE SPEED SENSOR (MOUNTED ON DIFFERENTIAL) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN IND LEFT TURN IND RUN WIRE TAN WIRE TAN/LT GRN WIRE VOLT- METER VSS OUTPUT W/O DRL WARNING BUZZER MODULE (BELOW LEFT SIDE OF I/P) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 BAT 397 489 523 GND IGN (RUN) DSS INPUT DSS RETURN 115 OHMS 20 OHMS 4.9L, 5.0L, 5.8L FEDERAL UNDER 8600 GVW, 7.5L CALIF. ONLY 5.8L FED. OVER 8600 GVW, 7.5L EXCEPT CALIF. 5.8L FEDERAL OVER 8600 GVW, 7.5L EXCEPT CALIF. 92 OHMS AIR BAG IND AIR BAG MODULE (LEFT SIDE OF I/P) ALL CUTAWAYS ALL OTHER MODELS ALL VANS/WAGONS ANTI- SLOSH MODULE SOLID STATE ANTI-LOCK BRAKE IND B(+) BASE MODELS W/RABS LT BASE MODELS: W/RABS BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE CHARGE IND COOLANT TEMP DATA LINK CONNECTOR (DLC) (LEFT FRONT CORNER OF ENGINE COMPARTMENT) PNK/ WIRE DIODE C (IN MAIN HARNESS, NEAR PSOM) DK GRN WIRE DK GRN/LT GRN WIRE DK LT LT DUAL BRAKE WARNING DIODE/ RESISTOR ASSEMBLY DUAL BRAKE WARNING SWITCH ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) ENGINE COOLANT TEMP. GAUGE ENGINE OIL PRESS GAUGE EXCEPT BASE MODELS EXCEPT BASE MODELS: 5.8L FED OVER 8600 GVW, 7.5L EXCEPT CALIF. FASTEN SEAT BELT IND FUEL GAUGE FUEL LEVEL FUSE U GENERATOR/ REGULATOR GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT AT ALL TIMES HOT IN HOT IN HOT IN START OR RUN HOT W/MAIN LIGHT SWITCH IN PARK OR HEAD IGN IGNITION SWITCH ILLUM INSTRUMENT CLUSTER IGN INSTRUMENT LAMPS ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) FUSE 17 FUSE 1 LOCK LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT LT MALFUNCTION IND. "CHECK ENGINE LIGHT" BRAKE WARNING IND. NCA WIRE OFF OHMS OIL PRESS OR RUN FUSE 13 FUSE 18 PARKING BRAKE SWITCH (ABOVE LEFT COWL PANEL) PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) PPL/ 1000 OHMS PPL/ W/ DRL PPL/WHT WIRE PPL/YEL (OR LT GRN/RED) WIRE PPL/YEL WIRE PSOM DATA LINK CONNECTOR PROGRAMMING ENABLE (BEHIND LEFT SIDE OF I/P) REAR ANTI-LOCK BRAKE (RABS) SYSTEM MODULE (BEHIND RIGHT SIDE OF I/P) REAR AXLE SPEED SENSOR (MOUNTED ON DIFFERENTIAL) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN IND LEFT TURN IND RUN WIRE TAN WIRE TAN/LT GRN WIRE VOLT- METER VSS OUTPUT W/O DRL WARNING BUZZER MODULE (BELOW LEFT SIDE OF I/P) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 BAT GND IGN (RUN) DSS INPUT DSS RETURN 115 OHMS 20 OHMS 4 WHEEL ANTI-LOCK BRAKES 92 OHMS ABS DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF I/P) AIR BAG IND AIR BAG MODULE (BEHIND LEFT SIDE OF I/P) ALL CUTAWAYS ALL VANS/WAGONS ANTI- SLOSH MODULE SOLID STATE ANTI-LOCK BRAKE IND B(+) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRAKE WARNING IND. CHECK ENGINE LIGHT CHARGE IND COOLANT TEMP DAYTIME RUNNING LAMPS (DRL) MODULE PCM (LOWER RIGHT FRONT OF ENGINE COMPT) DIESEL WARNING LAMPS DISPLAY MODULE DIODE DIODE A (IN ENGINE CONTROL SENSOR HARNESS) DK (NOT USED) (NOT USED) LT DUAL BRAKE WARNING SWITCH DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE ENGINE COMPT FUSE PANEL LT ENGINE COOLANT TEMP. GAUGE ENGINE COOLANT TEMPERATURE SENDER ENGINE OIL PRESS GAUGE ENGINE OIL PRESSURE SWITCH FASTEN SEAT BELT IND FUEL GAUGE FUEL LEVEL FUEL PUMP/ SENDER (BELOW VEHICLE IN FUEL TANK) FUEL WATER SWITCH FUSE 13 GENERATOR/ REGULATOR GND IGN GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT IN HOT W/MAIN LIGHT SWITCH IN PARK OR HEAD IGN IGNITION SWITCH ILLUM IND INSTRUMENT CLUSTER IGN INSTRUMENT LAMPS ILLUMINATION LEFT TURN IND RIGHT TURN IND LOCK OFF LOW VACUUM WARNING SWITCH LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT LT MODULE (ON LEFT FRONT FRAME RAIL) NCA WIRE OHMS OIL PRESS OR RUN FUSE OVER- HEAT IND. OVERHEAT WARNING SWITCH (TOP LEFT FRONT OF ENGINE) PARKING BRAKE SWITCH (ABOVE LEFT COWL PANEL) PLUGGED FUEL FILTER IND. PLUGGED FUEL FILTER VACUUM SWITCH (TOP LEFT REAR OF ENGINE) PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) POWERTRAIN CONTROL MODULE (PCM) (NEAR BRAKE MASTER CYLINDER) PPL PPL/ W/ DRL PPL/WHT WIRE PPL/YEL WIRE PROGRAMMING ENABLE PSOM DATA LINK CONNECTOR (BEHIND LEFT SIDE OF I/P) SOLID STATE REAR AXLE SPEED SENSOR (MOUNTED ON DIFFERENTIAL) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE SOLID STATE TAN WIRE TAN/LT GRN WIRE VOLT- METER VSS OUTPUT W/O DRL WAIT TO WATER -IN- FUEL IND. WARNING BUZZER MODULE (BELOW LEFT SIDE OF I/P) WATER IN FUEL SENSOR (TOP LEFT SIDE OF ENGINE) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 BAT GND IGN (RUN) DSS INPUT DSS RETURN 115 OHMS 92 OHMS ABS DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF I/P) AIR BAG IND AIR BAG MODULE (BEHIND LEFT SIDE OF I/P) ALL CUTAWAYS ALL VANS/WAGONS ANTI- LOCK BRAKE IND. BRAKE WARNING IND. ANTI- SLOSH MODULE SOLID STATE B(+) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE CHARGE IND CHECK ENGINE LIGHT COOLANT TEMP DAYTIME RUNNING LAMPS (DRL) MODULE (LOWER RIGHT FRONT OF ENGINE COMPT) DIESEL WARNING LAMPS DISPLAY MODULE DIODE DIODE A (IN ENGINE CONTROL SENSOR HARNESS) LT LT DK GRN WIRE DK GRN/LT GRN WIRE DUAL BRAKE WARNING DIODE/ RESISTOR ASSEMBLY ENGINE COMPT FUSE PANEL LT ENGINE COOLANT TEMP. GAUGE ENGINE COOLANT TEMPERATURE SENDER (LOWER LEFT SIDE OF ENGINE) ENGINE OIL PRESS GAUGE ENGINE OIL PRESSURE SWITCH (FRONT OF ENGINE, NEAR A/C COMPRESSOR) EXTERIOR LIGHTS EXTERIOR LIGHTS IGNITION SWITCH SYSTEM FASTEN SEAT BELT IND FUEL GAUGE FUEL LEVEL FUEL WATER SWITCH FUSE FUSE 13 GENERATOR/ REGULATOR GND IGN GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT IN HOT IN HOT AT ALL TIMES OR RUN FUSE 1 FUSE 18 HOT IN RUN HOT W/MAIN LIGHT SWITCH IN PARK OR HEAD IGN ILLUM IND INSTRUMENT CLUSTER IGN INSTRUMENT LAMPS ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) FUSE 17 LOCK OFF LOW VACUUM WARNING SWITCH LT (NOT USED) LT DUAL BRAKE WARNING SWITCH LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE NCA WIRE OHMS OIL PRESS OR RUN OVER- HEAT IND. OVERHEAT WARNING SWITCH PARKING BRAKE SWITCH (ABOVE LEFT COWL PANEL) PLUGGED FUEL FILTER IND. PLUGGED FUEL FILTER VACUUM SWITCH (TOP LEFT REAR OF ENGINE) PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE POWERTRAIN CONTROL MODULE (PCM) (NEAR BRAKE MASTER CYLINDER) PPL PPL/ 1000 OHMS PPL/ W/ DRL PPL/ W/O DRL PPL/WHT WIRE PPL/YEL WIRE PROGRAMMING ENABLE PSOM DATA LINK CONNECTOR REAR ANTI-LOCK BRAKE SYSTEM (RABS) MODULE (BEHIND RIGHT SIDE OF I/P) 2 7 REAR AXLE SPEED SENSOR (MOUNTED ON DIFFERENTIAL) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN IND LEFT TURN IND RUN WIRE SOLID STATE SYSTEM TAN WIRE TAN/LT GRN WIRE VOLT- METER VSS OUTPUT WARNING BUZZER MODULE (BELOW LEFT SIDE OF I/P) WATER -IN- FUEL IND. WAIT TO WATER IN FUEL SENSOR (TOP LEFT SIDE OF ENGINE) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 BAT 397 489 523 GND IGN (RUN) DSS INPUT DSS RETURN 115 OHMS 20 OHMS 4.9L, 5.0L, 5.8L FEDERAL UNDER 8600 GVW, 7.5L CALIF. ONLY 5.8L FED. OVER 8600 GVW, 7.5L EXCEPT CALIF. 5.8L FEDERAL OVER 8600 GVW, 7.5L EXCEPT CALIF. 92 OHMS AIR BAG IND AIR BAG MODULE (LEFT SIDE OF I/P) ALL CUTAWAYS ALL OTHER MODELS ALL VANS/WAGONS ANTI- SLOSH MODULE SOLID STATE ANTI-LOCK BRAKE IND B(+) BASE MODELS W/RABS LT BASE MODELS: W/RABS BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE CHARGE IND COOLANT TEMP DATA LINK CONNECTOR (DLC) (LEFT FRONT CORNER OF ENGINE COMPARTMENT) PNK/ WIRE DIODE C (IN MAIN HARNESS, NEAR PSOM) DK GRN WIRE DK GRN/LT GRN WIRE DK LT LT DUAL BRAKE WARNING DIODE/ RESISTOR ASSEMBLY DUAL BRAKE WARNING SWITCH ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) ENGINE COOLANT TEMP. GAUGE ENGINE OIL PRESS GAUGE EXCEPT BASE MODELS EXCEPT BASE MODELS: 5.8L FED OVER 8600 GVW, 7.5L EXCEPT CALIF. FASTEN SEAT BELT IND FUEL GAUGE FUEL LEVEL FUSE U GENERATOR/ REGULATOR GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT AT ALL TIMES HOT IN HOT IN HOT IN START OR RUN HOT W/MAIN LIGHT SWITCH IN PARK OR HEAD IGN IGNITION SWITCH ILLUM INSTRUMENT CLUSTER IGN INSTRUMENT LAMPS ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) FUSE 17 FUSE 1 LOCK LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT LT MALFUNCTION IND. "CHECK ENGINE LIGHT" BRAKE WARNING IND. NCA WIRE OFF OHMS OIL PRESS OR RUN FUSE 13 FUSE 18 PARKING BRAKE SWITCH (ABOVE LEFT COWL PANEL) PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) PPL/ 1000 OHMS PPL/ W/ DRL PPL/WHT WIRE PPL/YEL (OR LT GRN/RED) WIRE PPL/YEL WIRE PSOM DATA LINK CONNECTOR PROGRAMMING ENABLE (BEHIND LEFT SIDE OF I/P) REAR ANTI-LOCK BRAKE (RABS) SYSTEM MODULE (BEHIND RIGHT SIDE OF I/P) REAR AXLE SPEED SENSOR (MOUNTED ON DIFFERENTIAL) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN IND LEFT TURN IND RUN WIRE TAN WIRE TAN/LT GRN WIRE VOLT- METER VSS OUTPUT W/O DRL WARNING BUZZER MODULE (BELOW LEFT SIDE OF I/P) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE