Ford Club Wagon E350 (1996-1998) grn Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 BAT 397 489 523 GND IGN (RUN) DSS INPUT DSS RETURN 115 OHMS 20 OHMS 4 WHEEL ANTI-LOCK BRAKES 21 16 23 22 9 4.9L, 5.0L, 5.8L FEDERAL UNDER 8600 GVW, 7.5L CALIF. ONLY 5.8L FED. OVER 8600 GVW, 7.5L EXCEPT CALIF. W/O DRL ALL OTHER MODELS 5.8L FEDERAL OVER 8600 GVW, 7.5L EXCEPT CALIF. 603 523 MODULE (ON LEFT FRONT FRAME RAIL) 92 OHMS AIR BAG IND AIR BAG MODULE (BEHIND LEFT SIDE OF I/P) ALL CUTAWAYS ALL VANS/WAGONS ANTI- SLOSH MODULE SOLID STATE ANTI-LOCK BRAKE IND B(+) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRAKE WARNING IND CHARGE IND COOLANT TEMP DIODE C (IN MAIN HARNESS, NEAR T/O TO PSOM) DK DK DK GRN WIRE DK GRN/LT GRN WIRE DUAL BRAKE WARNING SWITCH (IN BOTTOM OF BRAKE MASTER CYLINDER) ENGINE COOLANT TEMP. GAUGE ENGINE OIL PRESS GAUGE FASTEN SEAT BELT IND FUEL GAUGE FUEL LEVEL GENERATOR/ REGULATOR GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HIGH BEAM IND HOT AT ALL TIMES HOT IN HOT IN HOT W/MAIN LIGHT SWITCH IN PARK OR HEAD IGN IGNITION SWITCH ILLUM INSTRUMENT CLUSTER INSTRUMENT LAMPS ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) FUSE 17 FUSE 1 LEFT TURN IND RIGHT TURN IND LOCK OFF LT BLU WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MALFUNCTION IND. "CHECK ENGINE LIGHT" NCA WIRE OHMS OIL PRESS OR RUN FUSE 13 FUSE 18 PARKING BRAKE SWITCH (ABOVE LEFT COWL PANEL) PNK REAR AXLE SPEED SENSOR (MOUNTED ON DIFFER- ENTIAL) WIRE PNK/ DATA LINK CONNECTOR (DLC) (LEFT FRONT CORNER OF ENGINE COMPARTMENT) WIRE PNK/BLK WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) PPL PPL PPL/WHT WIRE PPL/YEL WIRE PROGRAMMING ENABLE PSOM DATA LINK CONNECTOR (BEHIND LEFT SIDE OF I/P) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE TAN WIRE TAN/LT GRN WIRE VOLT- METER VSS OUTPUT W/ DRL PPL W/O DRL W/PREMIUM SOUND SYSTEM WARNING BUZZER MODULE (BELOW LEFT SIDE OF I/P) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 BAT 397 489 523 GND IGN (RUN) DSS INPUT DSS RETURN 115 OHMS 20 OHMS 4.9L, 5.0L, 5.8L FEDERAL UNDER 8600 GVW, 7.5L CALIF. ONLY 5.8L FED. OVER 8600 GVW, 7.5L EXCEPT CALIF. 5.8L FEDERAL OVER 8600 GVW, 7.5L EXCEPT CALIF. 92 OHMS AIR BAG IND AIR BAG MODULE (LEFT SIDE OF I/P) ALL CUTAWAYS ALL OTHER MODELS ALL VANS/WAGONS ANTI- SLOSH MODULE SOLID STATE ANTI-LOCK BRAKE IND B(+) BASE MODELS W/RABS LT BASE MODELS: W/RABS BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE CHARGE IND COOLANT TEMP DATA LINK CONNECTOR (DLC) (LEFT FRONT CORNER OF ENGINE COMPARTMENT) PNK/ WIRE DIODE C (IN MAIN HARNESS, NEAR PSOM) DK GRN WIRE DK GRN/LT GRN WIRE DK LT LT DUAL BRAKE WARNING DIODE/ RESISTOR ASSEMBLY DUAL BRAKE WARNING SWITCH ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) ENGINE COOLANT TEMP. GAUGE ENGINE OIL PRESS GAUGE EXCEPT BASE MODELS EXCEPT BASE MODELS: 5.8L FED OVER 8600 GVW, 7.5L EXCEPT CALIF. FASTEN SEAT BELT IND FUEL GAUGE FUEL LEVEL FUSE U GENERATOR/ REGULATOR GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT AT ALL TIMES HOT IN HOT IN HOT IN START OR RUN HOT W/MAIN LIGHT SWITCH IN PARK OR HEAD IGN IGNITION SWITCH ILLUM INSTRUMENT CLUSTER IGN INSTRUMENT LAMPS ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) FUSE 17 FUSE 1 LOCK LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT LT MALFUNCTION IND. "CHECK ENGINE LIGHT" BRAKE WARNING IND. NCA WIRE OFF OHMS OIL PRESS OR RUN FUSE 13 FUSE 18 PARKING BRAKE SWITCH (ABOVE LEFT COWL PANEL) PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) PPL/ 1000 OHMS PPL/ W/ DRL PPL/WHT WIRE PPL/YEL (OR LT GRN/RED) WIRE PPL/YEL WIRE PSOM DATA LINK CONNECTOR PROGRAMMING ENABLE (BEHIND LEFT SIDE OF I/P) REAR ANTI-LOCK BRAKE (RABS) SYSTEM MODULE (BEHIND RIGHT SIDE OF I/P) REAR AXLE SPEED SENSOR (MOUNTED ON DIFFERENTIAL) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN IND LEFT TURN IND RUN WIRE TAN WIRE TAN/LT GRN WIRE VOLT- METER VSS OUTPUT W/O DRL WARNING BUZZER MODULE (BELOW LEFT SIDE OF I/P) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 BAT 397 489 523 GND IGN (RUN) DSS INPUT DSS RETURN 115 OHMS 20 OHMS 4 WHEEL ANTI-LOCK BRAKES 21 16 23 22 9 4.9L, 5.0L, 5.8L FEDERAL UNDER 8600 GVW, 7.5L CALIF. ONLY 5.8L FED. OVER 8600 GVW, 7.5L EXCEPT CALIF. W/O DRL ALL OTHER MODELS 5.8L FEDERAL OVER 8600 GVW, 7.5L EXCEPT CALIF. 603 523 MODULE (ON LEFT FRONT FRAME RAIL) 92 OHMS AIR BAG IND AIR BAG MODULE (BEHIND LEFT SIDE OF I/P) ALL CUTAWAYS ALL VANS/WAGONS ANTI- SLOSH MODULE SOLID STATE ANTI-LOCK BRAKE IND B(+) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRAKE WARNING IND CHARGE IND COOLANT TEMP DIODE C (IN MAIN HARNESS, NEAR T/O TO PSOM) DK DK DK GRN WIRE DK GRN/LT GRN WIRE DUAL BRAKE WARNING SWITCH (IN BOTTOM OF BRAKE MASTER CYLINDER) ENGINE COOLANT TEMP. GAUGE ENGINE OIL PRESS GAUGE FASTEN SEAT BELT IND FUEL GAUGE FUEL LEVEL GENERATOR/ REGULATOR GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HIGH BEAM IND HOT AT ALL TIMES HOT IN HOT IN HOT W/MAIN LIGHT SWITCH IN PARK OR HEAD IGN IGNITION SWITCH ILLUM INSTRUMENT CLUSTER INSTRUMENT LAMPS ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) FUSE 17 FUSE 1 LEFT TURN IND RIGHT TURN IND LOCK OFF LT BLU WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MALFUNCTION IND. "CHECK ENGINE LIGHT" NCA WIRE OHMS OIL PRESS OR RUN FUSE 13 FUSE 18 PARKING BRAKE SWITCH (ABOVE LEFT COWL PANEL) PNK REAR AXLE SPEED SENSOR (MOUNTED ON DIFFER- ENTIAL) WIRE PNK/ DATA LINK CONNECTOR (DLC) (LEFT FRONT CORNER OF ENGINE COMPARTMENT) WIRE PNK/BLK WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) PPL PPL PPL/WHT WIRE PPL/YEL WIRE PROGRAMMING ENABLE PSOM DATA LINK CONNECTOR (BEHIND LEFT SIDE OF I/P) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE TAN WIRE TAN/LT GRN WIRE VOLT- METER VSS OUTPUT W/ DRL PPL W/O DRL W/PREMIUM SOUND SYSTEM WARNING BUZZER MODULE (BELOW LEFT SIDE OF I/P) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 BAT 397 489 523 GND IGN (RUN) DSS INPUT DSS RETURN 115 OHMS 20 OHMS 4.9L, 5.0L, 5.8L FEDERAL UNDER 8600 GVW, 7.5L CALIF. ONLY 5.8L FED. OVER 8600 GVW, 7.5L EXCEPT CALIF. 5.8L FEDERAL OVER 8600 GVW, 7.5L EXCEPT CALIF. 92 OHMS AIR BAG IND AIR BAG MODULE (LEFT SIDE OF I/P) ALL CUTAWAYS ALL OTHER MODELS ALL VANS/WAGONS ANTI- SLOSH MODULE SOLID STATE ANTI-LOCK BRAKE IND B(+) BASE MODELS W/RABS LT BASE MODELS: W/RABS BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE CHARGE IND COOLANT TEMP DATA LINK CONNECTOR (DLC) (LEFT FRONT CORNER OF ENGINE COMPARTMENT) PNK/ WIRE DIODE C (IN MAIN HARNESS, NEAR PSOM) DK GRN WIRE DK GRN/LT GRN WIRE DK LT LT DUAL BRAKE WARNING DIODE/ RESISTOR ASSEMBLY DUAL BRAKE WARNING SWITCH ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) ENGINE COOLANT TEMP. GAUGE ENGINE OIL PRESS GAUGE EXCEPT BASE MODELS EXCEPT BASE MODELS: 5.8L FED OVER 8600 GVW, 7.5L EXCEPT CALIF. FASTEN SEAT BELT IND FUEL GAUGE FUEL LEVEL FUSE U GENERATOR/ REGULATOR GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT AT ALL TIMES HOT IN HOT IN HOT IN START OR RUN HOT W/MAIN LIGHT SWITCH IN PARK OR HEAD IGN IGNITION SWITCH ILLUM INSTRUMENT CLUSTER IGN INSTRUMENT LAMPS ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) FUSE 17 FUSE 1 LOCK LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT LT MALFUNCTION IND. "CHECK ENGINE LIGHT" BRAKE WARNING IND. NCA WIRE OFF OHMS OIL PRESS OR RUN FUSE 13 FUSE 18 PARKING BRAKE SWITCH (ABOVE LEFT COWL PANEL) PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) PPL/ 1000 OHMS PPL/ W/ DRL PPL/WHT WIRE PPL/YEL (OR LT GRN/RED) WIRE PPL/YEL WIRE PSOM DATA LINK CONNECTOR PROGRAMMING ENABLE (BEHIND LEFT SIDE OF I/P) REAR ANTI-LOCK BRAKE (RABS) SYSTEM MODULE (BEHIND RIGHT SIDE OF I/P) REAR AXLE SPEED SENSOR (MOUNTED ON DIFFERENTIAL) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN IND LEFT TURN IND RUN WIRE TAN WIRE TAN/LT GRN WIRE VOLT- METER VSS OUTPUT W/O DRL WARNING BUZZER MODULE (BELOW LEFT SIDE OF I/P) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

4 WABS RELAY 4 WHEEL ANTI-LOCK 4 WHEEL ANTI-LOCK BRAKES 497 498 495 496 PNK WIRE ABS DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF I/P) ANTI-LOCK BRAKE INDICATOR BLK TAN/ WIRE BLK WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE FLUID LEVEL SW MODULE POWER BRAKE SW INPUT BRAKE INDICATOR OUT PARK BRAKE ON INPUT BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL BRACKET) BRAKE WARNING INDICATOR BRAKE WARNING INPUT DAYTIME RUNNING LAMPS (DRL) MODULE (LOWER RIGHT FRONT OF ENGINE, NEAR HORNS) DIODE A (ENGINE CONTROL SENSOR HARNESS) DK GRN WIRE DK GRN/YEL WIRE EMF CTRL OUTPUT ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) FUSE 1 FUSE 17 FUSE 18 FUSE U FUSE V GRN WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN HOT IN START OR RUN IGNITION SWITCH INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM (DIODE C) INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LAMP GROUND BRAKE WARNING IND REAR SPEED INPUT ABS IND CTRL LEFT FNT SIG GROUND LEFT FRONT DUMP VALVE LEFT FRONT ISO VALVE LEFT FRONT WHEEL SENSOR (AT LEFT FRONT WHEEL) LOCK OFF LOW VACUUM WARNING SWITCH (LEFT FRONT OF ENGINE COMPARTMENT) LT BLU/PNK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE NOT USED ORG TAN/ WIRE ORG/ WIRE ORG/YEL WIRE PARKING BRAKE SWITCH (ABOVE LEFT COWL PANEL) PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE POWER GROUND 2 PPL PPL/WHT WIRE PPL/YEL WIRE PROGRAMMABLE SPEEDOMETER/ ODOMETER MODULE (PSOM) (BEHIND LEFT SIDE OF I/P) PUMP MOTOR (ON LEFT FRONT FRAME RAIL) PUMP MOTOR POWER REAR AXLE SPEED SENSOR (BELOW REAR OF VEHICLE, MOUNTED ON DIFFERENTIAL) REAR DUMP VALVE REAR ISO VALVE REAR RESET REAR RESET SWITCH RED WIRE RED/PNK WIRE RED/YEL WIRE RIGHT FNT SIG GROUND REAR SIG GROUND RIGHT FRONT DUMP VALVE RIGHT FRONT ISO VALVE RIGHT FRONT WHEEL SENSOR (AT RIGHT FRONT WHEEL) RLY CTRL OUTPUT SERIAL COMMUNICATION RUN WIRE TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/RED WIRE W/ DRL W/O DRL W/DRL W/O DRL WHT WIRE YEL BLK/ WIRE YEL RED/ WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

ACCEL SET/ BLK WIRE BLK/LT BLU WIRE BLU WIRE BRAKE PEDAL POSITION (BPP) SWITCH (ON BRACKET, ABOVE BRAKE PEDAL) BRAKE PRES- SURE SWITCH (BOTTOM OF BRAKE MASTER CYL- INDER) CLOCK SPRING ASSEMBLY (TOP OF STEERING COLUMN) COAST DK (ENGINE HARN, LEFT REAR OF ENG COMPT) DK DK DOOR LOCKS SYSTEM ENGINE COMP- ARTMENT FUSE BOX FUSE 27 FUSE 11 GRN WIRE GRY WIRE GRY/BLK WIRE HORN RELAY (ENGINE COMPT FUSE BOX) HORN SWITCH HOT AT ALL TIMES HOT IN I/P FUSE PANEL ILLUMINATION INSTRUMENT CLUSTER LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/RED WIRE NCA WIRE OFF OHMS 120 OHMS 2200 OHMS 680 ORG/ WIRE ORG/YEL WIRE PNK WIRE PNK/ORG WIRE RED WIRE RED/LT GRN WIRE RESUME RUN WIRE SPEED CONTROL SWITCH ASSEMBLY (TOP OF STEERING COLUMN) SPEEDO YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 BAT GND IGN (RUN) DSS INPUT DSS RETURN 115 OHMS 20 OHMS 4 WHEEL ANTI-LOCK BRAKES 92 OHMS ABS DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF I/P) AIR BAG IND AIR BAG MODULE (BEHIND LEFT SIDE OF I/P) ALL CUTAWAYS ALL VANS/WAGONS ANTI- SLOSH MODULE SOLID STATE ANTI-LOCK BRAKE IND B(+) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRAKE WARNING IND. CHECK ENGINE LIGHT CHARGE IND COOLANT TEMP DAYTIME RUNNING LAMPS (DRL) MODULE PCM (LOWER RIGHT FRONT OF ENGINE COMPT) DIESEL WARNING LAMPS DISPLAY MODULE DIODE DIODE A (IN ENGINE CONTROL SENSOR HARNESS) DK (NOT USED) (NOT USED) LT DUAL BRAKE WARNING SWITCH DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE ENGINE COMPT FUSE PANEL LT ENGINE COOLANT TEMP. GAUGE ENGINE COOLANT TEMPERATURE SENDER ENGINE OIL PRESS GAUGE ENGINE OIL PRESSURE SWITCH FASTEN SEAT BELT IND FUEL GAUGE FUEL LEVEL FUEL PUMP/ SENDER (BELOW VEHICLE IN FUEL TANK) FUEL WATER SWITCH FUSE 13 GENERATOR/ REGULATOR GND IGN GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT IN HOT W/MAIN LIGHT SWITCH IN PARK OR HEAD IGN IGNITION SWITCH ILLUM IND INSTRUMENT CLUSTER IGN INSTRUMENT LAMPS ILLUMINATION LEFT TURN IND RIGHT TURN IND LOCK OFF LOW VACUUM WARNING SWITCH LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT LT MODULE (ON LEFT FRONT FRAME RAIL) NCA WIRE OHMS OIL PRESS OR RUN FUSE OVER- HEAT IND. OVERHEAT WARNING SWITCH (TOP LEFT FRONT OF ENGINE) PARKING BRAKE SWITCH (ABOVE LEFT COWL PANEL) PLUGGED FUEL FILTER IND. PLUGGED FUEL FILTER VACUUM SWITCH (TOP LEFT REAR OF ENGINE) PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) POWERTRAIN CONTROL MODULE (PCM) (NEAR BRAKE MASTER CYLINDER) PPL PPL/ W/ DRL PPL/WHT WIRE PPL/YEL WIRE PROGRAMMING ENABLE PSOM DATA LINK CONNECTOR (BEHIND LEFT SIDE OF I/P) SOLID STATE REAR AXLE SPEED SENSOR (MOUNTED ON DIFFERENTIAL) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE SOLID STATE TAN WIRE TAN/LT GRN WIRE VOLT- METER VSS OUTPUT W/O DRL WAIT TO WATER -IN- FUEL IND. WARNING BUZZER MODULE (BELOW LEFT SIDE OF I/P) WATER IN FUEL SENSOR (TOP LEFT SIDE OF ENGINE) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 BAT GND IGN (RUN) DSS INPUT DSS RETURN 115 OHMS 92 OHMS ABS DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF I/P) AIR BAG IND AIR BAG MODULE (BEHIND LEFT SIDE OF I/P) ALL CUTAWAYS ALL VANS/WAGONS ANTI- LOCK BRAKE IND. BRAKE WARNING IND. ANTI- SLOSH MODULE SOLID STATE B(+) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE CHARGE IND CHECK ENGINE LIGHT COOLANT TEMP DAYTIME RUNNING LAMPS (DRL) MODULE (LOWER RIGHT FRONT OF ENGINE COMPT) DIESEL WARNING LAMPS DISPLAY MODULE DIODE DIODE A (IN ENGINE CONTROL SENSOR HARNESS) LT LT DK GRN WIRE DK GRN/LT GRN WIRE DUAL BRAKE WARNING DIODE/ RESISTOR ASSEMBLY ENGINE COMPT FUSE PANEL LT ENGINE COOLANT TEMP. GAUGE ENGINE COOLANT TEMPERATURE SENDER (LOWER LEFT SIDE OF ENGINE) ENGINE OIL PRESS GAUGE ENGINE OIL PRESSURE SWITCH (FRONT OF ENGINE, NEAR A/C COMPRESSOR) EXTERIOR LIGHTS EXTERIOR LIGHTS IGNITION SWITCH SYSTEM FASTEN SEAT BELT IND FUEL GAUGE FUEL LEVEL FUEL WATER SWITCH FUSE FUSE 13 GENERATOR/ REGULATOR GND IGN GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT IN HOT IN HOT AT ALL TIMES OR RUN FUSE 1 FUSE 18 HOT IN RUN HOT W/MAIN LIGHT SWITCH IN PARK OR HEAD IGN ILLUM IND INSTRUMENT CLUSTER IGN INSTRUMENT LAMPS ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) FUSE 17 LOCK OFF LOW VACUUM WARNING SWITCH LT (NOT USED) LT DUAL BRAKE WARNING SWITCH LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE NCA WIRE OHMS OIL PRESS OR RUN OVER- HEAT IND. OVERHEAT WARNING SWITCH PARKING BRAKE SWITCH (ABOVE LEFT COWL PANEL) PLUGGED FUEL FILTER IND. PLUGGED FUEL FILTER VACUUM SWITCH (TOP LEFT REAR OF ENGINE) PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE POWERTRAIN CONTROL MODULE (PCM) (NEAR BRAKE MASTER CYLINDER) PPL PPL/ 1000 OHMS PPL/ W/ DRL PPL/ W/O DRL PPL/WHT WIRE PPL/YEL WIRE PROGRAMMING ENABLE PSOM DATA LINK CONNECTOR REAR ANTI-LOCK BRAKE SYSTEM (RABS) MODULE (BEHIND RIGHT SIDE OF I/P) 2 7 REAR AXLE SPEED SENSOR (MOUNTED ON DIFFERENTIAL) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN IND LEFT TURN IND RUN WIRE SOLID STATE SYSTEM TAN WIRE TAN/LT GRN WIRE VOLT- METER VSS OUTPUT WARNING BUZZER MODULE (BELOW LEFT SIDE OF I/P) WATER -IN- FUEL IND. WAIT TO WATER IN FUEL SENSOR (TOP LEFT SIDE OF ENGINE) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

4 WABS RELAY 4 WHEEL ANTI-LOCK 4 WHEEL ANTI-LOCK BRAKES 497 498 495 496 PNK WIRE 5.8L FEDERAL OVER 8600 GVW, 7.5L EXCEPT CALIF. W/O DRL ALL OTHERS ANTI-LOCK BRAKE INDICATOR BLK TAN/ WIRE BLK WIRE BLK/ YEL WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE FLUID LEVEL SW MODULE POWER BRAKE SW INPUT BRAKE INDICATOR OUT PARK BRAKE ON INPUT BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL BRACKET) BRAKE WARNING INDICATOR DAYTIME RUNNING LAMPS (DRL) MODULE (LOWER RIGHT FRONT OF ENGINE, NEAR HORNS) DIODE C (IN MAIN HARNESS) DK GRN WIRE DK GRN/YEL WIRE EMF CTRL OUTPUT ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) FUSE 1 FUSE 17 FUSE 18 FUSE U FUSE V GRN WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN HOT IN START OR RUN IGNITION SWITCH INSTRUMENT CLUSTER INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LAMP GROUND BRAKE WARNING IND REAR SPEED INPUT ABS IND CTRL LEFT FNT SIG GROUND LEFT FRONT DUMP VALVE LEFT FRONT ISO VALVE LEFT FRONT WHEEL SENSOR (AT LEFT FRONT WHEEL) LOCK OFF LT BLU WIRE LT BLU/PNK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE NOT USED ORG TAN/ WIRE ORG/ WIRE ORG/YEL WIRE PARKING BRAKE SWITCH (ABOVE LEFT COWL PANEL) PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE POWER GROUND 2 PPL PPL PPL PPL/WHT WIRE PPL/YEL WIRE PROGRAMMABLE SPEEDOMETER/ ODOMETER MODULE (PSOM) (BEHIND LEFT SIDE OF I/P) PUMP MOTOR (ON LEFT FRONT FRAME RAIL) PUMP MOTOR POWER REAR AXLE SPEED SENSOR (BELOW REAR OF VEHICLE, MOUNTED ON DIFFERENTIAL) REAR DUMP VALVE REAR ISO VALVE REAR RESET REAR RESET SWITCH RED WIRE RED YEL/ WIRE RED/PNK WIRE RED/YEL WIRE RIGHT FNT SIG GROUND REAR SIG GROUND RIGHT FRONT DUMP VALVE RIGHT FRONT ISO VALVE RIGHT FRONT WHEEL SENSOR (AT RIGHT FRONT WHEEL) RLY CTRL OUTPUT SERIAL COMMUNICATION RUN WIRE TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/RED WIRE W/ PREMIUM SOUND SYSTEM W/DRL W/O DRL W/O DRL W/DRL WHT WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

"WAIT TO START" INDICATOR MALFUNCTION INDICATOR LAMP APP REF VOLT RTN AUX TACH FEED AUXILIARY POWERTRAIN CONTROL CONNECTOR (PARTIAL) (BEHIND LEFT SIDE OF I/P) BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE ON/OFF SWITCH BRAKE PRESS SW BRAKE PRESSURE SWITCH (NEAR LEFT FRONT RAIL) BRAKE WARNING IND BRN/ORG WIRE BUS - CAM POS SENS CRUISE CONTROL SYSTEM DK GRN WIRE DK GRN/LT GRN WIRE DLC EBP ENGINE COMPARTMENT FUSE BOX ENGINE OIL TEMPERATURE SENSOR (FRONT TOP OF ENGINE) EOT FUSE 17 FUSE 2 LT FUSE 20 FUSE 4 FUSE 8 FUSE 9 GLOW PLUG RELAY GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE HORN/SPEED CTRL HOT AT ALL TIMES HOT AT ALL TIMES ENGINE COMPARTMENT FUSE BOX FUSE 11 HOT IN RUN OR START HOT IN RUN OR START I/P FUSE PANEL FUSE 8 I/P FUSE PANEL IAT IDLE VALIDATION SW IDLE VALIDATION SWITCH (OPEN AT IDLE) (NEAR ACCELE- RATOR PEDAL) IDM RELAY INJECTION PRESSURE REGULATOR (TOP CENTER OF ENGINE) INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM INTAKE AIR TEMPERATURE SENSOR (TOP CENTER OF ENGINE) LT GRN WIRE LT GRN/RED WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM DLC PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL 13 10 2 DATA LINK CONNECTOR (PARTIAL) (BELOW LEFT SIDE OF I/P) PPL/LT BLU WIRE PPL/ORG WIRE RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/YEL WIRE SHIELD GND SW GND TAN/ORG WIRE TAN/WHT WIRE TCIL TCS TFT VSS GND WHT/LT GRN WIRE WHT/PNK WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE