Ford Club Wagon E350 (1996-1998) glow plug relay Wiring diagrams

5.4L CNG 7.3L DIESEL 7.3L DIESEL W/ ELEC FUEL PUMP 7.3L DIESEL W/O ELEC FUEL PUMP 7.4L DIESEL W/ ELECTRIC FUEL PUMP ALL EXCEPT 7.3L DIESEL AUXILIARY BATTERY RELAY AUXILIARY BLOWER MOTOR RELAY BLK WIRE BLK/ORG WIRE BLK/RED WIRE BLOWER MOTOR RELAY BRN WIRE DIESEL ONLY DK GRN WIRE ENGINE COMPARTMENT BATTERY ENGINE COMPARTMENT FUSE BOX ENGINE COMPT. FUSE BOX FRAME BATTERY (DIESEL ONLY) FROM ENG COMPT FUSE FUSE BOX (FUSE 16) (DIAGRAM FROM ENG COMPT FUSE FUSE BOX (FUSE 17) (DIAGRAM FROM ENGINE COMPARTMENT FUSE BOX (DIAGRAM 1 OF 4) FUEL PUMP RELAY FUSE 10 FUSE 11 FUSE 12 FUSE 13 FUSE 14 FUSE 15 FUSE 16 FUSE 17 FUSE 19 FUSE 18 FUSE 20 FUSE 22 FUSE 23 FUSE 21 FUSE 26 FUSE 25 FUSE 27 FUSE 4 FUSE 8 FUSE 9 FUSIBLE LINK A FUSIBLE LINK B FUSIBLE LINK C FUSIBLE LINK D (14 GA- FUSIBLE LINK E (14 GA- FUSIBLE LINK F (12 GA- FUSIBLE LINK G (12 GA- GASOLINE GENERATOR GENERATOR, VOLTAGE REGULATOR GENERATOR/ VOLTAGE REGULATOR NGV MODULE GLOW PLUG RELAY GRY WIRE HORN RELAY DAYTIME RUNNING LAMPS ENGINE COMPARTMENT FUSE BOX IDM RELAY INSTRUMENT CLUSTER LT BLU WIRE MAIN LIGHT SWITCH ONLY ORG/ WIRE ORG/LT BLU WIRE PCM POWER RELAY POWERTRAIN CONTROL MODULE RED WIRE RED/WHT WIRE REMOTE KEYLESS ENTRY MODULE (W/ REMOTE KEYLESS ENTRY) STARTER MOTOR STARTER MOTOR RELAY TO ENG COMPT FUSE BOX (FUSE 13) (DIAGRAM 1 OF 4) TO ENG COMPT FUSE BOX (FUSE 8) (DIAGRAM 1 OF 4) TO ENGINE COMPT FUSE BOX (FUSE 9)(DIAGRAM 1 OF 4) TO SPLICE TO SPLICE 4 WHEEL ANTI-LOCK BRAKES MODULE (DIAGRAM 2 OF 4) TO SPLICE MODIFIED VEHICLE POWER (DIAGRAM 3 OF 4) TRAILER BACKUP LAMP RELAY TRAILER BATTERY CHARGE RELAY TRAILER RUNNING LAMP RELAY TRAILER/ CAMPER ADAPTER (ELECTRONIC BRAKE) W AUX HEAT OR A/C W/ AUX BATTERY W/ AUX BATTERY JUMPER W/ DRL ONLY W/O AUX BATTERY WIRES END IN HARNESS YEL WIRE YEL/LT BLU WIRE

4.2L ENGINE 5.4L CNG ONLY 5.4L ENGINE 4.6L ENGINE 6.8L ENGINE 7.3L DIESEL 7.3L DIESEL W/ ELECTRIC FUEL PUMP BLK WIRE DIGITAL TRANSMISSION RANGE SENSOR DK GRN WIRE ENGINE COMPARTMENT FUSE BOX ENGINE COMPARTMENT FUSE BOX PCM POWER DIODE ENGINE COMPT. FUSE BOX EXCEPT 5.4L CNG EXCEPT 7.3L DIESEL W/ ELECTRIC FUEL PUMP FROM I/P FUSE PANEL (FUSE 8) (DIAGRAM 3 OF 4) FROM IGNITION SWITCH (DIAGRAM 3 OF 4) FUEL LINE HEATER FUEL LINE HEATER NGV TIMER FUSE 15 FUSE 21 FUSE 3 FUSE 9 GLOW PLUG RELAY IDM RELAY IGN IGNITION COIL IGNITION COIL 3, 4 IGNITION COIL 3, 4 RADIO CAPACITOR NO 2 IGNITION COIL NO 10 IGNITION COIL NO 3 IGNITION COIL NO 2 IGNITION COIL NO 4 IGNITION COIL NO 7 IGNITION COIL NO 6 IGNITION COIL NO 8 IGNITION COIL NO 7 IGNITION COIL NO 6 IGNITION COIL NO 5 IGNITION COIL NO 8 IGNITION COIL NO 9 IGNITION COIL NO. 1 IGNITION COIL NO. 4 IGNITION COIL NO. 5 INTERIOR FUSE PANEL LT BLU WIRE LT GRN WIRE MAIN LIGHT SWITCH RADIO MASTER WINDOW/ DOOR LOCK CONTROL SWITCH NCA WIRE PCM POWER RELAY FUEL PUMP RELAY IDLE VALIDATION SWITCH PPL RADIO CAPACITOR NO 1 RADIO CAPACITOR NO 1 IGNITION COIL NO 3 IGNITION COIL NO 2 IGNITION COIL NO 1 RADIO CAPACITOR NO 2 RADIO CAPACITOR NO 1 RED WIRE RED/LT GRN WIRE REMOTE KEYLESS ENTRY MODULE RIGHT POWER DOOR LOCK/ WINDOW SWITCH TRAILER BATTERY CHARGE RELAY WHT WIRE WINDSHIELD WIPER MOTOR WIPER CONTROL MODULE YEL WIRE

"WAIT TO START" INDICATOR MALFUNCTION INDICATOR LAMP APP REF VOLT RTN AUX TACH FEED AUXILIARY POWERTRAIN CONTROL CONNECTOR (PARTIAL) (BEHIND LEFT SIDE OF I/P) BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE ON/OFF SWITCH BRAKE PRESS SW BRAKE PRESSURE SWITCH (NEAR LEFT FRONT RAIL) BRAKE WARNING IND BRN/ORG WIRE BUS - CAM POS SENS CRUISE CONTROL SYSTEM DK GRN WIRE DK GRN/LT GRN WIRE DLC EBP ENGINE COMPARTMENT FUSE BOX ENGINE OIL TEMPERATURE SENSOR (FRONT TOP OF ENGINE) EOT FUSE 17 FUSE 2 LT FUSE 20 FUSE 4 FUSE 8 FUSE 9 GLOW PLUG RELAY GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE HORN/SPEED CTRL HOT AT ALL TIMES HOT AT ALL TIMES ENGINE COMPARTMENT FUSE BOX FUSE 11 HOT IN RUN OR START HOT IN RUN OR START I/P FUSE PANEL FUSE 8 I/P FUSE PANEL IAT IDLE VALIDATION SW IDLE VALIDATION SWITCH (OPEN AT IDLE) (NEAR ACCELE- RATOR PEDAL) IDM RELAY INJECTION PRESSURE REGULATOR (TOP CENTER OF ENGINE) INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM INTAKE AIR TEMPERATURE SENSOR (TOP CENTER OF ENGINE) LT GRN WIRE LT GRN/RED WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM DLC PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL 13 10 2 DATA LINK CONNECTOR (PARTIAL) (BELOW LEFT SIDE OF I/P) PPL/LT BLU WIRE PPL/ORG WIRE RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/YEL WIRE SHIELD GND SW GND TAN/ORG WIRE TAN/WHT WIRE TCIL TCS TFT VSS GND WHT/LT GRN WIRE WHT/PNK WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

APP SENS AUX TACH FEED AUXILIARY POWERTRAIN CONTROL CONNECTOR (BEHIND LEFT SIDE OF DASH) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE ON/OFF SWITCH I/P FUSE PANEL BRAKE PRESS SW BRAKE PRESSURE SWITCH (LEFT SIDE OF ENGINE COMPT, BOTTOM OF MASTER CYL) BRAKE WARNING IND BRN/ORG WIRE BUS - CAM POS SENS CCS SOL DK GRN WIRE DK GRN/ LT GRN WIRE DK GRN/YEL WIRE DLC DRIVELINE DISCONN DRIVELINE DISCONNECT SWITCH (BEHIND LEFT SIDE OF DASH) EBP SENS ENGINE OIL TEMPERATURE SENSOR (CENTER LEFT SIDE OF ENGINE) EOT FUEL LINE HEATER (TOP CENTER OF ENGINE) FUEL LINE HTR FUEL PUMP (LEFT REAR OF ENGINE COMPT) FUEL PUMP RELAY FUSE 11 FUSE 17 FUSE 2 FUSE 20 FUSE 4 FUSE 9 GEN PWR SW GLOW PLUG RELAY GRN WIRE GRY WIRE GRY/RED WIRE HORN/SPEED CTRL HOT AT ALL TIMES HOT AT ALL TIMES ENGINE COMPARTMENT FUSE BOX FUSE 11 HOT IN RUN OR START HOT IN RUN OR START I/P FUSE PANEL FUSE 8 I/P FUSE PANEL FUSE 8 IAT IDLE VALIDATION SW IDLE VALIDATION SWITCH (OPEN AT IDLE) (LEFT SIDE OF DASH) IDM RELAY INDICATOR INERTIA FUEL SHUTOFF SWITCH (BEHIND RIGHT KICK PANEL) INJECTION PRESSURE REGULATOR (TOP OF ENGINE) INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM INTAKE AIR TEMPERATURE SENSOR (CENTER OF ENGINE COMPT, PART OF CLEAN AIR TUBE) LT BLU/ORG WIRE LT GRN WIRE LT GRN/RED WIRE MAL/ FUNCTION INDICATOR MIL DLC NOT USED ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL/LT BLU WIRE PPL/ORG WIRE RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE SHIELD GND STARTING/ CHARGING SYSTEM SW GND TAN/ORG WIRE TAN/WHT WIRE TCIL TCS SENS TFT VSS GND WAIT TO WATER IN FUEL IND WATER IN FUEL INDICATOR WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/PPL WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

APP REF VOLT RTN AUX TACH FEED AUXILIARY POWERTRAIN CONTROL CONNECTOR (PARTIAL) (BEHIND LEFT SIDE OF DASH) BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE ON/OFF SWITCH BRAKE PRESS SW BRAKE PRESSURE SWITCH (LEFT SIDE OF ENGINE COMPT, BOTTOM OF MASTER CYL) BRAKE WARNING IND BRN/ORG WIRE BUS - CAM POS SENS CRUISE CONTROL SYSTEM DK GRN WIRE DK GRN/LT GRN WIRE DLC EBP ENGINE OIL TEMPERATURE SENSOR (CENTER LEFT SIDE OF ENGINE) EOT FUSE 17 FUSE 20 FUSE 2 FUSE 4 FUSE 8 FUSE 9 GLOW PLUG RELAY GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE HORN/SPEED CTRL HOT AT ALL TIMES HOT AT ALL TIMES ENGINE COMPARTMENT FUSE BOX FUSE 11 HOT IN RUN OR START HOT IN RUN OR START I/P FUSE PANEL FUSE 8 I/P FUSE PANEL IAT IDLE VALIDATION SW IDLE VALIDATION SWITCH (OPEN AT IDLE) (LEFT SIDE OF DASH) IDM RELAY INJECTION PRESSURE REGULATOR (TOP OF ENGINE) INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM INTAKE AIR TEMPERATURE SENSOR (CENTER OF ENGINE COMPT, PART OF CLEAN AIR TUBE) LT GRN DK GRN/ WIRE LT GRN WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM DLC PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL 13 10 2 DATA LINK CONNECTOR (PARTIAL) (BELOW LEFT SIDE OF DASH) PPL/LT BLU WIRE PPL/ORG WIRE RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE SHIELD GND SW GND TAN/ORG WIRE TAN/WHT WIRE TCIL TCS TFT VSS GND WAIT TO START INDICATOR WHT/LT GRN WIRE WHT/PNK WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE