Ford Club Wagon E350 (1996-1998) check engine light Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 BAT GND IGN (RUN) DSS INPUT DSS RETURN 115 OHMS 92 OHMS ABS DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF I/P) AIR BAG IND AIR BAG MODULE (BEHIND LEFT SIDE OF I/P) ALL CUTAWAYS ALL VANS/WAGONS ANTI- LOCK BRAKE IND. BRAKE WARNING IND. ANTI- SLOSH MODULE SOLID STATE B(+) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE CHARGE IND CHECK ENGINE LIGHT COOLANT TEMP DAYTIME RUNNING LAMPS (DRL) MODULE (LOWER RIGHT FRONT OF ENGINE COMPT) DIESEL WARNING LAMPS DISPLAY MODULE DIODE DIODE A (IN ENGINE CONTROL SENSOR HARNESS) LT LT DK GRN WIRE DK GRN/LT GRN WIRE DUAL BRAKE WARNING DIODE/ RESISTOR ASSEMBLY ENGINE COMPT FUSE PANEL LT ENGINE COOLANT TEMP. GAUGE ENGINE COOLANT TEMPERATURE SENDER (LOWER LEFT SIDE OF ENGINE) ENGINE OIL PRESS GAUGE ENGINE OIL PRESSURE SWITCH (FRONT OF ENGINE, NEAR A/C COMPRESSOR) EXTERIOR LIGHTS EXTERIOR LIGHTS IGNITION SWITCH SYSTEM FASTEN SEAT BELT IND FUEL GAUGE FUEL LEVEL FUEL WATER SWITCH FUSE FUSE 13 GENERATOR/ REGULATOR GND IGN GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT IN HOT IN HOT AT ALL TIMES OR RUN FUSE 1 FUSE 18 HOT IN RUN HOT W/MAIN LIGHT SWITCH IN PARK OR HEAD IGN ILLUM IND INSTRUMENT CLUSTER IGN INSTRUMENT LAMPS ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) FUSE 17 LOCK OFF LOW VACUUM WARNING SWITCH LT (NOT USED) LT DUAL BRAKE WARNING SWITCH LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE NCA WIRE OHMS OIL PRESS OR RUN OVER- HEAT IND. OVERHEAT WARNING SWITCH PARKING BRAKE SWITCH (ABOVE LEFT COWL PANEL) PLUGGED FUEL FILTER IND. PLUGGED FUEL FILTER VACUUM SWITCH (TOP LEFT REAR OF ENGINE) PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE POWERTRAIN CONTROL MODULE (PCM) (NEAR BRAKE MASTER CYLINDER) PPL PPL/ 1000 OHMS PPL/ W/ DRL PPL/ W/O DRL PPL/WHT WIRE PPL/YEL WIRE PROGRAMMING ENABLE PSOM DATA LINK CONNECTOR REAR ANTI-LOCK BRAKE SYSTEM (RABS) MODULE (BEHIND RIGHT SIDE OF I/P) 2 7 REAR AXLE SPEED SENSOR (MOUNTED ON DIFFERENTIAL) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN IND LEFT TURN IND RUN WIRE SOLID STATE SYSTEM TAN WIRE TAN/LT GRN WIRE VOLT- METER VSS OUTPUT WARNING BUZZER MODULE (BELOW LEFT SIDE OF I/P) WATER -IN- FUEL IND. WAIT TO WATER IN FUEL SENSOR (TOP LEFT SIDE OF ENGINE) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

BAROMETRIC PRESSURE (BARO) SENSOR (BEHIND LEFT SIDE OF I/P) BLK ORG/ WIRE BLK WIRE BLK/WHT WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL BRACKET) BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR (FRONT OF ENGINE) CHECK ENGINE LIGHT CHK ENG GEN DATA DATA (-) DATA (+) GND PPL DATA LINK CONNECTOR (DLC) (PARTIAL) (BELOW LEFT SIDE OF I/P) PPL DIODE (PLUG- IN) DK BLU/LT GRN WIRE DK GRN WIRE ELECTRONIC PRESSURE CONTROL SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR ENGINE COMPARTMENT FUSE PANEL ENGINE OIL TEMPERATURE (EOT) SENSOR (CENTER LEFT SIDE OF ENGINE) FUSE 18 FUSE 5 FUSE LINK E 20 GA- GRY RED/ WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN HOT IN START OR RUN HOT IN START OR RUN ENGINE COMPARTMENT FUSE PANEL FUSE INSTRUMENT CLUSTER INTAKE AIR TEMPERATURE (IAT) SENSOR (CENTER OF ENGINE COMPARTMENT) INTERIOR FUSE PANEL FUSE 1 LT BLU WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (RIGHT SIDE OF ENGINE COMPARTMENT) NCA WIRE ORG YEL/ WIRE ORG/ BRN WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL/ ORG WIRE PPL/ YEL WIRE PPL/ORG WIRE PPL/YEL WIRE PROGRAMMABLE SPEEDOMETER/ ODOMETER MODULE (PSOM) (BEHIND LEFT SIDE OF I/P) RED WIRE RUN WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 TAN/ORG WIRE TAN/WHT WIRE TCC TCS VSS GND MAP TFT TCIL OD OFF TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION CONTROL SWITCH/INDICATOR LAMP TRANSMISSION RANGE (TR) SENSOR (LEFT SIDE OF TRANSMISSION) VSS OUTPUT WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/ WHT WIRE

ABS SYSTEM, BRAKE PRESSURE SWITCH ABS SYSTEM, WARNING BUZZER MODULE, FUEL WATER SWITCH, LOW VACUUM WARNING SWITCH AUXILIARY POWERTRAIN CONTROL CONNECTOR (PARTIAL) (BEHIND LEFT SIDE OF DASH) BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BRN/ORG WIRE BRN/WHT WIRE CCS AP SENS TCS VSS GND TFT CHECK ENGINE LIGHT DATA LINK CONNECTOR (DLC) (PARTIAL) (BELOW LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE SENSOR DK BLU/WHT WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ENG OIL IAT ENGINE COMPARTMENT FUSE BOX ENGINE COMPARTMENT FUSE BOX (LEFT FRONT OF ENGINE COMPT) FUSE 9 ENGINE CONTROLS FUSE 11 FUSE 2 FUSE 20 FUSE 4 GLOW PLUG RELAY, FUEL LINE HTR, IDLE VALIDATION SWITCH GND TCC KAPWR VSS GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE PANEL (BEHIND LEFT SIDE OF DASH) FUSE 8 INSTRUMENT CLUSTER INTAKE AIR TEMPERATURE SENSOR (CENTER OF ENGINE COMPT, PART OF CLEAN AIR TUBE) LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (RIGHT SIDE OF ENGINE COMPT) NCA WIRE ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL/ORG WIRE PPL/YEL WIRE PWR IN GND GND EPC TSS MAP ACEL PDL VREF SIG RTN BPP PWR IN GND RED WIRE RED/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL GEN DATA DATA (-) DATA (+) PPL TCIL OD OFF TORQUE CONVERTER CLUTCH SOLENOID COAST CLUTCH SOLENOID SHIFT SOLENOID 2 TURBINE SHAFT SPEED SENSOR (W/ ELECTRIC FUEL PUMP) (RIGHT SIDE OF TRANSMISSION) VEHICLE SPEED SENSOR (LEFT SIDE OF TRANSMISSION) WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE