Ford Club Wagon E350 (1996-1998) blk/pnk Wiring diagrams

464 643 (W/ ELEC FUEL PUMP) 643 464 (W/O ELECTRIC FUEL PUMP) 977 904 608 1044 STARTING/ CHARGING SYSTEM AIR BAG IND ANTI-LOCK BRAKE IND BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING IND CHARGE IND CONN A CONN B CONN C DAYTIME RUNNING LAMPS MODULE (IN RIGHT FRONT OF ENGINE COMPARTMENT, NEAR HORNS) DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE DUAL BRAKE WARNING SWITCH (BOTTOM OF MASTER CYLINDER) ENGINE COOLANT TEMPERATURE GAUGE ENGINE OIL PRESSURE GAUGE ENGINE OIL PRESSURE SWITCH (ON TOP RIGHT CENTER OF ENGINE) FASTEN SEATBELT IND FUEL FILTER IND (W/O ELECTRIC FUEL PUMP) FUEL WATER SWITCH (TOP RIGHT CENTER OF ENGINE) FUSE 14 FUSE 2 FUSE 36 FUSE 4 GRY/BLK WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT AT ALL TIMES HOT IN PARK OR HEAD HOT IN RUN OR START IGNITION SWITCH INSTRUMENT CLUSTER INSTRUMENT ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF DASH) LEFT TURN IND LOW OIL PRESS/HI COOLANT TEMP IND LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MALFUNCTION (MIL) IND OFF LOCK PARKING BRAKE SWITCH (NEAR LEFT KICK PANEL) PNK/LT GRN WIRE PPL/WHT WIRE PPL/YEL WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE RED/YEL WIRE RELAY (BEHIND CENTER OF DASH) RIGHT TURN IND RUN WIRE SPEEDO- METER SUPPLEMENTAL RESTRAINTS SYSTEM TACHO- METER TAN/LT GRN WIRE VOLTMETER W/ DRL W/O DRL W/ ELEC FUEL PUMP W/O ELEC FUEL PUMP WAIT TO START IND WAIT TO START IND (W/O ELECTRIC FUEL PUMP) WARNING SYSTEMS 603 932 WATER IN FUEL IND (W/ ELECTRIC FUEL PUMP ONLY) WATER IN FUEL IND (W/O ELECTRIC FUEL PUMP) WATER IN FUEL SENSOR (TOP LEFT CENTER OF ENGINE) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/WHT WIRE

28 5 WATER-FUEL PARK BRAKE IN 4 WHEEL ANTI-LOCK 45 100 ECT SIGNAL IN FUEL SIGNAL BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE CRUISE CONTROL DK GRN WIRE DK GRN/YEL WIRE ENGINE COOLANT TEMPERATURE SENSOR (ON LOWER LEFT FRONT OF ENGINE) FUEL PUMP MODULE (UNDER VEHICLE, IN FUEL TANK) GRY/BLK WIRE IN-TRANSIT FUEL PUMP MODULE (UNDER VEHICLE, ON LEFT FRAME RAIL) LOW VACCUM WARNING SWITCH (IN LEFT FRONT OF ENGINE COMPT) LT GRN/RED WIRE MIL IND PNK/LT GRN WIRE PNK/ORG WIRE PPL/WHT WIRE PPL/YEL WIRE REAR ANTI-LOCK BRAKE SYSTEM (RABS) MODULE (BEHIND CENTER OF DASH) RED WIRE RED/WHT WIRE RED/YEL WIRE TAN/LT GRN WIRE VANS, WAGONS CUTAWAYS VEHICLE SPEED SENSOR (UNDER VEHICLE, ON LEFT SIDE OF TRANSMISSION) VSS SIGNAL W/ ELEC FUEL PUMP WAIT TO STRT WHT/ BLK WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

** (5.4L, 6.8L) * (4.2L, 4.6L) 2 5 MIL IND BRAKE IND 45 ** 9 * 12 ECT SIGNAL FUEL SIGNAL 7 2 ANTI-LOCK IND BRAKE SWITCH 7.3L DIESEL ONLY AIR BAG ALL EXCEPT 7.3L DIESEL ANTI- SLOSH MODULE ANTI-LOCK BRAKE BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING CHARGE CHARGING CONN A CONN B CONN C CRUISE CONTROL DAYTIME RUNNING LAMPS MODULE DIESEL ONLY DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE DUAL BRAKE WARNING DIODE/ RESISTOR ASSEMBLY (LEFT SIDE OF I/P) DUAL BRAKE WARNING SWITCH (NEAR MASTER CYLINDER) ENGINE COOLANT TEMPERATURE GAUGE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF ENGINE) ENGINE OIL PRESSURE SWITCH (FRONT OF ENGINE) ENGINE OIL PRSSURE GAUGE EXTERIOR LIGHTS FASTEN BELTS OUTPUT FASTEN SEATBELT FUEL FILTER FUEL GAUGE FUEL PUMP MODULE (ON FUEL TANK) FUEL PUMP MODULE (ON FUEL TANK) IN-TRANSIT FUEL PUMP MODULE (ON LEFT FRAME RAIL) FUEL WATER SWITCH (DIESEL) (TOP RIGHT FRONT OF ENGINE) FUSE 14 FUSE 2 FUSE 36 FUSE 4 GND IGNITION SWITCH GRY/BLK WIRE GRY/WHT WIRE HEADLIGHTS HIGH BEAM HOT AT ALL TIMES HOT IN PARK OR HEAD HOT IN RUN OR START INSTRUMENT ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LEFT TURN LOW VACUUM WARNING SWITCH (LEFT FRONT OF ENGINE COMPT) LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE MALFUNCTION (MIL) OFF LOCK PARKING BRAKE SWITCH (ABOVE BRAKE PEDAL) PLUGGED FUEL FILTER VACUUM SWITCH (TOP RIGHT SIDE OF ENG) PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE PPL/WHT WIRE PPL/YEL WIRE REAR ANTI-LOCK BRAKE SYSTEM MODULE RED WIRE RED/BLK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN RUN WIRE SOLID STATE SPEEDOMETER SUPPLEMENTAL RESTRAINTS TAN/LT GRN WIRE VANS, WAGONS CUTAWAYS VEHICLE SPEED SENSOR (ON TRANSAXLE) VSS SIGNAL W/ DRL W/O DRL WAIT TO WAIT TO START WARNING BUZZER MODULE WATER IN FUEL WATER IN FUEL SENSOR (DIESEL) (TOP LEFT CENTER OF ENGINE) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/RED WIRE YEL/WHT WIRE

APP SENS AUX TACH FEED AUXILIARY POWERTRAIN CONTROL CONNECTOR (BEHIND LEFT SIDE OF DASH) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE ON/OFF SWITCH I/P FUSE PANEL BRAKE PRESS SW BRAKE PRESSURE SWITCH (LEFT SIDE OF ENGINE COMPT, BOTTOM OF MASTER CYL) BRAKE WARNING IND BRN/ORG WIRE BUS - CAM POS SENS CCS SOL DK GRN WIRE DK GRN/ LT GRN WIRE DK GRN/YEL WIRE DLC DRIVELINE DISCONN DRIVELINE DISCONNECT SWITCH (BEHIND LEFT SIDE OF DASH) EBP SENS ENGINE OIL TEMPERATURE SENSOR (CENTER LEFT SIDE OF ENGINE) EOT FUEL LINE HEATER (TOP CENTER OF ENGINE) FUEL LINE HTR FUEL PUMP (LEFT REAR OF ENGINE COMPT) FUEL PUMP RELAY FUSE 11 FUSE 17 FUSE 2 FUSE 20 FUSE 4 FUSE 9 GEN PWR SW GLOW PLUG RELAY GRN WIRE GRY WIRE GRY/RED WIRE HORN/SPEED CTRL HOT AT ALL TIMES HOT AT ALL TIMES ENGINE COMPARTMENT FUSE BOX FUSE 11 HOT IN RUN OR START HOT IN RUN OR START I/P FUSE PANEL FUSE 8 I/P FUSE PANEL FUSE 8 IAT IDLE VALIDATION SW IDLE VALIDATION SWITCH (OPEN AT IDLE) (LEFT SIDE OF DASH) IDM RELAY INDICATOR INERTIA FUEL SHUTOFF SWITCH (BEHIND RIGHT KICK PANEL) INJECTION PRESSURE REGULATOR (TOP OF ENGINE) INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM INTAKE AIR TEMPERATURE SENSOR (CENTER OF ENGINE COMPT, PART OF CLEAN AIR TUBE) LT BLU/ORG WIRE LT GRN WIRE LT GRN/RED WIRE MAL/ FUNCTION INDICATOR MIL DLC NOT USED ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL/LT BLU WIRE PPL/ORG WIRE RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE SHIELD GND STARTING/ CHARGING SYSTEM SW GND TAN/ORG WIRE TAN/WHT WIRE TCIL TCS SENS TFT VSS GND WAIT TO WATER IN FUEL IND WATER IN FUEL INDICATOR WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/PPL WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

A/C ON SIG ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH, ABOVE ACCEL PEDAL) ACCL POS SENS AIR COND- ITIONING SYSTEM BARO BAROMETRIC PRESSURE (BARO) SENSOR (BELOW LEFT SIDE OF DASH) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BOO SW BRN/ORG WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR (FRONT CENTER OF ENGINE) CHARGE IND CID SIG CMP RTN CRUISE CONTROL SYSTEM DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ECT SENS EPC SOL EPR EXHAUST BACK PRESSURE (EBP) SENSOR (TOP CENTER OF ENGINE) EXHAUST PRESSURE REGULATOR (TOP REAR OF ENGINE) FUEL DELIV SIG FUEL PUMP RLY FUEL PUMP/ SENDER GEN PWR SW GLOW PLUG CTRL GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE ICP SENS IDM ENABLE OUT IDM SIG IN INJECTION CONTROL PRESSURE (ICP) SENSOR (ON TOP OF ENGINE) INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM IPR SENS KAPWR LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (TOP RIGHT SIDE OF ENGINE COMPT) MAP SENS NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PNK WIRE PNK/ORG WIRE PPL/LT BLU WIRE PPL/ORG WIRE PPL/YEL WIRE PWR GND RED WIRE SIG RTN SPEED CTRL SIG SPEEDOMETER STARTING/ CHARGING SYSTEM TAN/WHT WIRE TCC TCIL TCS TSS SENS TURBINE SHAFT SPEED SENSOR (RIGHT SIDE OF TRANS) VEHICLE SPEED SENSOR (LEFT SIDE OF TRANS) VPWR VREF VS SENS VSS IN WAIT TO START IND WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/PPL WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

APP REF VOLT RTN AUX TACH FEED AUXILIARY POWERTRAIN CONTROL CONNECTOR (PARTIAL) (BEHIND LEFT SIDE OF DASH) BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE ON/OFF SWITCH BRAKE PRESS SW BRAKE PRESSURE SWITCH (LEFT SIDE OF ENGINE COMPT, BOTTOM OF MASTER CYL) BRAKE WARNING IND BRN/ORG WIRE BUS - CAM POS SENS CRUISE CONTROL SYSTEM DK GRN WIRE DK GRN/LT GRN WIRE DLC EBP ENGINE OIL TEMPERATURE SENSOR (CENTER LEFT SIDE OF ENGINE) EOT FUSE 17 FUSE 20 FUSE 2 FUSE 4 FUSE 8 FUSE 9 GLOW PLUG RELAY GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE HORN/SPEED CTRL HOT AT ALL TIMES HOT AT ALL TIMES ENGINE COMPARTMENT FUSE BOX FUSE 11 HOT IN RUN OR START HOT IN RUN OR START I/P FUSE PANEL FUSE 8 I/P FUSE PANEL IAT IDLE VALIDATION SW IDLE VALIDATION SWITCH (OPEN AT IDLE) (LEFT SIDE OF DASH) IDM RELAY INJECTION PRESSURE REGULATOR (TOP OF ENGINE) INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM INTAKE AIR TEMPERATURE SENSOR (CENTER OF ENGINE COMPT, PART OF CLEAN AIR TUBE) LT GRN DK GRN/ WIRE LT GRN WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM DLC PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL 13 10 2 DATA LINK CONNECTOR (PARTIAL) (BELOW LEFT SIDE OF DASH) PPL/LT BLU WIRE PPL/ORG WIRE RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE SHIELD GND SW GND TAN/ORG WIRE TAN/WHT WIRE TCIL TCS TFT VSS GND WAIT TO START INDICATOR WHT/LT GRN WIRE WHT/PNK WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

A/C ON SIG ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH, ABOVE ACCEL PEDAL) ACCL POS SENS AIR COND- ITIONING SYSTEM BARO BAROMETRIC PRESSURE (BARO) SENSOR (BELOW LEFT SIDE OF DASH) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BOO BRN/ORG WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR (FRONT CENTER OF ENGINE) CID SIG CMP RTN CRUISE CONTROL SYSTEM DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE ECT EPC EPR EXHAUST BACK PRESSURE (EBP) SENSOR (TOP CENTER OF ENGINE) EXHAUST PRESSURE REGULATOR (TOP REAR OF ENGINE) FUEL DELIV SIG GLOW PLUG CTRL GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE ICP+ IDM ENABLE OUT IDM SIG IN INJECTION CONTROL PRESSURE (ICP) SENSOR (ON TOP OF ENGINE) INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM IPR KAPWR LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (TOP RIGHT SIDE OF ENGINE COMPT) MAP NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH TCS PNK WIRE PNK/ORG WIRE PPL/LT BLU WIRE PPL/ORG WIRE PPL/YEL WIRE PWR GND RED WIRE SIG RTN SPEED CTRL SIG SPEEDOMETER TAN/WHT WIRE TCC TCIL VEHICLE SPEED SENSOR (LEFT SIDE OF TRANSMISSION) VPWR VREF VSS VSS IN WAIT TO START IND WHT/LT GRN WIRE WHT/PNK WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE