Ford Club Wagon E350 (1996-1998) air conditioning system Wiring diagrams

51 52 GROUND AIR CONDITIONING SYSTEM AIRD SOL. ANTI-THEFT MODULE (LEFT SIDE OF VEHICLE, BEHIND "B" PILLAR) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/PNK WIRE BUS (-) BUS (+) COIL WIRE DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF I/P) DISTRIBUTOR (LEFT SIDE OF ENGINE) DISTRIBUTOR SHIELD DK GRN/YEL WIRE EGR SOL. IDM MONITOR PIP SPK ANGLE PULSE FUSE 18 FUSE 5 FUSE 7 GROUND GRY WIRE GRY/ORG WIRE HOT IN HOT IN START OR RUN IGN GND PIP IGNITION CONTROL MODULE (ICM) (LEFT REAR OF ENGINE COMPARTMENT) IGNITION CONTROL MODULE (ICM) SHIELD INSTRUMENT CLUSTER INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LT BLU WIRE LT BLU/YEL WIRE LT GRN RED/ WIRE LT GRN WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP (MIL) MISFIRE SENS GND NCA WIRE OD OFF OR (LEFT SIDE OF ENGINE COMPARTMENT, NEAR BATTERY) ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE ORG/YEL WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PIP SPOUT IDM PWR COIL GND PNK WIRE PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL GEN SCAN TOOL IN PPL/ORG WIRE PWR SHIELD GND GND RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RUN WIRE SHIFT SOL 1 SHORTING BAR (LEFT REAR OF ENGINE COMPARTMENT) TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE TCIL TFI MODULE GND GROUND GROUND TRANS CTRL SW TRANS.) TRANSMISSION CONTROL SWITCH/ INDICATOR LAMP W/O ANTI- THEFT W/ ANTI- THEFT WHT WIRE WHT/LT GRN WIRE WHT/PNK WIRE YEL TAN WIRE YEL WIRE

820 OHMS AIR CONDITIONING SYSTEM BLK/LT BLU WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRN WIRE BRN/ORG WIRE BRN/PNK WIRE CKP SENS CKP SENS DATA LINK (-) DATA LINK (+) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN/YEL WIRE ECT INLET AIR CTRL NOT USED RPM SENS FEED ENDS IN HARNESS ENGINE COMPARTMENT FUSE BOX (LEFT FRONT OF ENGINE COMPT) FUSE 4 FUSE 8 FUSE 20 FUSE 9 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE PANEL (BEHIND LEFT SIDE OF DASH) IAT FUEL PUMP MON A/C ON SIG IGNITION COILS LT BLU WIRE LT GRN/WHT WIRE LT LT LT LT LT LT PNK WIRE MAF TFT NCA WIRE NOT USED OD OFF OD OFF IND FEPS (EPROM) PPL ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PNK LT DK WIRE PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/WHT WIRE PPL PPL/LT BLU WIRE PPL/ORG WIRE PWR GND GND IGN COIL 1 IGN COIL 5 PWR GND IGN COIL 3 RADIO CAPACITOR RED WIRE RED/LT GRN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCS TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL INDICATOR LAMP TRANSMISSION CONTROL SWITCH VSS WHT WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE

AIR CONDITIONING SYSTEM BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRN WIRE BRN/ORG WIRE BRN/PNK WIRE DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (PARTIAL) (LEFT SIDE OF DASH) 915 914 10 2 DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN/YEL WIRE ECT INLET AIR CTRL EVR SOL NOT USED ENDS IN HARNESS ENGINE COMPARTMENT FUSE BOX (LEFT FRONT OF ENGINE COMPT) FP SENDING UNIT FUSE 20 FUSE 8 FUSE 4 FUSE 9 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE PANEL (BEHIND LEFT SIDE OF DASH) IAT FUEL PUMP MON A/C ON SIG IGNITION COILS INSTRUMENT CLUSTER SYSTEM LT GRN WIRE LT GRN/WHT WIRE LT LT LT LT LT LT LT LT PNK WIRE MAF TFT MISFIRE SENS (+) MISFIRE SENS (-) NCA WIRE OD OFF OD OFF IND FEPS (EPROM) ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY PNK LT WIRE PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/WHT WIRE PPL PPL/ORG WIRE PWR GND GND IGN COIL 1 IGN COIL 5 PWR GND IGN COIL 3 RADIO CAPACITOR NO 1 (UPPER LEFT REAR OF ENGINE RADIO CAPACITOR NO 2 (RIGHT REAR OF ENGINE) RED WIRE RED/LT GRN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCS TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL INDICATOR LAMP VSS WHT WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/WHT WIRE

1 2 3 4 5 6 PIP SPOUT IDM PWR COIL GND PNK WIRE 570 224 923 GND TCS TFT 924 395 CCS PIP IGN POWER INJ 1,4,5,8 OUT INJ 2,3,6,7 OUT GND AIR CONDITIONING SYSTEM BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL SUPPORT) BRN WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE COIL WIRE DATA LINK CONNECTOR (LEFT FRONT CORNER OF ENGINE COMPT.) DATA LINK CONNECTOR (LEFT FRONT OF ENGINE COMPT.) DIODE (PLUG-IN) (IN ENGINE COMPARTMENT FUSE PANEL) DISTRIBUTOR 1 2 3 7 8 DISTRIBUTOR SHIELD DK GRN/YEL WIRE ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) PCM POWER RELAY FUSE 1 FUSE 18 FUSE C FUSE U GND IAC FP GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN IAT VREF EGR VALVE DATA (+) IGN GND MIL IGNITION COIL (LEFT REAR OF ENGINE) IGNITION CONTROL MODULE (ICM) (LEFT REAR OF ENGINE COMPARTMENT) IGNITION CONTROL MODULE (ICM) SHIELD INSTRUMENT CLUSTER INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) KAPWR BOO PSOM (+) IDM LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN RED/ WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP (MIL) MAP SIG RTN TP STI 359 355 209 NCA WIRE OR (LEFT SIDE OF ENGINE COMPARTMENT, NEAR BATTERY) ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE ORG/YEL WIRE PNK 929 361 SPOUT IGN POWER EPC WIRE PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL/ORG WIRE PPL/YEL WIRE RADIO CAPACITOR (ATTACHED TO IGNITION COIL) RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHORTING BAR (LEFT REAR OF ENGINE COMPARTMENT) TAN WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE TCC SOL TR SENSOR CANP TCIL EGR SOL TRANSMISSION RANGE (TR) SENSOR (LEFT SIDE OF TRANSMISSION) VSS (-) ECT FPM DATA (-) A/C ON AIRD WHT WIRE WHT/ BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/PNK WIRE WHT/PPL WIRE WHT/YEL WIRE YEL WIRE YEL/RED WIRE

51 52 GROUND AIR CONDITIONING SYSTEM ANTI-THEFT MODULE (LEFT SIDE OF VEHICLE, BEHIND "B" PILLAR) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/PNK WIRE BUS (-) BUS (+) COIL WIRE DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF I/P) DISTRIBUTOR (CENTER FRONT OF ENGINE) DISTRIBUTOR SHIELD DK GRN/YEL WIRE EGR SOL. IDM MONITOR PIP SPK ANGLE PULSE FUSE 18 FUSE 5 FUSE 7 GRY WIRE GRY/ORG WIRE HOT IN HOT IN START OR RUN IGN GND PIP IGNITION CONTROL MODULE (ICM) (LEFT REAR OF ENGINE COMPARTMENT) INSTRUMENT CLUSTER INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LT GRN RED/ WIRE LT GRN WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP (MIL) MISFIRE SENS GND NCA WIRE OD OFF ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE ORG/YEL WIRE PIP SPOUT IDM PWR COIL GND PNK WIRE PNK IGNITION CONTROL MODULE (ICM) SHIELD WIRE PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL GEN SCAN TOOL IN PPL/ORG WIRE PWR SHIELD GND GND RED WIRE RED/LT GRN WIRE RED/YEL WIRE RUN WIRE SHIFT SOL 1 SHORTING BAR (LEFT REAR OF ENGINE COMPARTMENT) TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE TCIL TFI MODULE GND GROUND GROUND TRANS CTRL SW TRANSMISSION CONTROL SWITCH/ INDICATOR LAMP VSS GROUND W/O ANTI- THEFT W/ ANTI- THEFT WHT WIRE WHT/LT GRN WIRE WHT/PNK WIRE WIRE COIL YEL TAN WIRE

360 648 1145 1143 570 1026 (ENDS IN HARNESS) AIR CONDITIONING SYSTEM BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRN/ORG WIRE BRN/PNK WIRE DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (PARTIAL) (BEHIND LEFT SIDE OF DASH) 915 914 10 2 DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN/PPL WIRE DK GRN/YEL WIRE ECT ENDS IN HARNESS ENGINE COMPARTMENT FUSE BOX (LEFT FRONT OF ENGINE COMPT) EVR SOL NOT USED FEPS (EPROM) FP SEND UNIT FUSE 20 FUSE 8 FUSE 4 FUSE 9 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE PANEL (BEHIND LEFT SIDE OF DASH) IGNITION COILS INSTRUMENT CLUSTER SYSTEM LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT LT LT LT LT LT LT LT LT LT PNK WIRE MAF TFT NOT USED IAT FUEL PUMP MON A/C ON SIG FUEL INJ 10 NCA WIRE NOT USED OD OFF ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY PNK WIRE PNK/ LT DK LT WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/WHT WIRE PPL PPL/LT BLU WIRE PPL/ORG WIRE PPL/YEL WIRE PWR GND IGN COIL 5 RADIO NOISE CAPACITOR RED WIRE RED/LT GRN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL INDICATOR LAMP VSS WHT WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/WHT WIRE

A/C ON SIG ACCELERATOR PEDAL POSITION SENSOR (UNDER LEFT SIDE OF I/P) ACCL PDL POS SENS AIR CONDITIONING SYSTEM BARO BAROMETRIC PRESSURE (BARO) SENSOR (BELOW I/P, AT BASE OF STEERING COLUMN) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BOO BRN/ORG WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR (FRONT CENTER OF ENGINE) CID SIG CMP RTN CRUISE CONTROL SYSTEM DK BLU/LT GRN WIRE DK GRN WIRE DK GRN/LT GRN WIRE ECT EPC EPR EXHAUST BACK PRESSURE (EBP) SENSOR (RIGHT SIDE OF ENGINE) EXHAUST PRESSURE REGULATOR (TOP CENTER OF ENGINE) FUEL DELIVERY SIG GLOW PLUG CTRL GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE ICP+ IDM ENABLE OUT IDM SIG IN INJECTION CONTROL PRESSURE (ICP) SENSOR (TOP LEFT SIDE OF ENGINE) INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM IPR KAPWR LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (TOP RIGHT SIDE OF SAFETY WALL) MAP NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH TCS PNK WIRE PNK/ORG WIRE PPL/LT BLU WIRE PPL/ORG WIRE PPL/YEL WIRE PWR GND RED WIRE SIG RTN SPEED CTRL SIG SPEEDOMETER TAN/WHT WIRE TCC TCIL VEHICLE SPEED SENSOR (LEFT SIDE OF TRANSMISSION) VPWR VREF VSS VSS IN WAIT TO START IND WHT/LT GRN WIRE WHT/PNK WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 PWR SHIELD GND GND 51 52 GROUND AIR CONDITIONING SYSTEM AIRD SOLENOID ANTI- SLOSH MODULE SOLID STATE ANTI-THEFT MODULE (LEFT SIDE OF VEHICLE, BEHIND "B" PILLAR) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/PNK WIRE BUS (-) BUS (+) COIL WIRE DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF I/P) DISTRIBUTOR (CENTER FRONT OF ENGINE) DISTRIBUTOR SHIELD DK GRN/YEL WIRE EGR SOL. IDM MONITOR PIP SPK ANGLE PULSE FUSE 18 FUSE 5 FUSE 7 GRY WIRE GRY/ORG WIRE HOT IN HOT IN START OR RUN IGN GND PIP IGNITION CONTROL MODULE (ICM) (LEFT REAR OF ENGINE COMPARTMENT) INSTRUMENT CLUSTER INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LT GRN RED/ WIRE LT GRN WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP (MIL) "CHECK ENGINE LIGHT" MISFIRE SENS GND NCA WIRE OD OFF ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE ORG/YEL WIRE PIP SPOUT IDM PWR COIL GND PNK WIRE PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL GEN SCAN TOOL IN PPL/ORG WIRE RED WIRE RED/LT GRN WIRE RED/YEL WIRE RUN WIRE SHIFT SOL NO.1 TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE TCIL TFI MODULE GND GROUND GROUND TO FUEL GAUGE TRANS CTRL SW TRANSMISSION CONTROL SWITCH/ INDICATOR LAMP VSS GROUND W/O ANTI- THEFT W/ ANTI- THEFT WHT WIRE WHT/LT GRN WIRE WHT/PNK WIRE WIRE COIL YEL TAN WIRE YEL WIRE YEL/WHT WIRE

1 2 3 4 5 6 PIP SPOUT IDM PWR COIL GND PNK WIRE 190 237 AIRB 570 224 923 GND TCS TFT ACD 924 395 CCS PIP IGNITION INJ 1,4,5,8 OUT INJ 2,3,6,7 OUT GND AIR CONDITIONING SYSTEM AIR CONDITIONING SYSTEM PPL BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL SUPPORT) BRN WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE COIL WIRE DATA LINK CONNECTOR (DLC) (LEFT FRONT CORNER OF ENGINE COMPARTMENT) DATA LINK CONNECTOR (DLC) (LEFT FRONT OF ENGINE COMPT) DIODE (PLUG-IN) (ENGINE COMPARTMENT FUSE PANEL) DISTRIBUTOR DISTRIBUTOR SHIELD DK GRN/YEL WIRE ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) FUSE 1 FUSE 18 FUSE C FUSE U GND IAC FP ENABLE GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN IAT VREF EGR VALVE DATA (+) IGN GND MIL IGNITION COIL (LEFT REAR OF ENGINE) IGNITION CONTROL MODULE (ICM) SHIELD IGNITION CONTROL MODULE (LEFT REAR OF ENGINE COMPARTMENT) INSTRUMENT CLUSTER INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) KAPWR BOO PSOM (+) IDM LT BLU WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN RED/ WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP (MIL) MAP SENSOR SIG RTN TP DATA 359 355 209 NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE ORG/YEL WIRE PCM POWER RELAY PNK 929 361 SPOUT IGNITION EPC WIRE PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL/ORG WIRE PPL/YEL WIRE RADIO CAPACITOR (ATTACHED TO IGNITION COIL) RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHORTING BAR (LEFT REAR OF ENGINE COMPARTMENT) TAN WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE TCC TR SENSOR EVAP TCIL EGR TRANSMISSION CONTROL SWITCH/ INDICATOR LAMP TRANSMISSION RANGE (TR) SENSOR (LEFT SIDE OF TRANSMISSION) VEHICLE SPEED INPUT VSS (-) ECT FPM DATA (-) A/C ON AIRD WHT WIRE WHT/ BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/PNK WIRE WHT/PPL WIRE WHT/YEL WIRE YEL WIRE YEL/RED WIRE