Ford Club Wagon E150 (1996-1998) wht/ppl Wiring diagrams

2 4 5 7 GROUND REAR AXLE SPEED INPUT REAR AXLE SPEED INPUT VEHICLE SPEED OUTPUT 2200 OHMS 4 WHEEL ANTI-LOCK 4-WHEEL ABS SYSTEM 4.9L, 5.0L, 5.8L FEDERAL UNDER 8600 GVW, ALL CALIF. ENGINES 5.8L FEDERAL OVER 8600 GVW, 7.5L FEDERAL ENGINES 9 22 REAR SENSOR LOW REAR SENSOR HIGH BLK WIRE BLK/WHT WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL BRACKET) BRAKE PRESSURE INPUT GROUND CLOCK SPRING ASSEMBLY (TOP OF STEERING COLUMN) COAST FUSE 1 FUSE 6 GRY/BLK WIRE HORN HORNS SYSTEM HOT AT ALL TIMES HOT IN ACCY OR RUN INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE NCA WIRE OFF ON ORG/ WIRE ORG/YEL WIRE PNK WIRE PNK/ORG WIRE PPL PROGRAMMABLE SPEEDOMETER/ ODOMETER MODULE (PSOM) (BEHIND LEFT SIDE OF I/P) REAR ANTI-LOCK BRAKE SYSTEM (RABS) MODULE (BEHIND RIGHT SIDE OF I/P) REAR AXLE SPEED SENSOR (BELOW REAR OF VEHICLE, MOUNTED ON DIFFERENTIAL) REAR-WHEEL ABS SYSTEM RED WIRE RED/LT GRN WIRE RED/PNK WIRE RESUME SET/ ACCEL 680 OHMS 120 OHMS SPEED CONTROL/ HORN SWITCH (STEERING COLUMN ASSEMBLY) VEHICLE SPEED SENSOR OR PSOM INPUT (VSS +) WHEEL SPEED SENSOR HIGH WHEEL SPEED SENSOR LOW WHT WIRE WHT/PPL WIRE YEL WIRE

2 4 5 7 GROUND REAR AXLE SPEED INPUT REAR AXLE SPEED INPUT VEHICLE SPEED OUTPUT 2200 OHMS 4 WHEEL ANTI-LOCK 4-WHEEL ABS SYSTEM 4.9L, 5.0L, 5.8L FEDERAL UNDER 8600 GVW, ALL CALIF. ENGINES 5.8L FEDERAL OVER 8600 GVW, 7.5L FEDERAL ENGINES 9 22 REAR SENSOR LOW REAR SENSOR HIGH BLK WIRE BLK/WHT WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL BRACKET) BRAKE PRESSURE INPUT GROUND CLOCK SPRING ASSEMBLY (TOP OF STEERING COLUMN) COAST FUSE 1 FUSE 6 GRY/BLK WIRE HORN HORNS SYSTEM HOT AT ALL TIMES HOT IN ACCY OR RUN INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE NCA WIRE OFF ON ORG/ WIRE ORG/YEL WIRE PNK WIRE PNK/ORG WIRE PPL PROGRAMMABLE SPEEDOMETER/ ODOMETER MODULE (PSOM) (BEHIND LEFT SIDE OF I/P) REAR ANTI-LOCK BRAKE SYSTEM (RABS) MODULE (BEHIND RIGHT SIDE OF I/P) REAR AXLE SPEED SENSOR (BELOW REAR OF VEHICLE, MOUNTED ON DIFFERENTIAL) REAR-WHEEL ABS SYSTEM RED WIRE RED/LT GRN WIRE RED/PNK WIRE RESUME SET/ ACCEL 680 OHMS 120 OHMS SPEED CONTROL/ HORN SWITCH (STEERING COLUMN ASSEMBLY) VEHICLE SPEED SENSOR OR PSOM INPUT (VSS +) WHEEL SPEED SENSOR HIGH WHEEL SPEED SENSOR LOW WHT WIRE WHT/PPL WIRE YEL WIRE

COIL DATA (STI) (5.8L) DATA LINK CONN (7.5L) DATA LINK CONN DATA LINK CONN (+) SENS DATA LINK CONNECTOR (DLC) (LEFT FRONT CORNER OF ENGINE COMPARTMENT) ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) FUEL PUMP ENABLE OUTPUT FUEL PUMP RELAY FUSE 18 GRY WIRE GRY/RED WIRE HOT IN START OR RUN INSTRUMENT CLUSTER INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LT BLU WIRE LT BLU/ORG WIRE LT GRN WIRE MALFUNCTION IND LP MALFUNCTION INDICATOR LAMP (MIL) "CHECK ENGINE LIGHT" NCA WIRE ORG/ WIRE PNK WIRE PNK/LT GRN WIRE PPL 209 RED WIRE RED/YEL WIRE SENS SIG RTN TAN WIRE WHT WIRE WHT/PPL WIRE YEL WIRE

2 4 5 7 GROUND REAR AXLE SPEED INPUT REAR AXLE SPEED INPUT VEHICLE SPEED OUTPUT 2200 OHMS 4 WHEEL ANTI-LOCK 4-WHEEL ABS SYSTEM 4.9L, 5.0L, 5.8L FEDERAL UNDER 8600 GVW, ALL CALIF. ENGINES 5.8L FEDERAL OVER 8600 GVW, 7.5L FEDERAL ENGINES 9 22 REAR SENSOR LOW REAR SENSOR HIGH BLK WIRE BLK/WHT WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL BRACKET) BRAKE PRESSURE INPUT GROUND CLOCK SPRING ASSEMBLY (TOP OF STEERING COLUMN) COAST FUSE 1 FUSE 6 GRY/BLK WIRE HORN HORNS SYSTEM HOT AT ALL TIMES HOT IN ACCY OR RUN INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE NCA WIRE OFF ON ORG/ WIRE ORG/YEL WIRE PNK WIRE PNK/ORG WIRE PPL PROGRAMMABLE SPEEDOMETER/ ODOMETER MODULE (PSOM) (BEHIND LEFT SIDE OF I/P) REAR ANTI-LOCK BRAKE SYSTEM (RABS) MODULE (BEHIND RIGHT SIDE OF I/P) REAR AXLE SPEED SENSOR (BELOW REAR OF VEHICLE, MOUNTED ON DIFFERENTIAL) REAR-WHEEL ABS SYSTEM RED WIRE RED/LT GRN WIRE RED/PNK WIRE RESUME SET/ ACCEL 680 OHMS 120 OHMS SPEED CONTROL/ HORN SWITCH (STEERING COLUMN ASSEMBLY) VEHICLE SPEED SENSOR OR PSOM INPUT (VSS +) WHEEL SPEED SENSOR HIGH WHEEL SPEED SENSOR LOW WHT WIRE WHT/PPL WIRE YEL WIRE

BLK WIRE BLK/WHT WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL BRACKET) BRN ORG/ WIRE BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CHECK ENGINE LIGHT "MALFUNCTION INDICATOR LIGHT (MIL)" COAST CLUTCH SOLENOID (BACK UP LAMP SWITCH TO REAR LAMP FEED HARNESS, IN DATA LINK CONNECTOR (DLC) (LEFT FRONT CORNER OF ENGINE COMPARTMENT) DATA LINK CONNECTOR (DLC) (PARTIAL) (LEFT FRONT CORNER OF ENGINE COMPARTMENT) DIODE (PLUG- IN) ELECTRONIC PRESSURE CONTROL SOLENOID SHIFT SOLENOID 1 ENGINE COMPARTMENT FUSE PANEL ENGINE COMPARTMENT FUSE PANEL FUSE FUSE FUSE 18 FUSE 5 GND IAT VREF DATA (+) TR TCIL IGN EPC GND TCS TFT MAP SIG RTN TP DATA GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN HOT IN START OR RUN INSTRUMENT CLUSTER INTAKE AIR TEMPERATURE (IAT) SENSOR (RIGHT SIDE OF ENGINE, NEAR FUEL INJECTOR 1) INTERIOR FUSE PANEL FUSE 1 LT BLU WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (RIGHT SIDE OF ENGINE COMPARTMENT) NCA WIRE OD OFF ORG BLK WIRE ORG PPL/ WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL/ORG WIRE PPL/YEL WIRE PROGRAMMABLE SPEEDOMETER/ ODOMETER MODULE (PSOM) (BEHIND LEFT SIDE OF I/P) RED WIRE RED/ GRY WIRE RUN WIRE TAN/ORG WIRE TAN/WHT WIRE TCC CCS IGN GND TCIL THROTTLE POSITION (TP) SENSOR (RIGHT FRONT OF ENGINE) TORQUE CONVERTER CLUTCH SOLENOID SHIFT SOLENOID 2 TRANSMISSION TRANSMISSION CONTROL SWITCH/INDICATOR LAMP TRANSMISSION FLUID TEMPERATURE SENSOR TRANSMISSION RANGE (TR) SENSOR (LEFT SIDE OF TRANSMISSION) VSS INPUT VSS OUTPUT WHT WIRE WHT YEL/ WIRE WHT/LT GRN WIRE WHT/PPL WIRE WHT/YEL WIRE YEL PPL WIRE YEL WIRE YEL/ ORG WIRE

"ANTI-THEFT" INDICATOR ALARM INDICATOR ANTI-THEFT MODULE (LEFT SIDE OF VEHICLE, BEHIND "B" PILLAR) BATTERY BLK WIRE BLU WIRE BRN WIRE BRN/WHT WIRE CIRCUIT BREAKER 12 COURTESY LP SWITCHES DIODE B (IN WINDOW REG. RELAY SWITCH HARNESS) DISARM SWITCH DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK DK DK GRN WIRE DK GRN/PPL WIRE DK GRN/WHT WIRE DOOR LOCK CONTROL DOOR LOCK CONTROL DRIVER'S DOOR LOCK CONTROL DOOR LOCKS SYSTEM (KEYLESS ENTRY CIRCUIT) FUSE 7 FUSE 8 GROUND HEADLIGHTS SYSTEM HOOD TAMPER DET. INPUT HORN RELAY OUTPUT HORNS SYSTEM HOT AT ALL TIMES HOT IN ACCY OR RUN HOT IN START IGN KEY CYL SENSOR INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) FUSE 6 INTERIOR LIGHTS SYSTEM (COURTESY LIGHTS) LEFT COURTESY LAMP SWITCH (MOUNTED IN LEFT DOOR JAMB) LEFT DOOR LOCK CYLINDER SWITCH (LOWER LEFT CORNER OF LEFT DOOR) LOCK ALL DOORS LOW BEAM HDLPS OUTPUT LT BLU WIRE LT GRN WIRE LT GRN/YEL WIRE NCA WIRE ORG/ WIRE PANIC ACTIVATE OUT COURTESY LAMP SWITCH INPUT PANIC ALARM INPUT PARKING LAMPS OUTPUT PNK WIRE PNK/BLK WIRE PNK/ORG WIRE PPL PPL (RIGHT REAR CORNER OF ENGINE COMPARTMENT) ANTI-THEFT HOOD SWITCH REAR COURTESY LAMP SWITCH (IN RIGHT REAR DOOR JAMB) REAR DOOR LOCK CYLINDER SWITCH (BELOW LICENSE PLATE) RED WIRE RED/BLK WIRE RED/ORG WIRE RED/PNK WIRE REMOTE KEYLESS ENTRY MODULE (BEHIND LEFT "B" PILLAR) RIGHT COURTESY LAMP SWITCH (MOUNTED IN RIGHT DOOR JAMB) RIGHT DOOR KEY CYLINDER SWITCH (LOWER RIGHT SIDE OF DOOR) RIGHT DOOR KEY CYLINDER SWITCH IN RUN/ACCY INPUT SIDE DOOR COURTESY LAMP SWITCH (BEHIND RIGHT "B" PILLAR) SIDE DOOR LOCK CTRL STARTER INTERRUPT IN STARTER INTERRUPT OUT STARTING/ CHARGING SYSTEM (STARTER CIRCUIT) STEERING COLUMN ASSEMBLY IGNITION KEY CYLINDER SENSOR TAN WIRE TAN/LT GRN WIRE UNLOCK DRIVER'S DOOR UNLOCK SENSE WARNING BUZZER MODULE (BELOW LEFT SIDE OF I/P) PNK DOOR OPEN INPUT WIRE WHT WIRE WHT/PNK WIRE WHT/PPL WIRE YEL WIRE YEL/LT GRN WIRE

BLK WIRE BLK/PNK WIRE DIGITAL TRANSMISSION RANGE (DTR) SENSOR (LEFT SIDE OF TRANSMISSION) EXTERIOR LIGHTS (TRAILER BACKUP LAMP RELAY) FUSE 12 HOT IN RUN I/P FUSE PANEL (BEHIND LEFT SIDE OF DASH) LEFT BACKUP LAMP PPL/ORG WIRE WHT/PPL WIRE

1 2 3 4 5 6 7 8 GROUND DOOR SW INPUT BLK WIRE BLK/LT BLU WIRE CTSY LP CTRL CUTAWAY MODELS CUTAWAY ONLY DOME DOME/MAP SWITCH AND LAMP EXTERIOR LIGHTS SYSTEM (TRAILER/ CAMPER ADAPTER) FUSE 4 HIGH MOUNTED STOP/ CARGO LAMP HIGH MOUNTED STOP/CARGO LAMP, REAR COURTESY LAMP SWITCH (DIAGRAM 3 OF 3) HINGE DOOR SLIDING DOOR HOT AT ALL TIMES HOT IN RUN FUSE 24 I/P FUSE PANEL IGNITION BATTERY ILLUMINATED ENTRY MODULE (BEHIND CENTER OF DASH) LEFT LEFT COURTESY LAMP SWITCH LEFT DOOR HANDLE SWITCH LT BLU WIRE LT GRN WIRE LT GRN/YEL WIRE MAIN LIGHT SWITCH PNK WIRE PPL RED WIRE RIGHT RIGHT COURTESY LAMP SWITCH RIGHT DOOR HANDLE SWITCH RIGHT LEFT SIDE DOOR COURTESY LAMP SWITCH VANS/ WAGONS ONLY VANS/WAGONS ONLY W/ FULL HEADLINER W/ILLUMINATED ENTRY VANS/WAGONS, CUTAWAYS W/O FULL HEADLINER WARNING SYSTEMS (WARNING BUZZER MODULE) WHT WIRE WHT/LT BLU WIRE WHT/PPL WIRE YEL WIRE

ANTI-THEFT SYSTEM ANTI-THEFT SYSTEM (SIDE DOOR COURTESY LAMP SWITCH) ANTI-THEFT SYSTEM HEADLIGHTS SYSTEM BATTERY SIDE/REAR DOOR LOCK CTRL BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BUTTON CONTACT (ATTACHED TO REAR OF "B" PILLAR) DK BLU WIRE DOOR LOCK CONTROL SIDE DOOR LOCK CTRL INTERIOR LAMPS OUTPUT DOOR LOCK CONTROL SWITCH EXTERIOR LIGHTS SYSTEM (MAIN LIGHT SWITCH) FUSE 4 FUSE 5 FUSE 3 GROUND BATTERY GROUND UNLOCK INPUT LOCK INPUT HEADLAMPS BATTERY RIGHT FRONT DOOR LOCK HEADLIGHTS SYSTEM HORNS SYSTEM HOT AT ALL TIMES HOT AT ALL TIMES ENGINE COMPARTMENT FUSE BOX FUSE 16 HOT IN ACCY OR RUN HOT AT ALL TIMES I/P FUSE PANEL KICK PANEL) LEFT DOOR HANDLE SWITCH LEFT FRONT DOOR LOCK MOTOR LOCK LT BLU WIRE LT GRN WIRE MASTER WINDOW ORG/ WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE PPL REAR DOOR LOCK MOTOR REAR POWER DOOR LOCK SWITCH RED WIRE RED/BLK WIRE RED/ORG WIRE REMOTE KEYLESS ENTRY MODULE (BEHIND LEFT "B" PILLAR) RIGHT DOOR HANDLE SWITCH RIGHT FRONT DOOR LOCK MOTOR RIGHT POWER DOOR LOCK/ WINDOW SWITCH RKE DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) SIDE DOOR COURTESY SW IN SIDE DOOR LOCK MOTOR UNLOCK UNLOCK LOCK W/ SLIDING DOOR W/O SLIDING DOOR WHT WIRE WHT/LT BLU WIRE WHT/PPL WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 PIP SPOUT IDM PWR COIL GND PNK WIRE 570 224 923 GND TCS TFT 924 395 CCS PIP IGN POWER INJ 1,4,5,8 OUT INJ 2,3,6,7 OUT GND AIR CONDITIONING SYSTEM BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL SUPPORT) BRN WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE COIL WIRE DATA LINK CONNECTOR (LEFT FRONT CORNER OF ENGINE COMPT.) DATA LINK CONNECTOR (LEFT FRONT OF ENGINE COMPT.) DIODE (PLUG-IN) (IN ENGINE COMPARTMENT FUSE PANEL) DISTRIBUTOR 1 2 3 7 8 DISTRIBUTOR SHIELD DK GRN/YEL WIRE ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) PCM POWER RELAY FUSE 1 FUSE 18 FUSE C FUSE U GND IAC FP GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN IAT VREF EGR VALVE DATA (+) IGN GND MIL IGNITION COIL (LEFT REAR OF ENGINE) IGNITION CONTROL MODULE (ICM) (LEFT REAR OF ENGINE COMPARTMENT) IGNITION CONTROL MODULE (ICM) SHIELD INSTRUMENT CLUSTER INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) KAPWR BOO PSOM (+) IDM LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN RED/ WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP (MIL) MAP SIG RTN TP STI 359 355 209 NCA WIRE OR (LEFT SIDE OF ENGINE COMPARTMENT, NEAR BATTERY) ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE ORG/YEL WIRE PNK 929 361 SPOUT IGN POWER EPC WIRE PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL/ORG WIRE PPL/YEL WIRE RADIO CAPACITOR (ATTACHED TO IGNITION COIL) RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHORTING BAR (LEFT REAR OF ENGINE COMPARTMENT) TAN WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE TCC SOL TR SENSOR CANP TCIL EGR SOL TRANSMISSION RANGE (TR) SENSOR (LEFT SIDE OF TRANSMISSION) VSS (-) ECT FPM DATA (-) A/C ON AIRD WHT WIRE WHT/ BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/PNK WIRE WHT/PPL WIRE WHT/YEL WIRE YEL WIRE YEL/RED WIRE