Ford Club Wagon E150 (1996-1998) brn/org Wiring diagrams

BLK WIRE BLK/WHT WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL BRACKET) BRN ORG/ WIRE BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CHECK ENGINE LIGHT "MALFUNCTION INDICATOR LAMP (MIL)" COAST CLUTCH SOLENOID (BACK UP LAMP SWITCH TO REAR LAMP FEED HARNESS, IN DATA LINK CONNECTOR (DLC) (PARTIAL) (BELOW LEFT SIDE OF I/P) DIODE (PLUG- IN) ELECTRONIC PRESSURE CONTROL SOLENOID SHIFT SOLENOID 1 ENGINE COMPARTMENT FUSE PANEL ENGINE COMPARTMENT FUSE PANEL FUSE FUSE FUSE 18 FUSE 5 GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN HOT IN START OR RUN INSTRUMENT CLUSTER INTERIOR FUSE PANEL FUSE 1 LT BLU WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MASS AIR FLOW (MAF) SENSOR (CENTER OF ENGINE COMPARTMENT) MIL GEN SCAN BUS - BUS + GND GND PPL NCA WIRE ORG BLK WIRE ORG PPL/ WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL/ORG WIRE PPL/YEL WIRE PROGRAMMABLE SPEEDOMETER/ ODOMETER MODULE (PSOM) (BEHIND LEFT SIDE OF I/P) RED WIRE RED/ GRY WIRE RUN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL OD OFF THROTTLE POSITION (TP) SENSOR (TOP LEFT SIDE OF ENGINE) TORQUE CONVERTER CLUTCH SOLENOID SHIFT SOLENOID 2 TRANSMISSION TRANSMISSION CONTROL SWITCH/INDICATOR LAMP TRANSMISSION FLUID TEMPERATURE SENSOR TRANSMISSION RANGE (TR) SENSOR (LEFT SIDE OF TRANSMISSION) VSS INPUT VSS OUTPUT WHT WIRE WHT YEL/ WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL PPL WIRE YEL WIRE YEL/ ORG WIRE

BLK WIRE BLK/WHT WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL BRACKET) BRN ORG/ WIRE BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CHECK ENGINE LIGHT "MALFUNCTION INDICATOR LIGHT (MIL)" COAST CLUTCH SOLENOID (BACK UP LAMP SWITCH TO REAR LAMP FEED HARNESS, IN DATA LINK CONNECTOR (DLC) (LEFT FRONT CORNER OF ENGINE COMPARTMENT) DATA LINK CONNECTOR (DLC) (PARTIAL) (LEFT FRONT CORNER OF ENGINE COMPARTMENT) DIODE (PLUG- IN) ELECTRONIC PRESSURE CONTROL SOLENOID SHIFT SOLENOID 1 ENGINE COMPARTMENT FUSE PANEL ENGINE COMPARTMENT FUSE PANEL FUSE FUSE FUSE 18 FUSE 5 GND IAT VREF DATA (+) TR TCIL IGN EPC GND TCS TFT MAP SIG RTN TP DATA GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN HOT IN START OR RUN INSTRUMENT CLUSTER INTAKE AIR TEMPERATURE (IAT) SENSOR (RIGHT SIDE OF ENGINE, NEAR FUEL INJECTOR 1) INTERIOR FUSE PANEL FUSE 1 LT BLU WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (RIGHT SIDE OF ENGINE COMPARTMENT) NCA WIRE OD OFF ORG BLK WIRE ORG PPL/ WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL/ORG WIRE PPL/YEL WIRE PROGRAMMABLE SPEEDOMETER/ ODOMETER MODULE (PSOM) (BEHIND LEFT SIDE OF I/P) RED WIRE RED/ GRY WIRE RUN WIRE TAN/ORG WIRE TAN/WHT WIRE TCC CCS IGN GND TCIL THROTTLE POSITION (TP) SENSOR (RIGHT FRONT OF ENGINE) TORQUE CONVERTER CLUTCH SOLENOID SHIFT SOLENOID 2 TRANSMISSION TRANSMISSION CONTROL SWITCH/INDICATOR LAMP TRANSMISSION FLUID TEMPERATURE SENSOR TRANSMISSION RANGE (TR) SENSOR (LEFT SIDE OF TRANSMISSION) VSS INPUT VSS OUTPUT WHT WIRE WHT YEL/ WIRE WHT/LT GRN WIRE WHT/PPL WIRE WHT/YEL WIRE YEL PPL WIRE YEL WIRE YEL/ ORG WIRE

BLK WIRE BLK/WHT WIRE BRN WIRE BRN/ORG WIRE BRN/PNK WIRE COAST CLUTCH SOLENOID DIODE (PLUG- IN) DK BLU WIRE DK GRN WIRE DK GRN/YEL WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) FUEL PUMP RELAY FUSE C FUSE G FUSE H FUSE U GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN START OR RUN IGNITION SWITCH LOCK OFF LT BLU WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MISFIRE SENSOR (LOWER RIGHT FRONT OF ENGINE) ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER RELAY PNK WIRE PPL PPL/ORG WIRE PPL/YEL WIRE RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RUN WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 STARTER MOTOR RELAY (LEFT FRONT CORNER OF ENGINE COMPARTMENT) TAN/LT BLU WIRE TORQUE CONVERTER CLUTCH (TCC) SOLENOID TRANS.) TRANSMISSION TRANSMISSION FLUID TEMPERATURE SENSOR TRANSMISSION RANGE (TR) SENSOR (LEFT SIDE OF TRANSMISSION) WHT WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/YEL WIRE YEL WIRE

#6 FUEL INJECTORS (IN INTAKE MANIFOLD) AIRB SOLENOID (REAR OF LEFT VALVE COVER, ON BRACKET) AIRD SOLENOID (REAR OF LEFT VALVE COVER, ON BRACKET) ALL CUTAWAYS ALL VANS, WAGONS BLK WIRE BLK/WHT WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL BRACKET) BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/YEL WIRE CLASS 1 TRAILER ADAPTER ONLY DK BLU WIRE DK GRN/YEL WIRE EGR SOLENOID (REAR OF LEFT VALVE COVER, ON BRACKET) FUEL PUMP/ SENDER (BELOW VEHICLE IN FUEL TANK) FUSE I GRY WIRE GRY/RED WIRE HOT AT ALL TIMES IDLE AIR CONTROL (IAC) VALVE (LEFT SIDE OF ENGINE, ABOVE DISTRIBUTER) IN-TRANSIT FUEL PUMP/ SENDER (BELOW VEHICLE, ALONG LEFT FRAME RAIL) INERTIA FUEL SHUTOFF (IFS) (BEHIND RIGHT COWL PANEL) INSTRUMENT CLUSTER SYSTEM (ANTI-SLOSH MODULE/FUEL GAUGE) INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MASS AIR FLOW (MAF) SENSOR (CENTER OF ENGINE COMPARTMENT) NCA WIRE ORG/ WIRE PNK WIRE PNK/BLK WIRE PPL/YEL WIRE REAR FUEL PUMP/ SENDER (MOUNTED ON LEFT REAR FRAME CROSSMEMBER) RED WIRE RED/LT GRN WIRE TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TRAILER/CAMPER ADAPTER CONNECTOR W/TRAILER ADAPTER ONLY WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/YEL WIRE YEL WIRE YEL/WHT WIRE

BLK WIRE BLK/WHT WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE BRY/YEL WIRE CATALYST MONITOR SENSOR (CMS) (NEAR LOWER RIGHT SIDE OF TRANSMISSION) DELTA PRESSURE FEEDBACK EGR (DPFE) SENSOR (RIGHT SIDE OF ENGINE) DK BLU WIRE FUEL INJECTOR #5 FUEL INJECTOR #3 FUEL INJECTOR #1 GROUND GROUND FUEL INJECTOR 6 FUEL INJECTOR 4 FUEL INJECTOR 2 GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEGO SNS MN #11 HEGO SNS MN #21 CMS SENSOR IAC VALVE KNOCK SENSOR (KS) (LEFT SIDE OF ENGINE, NEAR IGNITION COIL) LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE NCA WIRE PNK/YEL WIRE POWER INPUT PPL/YEL WIRE PROGRAMMABLE SPEEDOMETER/ ODOMETER MODULE (PSOM) (BEHIND LEFT SIDE OF I/P) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/WHT WIRE TAN WIRE TAN/BLK WIRE TCIL IND. LP. FUEL PMP RLY CTRL EPC SOLENOID THROTTLE POSITION (TP) SENSOR (TOP LEFT SIDE OF ENGINE) TRANS RNG SENSOR VAPOR MANAGEMENT VALVE (CENTER OF ENGINE COMPARTMENT) VSS INPUT VSS OUTPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/YEL WIRE WIDE OPEN THROT. AIRB SOLENOID POWER INPUT YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE

1 2 3 4 5 6 PIP SPOUT IDM PWR COIL GND PNK WIRE 570 224 923 GND TCS TFT 924 395 CCS PIP IGN POWER INJ 1,4,5,8 OUT INJ 2,3,6,7 OUT GND AIR CONDITIONING SYSTEM BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL SUPPORT) BRN WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE COIL WIRE DATA LINK CONNECTOR (LEFT FRONT CORNER OF ENGINE COMPT.) DATA LINK CONNECTOR (LEFT FRONT OF ENGINE COMPT.) DIODE (PLUG-IN) (IN ENGINE COMPARTMENT FUSE PANEL) DISTRIBUTOR 1 2 3 7 8 DISTRIBUTOR SHIELD DK GRN/YEL WIRE ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) PCM POWER RELAY FUSE 1 FUSE 18 FUSE C FUSE U GND IAC FP GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN IAT VREF EGR VALVE DATA (+) IGN GND MIL IGNITION COIL (LEFT REAR OF ENGINE) IGNITION CONTROL MODULE (ICM) (LEFT REAR OF ENGINE COMPARTMENT) IGNITION CONTROL MODULE (ICM) SHIELD INSTRUMENT CLUSTER INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) KAPWR BOO PSOM (+) IDM LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN RED/ WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP (MIL) MAP SIG RTN TP STI 359 355 209 NCA WIRE OR (LEFT SIDE OF ENGINE COMPARTMENT, NEAR BATTERY) ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE ORG/YEL WIRE PNK 929 361 SPOUT IGN POWER EPC WIRE PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL/ORG WIRE PPL/YEL WIRE RADIO CAPACITOR (ATTACHED TO IGNITION COIL) RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHORTING BAR (LEFT REAR OF ENGINE COMPARTMENT) TAN WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE TCC SOL TR SENSOR CANP TCIL EGR SOL TRANSMISSION RANGE (TR) SENSOR (LEFT SIDE OF TRANSMISSION) VSS (-) ECT FPM DATA (-) A/C ON AIRD WHT WIRE WHT/ BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/PNK WIRE WHT/PPL WIRE WHT/YEL WIRE YEL WIRE YEL/RED WIRE

AIRD SOLENOID (REAR OF LEFT VALVE COVER, ON BRACKET) ALL CUTAWAYS ALL VANS AND WAGONS BLK WIRE BLK/WHT WIRE BRN WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE COAST CLUTCH SOLENOID DK GRN WIRE DK GRN/YEL WIRE EGR SOLENOID (REAR OF LEFT VALVE COVER, ON BRACKET) ELECTRONIC PRESSURE (EPC) CONTROL SOLENOID SHIFT SOLENOID NO.2 ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) FUEL PUMP RELAY FUEL INJECTORS FUEL PUMP/ SENDER (BELOW VEHICLE IN FUEL TANK) FUSE H GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HEATED OXYGEN SENSOR HOT AT ALL TIMES HOT AT ALL TIMES IGNITION SWITCH HOT IN RUN INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) FUSE 5 IDLE AIR CONTROL (IAC) VALVE (FRONT OF ENGINE, NEAR DISTRIBUTOR) IN-TRANSIT FUEL PUMP/SENDER (BELOW VEHICLE, ALONG LEFT FRAME RAIL) INERTIA FUEL SHUT OFF (IFS) SWITCH (BEHIND RIGHT COWL PANEL) LOCK OFF LT BLU/ORG WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE NCA WIRE NO.1 NO.2 NO.3 NO.4 NO.5 NO.6 NO.7 NO.8 OD OFF ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PPL PPL/ORG WIRE PPL/YEL WIRE REAR FUEL PUMP/ SENDER (MOUNTED ON LEFT REAR FRAME CROSSMEMBER) RED WIRE RED/ GRY WIRE RUN WIRE SHIFT SOLENOID NO.1 TAN WIRE TAN/WHT WIRE THROTTLE POSITION (TP) SENSOR (RIGHT FRONT OF ENGINE) TORQUE CONVERTER CLUTCH SOLENOID TRANS- MISSION FLUID TEMPER- ATURE SENSOR TRANSMISSION CONTROL SWITCH/ INDICATOR LAMP TCIL WHT BRN WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE

BLK WIRE BLK/WHT WIRE BRN WIRE BRN/ORG WIRE BRN/PNK WIRE COAST CLUTCH SOLENOID DIODE (PLUG- IN) DK BLU WIRE DK GRN WIRE DK GRN/YEL WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) FUEL PUMP RELAY FUSE C FUSE G FUSE H FUSE U GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN START OR RUN IGNITION SWITCH LOCK OFF LT BLU WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MISFIRE SENSOR (LOWER RIGHT FRONT OF ENGINE) ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER RELAY PNK WIRE PPL PPL/ORG WIRE PPL/YEL WIRE RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RUN WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 STARTER MOTOR RELAY (LEFT FRONT CORNER OF ENGINE COMPARTMENT) TAN/LT BLU WIRE TORQUE CONVERTER CLUTCH (TCC) SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TRANSMISSION TRANSMISSION RANGE (TR) SENSOR (LEFT SIDE OF TRANSMISSION) WHT WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/YEL WIRE YEL WIRE

ALL CUTAWAYS ALL VANS, WAGONS BLK WIRE BLK/WHT WIRE BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/YEL WIRE DK BLU WIRE DK GRN/YEL WIRE EGR SOLENOID (REAR OF LEFT VALVE COVER, ON BRACKET) FUEL PUMP/ SENDER (BELOW VEHICLE, VEHICLE, IN FUEL TANK) GRY WIRE GRY/RED WIRE IDLE AIR CONTROL (IAC) VALVE (FRONT OF ENGINE, NEAR DISTRIBUTOR) IN-TRANSIT FUEL PUMP/ SENDER (BELOW VEHICLE, ALONG LEFT FRAME RAIL) INERTIA FUEL SHUTOFF (IFS) (BEHIND RIGHT COWL PANEL) INSTRUMENT CLUSTER (ANTI-SLOSH MODULE) LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MASS AIR FLOW (MAF) SENSOR (CENTER OF ENGINE COMPARTMENT) NCA WIRE NO.1 NO.2 NO.3 NO.4 FUEL INJECTORS (IN INTAKE MANIFOLD) NO.5 NO.6 NO.7 NO.8 FUEL INJECTORS (IN INTAKE MANIFOLD) ORG/ WIRE PNK WIRE PNK/BLK WIRE PPL/YEL WIRE REAR FUEL PUMP/ SENDER (MOUNTED ON LEFT REAR FRAME CROSSMEMBER) RED WIRE RED/LT GRN WIRE TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TRAILER/CAMPER ADAPTER CONNECTOR W/CLASS 1 TRAILER ADAPTER ONLY W/TRAILER ADAPTER ONLY WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/WHT WIRE

BLK WIRE BLK/WHT WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL BRACKET) BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE BRY/YEL WIRE CATALYST MONITOR SENSOR (CMS) (LOWER MIDDLE SIDE OF VEHICLE) DELTA PRESSURE FEEDBACK EGR (DPFE) SENSOR (RIGHT SIDE OF ENGINE) DK BLU WIRE FUSE I GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN HEGO MN NO.11 HEGO MN NO.21 CMS SENSOR HOT AT ALL TIMES IAC VALVE INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE NCA WIRE NO.11 (BENEATH CENTER OF VEHICLE) NO.21 (LOWER LEFT SIDE OF TRANSMISSION) POWER DISTRIBUTION SYSTEM POWER INPUT FUEL INJ. NO.8 FUEL INJ. NO.6 FUEL INJ. NO.4 FUEL INJ. NO.2 PPL/YEL WIRE PROGRAMMABLE SPEEDOMETER/ ODOMETER MODULE (PSOM) (BEHIND LEFT SIDE OF I/P) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/WHT WIRE TAN WIRE TAN/BLK WIRE TAN/RED WIRE TCIL IND. LP. FUEL PMP RLY CTRL EPC SOLENOID THROTTLE POSITION (TP) SENSOR (RIGHT FRONT OF ENGINE) TRANS RNG SENSOR DPFE SENSOR VAPOR MANAGEMENT VALVE (CENTER OF ENGINE COMPARTMENT) VEHICLE SPD SENS. MISFIRE SENS. HEGO NO.11 VSS INPUT VSS OUTPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE