Ford Club Wagon E150 (1996-1998) all vans/wagons Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 BAT 397 489 523 GND IGN (RUN) DSS INPUT DSS RETURN 115 OHMS 20 OHMS 4 WHEEL ANTI-LOCK BRAKES 21 16 23 22 9 4.9L, 5.0L, 5.8L FEDERAL UNDER 8600 GVW, 7.5L CALIF. ONLY 5.8L FED. OVER 8600 GVW, 7.5L EXCEPT CALIF. W/O DRL ALL OTHER MODELS 5.8L FEDERAL OVER 8600 GVW, 7.5L EXCEPT CALIF. 603 523 MODULE (ON LEFT FRONT FRAME RAIL) 92 OHMS AIR BAG IND AIR BAG MODULE (BEHIND LEFT SIDE OF I/P) ALL CUTAWAYS ALL VANS/WAGONS ANTI- SLOSH MODULE SOLID STATE ANTI-LOCK BRAKE IND B(+) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRAKE WARNING IND CHARGE IND COOLANT TEMP DIODE C (IN MAIN HARNESS, NEAR T/O TO PSOM) DK DK DK GRN WIRE DK GRN/LT GRN WIRE DUAL BRAKE WARNING SWITCH (IN BOTTOM OF BRAKE MASTER CYLINDER) ENGINE COOLANT TEMP. GAUGE ENGINE OIL PRESS GAUGE FASTEN SEAT BELT IND FUEL GAUGE FUEL LEVEL GENERATOR/ REGULATOR GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HIGH BEAM IND HOT AT ALL TIMES HOT IN HOT IN HOT W/MAIN LIGHT SWITCH IN PARK OR HEAD IGN IGNITION SWITCH ILLUM INSTRUMENT CLUSTER INSTRUMENT LAMPS ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) FUSE 17 FUSE 1 LEFT TURN IND RIGHT TURN IND LOCK OFF LT BLU WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MALFUNCTION IND. "CHECK ENGINE LIGHT" NCA WIRE OHMS OIL PRESS OR RUN FUSE 13 FUSE 18 PARKING BRAKE SWITCH (ABOVE LEFT COWL PANEL) PNK REAR AXLE SPEED SENSOR (MOUNTED ON DIFFER- ENTIAL) WIRE PNK/ DATA LINK CONNECTOR (DLC) (LEFT FRONT CORNER OF ENGINE COMPARTMENT) WIRE PNK/BLK WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) PPL PPL PPL/WHT WIRE PPL/YEL WIRE PROGRAMMING ENABLE PSOM DATA LINK CONNECTOR (BEHIND LEFT SIDE OF I/P) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE TAN WIRE TAN/LT GRN WIRE VOLT- METER VSS OUTPUT W/ DRL PPL W/O DRL W/PREMIUM SOUND SYSTEM WARNING BUZZER MODULE (BELOW LEFT SIDE OF I/P) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 BAT 397 489 523 GND IGN (RUN) DSS INPUT DSS RETURN 115 OHMS 20 OHMS 4.9L, 5.0L, 5.8L FEDERAL UNDER 8600 GVW, 7.5L CALIF. ONLY 5.8L FED. OVER 8600 GVW, 7.5L EXCEPT CALIF. 5.8L FEDERAL OVER 8600 GVW, 7.5L EXCEPT CALIF. 92 OHMS AIR BAG IND AIR BAG MODULE (LEFT SIDE OF I/P) ALL CUTAWAYS ALL OTHER MODELS ALL VANS/WAGONS ANTI- SLOSH MODULE SOLID STATE ANTI-LOCK BRAKE IND B(+) BASE MODELS W/RABS LT BASE MODELS: W/RABS BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE CHARGE IND COOLANT TEMP DATA LINK CONNECTOR (DLC) (LEFT FRONT CORNER OF ENGINE COMPARTMENT) PNK/ WIRE DIODE C (IN MAIN HARNESS, NEAR PSOM) DK GRN WIRE DK GRN/LT GRN WIRE DK LT LT DUAL BRAKE WARNING DIODE/ RESISTOR ASSEMBLY DUAL BRAKE WARNING SWITCH ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) ENGINE COOLANT TEMP. GAUGE ENGINE OIL PRESS GAUGE EXCEPT BASE MODELS EXCEPT BASE MODELS: 5.8L FED OVER 8600 GVW, 7.5L EXCEPT CALIF. FASTEN SEAT BELT IND FUEL GAUGE FUEL LEVEL FUSE U GENERATOR/ REGULATOR GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT AT ALL TIMES HOT IN HOT IN HOT IN START OR RUN HOT W/MAIN LIGHT SWITCH IN PARK OR HEAD IGN IGNITION SWITCH ILLUM INSTRUMENT CLUSTER IGN INSTRUMENT LAMPS ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) FUSE 17 FUSE 1 LOCK LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT LT MALFUNCTION IND. "CHECK ENGINE LIGHT" BRAKE WARNING IND. NCA WIRE OFF OHMS OIL PRESS OR RUN FUSE 13 FUSE 18 PARKING BRAKE SWITCH (ABOVE LEFT COWL PANEL) PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) PPL/ 1000 OHMS PPL/ W/ DRL PPL/WHT WIRE PPL/YEL (OR LT GRN/RED) WIRE PPL/YEL WIRE PSOM DATA LINK CONNECTOR PROGRAMMING ENABLE (BEHIND LEFT SIDE OF I/P) REAR ANTI-LOCK BRAKE (RABS) SYSTEM MODULE (BEHIND RIGHT SIDE OF I/P) REAR AXLE SPEED SENSOR (MOUNTED ON DIFFERENTIAL) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN IND LEFT TURN IND RUN WIRE TAN WIRE TAN/LT GRN WIRE VOLT- METER VSS OUTPUT W/O DRL WARNING BUZZER MODULE (BELOW LEFT SIDE OF I/P) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 BAT 397 489 523 GND IGN (RUN) DSS INPUT DSS RETURN 115 OHMS 20 OHMS 4 WHEEL ANTI-LOCK BRAKES 21 16 23 22 9 4.9L, 5.0L, 5.8L FEDERAL UNDER 8600 GVW, 7.5L CALIF. ONLY 5.8L FED. OVER 8600 GVW, 7.5L EXCEPT CALIF. W/O DRL ALL OTHER MODELS 5.8L FEDERAL OVER 8600 GVW, 7.5L EXCEPT CALIF. 603 523 MODULE (ON LEFT FRONT FRAME RAIL) 92 OHMS AIR BAG IND AIR BAG MODULE (BEHIND LEFT SIDE OF I/P) ALL CUTAWAYS ALL VANS/WAGONS ANTI- SLOSH MODULE SOLID STATE ANTI-LOCK BRAKE IND B(+) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRAKE WARNING IND CHARGE IND COOLANT TEMP DIODE C (IN MAIN HARNESS, NEAR T/O TO PSOM) DK DK DK GRN WIRE DK GRN/LT GRN WIRE DUAL BRAKE WARNING SWITCH (IN BOTTOM OF BRAKE MASTER CYLINDER) ENGINE COOLANT TEMP. GAUGE ENGINE OIL PRESS GAUGE FASTEN SEAT BELT IND FUEL GAUGE FUEL LEVEL GENERATOR/ REGULATOR GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HIGH BEAM IND HOT AT ALL TIMES HOT IN HOT IN HOT W/MAIN LIGHT SWITCH IN PARK OR HEAD IGN IGNITION SWITCH ILLUM INSTRUMENT CLUSTER INSTRUMENT LAMPS ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) FUSE 17 FUSE 1 LEFT TURN IND RIGHT TURN IND LOCK OFF LT BLU WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MALFUNCTION IND. "CHECK ENGINE LIGHT" NCA WIRE OHMS OIL PRESS OR RUN FUSE 13 FUSE 18 PARKING BRAKE SWITCH (ABOVE LEFT COWL PANEL) PNK REAR AXLE SPEED SENSOR (MOUNTED ON DIFFER- ENTIAL) WIRE PNK/ DATA LINK CONNECTOR (DLC) (LEFT FRONT CORNER OF ENGINE COMPARTMENT) WIRE PNK/BLK WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) PPL PPL PPL/WHT WIRE PPL/YEL WIRE PROGRAMMING ENABLE PSOM DATA LINK CONNECTOR (BEHIND LEFT SIDE OF I/P) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE TAN WIRE TAN/LT GRN WIRE VOLT- METER VSS OUTPUT W/ DRL PPL W/O DRL W/PREMIUM SOUND SYSTEM WARNING BUZZER MODULE (BELOW LEFT SIDE OF I/P) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 BAT 397 489 523 GND IGN (RUN) DSS INPUT DSS RETURN 115 OHMS 20 OHMS 4.9L, 5.0L, 5.8L FEDERAL UNDER 8600 GVW, 7.5L CALIF. ONLY 5.8L FED. OVER 8600 GVW, 7.5L EXCEPT CALIF. 5.8L FEDERAL OVER 8600 GVW, 7.5L EXCEPT CALIF. 92 OHMS AIR BAG IND AIR BAG MODULE (LEFT SIDE OF I/P) ALL CUTAWAYS ALL OTHER MODELS ALL VANS/WAGONS ANTI- SLOSH MODULE SOLID STATE ANTI-LOCK BRAKE IND B(+) BASE MODELS W/RABS LT BASE MODELS: W/RABS BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE CHARGE IND COOLANT TEMP DATA LINK CONNECTOR (DLC) (LEFT FRONT CORNER OF ENGINE COMPARTMENT) PNK/ WIRE DIODE C (IN MAIN HARNESS, NEAR PSOM) DK GRN WIRE DK GRN/LT GRN WIRE DK LT LT DUAL BRAKE WARNING DIODE/ RESISTOR ASSEMBLY DUAL BRAKE WARNING SWITCH ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) ENGINE COOLANT TEMP. GAUGE ENGINE OIL PRESS GAUGE EXCEPT BASE MODELS EXCEPT BASE MODELS: 5.8L FED OVER 8600 GVW, 7.5L EXCEPT CALIF. FASTEN SEAT BELT IND FUEL GAUGE FUEL LEVEL FUSE U GENERATOR/ REGULATOR GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT AT ALL TIMES HOT IN HOT IN HOT IN START OR RUN HOT W/MAIN LIGHT SWITCH IN PARK OR HEAD IGN IGNITION SWITCH ILLUM INSTRUMENT CLUSTER IGN INSTRUMENT LAMPS ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) FUSE 17 FUSE 1 LOCK LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT LT MALFUNCTION IND. "CHECK ENGINE LIGHT" BRAKE WARNING IND. NCA WIRE OFF OHMS OIL PRESS OR RUN FUSE 13 FUSE 18 PARKING BRAKE SWITCH (ABOVE LEFT COWL PANEL) PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) PPL/ 1000 OHMS PPL/ W/ DRL PPL/WHT WIRE PPL/YEL (OR LT GRN/RED) WIRE PPL/YEL WIRE PSOM DATA LINK CONNECTOR PROGRAMMING ENABLE (BEHIND LEFT SIDE OF I/P) REAR ANTI-LOCK BRAKE (RABS) SYSTEM MODULE (BEHIND RIGHT SIDE OF I/P) REAR AXLE SPEED SENSOR (MOUNTED ON DIFFERENTIAL) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN IND LEFT TURN IND RUN WIRE TAN WIRE TAN/LT GRN WIRE VOLT- METER VSS OUTPUT W/O DRL WARNING BUZZER MODULE (BELOW LEFT SIDE OF I/P) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 BAT 397 489 523 GND IGN (RUN) DSS INPUT DSS RETURN 115 OHMS 20 OHMS 4 WHEEL ANTI-LOCK BRAKES 21 16 23 22 9 4.9L, 5.0L, 5.8L FEDERAL UNDER 8600 GVW, 7.5L CALIF. ONLY 5.8L FED. OVER 8600 GVW, 7.5L EXCEPT CALIF. W/O DRL ALL OTHER MODELS 5.8L FEDERAL OVER 8600 GVW, 7.5L EXCEPT CALIF. 603 523 MODULE (ON LEFT FRONT FRAME RAIL) 92 OHMS AIR BAG IND AIR BAG MODULE (BEHIND LEFT SIDE OF I/P) ALL CUTAWAYS ALL VANS/WAGONS ANTI- SLOSH MODULE SOLID STATE ANTI-LOCK BRAKE IND B(+) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRAKE WARNING IND CHARGE IND COOLANT TEMP DIODE C (IN MAIN HARNESS, NEAR T/O TO PSOM) DK DK DK GRN WIRE DK GRN/LT GRN WIRE DUAL BRAKE WARNING SWITCH (IN BOTTOM OF BRAKE MASTER CYLINDER) ENGINE COOLANT TEMP. GAUGE ENGINE OIL PRESS GAUGE FASTEN SEAT BELT IND FUEL GAUGE FUEL LEVEL GENERATOR/ REGULATOR GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HIGH BEAM IND HOT AT ALL TIMES HOT IN HOT IN HOT W/MAIN LIGHT SWITCH IN PARK OR HEAD IGN IGNITION SWITCH ILLUM INSTRUMENT CLUSTER INSTRUMENT LAMPS ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) FUSE 17 FUSE 1 LEFT TURN IND RIGHT TURN IND LOCK OFF LT BLU WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MALFUNCTION IND. "CHECK ENGINE LIGHT" NCA WIRE OHMS OIL PRESS OR RUN FUSE 13 FUSE 18 PARKING BRAKE SWITCH (ABOVE LEFT COWL PANEL) PNK REAR AXLE SPEED SENSOR (MOUNTED ON DIFFER- ENTIAL) WIRE PNK/ DATA LINK CONNECTOR (DLC) (LEFT FRONT CORNER OF ENGINE COMPARTMENT) WIRE PNK/BLK WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) PPL PPL PPL/WHT WIRE PPL/YEL WIRE PROGRAMMING ENABLE PSOM DATA LINK CONNECTOR (BEHIND LEFT SIDE OF I/P) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE TAN WIRE TAN/LT GRN WIRE VOLT- METER VSS OUTPUT W/ DRL PPL W/O DRL W/PREMIUM SOUND SYSTEM WARNING BUZZER MODULE (BELOW LEFT SIDE OF I/P) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 BAT 397 489 523 GND IGN (RUN) DSS INPUT DSS RETURN 115 OHMS 20 OHMS 4.9L, 5.0L, 5.8L FEDERAL UNDER 8600 GVW, 7.5L CALIF. ONLY 5.8L FED. OVER 8600 GVW, 7.5L EXCEPT CALIF. 5.8L FEDERAL OVER 8600 GVW, 7.5L EXCEPT CALIF. 92 OHMS AIR BAG IND AIR BAG MODULE (LEFT SIDE OF I/P) ALL CUTAWAYS ALL OTHER MODELS ALL VANS/WAGONS ANTI- SLOSH MODULE SOLID STATE ANTI-LOCK BRAKE IND B(+) BASE MODELS W/RABS LT BASE MODELS: W/RABS BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE CHARGE IND COOLANT TEMP DATA LINK CONNECTOR (DLC) (LEFT FRONT CORNER OF ENGINE COMPARTMENT) PNK/ WIRE DIODE C (IN MAIN HARNESS, NEAR PSOM) DK GRN WIRE DK GRN/LT GRN WIRE DK LT LT DUAL BRAKE WARNING DIODE/ RESISTOR ASSEMBLY DUAL BRAKE WARNING SWITCH ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) ENGINE COOLANT TEMP. GAUGE ENGINE OIL PRESS GAUGE EXCEPT BASE MODELS EXCEPT BASE MODELS: 5.8L FED OVER 8600 GVW, 7.5L EXCEPT CALIF. FASTEN SEAT BELT IND FUEL GAUGE FUEL LEVEL FUSE U GENERATOR/ REGULATOR GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT AT ALL TIMES HOT IN HOT IN HOT IN START OR RUN HOT W/MAIN LIGHT SWITCH IN PARK OR HEAD IGN IGNITION SWITCH ILLUM INSTRUMENT CLUSTER IGN INSTRUMENT LAMPS ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) FUSE 17 FUSE 1 LOCK LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT LT MALFUNCTION IND. "CHECK ENGINE LIGHT" BRAKE WARNING IND. NCA WIRE OFF OHMS OIL PRESS OR RUN FUSE 13 FUSE 18 PARKING BRAKE SWITCH (ABOVE LEFT COWL PANEL) PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) PPL/ 1000 OHMS PPL/ W/ DRL PPL/WHT WIRE PPL/YEL (OR LT GRN/RED) WIRE PPL/YEL WIRE PSOM DATA LINK CONNECTOR PROGRAMMING ENABLE (BEHIND LEFT SIDE OF I/P) REAR ANTI-LOCK BRAKE (RABS) SYSTEM MODULE (BEHIND RIGHT SIDE OF I/P) REAR AXLE SPEED SENSOR (MOUNTED ON DIFFERENTIAL) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN IND LEFT TURN IND RUN WIRE TAN WIRE TAN/LT GRN WIRE VOLT- METER VSS OUTPUT W/O DRL WARNING BUZZER MODULE (BELOW LEFT SIDE OF I/P) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE