Ford Cab & Chassis F350 Super Duty (1999-2012) manifold intake air heater 58 amp Wiring diagrams

BLK WIRE BLK/ORG WIRE BLK/PNK WIRE BRN WIRE BRN/ORG WIRE CLUTCH PEDAL POSITION (CPP) SWITCH (ABOVE CLUTCH PEDAL) OVERDRIVE CANCEL SWITCH CRUISE SET LAMP DK BLU WIRE DK GRN WIRE FUSE FUSE LINK B (12 GA- FUSE LINK D 20 GA- FUSE LINK E 20 GA- FUSE LINK F (20 GA FUSE LINK G (20 GA- FUSE LINK H (12 GA GLOW PLUG RELAY (LEFT SIDE OF ENGINE COMPT) GLOW PLUGS GRY WIRE GRY/ORG WIRE GRY/WHT WIRE HIGH/LOW INDICATOR SWITCH (NEAR DTR SENSOR) HOT AT ALL TIMES HOT IN RUN OR START CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) IDLE VALIDATION SWITCH (OPEN AT IDLE) (LOWER LEFT SIDE OF DASH) INJECTION PRESSURE REGULATOR (TOP CENTER OF ENGINE) INSTRUMENT CLUSTER WAIT TO LT BLU/BLK WIRE LT BLU/ORG WIRE LT GRN WIRE LT GRN/RED WIRE MAL- FUNCTION IND MANIFOLD INTAKE AIR HEATER 58 AMP MANIFOLD INTAKE AIR HEATER RELAY (CENTER OF ENGINE COMPT) NCA WIRE ORG/BLK WIRE ORG/LT BLU WIRE ORG/YEL WIRE PNK/LT GRN WIRE RED WIRE RED YEL/ WIRE RED/LT GRN WIRE RED/YEL WIRE TACH TAN/LT BLU WIRE TAN/WHT WIRE TCIL TCS VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE WATER IN FUEL FUEL RESET LOW WHT LT GRN/ WIRE WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/VIO WIRE YEL WIRE YEL/RED WIRE YEL/WHT WIRE

BLK WIRE BLK/ORG WIRE BLK/PNK WIRE BRAKE PEDAL POSITION SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/YEL WIRE CID SIG IN COAST CLUTCH SOLENOID DIGITAL TRANSMISSION RANGE (DTR) SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/WHT WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE ELECT FEED BACK SIG ELECTRONIC PRESSURE CONTROL SOLENOID FUEL DELIVERY SIG FUEL GAUGE SENDER FUEL INJ FEED FUEL INJECTOR 1 FUEL INJECTOR 2 FUEL INJECTOR 3 FUEL INJECTOR 4 FUEL INJECTOR 5 FUEL INJECTOR 6 FUEL INJECTOR 7 FUEL INJECTOR 8 FUEL INJECTORS FUSE 2 FUSE LINK B (12 GA- FUSE LINK F (20 GA FUSE LINK G (20 GA- FUSE LINK H (12 GA GENERIC ELECTRONIC MODULE (GEM) GLOW PLUG RELAY (TOP RIGHT SIDE OF ENGINE) GLOW PLUGS GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES INJ SHIELD GND INJECTOR DRIVER MODULE INSTRUMENT CLUSTER (SPEEDO- METER) JUNCTION BOX FUSE/ RELAY PANEL FUSE 15 JUNCTION BOX FUSE/RELAY PANEL LT BLU WIRE LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/ORG WIRE MANIFOLD INTAKE AIR HEATER 58 AMP MANIFOLD INTAKE AIR HEATER RELAY (CENTER OF ENGINE COMPT) NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE P, 2, 1 P, R, 2 P, R, 2, 1 P, R, N PNK/ORG WIRE PNK/YEL WIRE PPL/ORG WIRE PPL/YEL WIRE PWR GND PWR IN RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 SIG RTN SIGNAL RETURN SPEED CONTROL SERVO/ AMPLIFIER ASSEMBLY TAN WIRE TAN/BLK WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/WHT WIRE

& FUEL CHARGE HARN, NEAR BREAKOUT FOR RIGHT SIDE OF ENGINE) A/T BLK WIRE BLK/ORG WIRE BRN WIRE BRN/ORG WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) CLUTCH PEDAL POSITION (CPP) SWITCH (M/T) (ABOVE CLUTCH PEDAL) DK BLU WIRE DK GRN WIRE DK GRN/YEL WIRE ENGINE COOLANT TEMPERATURE (ECT) SENSOR (ON FRONT OF ENGINE) FROM PCM POWER RELAY (DIAGRAM 1 OF 4) FUEL PUMP RELAY FUSE 40 FUSE LINK C (12 GA FUSE LINK D (12 GA FUSE LINK F (20 GA FUSE LINK G (20 GA- GLOW PLUG RELAY (AT TOP OF ENGINE) GLOW PLUGS GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES INJECTOR PRESSURE SENSOR (ON TOP CENTER OF ENGINE) INSTRUMENT CLUSTER SPEED CONTROL SET LAMP INSTRUMENT CLUSTER SYSTEM LT BLU/ORG WIRE LT GRN WIRE LT GRN/RED WIRE M/T MANIFOLD INTAKE AIR HEATER 58 AMP MANIFOLD INTAKE AIR HEATER RELAY (AT TOP RIGHT SIDE OF ENGINE) NCA WIRE O/D OFF IND ORG/BLK WIRE ORG/LT BLU WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PARK BRAKE SWITCH (ON PARK BRAKE ASSEMBLY) RED WIRE RED YEL/ WIRE RED/LT GRN WIRE RED/YEL WIRE TAN/LT BLU WIRE TAN/WHT WIRE TCS VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE WHT LT GRN/ WIRE WHT/BLK WIRE WHT/LT GRN WIRE YEL WIRE YEL/RED WIRE YEL/WHT WIRE