Ford Bronco V (1992-1996) powertrain control module (left side of safety wall) Wiring diagrams

*5.0L W/ E40D BLU WIRE DATA ENGINE CONTROLS SYSTEM EXCEPT 5.0L GRN WIRE GRY/RED WIRE HOT IN RUN OR START INSTRUMENT CLUSTER LT BLU/ORG WIRE LT EXCEPT 7.3L IDI DIESEL MALFUNCTION INDICATOR LAMP ORG/ WIRE PNK LT WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF SAFETY WALL) PPL VIP DATA LINK CONNECTOR (LEFT REAR OF ENGINE COMPT, ON BRACKET) SIG RTN STI STO/MIL TAN/ORG WIRE VIP DATA LINK CONNECTOR (LEFT REAR OF ENGINE COMPT, ON BRACKET) WHT WIRE WHT/PPL WIRE

*5.0L W/ E40D BLU WIRE DATA ENGINE CONTROLS SYSTEM EXCEPT 5.0L GRN WIRE GRY/RED WIRE HOT IN RUN OR START INSTRUMENT CLUSTER LT BLU/ORG WIRE LT EXCEPT 7.3L IDI DIESEL MALFUNCTION INDICATOR LAMP ORG/ WIRE PNK LT WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF SAFETY WALL) PPL VIP DATA LINK CONNECTOR (LEFT REAR OF ENGINE COMPT, ON BRACKET) SIG RTN STI STO/MIL TAN/ORG WIRE VIP DATA LINK CONNECTOR (LEFT REAR OF ENGINE COMPT, ON BRACKET) WHT WIRE WHT/PPL WIRE

5 3 LINK CONNECTOR (LEFT SIDE OF ENGINE COMPT) ACCLERATION SENSOR (ON REAR AXLE) ANTI-LOCK BRAKES INDICATOR BLK WIRE BLK/LT BLU WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL SUPPORT) DK GRN WIRE ENGINE COMPART- MENT FUSE BOX ENGINE COMPARTMENT FUSE BOX FUSE FUSE 13 FUSE 17 FUSE FUSE FUSE PANEL GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START HYDRAULIC UNIT (LEFT SIDE OF ENGINE COMPARTMENT) INSTRUMENT CLUSTER ISO VALVE LEFT FRONT DUMP VALVE LT BLU/PNK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/YEL WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE ORG/RED WIRE ORG/WHT WIRE ORG/YEL WIRE PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF SAFETY WALL) PPL PPL/ORG WIRE PROGRAMMABLE SPEEDOMETER/ ODOMETER MODULE PUMP MOTOR PUMP MOTOR RLY COIL (-) G-SWITCH #2 REAR AXLE SENSOR REAR DUMP VALVE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RELAY 1 RELAY 2 RIGHT FRONT DUMP VALVE RIGHT FRONT LEFT FRONT RIGHT SENSOR (HIGH) MOTOR SPEED SENS HIGH MOTOR SPEED SENS LOW PPL SENSOR SENSOR (AT RIGHT FRONT WHEEL) (AT LEFT FRONT WHEEL) TAN WIRE TAN/BLK WIRE TAN/ORG WIRE TAN/RED WIRE TAN/YEL WIRE TRAILER RELAY BOX VEHICLE SPEED SENSOR LEFT FRONT ISO VALVE WHT WIRE WHT/LT BLU WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

1 2 3 4 5 6 7 ANTI-LOCK BRAKE IND. 500 OHMS ANTI-THEFT IND. GND 8 9 AIR BAG IND. 10 11 12 13 14 ALL EXCEPT 4.9L, LIGHTNING, BRONCO ONLY BAT (+) GND BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT (OR BLK/LT BLU) WIRE BLK/YEL WIRE BLU WIRE CHARGE IND. IGN CHECK ENGINE IND CONN B COOLANT TEMP DIESEL ENGINES ONLY DIESEL WARNING LAMPS DISPLAY DI DIESEL WAIT-TO- START IND. IGN DK BLU/LT GRN WIRE DK GRN WIRE DK GRN/LT GRN WIRE ENABLE PSOM PROGRAMMING CONNECTOR ENGINE WARNING IND. EXTERIOR LIGHTS SYSTEM (MULTI-FUNCTION SWITCH) FASTEN SEAT BELT IND. ILLUM. LAMPS FUEL GAUGE 13 14 FUEL LEVEL CONN A COOLANT TEMP. GAUGE (W/ TACH) (W/O TACH) FUEL WATER SWITCH (RIGHT SIDE OF ENGINE, ON BOTTOM OF FUEL FILTER/HEATER) FUSE 10 FUSE 18 FUSE 17 FUSE 8 FUSE PANEL: I/P GLOW PLUG RELAY (TOP CENTER REAR OF ENGINE) GRN WIRE GRY/BLK WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM (MULTI- FUNCTION SWITCH) HI-BEAM IND HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START HOT W/ LIGHT SW IN HEAD OR PARK IDI DIESEL IGNITION SWITCH IGNITION SWITCH GND INSTRUMENT CLUSTER LEFT TURN IND LIGHTNING, BRONCO ONLY LOCK OFF LOW RANGE IND. LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK-OR-LT GRN/YEL WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE LT OVERHEAT WARNING SWITCH (CLOSED AT 247 F) (LEFT FRONT OF ENGINE) LT PPL MECHANICAL SHIFT ONLY OIL PRESS GAUGE OIL PRESS. 20 OHMS PLUGGED FUEL FILTER IND. 1 2 3 4 5 6 7 8 PLUGGED FUEL FILTER SWITCH (RIGHT SIDE OF ENGINE, IN FUEL FILTER/HEATER HOUSING) PNK/LT GRN WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF SAFETY WALL) PPL/WHT WIRE RED WIRE RED/LT GRN WIRE RED/PNK-OR-ORG/LT BLU WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN IND. ILLUM. RUN WIRE SOLID STATE TAN/LT GRN WIRE VOLT- METER IGN GND 10 11 12 W/ TACH W/O TACH WARNING CHIME MODULE (BEHIND LOWER CENTER OF I/P) WATER-IN- FUEL IND. GND WATER-IN- FUEL SENSOR (RIGHT SIDE OF ENGINE, NEAR FUEL FILTER) WHT WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/PPL WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

1 2 3 4 5 6 PIP SPOUT AIR CONDITIONING SYSTEM AIRB BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/LT GRN WIRE BRN/PNK WIRE BRN/WHT WIRE COIL WIRE CPP CANP CSE GND IAC FP KS PSP IAT VREF EVP DATA (+) DATA LINK CONNECTOR (LEFT REAR OF ENGINE COMPT, ON BRACKET) DISTRIBUTOR DK GRN/YEL WIRE ENGINE COMPARTMENT FUSE BOX PCM POWER RELAY EVR FUSE 17 FUSE I FUSE PANEL FUSE U GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN IGN GND STO/MIL IGNITION COIL (LEFT REAR OF ENGINE, NEAR INTAKE MANIFOLD) IGNITION CONTROL MODULE (LEFT REAR OF ENGINE COMPARTMENT, ON FENDER APRON) INSTRUMENT CLUSTER INSTRUMENT CLUSTERS SYSTEM LT BLU/ORG WIRE LT GRN/BLK WIRE LT GRN/RED WIRE M/T MALFUNCTION INDICATOR MAP SIG RTN TP STI NCA WIRE ORG/ WIRE ORG/RED WIRE PCM POWER DIODE PIP VPWR INJ BANK 1 INJ BANK 2 PWR GND PNK SPOUT VPWR WIRE PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF SAFETY WALL) PPL/YEL WIRE PSOM (+) IDM PSOM (-) ECT FPM DATA (-) ACCS AIRD PWR COIL GND PWR GND RADIO CAPACITOR (LEFT SIDE OF ENGINE, NEAR IGNITION COIL) RED WIRE RED/LT GRN WIRE RED/YEL WIRE TAN WIRE TAN/ORG WIRE TAN/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/PNK WIRE WHT/PPL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

#1 SHIFT SOLENOID #2 SHIFT SOLENOID 1 2 3 4 5 6 PIP SPOUT AIR CONDITIONING SYSTEM BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE ON/OFF (BOO) SWITCH BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/PNK WIRE BRN/WHT WIRE BRN/YEL WIRE COIL WIRE DATA LINK CONNECTOR (LEFT REAR OF ENGINE COMPT, ON BRACKET) DISTRIBUTOR DK GRN/WHT WIRE DK GRN/YEL WIRE ELECTRONIC PRES- SURE CONTROL 2 7 8 VEHICLE POWER ENGINE COMPARTMENT FUSE BOX PCM POWER RELAY FUSE 13 FUSE 17 FUSE I FUSE PANEL FUSE U GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN IAT VREF EVP IGNITION COIL (LEFT REAR OF ENGINE, NEAR INTAKE MANIFOLD) IGNITION CONTROL MODULE (LEFT REAR OF ENGINE COMPARTMENT, ON FENDER APRON) INSTRUMENT CLUSTER INSTRUMENT CLUSTERS SYSTEM LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE ORG/YEL WIRE OSS MLP AIRB TCIL EVR AIRD INJ 4 SPOUT VPWR EPC INJ 3 PWR GND TCS PCM POWER DIODE PIP VPWR INJ 1 INJ 2 PWR GND PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF SAFETY WALL) PPL/ORG WIRE PPL/YEL WIRE PWR COIL GND RADIO CAPACITOR (LEFT SIDE OF ENGINE, NEAR IGNITION COIL) RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE SIG RTN TP STI TFI MAF SIGNAL RETURN SPEED CONTROL SERVO/AMPLIFIER ASSEMBLY TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/RED WIRE TAN/WHT WIRE TAN/YEL WIRE TCC TORQUE CON- VERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/PNK WIRE WHT/PPL WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

#1 SHIFT SOLENOID #2 SHIFT SOLENOID 1 2 3 4 5 6 PIP SPOUT AIR CONDITIONING SYSTEM BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE ON/OFF (BOO) SWITCH BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE BRN/YEL WIRE CCS PIP VPWR INJ 1 INJ 2 PWR GND COAST CLUTCH SOLENOID 7 8 COIL WIRE DATA LINK CONNECTOR (LEFT REAR OF ENGINE COMPT, ON BRACKET) DISTRIBUTOR DK GRN/YEL WIRE ELECTRONIC PRES- SURE CONTROL SOLENOID ENGINE COMPARTMENT FUSE BOX PCM POWER RELAY FUSE 13 FUSE 17 FUSE I FUSE PANEL FUSE U GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN IAT VREF EVP IGNITION COIL (LEFT REAR OF ENGINE, NEAR INTAKE MANIFOLD) IGNITION CONTROL MODULE (LEFT REAR OF ENGINE COMPARTMENT, ON FENDER APRON) INSTRUMENT CLUSTER INSTRUMENT CLUSTERS SYSTEM LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR MLP AIRB TCIL EVR AIRD INJ 4 SPOUT VPWR EPC INJ 3 PWR GND TCS NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE ORG/YEL WIRE PCM POWER DIODE PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF SAFETY WALL) PPL/ORG WIRE PPL/YEL WIRE PWR COIL GND RADIO CAPACITOR (LEFT SIDE OF ENGINE, NEAR IGNITION COIL) RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE SIG RTN TP STI TFI MAF SPEED CONTROL SERVO/AMPLIFIER ASSEMBLY TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/RED WIRE TAN/WHT WIRE TAN/YEL WIRE TCC TORQUE CON- VERTER CLUTCH SOLENOID TRANSMISSION OIL TEMP SENSOR WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/PNK WIRE WHT/PPL WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

1 2 3 4 5 6 PIP SPOUT PNK WIRE 190 237 AIRB 570 224 923 PWR GND TCS TFT ACD 924 395 CCS PIP EPCPWR/VPWR INJ BANK 1 INJ BANK 2 PWR GND AIR CONDITIONING SYSTEM BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE ON/OFF SWITCH (TOP LEFT SIDE OF BRAKE/CLUTCH PEDAL SUPPORT) BRN WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE COIL WIRE CSE GND IAC FP DATA LINK CONNECTOR (LEFT REAR OF ENGINE COMPT) DATA LINK CONNECTOR (LEFT REAR OF ENGINE COMPT, ON BRACKET) DISTRIBUTOR 1 2 3 7 8 DK GRN/YEL WIRE ENGINE COMPARTMENT FUSE BOX PCM POWER RELAY FUSE 13 FUSE 17 FUSE I FUSE PANEL FUSE U GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN IAT VREF EVP DATA (+) IGN GND STO/MIL IGNITION COIL (NEAR INTAKE MANIFOLD) INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR MANUAL LEVER POSITION SENSOR MAP SIG RTN TP STI 359 355 209 MLP OR PNP CANP TCIL EVR NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE ORG/YEL WIRE PCM POWER DIODE PNK 929 361 SPOUT ECPPWR/VPWR EPC WIRE PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF SAFETY WALL) PPL PPL/ORG WIRE PPL/YEL WIRE PSOM (-) ECT FPM DATA (-) ACCS AIRD PWR COIL GND RADIO CAPACITOR (NEAR IGNITION COIL) RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE SPOUT CHECK CONNECTOR (NEAR IGNITION CONTROL MODULE) STARTING/ CHARGING SYSTEM TAN WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE TCC TRANSMISSION TRANSMISSIONS SYSTEM WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/PNK WIRE WHT/PPL WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE