Ford Aerostar I (1986-1997) wht/ppl Wiring diagrams

3-4/4-3 SHIFT SOLENOID BLK WIRE BLK/LT GRN WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL SUPPORT) BRN/WHT WIRE DATA LINK CONNECTOR (DLC) (LEFT REAR OF ENGINE COMPARTMENT, ON SAFETY WALL) DIFFERENTIAL SPEED SENSOR (DSS) (TOP OF REAR AXLE) DK BLU WIRE DSS INPUT DSS RETURN DSS TEST CONNECTOR (LEFT REAR OF ENGINE COMPARTMENT, ON SAFETY WALL) ENGINE COMPARTMENT FUSE BOX ENGINE CONTROLS SYSTEM (IGNITION SYSTEM) PNK WIRE FUEL PUMP RELAY FUSE 1 FUSE 18 FUSE LINK E 20 GA- FUSE LINK G (20 GA- FUSE LINK J (20 GA- FUSE PANEL GRN WIRE GRY WIRE GRY/BLK WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN HOT IN START OR RUN INSTRUMENT CLUSTER LT GRN WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP (MIL) (CHECK ENGINE) ORG/RED WIRE ORG/YEL WIRE PCM POWER RELAY PCM POWER RELAY DIODE PNK 523 WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PSOM MODULE RED WIRE RED/LT GRN WIRE SPEED OUTPUT STI CONNECTOR (LEFT REAR OF ENGINE COMPARTMENT, ON SAFETY WALL) TAN/ORG WIRE THROTTLE POSITION (TP) SENSOR (TOP CENTER FRONT OF ENGINE, ON THROTTLE BODY) TORQUE CONVERTER CLUTCH (TCC) SOLENOID WHT/PPL WIRE YEL WIRE

1995 VFTC A/C CLUTCH DIODE A/C CLUTCH FIELD COIL A/C CONTROL ASSEMBLY A/C CUTOUT RELAY AUXILIARY A/C SYSTEM REFRIGERANT VALVE SOLENOID AUXILIARY BLOWER MOTOR AUXILIARY BLOWER MOTOR RESISTOR ASSEMBLY AUXILIARY POWER RELAY BLK WIRE BLK/YEL WIRE BLOWER MOTOR BLOWER MOTOR RESISTOR ASSEMBLY BLU WIRE BRN WIRE BRN/ORG WIRE CLUTCH CYCLING PRESSURE SWITCH DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK GRN/ORG WIRE DK OFF HI FRONT AUXILIARY BLOWER MOTOR SWITCH FUSE 6 FUSE 9 FUSE PANEL FUSIBLE LINK GRN WIRE HOT AT ALL TIMES HOT IN ACCY OR RUN HOT IN RUN LO HI LT BLU/ORG WIRE LT GRN WIRE LT GRN/WHT WIRE MAIN BLOWER MOTOR SWITCH MED REAR LO OFF OFF FLOOR VENT MIX NORM MAX DEF OFF HEAT VENT MIX NORM MAX DEFROST ORG/BLK WIRE ORG/RED WIRE PCM POWER RELAY PNK/WHT WIRE PNK/YEL WIRE POWER- TRAIN CONTROL MODULE PPL REAR AUXILIARY BLOWER MOTOR SWITCH RED WIRE RED/ORG WIRE WHT WIRE WHT/PPL WIRE YEL WIRE YEL/RED WIRE

19 484 694 INTERIOR LIGHTS SYSTEM 372 830 370 805 368 831 287 804 (NOT USED) 8 7 6 5 4 3 2 1 MEMORY PWR BLK/LT GRN WIRE BLK/WHT WIRE BRN/ORG WIRE DK BLU/ORG WIRE FUSE 11 FUSE 8 FUSE PANEL (BEHIND LEFT SIDE OF DASH) HOT AT ALL TIMES HOT IN ACC OR RUN LEFT FRONT SPEAKER LEFT REAR DOOR OR LIFTGATE SPEAKER LEFT REAR SEAT SPEAKER LT BLU/RED WIRE LT GRN/YEL WIRE ORG/BLK WIRE ORG/LT GRN WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/YEL WIRE RADIO RADIO PWR ILLUMINATION LCD DISPLAY RADIO GRND RED/BLK WIRE RIGHT FRONT SPEAKER RIGHT REAR DOOR OR LIFTGATE SPEAKER RIGHT REAR SEAT SPEAKER TAN WIRE WHT/LT GRN WIRE WHT/PPL WIRE YEL/BLK WIRE

8 7 6 5 4 3 2 1 RADIO MEMORY BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BRN/ORG WIRE DK BLU/ORG WIRE FUSE 11 FUSE 8 FUSE PANEL (BEHIND LEFT SIDE OF DASH) HOT AT ALL TIMES HOT IN ACC OR RUN ILLUMINATION IN GROUND MEMORY SEEK UP LEFT FRONT SPEAKER LEFT LIFTGATE SPEAKER LEFT REAR DOOR SPEAKER LEFT REAR SEAT SPEAKER LT BLU/RED WIRE LT GRN/YEL WIRE NCA WIRE ORG/BLK WIRE ORG/LT GRN WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/YEL WIRE POWER ILLUMINATION LCD DISPLAY GROUND RADIO RED/BLK WIRE REMOTE HEADPHONE MODULE (BEHIND LEFT SIDE OF CARGO AREA, BEHIND TRIM PANEL) RIGHT FRONT SPEAKER RIGHT LIFTGATE SPEAKER RIGHT REAR DOOR SPEAKER RIGHT REAR SEAT SPEAKER TAN WIRE W/ CARGO DOORS W/ REAR LIFTGATE WHT/LT GRN WIRE WHT/PPL WIRE YEL/BLK WIRE

8 7 6 5 4 3 2 1 BATTERY BLK/LT GRN WIRE BLK/WHT WIRE BRN/ORG WIRE DK BLU/ORG WIRE FUSE 11 FUSE 8 FUSE PANEL (BEHIND LEFT END OF DASH) HOT AT ALL TIMES HOT IN ACC OR RUN LEFT FRONT SPEAKER LT BLU/RED WIRE LT GRN/YEL WIRE NOT USED ORG/BLK WIRE ORG/LT GRN WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/YEL WIRE RADIO RADIO PWR ILLUMINATION LCD DISPLAY GROUND RED/BLK WIRE RIGHT FRONT SPEAKER TAN WIRE WHT/LT GRN WIRE WHT/PPL WIRE YEL/BLK WIRE

BAT ACC/RUN BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/YEL WIRE BRN WIRE CARGO LAMP COURTESY LAMP RELAY (FRONT OF LEFT "D" PILLAR, ABOVE REAR LAMPS GROMMET) DOME AND READING LAMPS DOME LAMP DOME OFF ENGINE COMPARTMENT LAMP ENGINE COMPARTMENT LAMP MERCURY SWITCH FUSE 4 FUSE 8 FUSE PANEL: I/P GLOVE BOX LAMP AND SWITCH GRY/RED WIRE HOT AT ALL TIMES HOT IN ACCY OR RUN FUSE PANEL: I/P FUSE 6 ILLUMINATED ENTRY OUTPUT DOOR HANDLES INPUT GROUND ILLUMINATED ENTRY TIMER (CENTER REAR OF LEFT "B" PILLAR) INSTRUMENT CLUSTERS SYSTEM LEFT COURTESY LAMP SWITCH LEFT DOOR HANDLE SWITCH (ON TOP OF LATCH ASSEMBLY) LEFT INSTRUMENT PANEL COURTESY LAMP LEFT VANITY MIRROR LAMP AND SWITCH LIFTGATE AJAR SWITCH (IN LOWER CENTER OF LIFTGATE, ON LATCH ASSEMBLY) LT BLU WIRE LT GRN WIRE LT GRN/YEL WIRE MAIN LIGHT SWITCH MIRRORS SYSTEM NCA WIRE REAR DOOR LATCH SWITCH (IN TOP OF RIGHT REAR DOOR) RIGHT COURTESY LAMP SWITCH RIGHT DOOR HANDLE SWITCH (ON TOP OF LATCH ASSEMBLY) RIGHT INSTRUMENT PANEL COURTESY LAMP RIGHT REAR DOOR AJAR SWITCH (IN LOWER LEFT CORNER OF RIGHT REAR DOOR) RIGHT VANITY MIRROR LAMP AND SWITCH SLIDING DOOR COURTESY LAMP SWITCH STEPWELL LAMP TAN/WHT WIRE W/ DUAL REAR DOORS W/ ILLUMINATED ENTRY W/ LIFTGATE W/ READING LAMPS W/O READING LAMPS WHT/LT BLU WIRE WHT/PPL WIRE YEL WIRE

100- 150 2200 OHMS 40- 75 50,000 OHMS ASSEMBLY (INSIDE STEERING BATTERY BLK WIRE BLU WIRE BRN WIRE BRN/LT GRN WIRE CLOCK- SPRING COLUMN) EXTERIOR LIGHTS SYSTEM (MULTI-FUNCTION SWITCH) FUSE 12 FUSE 17 FUSE 6 FUSE 1 FUSE 8 FUSE PANEL GROUND SPEED INPUT IGNITION CNTL SW INPUT BRAKE INPUT GRY WIRE GRY/BLK WIRE HORN RELAY (RIGHT SIDE OF STEERING COLUMN) HORNS SYSTEM HOT AT ALL TIMES HOT IN ACCY OR RUN HOT IN RUN INSTRUMENT CLUSTER LT BLU WIRE LT BLU/BLK WIRE LT GRN OR WIRE LT GRN WIRE NCA WIRE OHMS ORG/ WIRE ORG/YEL WIRE PNK WIRE PPL PPL BRAKE ON/OFF (BOO) PPL LT PPL/LT BLU WIRE PSOM MODULE RED WIRE RED/LT GRN WIRE RED/WHT WIRE RESUME RUN WIRE SERVO MOTOR ACTUATOR (CONNECTS TO THROTTLE LINKAGE) SET- SLOW FAST SOL+ VENT SPEED CONTROL AMPLIFIER (RIGHT SIDE OF INSTRUMENT PANEL, ABOVE COWL PANEL) SPEED CONTROL SWITCH OFF ASSEMBLY (PARTIAL) (IN STEERING SPEED OUTPUT GND SUPPORT) SWITCH (ON BRAKE PEDAL) VAC VACUUM DISTRIBUTION VACUUM DUMP VALVE (VENTS TO ATMOSPHERE WHEEL) WHEN BRAKE IS DEPRESSED) WHT WIRE WHT/PNK WIRE WHT/PPL WIRE YEL WIRE YEL/RED WIRE

AUXILIARY POWER RELAY BATTERY BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BRN WIRE DK BLU WIRE DK GRN WIRE ENGINE COMPARTMENT RELAY BOX FUSE 14 FUSE 2 FUSE 6 FUSE 11 FUSE LINK A 16 GA- FUSE LINK B 16 GA- FUSE LINK C 18 GA- FUSE LINK D 20 GA- FUSE LINK E 20 GA- FUSE LINK F 18 GA- FUSE LINK J (20 GA- FUSE LINK K 12 GA- FUSE PANEL: I/P GRY WIRE GRY/YEL WIRE IGNITION SWITCH ILLUM- INATED ENTRY TIMER INLINE FUSE INTEGRAL ALTERNATOR REGULATOR LOCK OFF LT BLU/BLK WIRE MASTER WINDOW/ DOOR LOCK SWITCH ORG BLK WIRE PCM POWER RELAY FUEL PUMP RELAY POWER DOOR LOCK MODULE DOOR LOCK/ UNLOCK CONTROL RELAY POWER- TRAIN CONTROL MODULE RADIO A/C- HEATER CONTROL ASSEMBLY SPEED CONTROL AMPLIFIER REAR WINDOW DEFROST CONTROL RED WIRE RED/LT GRN WIRE RIGHT WINDOW/ DOOR LOCK SWITCH RUN WIRE SLIDING DOOR AJAR RELAY STARTER MOTOR SOLENOID STARTER RELAY TO CLUTCH PEDAL POSITION SWITCH OR PARK/NEUTRAL POSITION SWITCH TO FUSE 17 (FUSE PANEL: I/P) TO FUSE 7 (FUSE PANEL: I/P) TO FUSES 10, 1 (FUSE PANEL: I/P) TO FUSES 15, 18 (FUSE PANEL: I/P), FUSE LINK G, INSTRUMENT CLUSTER TO FUSES 4, 8, 12, 16 (FUSE PANEL: I/P) TO FUSES 5, 9 (FUSE PANEL: I/P) TO MAIN LIGHT SWITCH TO MAIN LIGHT SWITCH RIGHT WINDOW/ DOOR LOCK SWITCH TRAILER TOW RELAY MODULE WHT/PNK WIRE WHT/PPL WIRE WIPER CONTROL MODULE WIND- SHIELD WIPER MOTOR YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

1 2 3 4 5 6 PIP SPOUT IDM IGN PWR COIL OUTPUT IGN GND PNK WIRE 3-4/4-3 SHIFT SOLENOID 359 355 209 SIG RTN TP STI 971 331 TCC WAC AIR CONDITIONING SYSTEM APRON, NEAR AIR CLEANER) BATTERY GROUND (ATTACHED TO NEGATIVE BATTERY POST) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BRAKE ON/OFF SWITCH (BEHIND STEERING COLUMN) BRN/LT BLU WIRE BRN/WHT WIRE BRN/YEL WIRE DATA LINK CONNECTOR (RIGHT REAR CORNER OF ENGINE COMPARTMENT) DISTRIBUTOR DK BLU WIRE DK GRN/ORG WIRE DK GRN/YEL WIRE ENGINE COMPARTMENT RELAY BOX PCM POWER RELAY FUSE 1 FUSE LINK G (20 GA- FUSE LINK J (20 GA- FUSE PANEL GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN IAT VREF IGNITION COIL IGNITION CONTROL MODULE (ICM) (CENTER OF RIGHT FENDER INJ 3 PWR GND INJ 4 SPOUT VPWR PNK 929 361 WIRE INJ 5 IGN GND STO/MIL DATA (+) DATA (-) CSE GND IAC FP INSTRUMENT CLUSTER LT BLU/ORG WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MAF SS 3/4 NCA WIRE ORG/RED WIRE ORG/YEL WIRE PCM POWER RELAY DIODE PIP VPWR INJ 1 INJ 2 PWR GND PNK PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE PNP POWER DISTRIBUTION SYSTEM PPL/BLK WIRE PSOM (-) ECT FPM MAF RTN ACCS CANP INJ 6 RADIO NOISE CAPACITOR (TOP LEFT REAR OF ENGINE, NEAR IGNITION COIL) RED WIRE RED/LT GRN WIRE RED/WHT WIRE STARTING/ CHARGING SYSTEM STI CONNECTOR (RIGHT REAR CORNER OF ENGINE COMPARTMENT) TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/YEL WIRE TORQUE CONVERTER CLUTCH SOLENOID WHT WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/PPL WIRE YEL WIRE

3-4/4-3 SHIFT SOLENOID 359 355 209 SIG RTN TP STI 971 331 TCC WAC AIR CONDITIONING SYSTEM AUTOMATIC TRANSMISSION BATTERY GROUND (ATTACHED TO NEGATIVE BATTERY POST) BLK WIRE BLK/LT GRN WIRE BRAKE ON/OFF SWITCH (BEHIND STEERING COLUMN) BRN/WHT WIRE CPP M/T-PNP A/T CANP CRANKSHAFT POSITION SENSOR (LOWER RIGHT FRONT OF ENGINE COMPARTMENT) CSE GND IAC FP 264 926 DATA DATA LINK CONNECTOR (LEFT REAR OF ENGINE COMPARTMENT ON SAFETY WALL) DIODE DK BLU WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/YEL WIRE ENGINE COMPARTMENT RELAY BOX PCM POWER RELAY FUSE 1 FUSE LINK E 20 GA- DK BLUE FUSE LINK G 20 GA- DK BLUE FUSE LINK J 20 GA- DK BLUE FUSE PANEL GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT START OR RUN IAT VREF IGNITION COIL (RIGHT SIDE OF VALVE COVER) IGNITION CONTROL MODULE (CENTER OF RIGHT FENDER APRON NEAR AIR CLEANER) INSTRUMENT CLUSTER LT BLU/ORG WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MAF MAF RTN IGN GND STO/MIL NCA WIRE OCT ADJ OCTANE ADJUST PLUG (TOP LEFT REAR OF ENGINE COMPT) ORG/ WIRE ORG/RED WIRE ORG/YEL WIRE PIP VPWR INJ BANK 1 INJ BANK 2 PWR GND PNK 11 395 WIRE PNK 929 361 SPOUT VPWR WIRE PNK PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF BRAKE MASTER CYLINDER) PSOM (-) ECT FPM DATA (-) ACCS 354 238 915 198 PWR GND RADIO NOISE CAPACITOR (NEAR IGNITION COIL) RED WIRE RED/LT GRN WIRE SPARK PLUGS SPEED OUTPUT SPOUT CHECK CONNECTOR (NEAR MASTER CYLINDER) STARTING/ CHARGING SYSTEM STI CONNECTOR (LEFT REAR OF ENGINE COMPT ON SAFETY WALL) TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/YEL WIRE TORQUE CONVERTER CLUTCH SOLENOID WHT WIRE WHT/LT BLU WIRE WHT/PPL WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE YEL/WHT WIRE