Ford Aerostar I (1986-1997) pnk Wiring diagrams

3-4/4-3 SHIFT SOLENOID BLK WIRE BLK/LT GRN WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL SUPPORT) BRN/WHT WIRE DATA LINK CONNECTOR (DLC) (LEFT REAR OF ENGINE COMPARTMENT, ON SAFETY WALL) DIFFERENTIAL SPEED SENSOR (DSS) (TOP OF REAR AXLE) DK BLU WIRE DSS INPUT DSS RETURN DSS TEST CONNECTOR (LEFT REAR OF ENGINE COMPARTMENT, ON SAFETY WALL) ENGINE COMPARTMENT FUSE BOX ENGINE CONTROLS SYSTEM (IGNITION SYSTEM) PNK WIRE FUEL PUMP RELAY FUSE 1 FUSE 18 FUSE LINK E 20 GA- FUSE LINK G (20 GA- FUSE LINK J (20 GA- FUSE PANEL GRN WIRE GRY WIRE GRY/BLK WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN HOT IN START OR RUN INSTRUMENT CLUSTER LT GRN WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP (MIL) (CHECK ENGINE) ORG/RED WIRE ORG/YEL WIRE PCM POWER RELAY PCM POWER RELAY DIODE PNK 523 WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PSOM MODULE RED WIRE RED/LT GRN WIRE SPEED OUTPUT STI CONNECTOR (LEFT REAR OF ENGINE COMPARTMENT, ON SAFETY WALL) TAN/ORG WIRE THROTTLE POSITION (TP) SENSOR (TOP CENTER FRONT OF ENGINE, ON THROTTLE BODY) TORQUE CONVERTER CLUTCH (TCC) SOLENOID WHT/PPL WIRE YEL WIRE

3-4/4-3 SHIFT SOLENOID BLK WIRE BLK/LT GRN WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL SUPPORT) BRN/WHT WIRE DATA LINK CONNECTOR (DLC) (LEFT REAR OF ENGINE COMPARTMENT, ON SAFETY WALL) DIFFERENTIAL SPEED SENSOR (DSS) (TOP OF REAR AXLE) DK BLU WIRE DSS INPUT DSS RETURN DSS TEST CONNECTOR (LEFT REAR OF ENGINE COMPARTMENT, ON SAFETY WALL) ENGINE COMPARTMENT FUSE BOX ENGINE CONTROLS SYSTEM (IGNITION SYSTEM) PNK WIRE ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP LEFT FRONT OF ENGINE) FUEL PUMP RELAY FUSE 1 FUSE 18 FUSE LINK E 20 GA- FUSE LINK G (20 GA- FUSE LINK J (20 GA- FUSE PANEL GRN WIRE GRY WIRE GRY/BLK WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN HOT IN START OR RUN INSTRUMENT CLUSTER LT BLU/ORG WIRE LT GRN WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP (MIL) (CHECK ENGINE) ORG/ WIRE ORG/RED WIRE ORG/YEL WIRE PCM POWER RELAY PCM POWER RELAY DIODE PNK 523 WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PSOM MODULE RED WIRE RED/LT GRN WIRE RED/YEL WIRE SPEED OUTPUT STI CONNECTOR (LEFT REAR OF ENGINE COMPARTMENT, ON SAFETY WALL) TAN/ORG WIRE THROTTLE POSITION (TP) SENSOR (TOP LEFT FRONT OF ENGINE, ON THROTTLE BODY) TORQUE CONVERTER CLUTCH (TCC) SOLENOID WHT/PPL WIRE YEL WIRE

3.0L 4.0L BLU WIRE DATA LINK CONNECTOR (DLC) (LEFT REAR OF ENGINE COMPARTMENT) FUEL PUMP RELAY FUSE 18 FUSE LINK E 20 GA- FUSE PANEL GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN START OR RUN INSTRUMENT CLUSTER LT BLU WIRE LT ENGINE COMPARTMENT FUSE BOX LT GRN WIRE MALFUNCTION IND ORG/ WIRE PCM POWER RELAY PNK LT WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (TOP LEFT SIDE OF SAFETY WALL) RED WIRE TAN WIRE YEL WIRE

100- 150 2200 OHMS 40- 75 50,000 OHMS ASSEMBLY (INSIDE STEERING BATTERY BLK WIRE BLU WIRE BRN WIRE BRN/LT GRN WIRE CLOCK- SPRING COLUMN) EXTERIOR LIGHTS SYSTEM (MULTI-FUNCTION SWITCH) FUSE 12 FUSE 17 FUSE 6 FUSE 1 FUSE 8 FUSE PANEL GROUND SPEED INPUT IGNITION CNTL SW INPUT BRAKE INPUT GRY WIRE GRY/BLK WIRE HORN RELAY (RIGHT SIDE OF STEERING COLUMN) HORNS SYSTEM HOT AT ALL TIMES HOT IN ACCY OR RUN HOT IN RUN INSTRUMENT CLUSTER LT BLU WIRE LT BLU/BLK WIRE LT GRN OR WIRE LT GRN WIRE NCA WIRE OHMS ORG/ WIRE ORG/YEL WIRE PNK WIRE PPL PPL BRAKE ON/OFF (BOO) PPL LT PPL/LT BLU WIRE PSOM MODULE RED WIRE RED/LT GRN WIRE RED/WHT WIRE RESUME RUN WIRE SERVO MOTOR ACTUATOR (CONNECTS TO THROTTLE LINKAGE) SET- SLOW FAST SOL+ VENT SPEED CONTROL AMPLIFIER (RIGHT SIDE OF INSTRUMENT PANEL, ABOVE COWL PANEL) SPEED CONTROL SWITCH OFF ASSEMBLY (PARTIAL) (IN STEERING SPEED OUTPUT GND SUPPORT) SWITCH (ON BRAKE PEDAL) VAC VACUUM DISTRIBUTION VACUUM DUMP VALVE (VENTS TO ATMOSPHERE WHEEL) WHEN BRAKE IS DEPRESSED) WHT WIRE WHT/PNK WIRE WHT/PPL WIRE YEL WIRE YEL/RED WIRE

BLK WIRE BLK/PNK WIRE BLU WIRE BRN/WHT WIRE CIRCUIT BREAKER 2 DK BLU WIRE DK GRN WIRE FUSE PANEL GROUND HI OFF INT MAX LO OHMS OHMS INT MIN HOT IN ACCY OR RUN IGNITION INPUT INT MAX INT MIN MULTI- FUNCTION SWITCH WIPER SWITCH OFF OHMS ORG/ WIRE PARK SWITCH PARK WIPER MOTOR PNK WIRE PUMP MOTOR CONTROL RED WIRE RUN WIRE WASHER SWITCH WHT WIRE WINDSHIELD WASHER PUMP MOTOR (IN WASHER RESERVOIR) WINDSHIELD WIPER MOTOR WIPER CONTROL MODULE (RIGHT OF STEERING COLUMN) WIPER MODE WIPER MOTOR (COMMON) WIPER MOTOR (HI) WIPER MOTOR (LO) WIPER MOTOR PARK SW YEL WIRE YEL/RED WIRE

AIR BAG IND ANTI- SLOSH MODULE BATTERY GROUND BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRAKE IND CHECK OIL IND. IGN CONN B CONN C COOLANT TEMP COOLANT TEMP GAUGE DK GRN WIRE DK GRN/LT GRN WIRE DOOR AJAR IND ELECTRONIC 4 WHEEL DRIVE IND. ENABLE PSOM PROGRAMMING CONNECTOR ENGINE EXTERIOR LIGHTS SYSTEM (MULTI-FUNCTION SWITCH) FASTEN BELTS IND. FUEL LEVEL FUSE 13 FUSE 17 FUSE 8 FUSE PANEL: I/P GND CONN A VOLT- METER 1 2 3 4 5 6 7 8 9 10 11 12 13 14 GND FUEL GAUGE GRN WIRE GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM (MULTI- FUNCTION SWITCH) HIGH BEAM IND HOT AT ALL TIMES HOT IN HOT W/ LAMP SW IN PARK OR HEAD IGN IGN AMP IND. IGNITION SWITCH ILLUM ILLUM. LAMPS INSTRUMENT CLUSTER INTEGRAL ALTERNATOR REGULATOR (TOP RIGHT FRONT OF LEFT TURN IND LOCK OFF LT AIR BAG DIAGNOSTIC MODULE (BEHIND LEFT SIDE OF I/P, NEAR TOP OF COWL PANEL) LT BLU/RED WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE LT LT MALFUNCTION IND. IGN OHMS OHMS REAR ABS IND. OIL PRESS OIL PRESS GAUGE ORG/ WIRE PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE PPL/WHT WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN IND RUN WIRE SPEED CONTROL AMPLIFIER (BEHIND RIGHT SIDE OF I/P, ABOVE COWL PANEL) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE FLUID LEVEL SWITCH BRAKE WARNING RESISTOR/DIODE ASSEMBLY COURTESY LAMP RELAY (LEFT REAR CORNER OF CARGO AREA) DATA LINK CONNECTOR (LEFT REAR OF ENGINE COMPT, ON SAFETY WALL) DAYTIME RUNNING LAMPS MODULE DIFFERENTIAL SPEED SENSOR DK GRN WIRE DK LT DSS TEST CONNECTOR (LEFT REAR OF ENGINE COMPT, ON SAFETY WALL) FUSE FUSE 18 GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT IN HOT IN RUN OR IGNITION SWITCH IND. CTRL IN LEFT FRONT DOOR AJAR SWITCH LIFTGATE AJAR SWITCH LOCK OFF GND LOW OIL LEVEL RELAY LOW OIL LEVEL SWITCH (LOWER RIGHT SIDE OF ENGINE, ON SIDE OF OIL PAN) LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/YEL WIRE OIL LVL IN GND OR RUN FUSE 6 20 PANEL: I/P PARK BRAKE SWITCH (ON PARK BRAKE SUPPORT) PNK LT WIRE PNK WIRE PNK/LT GRN WIRE PPL PPL SLIDING DOOR AJAR RELAY PPL/WHT WIRE PRESSURE DIFFERENTIAL WARNING SWITCH REAR ANTI-LOCK BRAKE MODULE REAR DOOR LATCH SWITCH RIGHT REAR DOOR AJAR SWITCH RED WIRE RED/PNK WIRE RED/YEL WIRE RIGHT FRONT DOOR AJAR SWITCH RUN WIRE TAN WIRE TAN/LT GRN WIRE W/ DRL W/ DUAL REAR DOORS W/ LIFTGATE W/O DRL WHT WIRE WHT/PNK WIRE YEL WIRE

7 8 LK SLDG DR CNTL BAT BLK WIRE BLK/WHT WIRE BUTTON CONNECTORS DOOR LOCK/UNLOCK CONTROL RELAY FUSE LINK GROUND HOT AT ALL TIMES IN-LINE FUSE LEFT FRONT DOOR LOCK MOTOR LIFTGATE DOOR LOCK MOTOR LOCK MASTER WINDOW/DOOR LOCK SWITCH ORG/ WIRE PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE POWER DOOR LOCK MODULE (LEFT FRONT OF CARGO AREA, BEHIND LEFT "B" PILLAR) RIGHT FRONT DOOR LOCK MOTOR RIGHT REAR DOOR LOCK MOTOR RIGHT WINDOW/DOOR LOCK SWITCH SLIDING DOOR LOCK MOTOR UN LOCK UNLK CNTL LOCK CNTL UNLOCK WITH DUAL REAR DOORS WITH LIFTGATE YEL/BLK WIRE