Ford Aerostar I (1986-1997) fuse link j (20 ga- Wiring diagrams

3-4/4-3 SHIFT SOLENOID BLK WIRE BLK/LT GRN WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL SUPPORT) BRN/WHT WIRE DATA LINK CONNECTOR (DLC) (LEFT REAR OF ENGINE COMPARTMENT, ON SAFETY WALL) DIFFERENTIAL SPEED SENSOR (DSS) (TOP OF REAR AXLE) DK BLU WIRE DSS INPUT DSS RETURN DSS TEST CONNECTOR (LEFT REAR OF ENGINE COMPARTMENT, ON SAFETY WALL) ENGINE COMPARTMENT FUSE BOX ENGINE CONTROLS SYSTEM (IGNITION SYSTEM) PNK WIRE FUEL PUMP RELAY FUSE 1 FUSE 18 FUSE LINK E 20 GA- FUSE LINK G (20 GA- FUSE LINK J (20 GA- FUSE PANEL GRN WIRE GRY WIRE GRY/BLK WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN HOT IN START OR RUN INSTRUMENT CLUSTER LT GRN WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP (MIL) (CHECK ENGINE) ORG/RED WIRE ORG/YEL WIRE PCM POWER RELAY PCM POWER RELAY DIODE PNK 523 WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PSOM MODULE RED WIRE RED/LT GRN WIRE SPEED OUTPUT STI CONNECTOR (LEFT REAR OF ENGINE COMPARTMENT, ON SAFETY WALL) TAN/ORG WIRE THROTTLE POSITION (TP) SENSOR (TOP CENTER FRONT OF ENGINE, ON THROTTLE BODY) TORQUE CONVERTER CLUTCH (TCC) SOLENOID WHT/PPL WIRE YEL WIRE

3-4/4-3 SHIFT SOLENOID BLK WIRE BLK/LT GRN WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL SUPPORT) BRN/WHT WIRE DATA LINK CONNECTOR (DLC) (LEFT REAR OF ENGINE COMPARTMENT, ON SAFETY WALL) DIFFERENTIAL SPEED SENSOR (DSS) (TOP OF REAR AXLE) DK BLU WIRE DSS INPUT DSS RETURN DSS TEST CONNECTOR (LEFT REAR OF ENGINE COMPARTMENT, ON SAFETY WALL) ENGINE COMPARTMENT FUSE BOX ENGINE CONTROLS SYSTEM (IGNITION SYSTEM) PNK WIRE ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP LEFT FRONT OF ENGINE) FUEL PUMP RELAY FUSE 1 FUSE 18 FUSE LINK E 20 GA- FUSE LINK G (20 GA- FUSE LINK J (20 GA- FUSE PANEL GRN WIRE GRY WIRE GRY/BLK WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN HOT IN START OR RUN INSTRUMENT CLUSTER LT BLU/ORG WIRE LT GRN WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP (MIL) (CHECK ENGINE) ORG/ WIRE ORG/RED WIRE ORG/YEL WIRE PCM POWER RELAY PCM POWER RELAY DIODE PNK 523 WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PSOM MODULE RED WIRE RED/LT GRN WIRE RED/YEL WIRE SPEED OUTPUT STI CONNECTOR (LEFT REAR OF ENGINE COMPARTMENT, ON SAFETY WALL) TAN/ORG WIRE THROTTLE POSITION (TP) SENSOR (TOP LEFT FRONT OF ENGINE, ON THROTTLE BODY) TORQUE CONVERTER CLUTCH (TCC) SOLENOID WHT/PPL WIRE YEL WIRE

AUXILIARY POWER RELAY BATTERY BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BRN WIRE DK BLU WIRE DK GRN WIRE ENGINE COMPARTMENT RELAY BOX FUSE 14 FUSE 2 FUSE 6 FUSE 11 FUSE LINK A 16 GA- FUSE LINK B 16 GA- FUSE LINK C 18 GA- FUSE LINK D 20 GA- FUSE LINK E 20 GA- FUSE LINK F 18 GA- FUSE LINK J (20 GA- FUSE LINK K 12 GA- FUSE PANEL: I/P GRY WIRE GRY/YEL WIRE IGNITION SWITCH ILLUM- INATED ENTRY TIMER INLINE FUSE INTEGRAL ALTERNATOR REGULATOR LOCK OFF LT BLU/BLK WIRE MASTER WINDOW/ DOOR LOCK SWITCH ORG BLK WIRE PCM POWER RELAY FUEL PUMP RELAY POWER DOOR LOCK MODULE DOOR LOCK/ UNLOCK CONTROL RELAY POWER- TRAIN CONTROL MODULE RADIO A/C- HEATER CONTROL ASSEMBLY SPEED CONTROL AMPLIFIER REAR WINDOW DEFROST CONTROL RED WIRE RED/LT GRN WIRE RIGHT WINDOW/ DOOR LOCK SWITCH RUN WIRE SLIDING DOOR AJAR RELAY STARTER MOTOR SOLENOID STARTER RELAY TO CLUTCH PEDAL POSITION SWITCH OR PARK/NEUTRAL POSITION SWITCH TO FUSE 17 (FUSE PANEL: I/P) TO FUSE 7 (FUSE PANEL: I/P) TO FUSES 10, 1 (FUSE PANEL: I/P) TO FUSES 15, 18 (FUSE PANEL: I/P), FUSE LINK G, INSTRUMENT CLUSTER TO FUSES 4, 8, 12, 16 (FUSE PANEL: I/P) TO FUSES 5, 9 (FUSE PANEL: I/P) TO MAIN LIGHT SWITCH TO MAIN LIGHT SWITCH RIGHT WINDOW/ DOOR LOCK SWITCH TRAILER TOW RELAY MODULE WHT/PNK WIRE WHT/PPL WIRE WIPER CONTROL MODULE WIND- SHIELD WIPER MOTOR YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

1 2 3 4 5 6 PIP SPOUT IDM IGN PWR COIL OUTPUT IGN GND PNK WIRE 3-4/4-3 SHIFT SOLENOID 359 355 209 SIG RTN TP STI 971 331 TCC WAC AIR CONDITIONING SYSTEM APRON, NEAR AIR CLEANER) BATTERY GROUND (ATTACHED TO NEGATIVE BATTERY POST) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BRAKE ON/OFF SWITCH (BEHIND STEERING COLUMN) BRN/LT BLU WIRE BRN/WHT WIRE BRN/YEL WIRE DATA LINK CONNECTOR (RIGHT REAR CORNER OF ENGINE COMPARTMENT) DISTRIBUTOR DK BLU WIRE DK GRN/ORG WIRE DK GRN/YEL WIRE ENGINE COMPARTMENT RELAY BOX PCM POWER RELAY FUSE 1 FUSE LINK G (20 GA- FUSE LINK J (20 GA- FUSE PANEL GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN IAT VREF IGNITION COIL IGNITION CONTROL MODULE (ICM) (CENTER OF RIGHT FENDER INJ 3 PWR GND INJ 4 SPOUT VPWR PNK 929 361 WIRE INJ 5 IGN GND STO/MIL DATA (+) DATA (-) CSE GND IAC FP INSTRUMENT CLUSTER LT BLU/ORG WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MAF SS 3/4 NCA WIRE ORG/RED WIRE ORG/YEL WIRE PCM POWER RELAY DIODE PIP VPWR INJ 1 INJ 2 PWR GND PNK PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE PNP POWER DISTRIBUTION SYSTEM PPL/BLK WIRE PSOM (-) ECT FPM MAF RTN ACCS CANP INJ 6 RADIO NOISE CAPACITOR (TOP LEFT REAR OF ENGINE, NEAR IGNITION COIL) RED WIRE RED/LT GRN WIRE RED/WHT WIRE STARTING/ CHARGING SYSTEM STI CONNECTOR (RIGHT REAR CORNER OF ENGINE COMPARTMENT) TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/YEL WIRE TORQUE CONVERTER CLUTCH SOLENOID WHT WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/PPL WIRE YEL WIRE