Ford Aerostar I (1986-1997) fuse 8 Wiring diagrams

19 484 694 INTERIOR LIGHTS SYSTEM 372 830 370 805 368 831 287 804 (NOT USED) 8 7 6 5 4 3 2 1 MEMORY PWR BLK/LT GRN WIRE BLK/WHT WIRE BRN/ORG WIRE DK BLU/ORG WIRE FUSE 11 FUSE 8 FUSE PANEL (BEHIND LEFT SIDE OF DASH) HOT AT ALL TIMES HOT IN ACC OR RUN LEFT FRONT SPEAKER LEFT REAR DOOR OR LIFTGATE SPEAKER LEFT REAR SEAT SPEAKER LT BLU/RED WIRE LT GRN/YEL WIRE ORG/BLK WIRE ORG/LT GRN WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/YEL WIRE RADIO RADIO PWR ILLUMINATION LCD DISPLAY RADIO GRND RED/BLK WIRE RIGHT FRONT SPEAKER RIGHT REAR DOOR OR LIFTGATE SPEAKER RIGHT REAR SEAT SPEAKER TAN WIRE WHT/LT GRN WIRE WHT/PPL WIRE YEL/BLK WIRE

8 7 6 5 4 3 2 1 RADIO MEMORY BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BRN/ORG WIRE DK BLU/ORG WIRE FUSE 11 FUSE 8 FUSE PANEL (BEHIND LEFT SIDE OF DASH) HOT AT ALL TIMES HOT IN ACC OR RUN ILLUMINATION IN GROUND MEMORY SEEK UP LEFT FRONT SPEAKER LEFT LIFTGATE SPEAKER LEFT REAR DOOR SPEAKER LEFT REAR SEAT SPEAKER LT BLU/RED WIRE LT GRN/YEL WIRE NCA WIRE ORG/BLK WIRE ORG/LT GRN WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/YEL WIRE POWER ILLUMINATION LCD DISPLAY GROUND RADIO RED/BLK WIRE REMOTE HEADPHONE MODULE (BEHIND LEFT SIDE OF CARGO AREA, BEHIND TRIM PANEL) RIGHT FRONT SPEAKER RIGHT LIFTGATE SPEAKER RIGHT REAR DOOR SPEAKER RIGHT REAR SEAT SPEAKER TAN WIRE W/ CARGO DOORS W/ REAR LIFTGATE WHT/LT GRN WIRE WHT/PPL WIRE YEL/BLK WIRE

8 7 6 5 4 3 2 1 BATTERY BLK/LT GRN WIRE BLK/WHT WIRE BRN/ORG WIRE DK BLU/ORG WIRE FUSE 11 FUSE 8 FUSE PANEL (BEHIND LEFT END OF DASH) HOT AT ALL TIMES HOT IN ACC OR RUN LEFT FRONT SPEAKER LT BLU/RED WIRE LT GRN/YEL WIRE NOT USED ORG/BLK WIRE ORG/LT GRN WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/YEL WIRE RADIO RADIO PWR ILLUMINATION LCD DISPLAY GROUND RED/BLK WIRE RIGHT FRONT SPEAKER TAN WIRE WHT/LT GRN WIRE WHT/PPL WIRE YEL/BLK WIRE

BAT ACC/RUN BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/YEL WIRE BRN WIRE CARGO LAMP COURTESY LAMP RELAY (FRONT OF LEFT "D" PILLAR, ABOVE REAR LAMPS GROMMET) DOME AND READING LAMPS DOME LAMP DOME OFF ENGINE COMPARTMENT LAMP ENGINE COMPARTMENT LAMP MERCURY SWITCH FUSE 4 FUSE 8 FUSE PANEL: I/P GLOVE BOX LAMP AND SWITCH GRY/RED WIRE HOT AT ALL TIMES HOT IN ACCY OR RUN FUSE PANEL: I/P FUSE 6 ILLUMINATED ENTRY OUTPUT DOOR HANDLES INPUT GROUND ILLUMINATED ENTRY TIMER (CENTER REAR OF LEFT "B" PILLAR) INSTRUMENT CLUSTERS SYSTEM LEFT COURTESY LAMP SWITCH LEFT DOOR HANDLE SWITCH (ON TOP OF LATCH ASSEMBLY) LEFT INSTRUMENT PANEL COURTESY LAMP LEFT VANITY MIRROR LAMP AND SWITCH LIFTGATE AJAR SWITCH (IN LOWER CENTER OF LIFTGATE, ON LATCH ASSEMBLY) LT BLU WIRE LT GRN WIRE LT GRN/YEL WIRE MAIN LIGHT SWITCH MIRRORS SYSTEM NCA WIRE REAR DOOR LATCH SWITCH (IN TOP OF RIGHT REAR DOOR) RIGHT COURTESY LAMP SWITCH RIGHT DOOR HANDLE SWITCH (ON TOP OF LATCH ASSEMBLY) RIGHT INSTRUMENT PANEL COURTESY LAMP RIGHT REAR DOOR AJAR SWITCH (IN LOWER LEFT CORNER OF RIGHT REAR DOOR) RIGHT VANITY MIRROR LAMP AND SWITCH SLIDING DOOR COURTESY LAMP SWITCH STEPWELL LAMP TAN/WHT WIRE W/ DUAL REAR DOORS W/ ILLUMINATED ENTRY W/ LIFTGATE W/ READING LAMPS W/O READING LAMPS WHT/LT BLU WIRE WHT/PPL WIRE YEL WIRE

100- 150 2200 OHMS 40- 75 50,000 OHMS ASSEMBLY (INSIDE STEERING BATTERY BLK WIRE BLU WIRE BRN WIRE BRN/LT GRN WIRE CLOCK- SPRING COLUMN) EXTERIOR LIGHTS SYSTEM (MULTI-FUNCTION SWITCH) FUSE 12 FUSE 17 FUSE 6 FUSE 1 FUSE 8 FUSE PANEL GROUND SPEED INPUT IGNITION CNTL SW INPUT BRAKE INPUT GRY WIRE GRY/BLK WIRE HORN RELAY (RIGHT SIDE OF STEERING COLUMN) HORNS SYSTEM HOT AT ALL TIMES HOT IN ACCY OR RUN HOT IN RUN INSTRUMENT CLUSTER LT BLU WIRE LT BLU/BLK WIRE LT GRN OR WIRE LT GRN WIRE NCA WIRE OHMS ORG/ WIRE ORG/YEL WIRE PNK WIRE PPL PPL BRAKE ON/OFF (BOO) PPL LT PPL/LT BLU WIRE PSOM MODULE RED WIRE RED/LT GRN WIRE RED/WHT WIRE RESUME RUN WIRE SERVO MOTOR ACTUATOR (CONNECTS TO THROTTLE LINKAGE) SET- SLOW FAST SOL+ VENT SPEED CONTROL AMPLIFIER (RIGHT SIDE OF INSTRUMENT PANEL, ABOVE COWL PANEL) SPEED CONTROL SWITCH OFF ASSEMBLY (PARTIAL) (IN STEERING SPEED OUTPUT GND SUPPORT) SWITCH (ON BRAKE PEDAL) VAC VACUUM DISTRIBUTION VACUUM DUMP VALVE (VENTS TO ATMOSPHERE WHEEL) WHEN BRAKE IS DEPRESSED) WHT WIRE WHT/PNK WIRE WHT/PPL WIRE YEL WIRE YEL/RED WIRE

AIR BAG IND ANTI- SLOSH MODULE BATTERY GROUND BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRAKE IND CHECK OIL IND. IGN CONN B CONN C COOLANT TEMP COOLANT TEMP GAUGE DK GRN WIRE DK GRN/LT GRN WIRE DOOR AJAR IND ELECTRONIC 4 WHEEL DRIVE IND. ENABLE PSOM PROGRAMMING CONNECTOR ENGINE EXTERIOR LIGHTS SYSTEM (MULTI-FUNCTION SWITCH) FASTEN BELTS IND. FUEL LEVEL FUSE 13 FUSE 17 FUSE 8 FUSE PANEL: I/P GND CONN A VOLT- METER 1 2 3 4 5 6 7 8 9 10 11 12 13 14 GND FUEL GAUGE GRN WIRE GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM (MULTI- FUNCTION SWITCH) HIGH BEAM IND HOT AT ALL TIMES HOT IN HOT W/ LAMP SW IN PARK OR HEAD IGN IGN AMP IND. IGNITION SWITCH ILLUM ILLUM. LAMPS INSTRUMENT CLUSTER INTEGRAL ALTERNATOR REGULATOR (TOP RIGHT FRONT OF LEFT TURN IND LOCK OFF LT AIR BAG DIAGNOSTIC MODULE (BEHIND LEFT SIDE OF I/P, NEAR TOP OF COWL PANEL) LT BLU/RED WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE LT LT MALFUNCTION IND. IGN OHMS OHMS REAR ABS IND. OIL PRESS OIL PRESS GAUGE ORG/ WIRE PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE PPL/WHT WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN IND RUN WIRE SPEED CONTROL AMPLIFIER (BEHIND RIGHT SIDE OF I/P, ABOVE COWL PANEL) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

AIR BAG DIAGNOSTIC MODULE BLK WIRE BLK/ORG WIRE BRN WIRE CARGO LAMP COURTESY LAMP RELAY ILLUM- INATED ENTRY TIMER FROM IGNITION SWITCH DAYTIME RUNNING LAMPS MODULE (CANADIAN ONLY) MAIN LIGHT SWITCH DK BLU/ORG WIRE DOME/ READING LAMPS ENGINE COMPART- MENT LAMP MERCURY SWITCH ENTRY ONLY FROM FUSE LINK A FUSE 1 FUSE 10 FUSE 12 FUSE 16 FUSE 4 FUSE 8 FUSE PANEL: I/P GLOVE BOX LAMP/ SWITCH HORN RELAY INSTRUMENT CLUSTER POWER MIRROR SWITCH INSTRUMENT PANEL CIGAR LIGHTER LEFT COURTESY LAMP SWITCH LEFT LUMBAR SEAT SWITCH LEFT VANITY MIRROR LAMP, SWITCH RIGHT VANITY MIRROR LAMP, SWITCH LT BLU/WHT WIRE LT GRN WIRE LT GRN YEL/ WIRE LT GRN/YEL WIRE MAIN LIGHT SWITCH FROM FUSE LINK B MULTI- FUNCTION SWITCH MULTI- FUNCTION SWITCH BRAKE ON/OFF (BOO) SWITCH NCA WIRE PARK/ NEUTRAL POSITION SWITCH POWERTRAIN CONTROL MODULE RADIO REAR ANTI-LOCK BRAKE MODULE REAR CIGAR LIGHTER RED WIRE RED/WHT WIRE RIGHT COURTESY LAMP SWITCH RIGHT LUMBAR SEAT SWITCH SLIDING DOOR COURTESY LAMP SWITCH SWITCH TAN/WHT WIRE W/ ILLUM- INATED WHT PNK/ WIRE WHT TAN/ WIRE WHT/PNK WIRE YEL WIRE YEL/ LT BLU WIRE YEL/ LT GRN WIRE YEL/LT BLU WIRE

BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BRN WIRE BRN/LT BLU WIRE DK GRN/LT GRN WIRE FASTEN BELTS INDICATOR FUSE 18 FUSE 4 FUSE 8 FUSE PANEL GROUND FASTEN BELTS INPUT HOT AT ALL TIMES HOT IN START OR RUN IGNITION INDICATOR OUTPUT INSTRUMENT CLUSTER KEY IN IGNITION INPUT LIGHTS ON INPUT KEY WARNING SWITCH LEFT COURTESY LAMP SWITCH LEFT DOOR OPEN INPUT LT GRN/YEL WIRE MAIN LIGHT SWITCH NCA WIRE OFF HEAD PARK RED/PNK WIRE RED/YEL WIRE SEAT BELT BUCKLE SWITCH TAN/WHT WIRE WARNING CHIME MODULE (BEHIND LEFT SIDE OF I/P, NEAR TOP OF COWL PANEL)