Dodge Ram Wagon B2500 (1996-2002) automatic shutdown relay Wiring diagrams

5 VOLT SUPPLY SENSOR GROUND AUTOMATIC SHUTDOWN RELAY BLK WIRE BLK/LT BLU WIRE BLK/TAN WIRE BLU WIRE BRN WIRE BRN/YEL WIRE CCD (+) CCD BUS(-) DK BLU WIRE DK BLU/BLK WIRE ECT SIG ENGINE CONTROLS SYSTEM FUSE 11 FUSE 9 FUSED (B+) TPS SIG GROUND GROUND GENERATOR GOVERNOR PRESSURE SIGNAL GRN WIRE GRY WIRE GRY/BLK WIRE HOT IN RUN, START IGN SENSOR GND PNP SW SENSE INSTRUMENT CLUSTER JUNCTION BLOCK LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MIL IND ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/DK GRN WIRE ORG/WHT WIRE OVERDRIVE LAMP OVERDRIVE SOLENOID CONTROL OVERDRIVE SWITCH PNK 5 WIRE PNK WIRE POWER SUPPLY POWERTRAIN CONTROL MODULE (CENTER OF FIREWALL) RED WIRE RED/WHT WIRE TAN/BLK WIRE TORQUE CONVERTER CLUTCH SOLENOID CONTROL TRANSMISSION RELAY OUTPUT TRANSMISSION SOLENOID ASSEMBLY (ON LEFT SIDE OF TRANSMISSION) TRANSMISSION TEMPERATURE SENSOR SIGNAL VARIABLE FORCE SOLENOID CONTROL VIO WIRE VIO/BRN WIRE VIO/LT BLU WIRE VIO/WHT WIRE WARNING LAMP DRIVE WHT WIRE WHT/BLK WIRE WHT/ORG WIRE WHT/PNK WIRE

7 6 5 4 PNK WIRE AUTOMATIC SHUTDOWN RELAY BLK WIRE BLK/LT BLU WIRE BLK/TAN WIRE BLK/VIO WIRE BLU WIRE BRN WIRE BRN/YEL WIRE CLOSED IN P&N POSITIONS DATA LINK CONNECTOR (BELOW STEERING COLUMN) DK BLU WIRE DK BLU/BLK WIRE DK GRN WIRE ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR (IN WATER JACKET AT FRONT OF INTAKE MANIFOLD) FUSE 14 FUSE 17/18 GRN WIRE HOT AT ALL TIMES JUNCTION BLOCK LT BLU WIRE LT GRN WIRE LT GRN/WHT WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR ORG/ WIRE ORG/DK BLU WIRE ORG/DK GRN WIRE OTHERS OUTPUT SHAFT SPEED SENSOR (ON BOTTOM OF TRANSMISSION) PARK/NEUTRAL POSITION SWITCH (ON LEFT LOWER SIDE OF TRANSMISSION) PNK 1 WIRE PNK WIRE POWER AMPLIFIER POWER DISTRIBUTION CENTER RED WIRE RED/WHT WIRE STARTING/ CHARGING SYSTEM (ENGINE STARTER MOTOR RELAY) STOP LAMP SW SENSE STOP LAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN WIRE TAN/BLK WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY ASSEMBLY) TRANSMISSION RELAY (IN PDC) VIO WIRE VIO/BRN WIRE VIO/LT BLU WIRE VIO/WHT WIRE VSS SIG W/ POWER AMPLIFIER WHT WIRE WHT/BLK WIRE WHT/ORG WIRE WHT/PNK WIRE YEL WIRE

3-SPEED A/T 5.2L, 5.9L ONLY AUTOMATIC SHUTDOWN RELAY BLK DK GRN/ WIRE BLK/DK GRN WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/TAN WIRE BRN WIRE BRN/DK BLU WIRE BRN/ORG WIRE BRN/WHT WIRE CAM POS SNS IDLE AIR 3 IDLE AIR 4 DISTRIBUTOR DK BLU WIRE DK BLU/BLK WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/BLK WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/WHT WIRE EGR SOL CTRL FUEL INJECTORS FUEL PUMP RELAY FUSED B(+) TPS SENS IN GEN FIELD DRV TCC DRVR INJ 6 DRIVER INJ 8 DRIVER GROUND GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/YEL WIRE IAT SENS IN ECT SENS IN IDLE AIR 2 IDLE AIR 1 IGN (POWER) IGNITION COIL (RIGHT FRONT OF ENGINE) INJ 1 DRIVER INJ 3 DRIVER INJ 5 DRIVER INJ 2 DRIVER INJ 4 DRIVER LT BLU/BRN WIRE LT GRN WHT/ WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MAP SENS IN NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OUTPUT SENS OUTPUT SHAFT SPEED SENSOR (SIDE OF TRANSMISSION) OVERDRV SOL PARK/NEUTRAL COIL 1 DRIVER CRNK POS SNS PNK/WHT WIRE POWER DISTRIBUTION CENTER POWERTRAIN CONTROL MODULE (RIGHT SIDE SAFETY WALL) PPL PPL/BLK WIRE PPL/BLU WIRE PPL/LT BLU WIRE PPL/WHT WIRE RED/WHT WIRE SENSOR GRD STARTING/ CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TAN/YEL WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANS TEMP IN INJ 7 DRIVER VAR FRCE SOL VEHICLE SPEED SENSOR VSS IN OUTPUT SENS GOV PRESS SIG TRANS RELAY WHT/DK BLU WIRE WHT/ORG WIRE YEL/BLK WIRE YEL/WHT WIRE

3-4 SHIFT SOL FUEL TEMP SENS OIL PRESS SIG ANTI-LOCK BRAKES SYSTEM AUTOMATIC SHUTDOWN RELAY BLK/DK GRN WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/TAN WIRE BRN WIRE BRN/DK BLU WIRE BRN/WHT WIRE BRN/YEL WIRE CAM POS SNS IDLE AIR 3 IDLE AIR 4 DK BLU WIRE DK BLU/BLK WIRE DK BLU/YEL WIRE DK GRN/BLK WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/WHT WIRE FIELD COIL FUEL INJECTORS FUEL PRESSURE SENSOR (RIGHT REAR OF FUEL RAIL) FUEL TEMPERATURE SENSOR (RIGHT REAR OF FUEL RAIL) FUSE 19/20 FUSE BLOCK FUSED B(+) TPS SENS IN GEN FIELD DRV TCC DRVR INJ 6 DRIVER INJ 8 DRIVER GENERATOR GND GND GOV PRESS SOL GRN WIRE GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE HIGH PRESSURE FUEL SHUT-OFF SOLENOID RELAY IAT SENS IN ECT SENS IN IDLE AIR 2 IDLE AIR 1 IGN RUN/START INJ 1 DRIVER INJ 3 DRIVER INJ 5 DRIVER INJ 2 DRIVER INJ 4 DRIVER LT BLU/BRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MAP SENS IN FUEL PRES SENS ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE OUTPUT SENS OUTPUT SPEED SENSOR (ON TRANSMISSION OVERDRIVE CASE) PARK/NEUTRAL COIL DRIVER CRNK POS SNS PNK WIRE POWER DISTRI- BUTION CENTER POWER DISTRIBUTION CENTER POWERTRAIN CONTROL MODULE (CENTER OF FIREWALL) RED/WHT WIRE SENSOR GND STARTING/ CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TAN/PNK WIRE TAN/YEL WIRE TRANS TEMP IN INJ 7 DRIVER VIO WIRE VIO/BLK WIRE VIO/ORG WIRE VIO/WHT WIRE VSS IN OUTPUT SENS GOV PRESS SIG TRANS RELAY WHT/DK BLU WIRE WHT/ORG WIRE YEL/BLK WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 TRANS RLY CTRL 3-4 SHIFT SOL ANTI-LOCK BRAKES SYSTEM AUTOMATIC SHUTDOWN RELAY BLK/DK GRN WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/TAN WIRE BRN WIRE BRN/DK BLU WIRE BRN/WHT WIRE BRN/YEL WIRE CAM POS SNS IDLE AIR 1 IDLE AIR 4 DK BLU/BLK WIRE DK BLU/YEL WIRE DK GRN/BLK WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/WHT WIRE FUEL INJECTORS FUEL PUMP RELAY FUSE 11 FUSE 6 FUSE BLOCK FUSED B(+) TPS SENS IN GEN FIELD DRV TCC DRVR INJ 6 DRIVER INJ 8 DRIVER GND GND GOV PRESS SOL GRN WIRE GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN OR START IAT SENS IN ECT SENS IN IDLE AIR 2 IDLE AIR 3 IGN RUN/START INJ 1 DRIVER INJ 3 DRIVER INJ 5 DRIVER INJ 2 DRIVER INJ 4 DRIVER LT BLU/BRN WIRE LT GRN/BLK WIRE LT GRN/PNK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MAP SENS IN OIL PRESS SIG ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE OUTPUT SPEED SENSOR (ON TRANSMISSION OVERDRIVE CASE) PARK/NEUTRAL COIL DRIVER CRNK POS SNS PNK WIRE PNK/WHT WIRE POWER DISTRIBUTION CENTER POWERTRAIN CONTROL MODULE (CENTER OF FIREWALL) RED WIRE RED/WHT WIRE SENSOR GND SPEED SENS GND STARTING/ CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TAN/YEL WIRE TRANS TEMP IN INJ 7 DRIVER TRANSMISSION SOLENOID ASSEMBLY (ON TRANSMISSION VALVE BODY) VIO WIRE VIO/BLK WIRE VIO/WHT WIRE VSS IN OUTPUT SPEED GOV PRESS SIG TRANS RELAY WHT/DK BLU WIRE WHT/ORG WIRE YEL/BLK WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 TRANS RLY CTRL 3-4 SHIFT SOL ANTI-LOCK BRAKES SYSTEM AUTOMATIC SHUTDOWN RELAY BLK/DK GRN WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/TAN WIRE BRN WIRE BRN/DK BLU WIRE BRN/WHT WIRE BRN/YEL WIRE CAM POS SNS IDLE AIR 1 IDLE AIR 4 DK BLU/BLK WIRE DK BLU/YEL WIRE DK GRN/BLK WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/WHT WIRE FUEL INJECTORS FUEL PUMP RELAY FUSE 11 FUSE 6 FUSE BLOCK FUSED B(+) TPS SENS IN GEN FIELD DRV TCC DRVR INJ 6 DRIVER INJ 8 DRIVER GND GND GOV PRESS SOL GRN WIRE GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN OR START IAT SENS IN ECT SENS IN IDLE AIR 2 IDLE AIR 3 IGN RUN/START INJ 1 DRIVER INJ 3 DRIVER INJ 5 DRIVER INJ 2 DRIVER INJ 4 DRIVER LT BLU/BRN WIRE LT GRN/BLK WIRE LT GRN/PNK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MAP SENS IN OIL PRESS SIG ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE OUTPUT SPEED SENSOR (ON TRANSMISSION OVERDRIVE CASE) PARK/NEUTRAL COIL DRIVER CRNK POS SNS PNK WIRE PNK/WHT WIRE POWER DISTRIBUTION CENTER POWERTRAIN CONTROL MODULE (CENTER OF FIREWALL) RED WIRE RED/WHT WIRE SENSOR GND SPEED SENS GND STARTING/ CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TAN/YEL WIRE TRANS TEMP IN INJ 7 DRIVER TRANSMISSION SOLENOID ASSEMBLY (ON TRANSMISSION VALVE BODY) VIO WIRE VIO/BLK WIRE VIO/WHT WIRE VSS IN OUTPUT SPEED GOV PRESS SIG TRANS RELAY WHT/DK BLU WIRE WHT/ORG WIRE YEL/BLK WIRE YEL/WHT WIRE