Wiring diagram engine performance 5.9l turbo diesels for Dodge Pickup R3500 (1996-2010)

1 2 3 4 5 6 7 8 TRANS RLY OUT A/T AUTOMATIC SHUTDOWN RELAY BATTERY BLK WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/TAN WIRE BLK/WHT WIRE BRN WIRE DK BLU WIRE DK BLU/BLK WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE EGR FAULT MON EGR SOL CTRL ENGINE COOLANT TEMPERATURE SENSOR (LEFT REAR OF CYLINDER HEAD) FUSE 8 FUSE 4 FUSED B(+) TPS SENS IN GEN FIELD DRV TCC DRVR GROUND GROUND GRY/BLK WIRE GRY/WHT WIRE GRY/YEL WIRE HEATED INTAKE AIR SYSTEM HEATED INTAKE AIR SYSTEM RELAY NO. 1 (BELOW LEFT BATTERY) HEATED INTAKE AIR SYSTEM RELAY NO. 2 (BELOW LEFT BATTERY) HOT AT ALL TIMES HOT IN RUN AND START FUSE BLOCK FUSE 9 IAT SENS IN ECT SENSOR IGN (POWER) INSTRUMENT CLUSTER SYSTEM LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE M/T NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE OUTPUT SENS PARK/NEUTRAL POSITION SWITCH PNK 22 23 WIRE PNK WIRE POWER DISTRIBUTION CENTER POWERTRAIN CONTROL MODULE (RIGHT SIDE SAFETY WALL) PRK/NEUTRAL AIR SYS RLY 1 SPEED SENS SIG AIR SYS RLY 2 RED WIRE RED/WHT WIRE SENSOR GRD SENSOR GRD GOV PRESS SIG VAR FORCE SOL OVERDRV SOL TCC SOL CTRL TRANS TEMP SNS TAN/BLK WIRE THROTTLE POSITION SENSOR (SIDE OF THROTLLE BODY) TRANS TEMP IN TRANSMISSION OUPUT SHAFT SPEED SENSOR (LEFT REAR OF TRANSMISSION) TRANSMISSION SOLENOID ASSEMBLY (TRANSMISSION) VAR FRCE SOL VIO WIRE VIO/WHT WIRE VSS IN OUTPUT SENS GOV PRESS SIG TRANS RELAY WAIT TO START OVERDRV SOL WATER IN FUEL WHT/ORG WIRE YEL/BLK WIRE

BATTERY BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/RED WIRE BLK/TAN WIRE BLK/WHT WIRE BRN WIRE COOLANT TEMP DIAG REQ DK BLU WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE EGR CONTROL MODULE EGR ENGINE ENGINE COOLANT TEMPERATURE SENSOR EGR FAULT EGR IAT EGR INTAKE AIR TEMPERATURE SENSOR EGR SOL EGR SOLENOID (RIGHT SIDE OF ENGINE) ENGINE SPEED SENSOR (FRONT OF ENGINE) ENGINE STARTER MOTOR RELAY (HOT IN START) FUEL HEATER (ABOVE STARTER MOTOR) FUEL HEATER RELAY (NEAR MASTER CYLINDER) FUEL SHUT DOWN RELAY (NEAR MASTER CYLINDER) FUEL SHUT DOWN SOLENOID (NEAR REAR OF INJECTION PUMP) GRY/BLK WIRE GRY/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE ORG/DK BLU WIRE PNK 13 14 WIRE PNK 22 23 WIRE PNK/DK GRN WIRE RED WIRE RED/VIO WIRE SHUT DWN REL TAN WIRE TAN/BLK WIRE TEMP SEN GRD TP SENS SIG VEHICLE SPEED SENSOR (REAR OF TRANSMISSION) VIO WIRE VIO/WHT WIRE WHT/ORG WIRE

A/C COMP RLY A/C HIGH PRESSURE CUTOUT SWITCH (A/C HIGH PRESSURE LINE) A/C LOW PRESSURE CUTOUT SWITCH (A/C LOW PRESSURE LINE) A/C REQUEST A/C SELECT IN BRAKE SW IN GENERATOR A/C SYSTEM AIR CONDITIONING SYSTEM (A/C-HEATER CONTROL SWITCH) AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL OVERDRV IND TRANS TEMP IND BATT TEMP SENS GEN IND DRVR MIL IND DRVR WATER IN FUEL BATTERY TEMPER- ATURE SENSOR (BELOW BATTERY) BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/RED WIRE BLK/WHT WIRE BRN WIRE CRUISE CONTROL SYSTEM CRUISE FEED ASD RELAY SENS TRANS OVERDRV DATA LINK CONNECTOR DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE EGR DIAG FUSE 11 FUSE BLOCK GEN IND LAMP GENERATOR GRY/LT BLU WIRE HOT IN START OR RUN INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM INTAKE AIR TEMPER- ATURE SENSOR (RIGHT SIDE OF INTAKE MANIFOLD) JOINT CONNECTOR C (BEHIND LEFT KNEE BOLSTER) LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MIL IND LAMP NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK 13 14 WIRE PNK WIRE PNK/BLK WIRE PNK/DK BLU WIRE PNK/DK GRN WIRE PNK/YEL WIRE POWER DISTRIBUTION CENTER POWERTRAIN CONTROL MODULE (RIGHT SIDE SAFETY WALL) RED WIRE RED/LT GRN WIRE SCI RECEIVE SCI TRANSMIT SPEEDOMETER STOP LAMP SWITCH (UNDER LEFT SIDE OF I/P) TACH SIGNAL TACH SIGNAL CRUISE SW IN TAN/ORG WIRE TAN/RED WIRE TAN/YEL WIRE TRANS- MISSION RELAY WATER IN FUEL SENSOR (BOTTOM OF FUEL FILTER) WHT/DK BLU WIRE WHT/ORG WIRE WHT/PNK WIRE YEL/RED WIRE