Dodge Pickup R3500 (1996-2010) wht/org Wiring diagrams

6 10 (5.9L) (6.7L) A/T AUXILIARY BATTERY B(+) BATTERY BLK WIRE BLK/GRY WIRE BRN WIRE CAN B BUS (+) CHARGING CIRCUIT CLUTCH INTERLOCK SWITCH (EXCEPT 6.7L: BEHIND LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DK BLU WIRE ELECTRONICS ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) EXCEPT RAM 3500 (CAB CHASSIS) FUSE 10 FUSE 11 FUSE 22 FUSED B (+) GRY WIRE GRY/RED WIRE HOLD-IN HOT AT ALL TIMES IGN SW OUT (START) GND IGN SW SENSE IGNITION SWITCH LT BLU WIRE M/T NCA WIRE ORG/ WIRE PULL- IN RAM 3500 (CAB CHASSIS) REAR OF ENGINE COMPT) RED WIRE SENSE SENTRY KEY REMOTE ENTRY MODULE (ON STEERING COLUMN) STARTER STARTER MTR CTRL OUTPUT TOTALLY INTEGRATED POWER MODULE TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) TRANSMISSION SOLENOID/TRS ASSEMBLY (RFE) (LEFT SIDE OF TRANSMISSION) TRS VIO WIRE VIO/BRN WIRE WHT WIRE WHT/ORG WIRE YEL WIRE

17 18 CAN B BUS(+) CAN B BUS(-) 33 42 28 27 APPS 1 RTN 36 37 6 25 SPEED CTRL BRAKE SW 4 5 1 21 CAN C BUS (+) CAN C BUS (-) 44 45 33 35 48 3 SPD SENS SIG SENS GND 6.7L 5.9L ACCEL ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH) APPS 1 SIG APPS 1 RTN APPS 2 RTN APPS 2 SIG APPS 2 SIG APPS 2 RTN APPS 1 SIG BLK WIRE BLU WIRE BRN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAN C BUS (+) CLUSTER COMPUTER DATA LINES SYSTEM DECEL DK BLU WIRE DK BLU/DK GRN WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) FUSE 28 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) FUSE 26 INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) LEFT SPEED CONTROL SWITCH OFF ORG/ WIRE OUTPUT SPEED SENSOR (5.9L) (BOTTOM OF TRANSMISSION) OUTPUT SPEED SENSOR (LEFT REAR OF TRANSMISSION) PNK EXTERIOR LIGHTS SYSTEM WIRE PNK WIRE REAR OF ENGINE COMPT) RED WIRE RESUME RIGHT SPEED CONTROL SWITCH SENS GND SENS GND S/C SW RTN S/C SW 1 SIG S/C SW 2 SIG 33 40 56 46 56 SENS SIG STEERING CONTROL MODULE (ON STEERING COLUMN) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TAN WIRE TRANSMISSION CONTROL MODULE VIO WIRE VIO/BRN WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL WIRE YEL/DK BLU WIRE

6 10 (5.9L) (6.7L) A/T AAT RETURN AUXILIARY BATTERY B(+) BATTERY BLK WIRE BLK/GRY WIRE BRN WIRE CAN B BUS (+) CHARGING CIRCUIT CLUTCH INTERLOCK SWITCH (LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DK BLU WIRE ELECTRONICS ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) EXCEPT RAM 3500 (CAB CHASSIS) FUSE 10 FUSE 11 FUSE 22 FUSED FUSED B (+) GRY WIRE GRY/RED WIRE HOLD-IN HOOD AJAR SWITCH HOOD AJAR SWITCH SENSE HOT AT ALL TIMES IGN SW GND B(+) OUT (START) IGN SW SENSE IGNITION SWITCH LEFT FRONT FENDER) LT BLU WIRE M/T ORG/ WIRE PULL- IN RAM 3500 (CAB CHASSIS) RED WIRE SENSE SNS STARTER STARTER MTR CTRL OUTPUT TAN WIRE TOTALLY INTEGRATED POWER MODULE TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) TRANSMISSION SOLENOID/TRS ASSEMBLY (RFE) (LEFT SIDE OF TRANSMISSION) TRS VIO WIRE VIO/BRN WIRE VIO/LT BLU WIRE VIO/TAN WIRE WHT WIRE WHT/ORG WIRE WIRELESS CONTROL MODULE YEL WIRE

6 10 (5.9L) (6.7L) A/T AUXILIARY BATTERY B(+) BATTERY BLK WIRE BLK/GRY WIRE BRN WIRE CAN B BUS (+) CHARGING CIRCUIT CLUTCH INTERLOCK SWITCH (EXCEPT 6.7L: BEHIND LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DK BLU WIRE ELECTRONICS ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) EXCEPT RAM 3500 (CAB CHASSIS) FUSE 10 FUSE 11 FUSE 22 FUSED B (+) GRY WIRE GRY/RED WIRE HOLD-IN HOT AT ALL TIMES IGN SW OUT (START) GND IGN SW SENSE IGNITION SWITCH LT BLU WIRE M/T NCA WIRE ORG/ WIRE PULL- IN RAM 3500 (CAB CHASSIS) REAR OF ENGINE COMPT) RED WIRE SENSE SENTRY KEY REMOTE ENTRY MODULE (ON STEERING COLUMN) STARTER STARTER MTR CTRL OUTPUT TOTALLY INTEGRATED POWER MODULE TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) TRANSMISSION SOLENOID/TRS ASSEMBLY (RFE) (LEFT SIDE OF TRANSMISSION) TRS VIO WIRE VIO/BRN WIRE WHT WIRE WHT/ORG WIRE YEL WIRE

1 2 3 4 5 6 DSL HIGH SIDE DRVR RTN ENG CTRL COM SNSR RTN RAD FAN MTR SPD SIG 1 2 3 4 AUTO HEADLAMPS SIG SUN SENSOR SIG 1 SUN SENSOR SIG 2 SENSOR GROUND 1 4 3 IGN RUN CTRL OUT IR SENSOR RETURN IR SENSOR SIGNAL 30 53 17 52 ENG CTRL COM SNSR RTN ENG CTRL COM SNSR RTN 4 RAD FAN MTR SPD SIG 4 2 3 1 BLWR MTR HI DRV FT BLW FD BLWR CTRL GND 70 16 33 6 IGN ULK/RUN/STRT A/C CLUTCH A/C CLUTCH COIL A/C COMPRESSOR, CLUTCH (LEFT SIDE OF ENGINE) A/C HEATER CONTROL A/C PRESS SIG A/C PRESS SNSE RTN A/C PRESS SNSE RTN A/C PRESS SNSR FD A/C PRESS SIG 1 2 3 A/C PRESS SNSR FD A/C PRESSURE TRANSDUCER B(+) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLOWER MODULE BLOWER MOTOR (RIGHT SIDE OF DASH) BLW MTR SPLY BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE BUS (-) CAN CAN IHS BUS (-) CAN IHS BUS (+) IOD FD FUSED IGN RUN CTRL OUT COIL COMPUTER DATA LINES SYSTEM CTRL OUT DK BLU WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DRIVER BLEND DOOR ACTUATOR (ON HVAC UNIT) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR EVAP SIG EVAP SNSE RTN EVAPORATOR TEMPERATURE SENSOR (CENTER OF DASH) FAN RADIATOR HIGH RELAY FAN RADIATOR LOW RELAY FUSE HALLEFCT ELECN ENG SPD OUT HALLEFCT ELECN ENG SPD OUT ENG CTRL COM SNSR RTN 2 COOL TEMP SNSR SIG 65 20 40 HOT AT ALL TIMES HOT AT ALL TIMES FUSE HOT W/ RUN RELAY ENERGIZED INFRARED SENSOR LT BLU WIRE LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE MODE DOOR ACTUATOR 1 (ON HVAC UNIT) MODE DOOR ACTUATOR 2 (ON HVAC UNIT) NAVIGATION SYSTEM ORG/ WIRE PASSENGER BLEND DOOR ACTUATOR (ON HVAC UNIT) PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE RAD FAN RAD FAN LOW SPD SIG RADIATOR FAN RADIATOR FAN DRIVE RECIRCULATION DOOR ACTUATOR RED/WHT WIRE RUN/START SIG HI SPD SUN SENSOR TAN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) CIRCUIT BOARD VIO/LT BLU WIRE VIO/ORG WIRE WHT/DK BLU WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/VIO WIRE

2 1 CAN IHS BUS(-) CAN IHS BUS(+) B(+) BLK WIRE BLK/BRN WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLK/WHT WIRE BRAKE FLUID LEVEL SENSOR (LEFT REAR OF ENGINE COMPT) CAN IHS CAN IHS SW SIG BUS (-) BUS (+) CAN-BUS CLUSTER COMPUTER DATA LINES SYSTEM DK GRN/ORG WIRE DK GRN/WHT WIRE DRIVER DOOR LATCH DRIVER SEAT BELT BUCKLE SWITCH DRV SEAT BELT BUCKLE SW GND DRV SEAT BELT BUCKLE SW SEN ERS AUTOSTIC SWITCH (W/ COLUMN SHIFT) EXCEPT 6.7L FUSE FUSED B(+) FUSED IGN RUN/START CONT OUT GROUND HDLP FOG LAMP SW HEADLAMP SWITCH HOT AT ALL TIMES LEFT REAR DOOR LATCH (EXCEPT REGULAR CAB) LT GRN WIRE LT GRN/ BLK WIRE LT GRN/GRY WIRE LT GRN/TAN WIRE MLFNCT SW RTN OCCUPANT RESTRAINT CONTROLLER MODULE (CENTER FRONT OF BODY) PARK BRK SW PARKING BRAKE SWITCH (TOP OF PARKING BRAKE PEDAL) PASS AJAR SW JN PASSENGER DOOR LATCH PNK/LT GRN WIRE RED/GRY WIRE RIGHT REAR DOOR LATCH (EXCEPT REGULAR CAB) RR LR BRAKE AJAR AJAR FLUID SW SW SIG SW RTN VIO WIRE VIO/GRY WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/YEL WIRE

BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE CAN C BUS (+) CAN C CAN C BUS (+) BUS (-) COMPUTER DATA LINES SYSTEM DYN SENS HIGH LNK DYN SENS LOW LNK DYNAMICS SENSOR (W/ ESP) (UNDER FRONT OF CENTER CONSOLE) ELECTRONICS B(+) FUSE 28 FUSE 30 FUSED IGN SW OUT (RUN-START) GRY WIRE GRY/ PNK WIRE HIGH LNK DYN SENS HOT AT ALL TIMES HOT IN ON OR START IGN SW OUT (RUN-START) LOW LNK DYN SENS LT BLU/ WHT WIRE LT GRN PNK/ WIRE LT GRN WHT/ WIRE ORG/ WIRE PNK/ LT GRN WIRE PNK/GRY WIRE PNK/LT GRN WIRE STEERING ANGLE SENSOR (W/ ESP) (ON STEERING COLUMN) TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) WHT LT GRN/ WIRE WHT WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE

BLK WIRE CAN IHS BUS (-) CLUSTER COMPUTER DATA LINES SYSTEM FUSE HOT AT ALL TIMES MOD FSED BATT FD RED/LT BLU WIRE TIRE PRESSURE MODULE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE

AIR CONDITIONING SYSTEM AUXILIARY BATTERY BATTERY TEMPERATURE SENSOR (UNDER BATTERY TRAY) BLK WIRE BRAKE LAMP SIG HTR RLY CTRL S/C SW 2 SIG GROUND BRN WIRE BRN/BLK WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CLUTCH INTERLOCK/ UPSTOP SWITCH (M/T) (LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DIAGNOSTIC PORT (TOP LEFT SIDE OF ENGINE) DK BLU/DK GRN WIRE DK BLU/LT GRN WIRE DK BLU/VIO WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) EXHAUST PRESSURE SENSOR 1/2 (RIGHT SIDE OF TRANSMISSION) EXHAUST TEMPERATURE SENSOR 1/1 (IN EXHAUST, FORWARD OF CATALYTIC CONVERTER) EXHAUST TEMPERATURE SENSOR 1/2 (IN EXHAUST, AT REAR OF CATALYTIC CONVERTER) EXHAUST TEMPERATURE SENSOR 1/3 (IN EXHAUST, DOWNSTREAM OF CATALYTIC CONVERTER) FUSED B (+) FUSIBLE LINK (10 GA- GROUND GROUND FUSED B(+) FUSED B(+) LOW DATA LINK INTAKE AIR HEATER INTAKE AIR HEATER RELAY (LEFT FRONT BUMPER) LT BLU WIRE LT GRN/BLK WIRE ORG/BRN WIRE PNK WIRE PNK/GRY WIRE RAM 2500 RED WIRE RED/YEL (OR BLK) WIRE RED/YEL (OR DK GRN) WIRE RED/YEL WIRE RLY CTRL RTN S/C SW 1 SIG RMT THROTTLE SIG S/C SW RTN PRES SENS SIG APPS 1 SIG SMT PWR RLY RTN A/C CLUTCH CTRL IGN SW OUT (RUN-START) TEMP 1 SENS SIG CAN C BUS (-) APPS 2 RTN UPSTOP SW SIG TAKEOFF SW IN INTERLOCK SW SIG SW RLY SIG VIO WIRE VIO/BRN WIRE VIO/DK GRN WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE

5 VOLT SUPPLY ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH) ADJ PIN SNS 2 APPS 1 RTN APPS 1 SIG APPS 2 RTN APPS 2 SIG B(+) HTR CTRL PMP CAN C CTRL OUT CTRL BUS (+) OUT BLK WIRE BLK/BRN WIRE BLK/ORG WIRE BLK/WHT WIRE BRN WIRE BRN/DK GRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE CAN B BUS (+) CAN C BUS (+) CLUSTER (LEFT REAR OF ENGINE) COMPUTER DATA LINES SYSTEM CURRENT PIN FEED CURRENT TRIM DK BLU/DK GRN WIRE DK BLU/LT BLU WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN/WHT WIRE EGR SENS FEED ELECTRONICS EXHAUST BRAKE SWITCH FUEL HEATER (LEFT SIDE OF ENGINE) FUEL LVL SENS SIG FUEL PMP FUEL FUEL PUMP MODULE (IN FUEL TANK) FUSE 28 FUSE 30 FUSE 37 FUSE 42 GROUND HIGH DATA LINK HOT AT ALL TIMES HOT IN RUN OR HTR CTRL IGN (RUN-START) IGN SW OUT (RUN-START) LOW DATA LINK ORG/DK BLU WIRE ORG/RED WIRE PANEL LAMP DRV PNK/GRY WIRE PNK/YEL WIRE RED WIRE RED/ORG WIRE RTN (DOWNSTREAM) RTN (UPSTREAM) S/C SW 1 SIG S/C SW 2 SIG S/C SW RTN SENSOR GROUND SIGNAL STEERING CONTROL MODULE (ON STEERING COLUMN) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) VIO WIRE VIO/BRN WIRE VIO/DK GRN WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE